FaultScore
See all results →
All makes Worst years, ranked Problems by part Analysis Problems by model year Recalls in Canada Recall lookup Compare two cars How we grade

Isuzu Rodeo recalls

NHTSA has issued 37 recalls covering the Isuzu Rodeo. A recall repair is always free, however old the car is.

Check your own car by VIN

Recalls apply to specific build ranges, so a recall listed here may or may not cover your particular vehicle. NHTSA's free VIN lookup is the authority: nhtsa.gov/recalls.

2004 Isuzu Rodeo Campaign 13V547000 31 Oct 2013

SUSPENSION:REAR

Isuzu Manufacturing Services of America, Inc (Isuzu) is recalling certain model year 2003-2004 Rodeo and Axiom, and 2003 Rodeo Sport vehicles that were originally sold in, or are currently registered in, Maine, New Hampshire, Vermont, Massachusetts, Rhode Island, Connecticut, New York, New Jersey, Pennsylvania, Delaware, Maryland, the District of Columbia, West Virginia, Ohio, Indiana, Michigan, Illinois, Wisconsin, Minnesota, Iowa, Kentucky and Missouri. These vehicles may experience excessive corrosion near the forward mounting point bracket for the left or right rear suspension lower link.

Risk: The corrosion may allow the bracket to detach from the frame, impacting vehicle handling and increasing the risk of a crash.

Remedy: Isuzu will notify owners, and dealers will inspect the rear suspension lower link bracket area. For vehicles in which little or no corrosion is found, the area will be treated with an anti-corrosive compound. For vehicles in which corrosion has damaged the rear suspension lower link bracket and affected its connection to the vehicle frame, a reinforcement bracket will be installed. In the event the corrosion is so severe that the reinforcement bracket remedy would not be sufficient, Isuzu will offer to repurchase the vehicle for an amount based on the Kelley Blue Book "Private Party" price. All inspections and remedies will be provided free of charge for vehicles that are 10 years old or less. For vehicles older than 10 years, Isuzu will offer a free remedy, but only if the vehicle is presented to an Isuzu service facility dealer within 12 months of when owner notifications were issued, after that time owners will be charged for the repairs. The recall is expected to begin in mid-December 2013. Isuzu owners may contact Isuzu at 1-800-255-6727.

1999 Isuzu Rodeo Campaign 10V436000 22 Sep 2010

SUSPENSION:REAR

ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.

Risk: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

1998 Isuzu Rodeo Campaign 10V436000 22 Sep 2010

SUSPENSION:REAR

ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.

Risk: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

2001 Isuzu Rodeo Campaign 10V436000 22 Sep 2010

SUSPENSION:REAR

ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.

Risk: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

2000 Isuzu Rodeo Campaign 10V436000 22 Sep 2010

SUSPENSION:REAR

ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.

Risk: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

2002 Isuzu Rodeo Campaign 10V436000 22 Sep 2010

SUSPENSION:REAR

ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.

Risk: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

1995 Isuzu Rodeo Campaign 06E065000 17 Jul 2006

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

1997 Isuzu Rodeo Campaign 06E065000 17 Jul 2006

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

1994 Isuzu Rodeo Campaign 06E065000 17 Jul 2006

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

1996 Isuzu Rodeo Campaign 06E065000 17 Jul 2006

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

1992 Isuzu Rodeo Campaign 06E065000 17 Jul 2006

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

1991 Isuzu Rodeo Campaign 06E065000 17 Jul 2006

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

1993 Isuzu Rodeo Campaign 06E065000 17 Jul 2006

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

2002 Isuzu Rodeo Campaign 05V466000 7 Oct 2005

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

CERTAIN SPORT UTILITY VEHICLES THAT HAVE BEEN EXPOSED TO FUEL CONTAMINATED WITH SILICON MAY DEVELOP SMALL PIN HOLES IN THE FUEL PUMP FEED PORT. SILICON HAS BEEN IDENTIFIED IN THE FUEL SYSTEMS OF AFFECTED VEHICLES AND IN CERTAIN FUEL AVAILABLE IN THE REGION OF TYLER, TEXAS. THIS RECALL WILL BE LAUNCHED FOR VEHICLES REGISTERED IN TEXAS AND THE FOUR SURROUNDING STATES: OKLAHOMA, ARKANSAS, NEW MEXICO AND LOUISIANA.

Risk: A FUEL LEAK COULD LEAD TO A VEHICLE FIRE.

Remedy: FOR VEHICLES REGISTERED IN THE STATES IDENTIFIED ABOVE, DEALERS WILL PROVIDE A NEW COVER OVER THE EXISTING FEED PORT ON THE FUEL PUMP OR, IF THE EXISTING FEED PORT HAS ALREADY BEEN DAMAGED, DEALERS WILL INSTALL A NEW FUEL PUMP THAT IS EQUIPPED WITH THE NEW COVER. THE NEW COVER WILL BE MADE OF A DIFFERENT MATERIAL. THE RECALL BEGAN ON NOVEMBER 25, 2005. OWNERS MAY CONTACT ISUZU AT 1-800-255-6727.

2004 Isuzu Rodeo Campaign 05V466000 7 Oct 2005

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

CERTAIN SPORT UTILITY VEHICLES THAT HAVE BEEN EXPOSED TO FUEL CONTAMINATED WITH SILICON MAY DEVELOP SMALL PIN HOLES IN THE FUEL PUMP FEED PORT. SILICON HAS BEEN IDENTIFIED IN THE FUEL SYSTEMS OF AFFECTED VEHICLES AND IN CERTAIN FUEL AVAILABLE IN THE REGION OF TYLER, TEXAS. THIS RECALL WILL BE LAUNCHED FOR VEHICLES REGISTERED IN TEXAS AND THE FOUR SURROUNDING STATES: OKLAHOMA, ARKANSAS, NEW MEXICO AND LOUISIANA.

Risk: A FUEL LEAK COULD LEAD TO A VEHICLE FIRE.

Remedy: FOR VEHICLES REGISTERED IN THE STATES IDENTIFIED ABOVE, DEALERS WILL PROVIDE A NEW COVER OVER THE EXISTING FEED PORT ON THE FUEL PUMP OR, IF THE EXISTING FEED PORT HAS ALREADY BEEN DAMAGED, DEALERS WILL INSTALL A NEW FUEL PUMP THAT IS EQUIPPED WITH THE NEW COVER. THE NEW COVER WILL BE MADE OF A DIFFERENT MATERIAL. THE RECALL BEGAN ON NOVEMBER 25, 2005. OWNERS MAY CONTACT ISUZU AT 1-800-255-6727.

1994 Isuzu Rodeo Campaign 02V281000 15 Oct 2002

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.

Risk: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.

Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MID-DECEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.

2001 Isuzu Rodeo Campaign 02V213000 9 Aug 2002

AIR BAGS:FRONTAL

ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.

Risk: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.

Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.

2000 Isuzu Rodeo Campaign 02V213000 9 Aug 2002

AIR BAGS:FRONTAL

ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER-SIDE AIR BAG INFLATOR MODULES WERE MANUFACTURED AND SHIPPED WITHOUT A NECESSARY COMPONENT KNOWN AS A CHECK VALVE PIN.

Risk: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT INFLATE PROPERLY OR SUFFICIENTLY RESULTING IN AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT.

Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST OR SEPTEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.

1999 Isuzu Rodeo Campaign 02I002000 3 Jun 2002

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ON CERTAIN SPORT UTILITY VEHICLES THAT ARE EQUIPPED WITH AN ANTI-LOCK BRAKING SYSTEM (ABS), THE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES IN CERTAIN TYPES OF BRAKING EVENTS.

Risk: EXTENDED STOPPING DISTANCE COULD RESULT, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL PROVIDE A REPLACEMENT COMPUTER ALGORITHM FOR THE ABS THAT IS BASED ON THE ALGORITHM USED IN ISUZU'S MY 2000 AND 2001 VEHICLES, WHICH HAVE NOT HAD THE PROBLEM. THIS CAMPAIGN WILL BE CONDUCTED IN PHASES, WITH THE MY 1998 2WD VEHICLES COVERED FIRST, SINCE THEY HAVE EXPERIENCED THE MOST PROBLEMS. OWNER NOTIFICATION BEGAN MARCH 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.

1998 Isuzu Rodeo Campaign 02I002000 3 Jun 2002

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ON CERTAIN SPORT UTILITY VEHICLES THAT ARE EQUIPPED WITH AN ANTI-LOCK BRAKING SYSTEM (ABS), THE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES IN CERTAIN TYPES OF BRAKING EVENTS.

Risk: EXTENDED STOPPING DISTANCE COULD RESULT, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL PROVIDE A REPLACEMENT COMPUTER ALGORITHM FOR THE ABS THAT IS BASED ON THE ALGORITHM USED IN ISUZU'S MY 2000 AND 2001 VEHICLES, WHICH HAVE NOT HAD THE PROBLEM. THIS CAMPAIGN WILL BE CONDUCTED IN PHASES, WITH THE MY 1998 2WD VEHICLES COVERED FIRST, SINCE THEY HAVE EXPERIENCED THE MOST PROBLEMS. OWNER NOTIFICATION BEGAN MARCH 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070.

1999 Isuzu Rodeo Campaign 01I002000 29 May 2001

ENGINE AND ENGINE COOLING:ENGINE

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1998-2000 RODEO (UE) AND AMIGO (UA) MODELS EQUIPPED WITH 2.2L 4-CYLINDER ENGINES. THE TIMING BELT COULD BREAK BEFORE THE RECOMMENDED SCHEDULED MAINTENANCE.

Risk: THIS CONDITION COULD CAUSE THE ENGINE TO CRANK BUT WILL NOT START OR THE ENGINE COULD STALL WHILE DRIVING AND WILL NOT RESTART.

Remedy: DEALER WILL INSPECT THE VEHICLE TO DETERMINE THE CONDITION OF THE TIMING BELT AND TENSIONER. THE DEALER WILL REPLACE THE TIMING BELT. DEPENDING ON THE CONDITION OR MODEL OF THE TIMING BELT TENSIONER, THE TENSIONER MAY ALSO BE REPLACED. ISUZU HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO REPLACE THE TIMING BELT. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS CAN CONTACT ISUZU AT 1-800-643-4070, EXT. 426, CONCERNING THIS PROGRAM.

1998 Isuzu Rodeo Campaign 01I002000 29 May 2001

ENGINE AND ENGINE COOLING:ENGINE

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1998-2000 RODEO (UE) AND AMIGO (UA) MODELS EQUIPPED WITH 2.2L 4-CYLINDER ENGINES. THE TIMING BELT COULD BREAK BEFORE THE RECOMMENDED SCHEDULED MAINTENANCE.

Risk: THIS CONDITION COULD CAUSE THE ENGINE TO CRANK BUT WILL NOT START OR THE ENGINE COULD STALL WHILE DRIVING AND WILL NOT RESTART.

Remedy: DEALER WILL INSPECT THE VEHICLE TO DETERMINE THE CONDITION OF THE TIMING BELT AND TENSIONER. THE DEALER WILL REPLACE THE TIMING BELT. DEPENDING ON THE CONDITION OR MODEL OF THE TIMING BELT TENSIONER, THE TENSIONER MAY ALSO BE REPLACED. ISUZU HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO REPLACE THE TIMING BELT. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS CAN CONTACT ISUZU AT 1-800-643-4070, EXT. 426, CONCERNING THIS PROGRAM.

2000 Isuzu Rodeo Campaign 01I002000 29 May 2001

ENGINE AND ENGINE COOLING:ENGINE

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1998-2000 RODEO (UE) AND AMIGO (UA) MODELS EQUIPPED WITH 2.2L 4-CYLINDER ENGINES. THE TIMING BELT COULD BREAK BEFORE THE RECOMMENDED SCHEDULED MAINTENANCE.

Risk: THIS CONDITION COULD CAUSE THE ENGINE TO CRANK BUT WILL NOT START OR THE ENGINE COULD STALL WHILE DRIVING AND WILL NOT RESTART.

Remedy: DEALER WILL INSPECT THE VEHICLE TO DETERMINE THE CONDITION OF THE TIMING BELT AND TENSIONER. THE DEALER WILL REPLACE THE TIMING BELT. DEPENDING ON THE CONDITION OR MODEL OF THE TIMING BELT TENSIONER, THE TENSIONER MAY ALSO BE REPLACED. ISUZU HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO REPLACE THE TIMING BELT. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS CAN CONTACT ISUZU AT 1-800-643-4070, EXT. 426, CONCERNING THIS PROGRAM.

2001 Isuzu Rodeo Campaign 01V055000 22 Feb 2001

AIR BAGS:FRONTAL

VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.

Risk: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.

Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.

2000 Isuzu Rodeo Campaign 01V055000 22 Feb 2001

AIR BAGS:FRONTAL

VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH THE INFLATORS IN THE PASSENGER SIDE AIR BAG MODULES HAVING THE WRONG AMOUNT OF GENERANT.

Risk: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, TOO MUCH GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.

Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG UNIT.

2001 Isuzu Rodeo Campaign 00V298000 5 Oct 2000

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. DURING THE MANUFACTURE OF CERTAIN FUEL RETURN HOSES, INCORRECT RUBBER MATERIAL FOR THE OUTER LAYER WAS USED.

Risk: THE FUEL RETURN HOSE DOES NOT MEET OZONE-RESISTANT SPECIFICATIONS, AND COULD ULTIMATELY CRACK, CAUSING FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE VEHICLE TO DETERMINE IF THE VEHICLE WAS EQUIPPED WITH AN INCORRECT HOSE. IF IT IS INCORRECT, DEALERS WILL REPLACE IT.

1999 Isuzu Rodeo Campaign 00V121001 28 Apr 2000

STRUCTURE:BODY

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE PERFORMANCE REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."

Risk: IN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.

Remedy: DEALERS WILL MODIFY THE INTERIOR OF YOUR VEHICLE.

1999 Isuzu Rodeo Campaign 00V058000 2 Mar 2000

SUSPENSION:REAR

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.

Risk: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.

1998 Isuzu Rodeo Campaign 00V058000 2 Mar 2000

SUSPENSION:REAR

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.

Risk: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.

1998 Isuzu Rodeo Campaign 98V170000 24 Jul 1998

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S

Risk: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.

Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.

1998 Isuzu Rodeo Campaign 97V206001 13 Nov 1997

UNKNOWN OR OTHER

VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.

Risk: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: ISUZU IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.

1995 Isuzu Rodeo Campaign 97V034001 7 Mar 1997

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

AN INTEGRATED CIRCUIT WITHIN THE VOLTAGE REGULATOR CAN CONTAIN MANUFACTURING ERRORS.

Risk: THIS CAN CAUSE EXCESSIVE ELECTRICAL CHARGING OF THE VEHICLE'S ALTERNATOR, RESULTING IN ENGINE CONTROL MALFUNCTION, AND/OR EVENTUAL ENGINE STALL.

Remedy: DEALERS WILL REPLACE THE VOLTAGE REGULATOR WITH A NEW REGULATOR.

1994 Isuzu Rodeo Campaign 97V034001 7 Mar 1997

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

AN INTEGRATED CIRCUIT WITHIN THE VOLTAGE REGULATOR CAN CONTAIN MANUFACTURING ERRORS.

Risk: THIS CAN CAUSE EXCESSIVE ELECTRICAL CHARGING OF THE VEHICLE'S ALTERNATOR, RESULTING IN ENGINE CONTROL MALFUNCTION, AND/OR EVENTUAL ENGINE STALL.

Remedy: DEALERS WILL REPLACE THE VOLTAGE REGULATOR WITH A NEW REGULATOR.

1994 Isuzu Rodeo Campaign 96V170002 17 Sep 1996

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

THE LATCH PLATE USED IN THE SEAT BELT BUCKLE WAS NOT MANUFACTURED ACCORDING TO DESIGN DIMENSIONS. IF THE SEAT BELT TONGUE IS INSERTED SLOWLY AT AN ANGLE INTO THE BUCKLE, THERE IS A POSSIBILITY OF PARTIAL ENGAGEMENT.

Risk: THIS CONDITION CAN CAUSE THE SEAT BELT TONGUE TO COME OUT OF THE BUCKLE IN THE EVENT OF A COLLISION OR HARD BRAKING OF THE VEHICLE INCREASING THE RISK OF PERSONAL INJURY TO AN OCCUPANT OF THE SEAT.

Remedy: DEALERS WILL INSPECT THE BUCKLE AND, IF NECESSARY, REPLACE THE BUCKLE ASSEMBLY WITH A NEW BUCKLE.

1994 Isuzu Rodeo Campaign 94V132000 19 Jul 1994

ENGINE AND ENGINE COOLING:ENGINE

CONSTANT EXPANSION AND CONTRACTION OF THE CYLINDER HEAD CAUSES THE CAMSHAFT SEAL END PLUG CAN BECOME DISLODGED FROM THE CYLINDER HEAD. THIS ALLOWS OIL TO LEAK FROM THE CAMSHAFT.

Risk: THIS CAN CAUSE ENGINE DAMAGE AND POSSIBLE ENGINE FIRE FROM OIL LEAKING ONTO THE HOT EXHAUST SYSTEM.

Remedy: DEALERS WILL INSTALL CAMSHAFT END SEAL PLUG RETAINER PLATES.

1993 Isuzu Rodeo Campaign 94V132000 19 Jul 1994

ENGINE AND ENGINE COOLING:ENGINE

CONSTANT EXPANSION AND CONTRACTION OF THE CYLINDER HEAD CAUSES THE CAMSHAFT SEAL END PLUG CAN BECOME DISLODGED FROM THE CYLINDER HEAD. THIS ALLOWS OIL TO LEAK FROM THE CAMSHAFT.

Risk: THIS CAN CAUSE ENGINE DAMAGE AND POSSIBLE ENGINE FIRE FROM OIL LEAKING ONTO THE HOT EXHAUST SYSTEM.

Remedy: DEALERS WILL INSTALL CAMSHAFT END SEAL PLUG RETAINER PLATES.

1991 Isuzu Rodeo Campaign 91V118000 12 Jul 1991

POWER TRAIN:AUTOMATIC TRANSMISSION

THE TRANSMISSION FLUID LEVEL GAUGES (DIP STICKS) INSTALLED IN THESE VEHICLES ARE NOT TO DESIGNED SPECIFICATIONS. THE GAUGE INDICATES THAT TRANSMISSION FLUID SHOULD BE ADDED WHEN IT IS AT THE CORRECT LEVEL.

Risk: ADDING MORE TRANSMISSION FLUID THAN REQUIRED WILL CAUSETHE FLUID TO LEAK THROUGH THE FLUID LEVEL GAUGE TUBE ONTO THE MANIFOLD AS THEENGINE TEMPERATURE RISES. THIS CREATES A POTENTIAL FOR A FIRE.

Remedy: REPLACE OIL LEVEL GAUGE AND NOTIFY OWNERS TO USE ONLY THE SPECIFIED AMOUNT OF AUTOMATIC TRANSMISSION FLUID.

Isuzu Rodeo recalls in Canada

Transport Canada runs its own recall programme. Its campaigns do not always mirror the American ones, so a Canadian owner reading a US-only list is reading about a different car than the one on their driveway.

1999 Isuzu Rodeo Recall 2010341 8 Oct 2010 3,876 units in Canada

Suspension

Certain vehicles operated in areas of heavy road de-icing material usage (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador) may experience excessive corrosion in the vicinity of the left or right forward mounting point bracket for the rear suspension lower link, prior to the time that such corrosion would normally be expected. In certain cases, excessive corrosion in this vicinity may result in the left or right rear suspension lower link bracket becoming detached from the frame, which can affect vehicle handling and potentially cause a crash resulting in property damage or personal injury. Correction: Inspection and repairs will be provided free of charge for vehicles that are ten years old or less. For vehicles over ten years old, GM of Canada will offer the same free remedy, but only if the vehicle is presented to a GM dealer no later than twelve (12) months after the owner notification letter mailing date.

1998 Isuzu Rodeo Recall 2010341 8 Oct 2010 3,876 units in Canada

Suspension

Certain vehicles operated in areas of heavy road de-icing material usage (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador) may experience excessive corrosion in the vicinity of the left or right forward mounting point bracket for the rear suspension lower link, prior to the time that such corrosion would normally be expected. In certain cases, excessive corrosion in this vicinity may result in the left or right rear suspension lower link bracket becoming detached from the frame, which can affect vehicle handling and potentially cause a crash resulting in property damage or personal injury. Correction: Inspection and repairs will be provided free of charge for vehicles that are ten years old or less. For vehicles over ten years old, GM of Canada will offer the same free remedy, but only if the vehicle is presented to a GM dealer no later than twelve (12) months after the owner notification letter mailing date.

2001 Isuzu Rodeo Recall 2010341 8 Oct 2010 3,876 units in Canada

Suspension

Certain vehicles operated in areas of heavy road de-icing material usage (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador) may experience excessive corrosion in the vicinity of the left or right forward mounting point bracket for the rear suspension lower link, prior to the time that such corrosion would normally be expected. In certain cases, excessive corrosion in this vicinity may result in the left or right rear suspension lower link bracket becoming detached from the frame, which can affect vehicle handling and potentially cause a crash resulting in property damage or personal injury. Correction: Inspection and repairs will be provided free of charge for vehicles that are ten years old or less. For vehicles over ten years old, GM of Canada will offer the same free remedy, but only if the vehicle is presented to a GM dealer no later than twelve (12) months after the owner notification letter mailing date.

2000 Isuzu Rodeo Recall 2010341 8 Oct 2010 3,876 units in Canada

Suspension

Certain vehicles operated in areas of heavy road de-icing material usage (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador) may experience excessive corrosion in the vicinity of the left or right forward mounting point bracket for the rear suspension lower link, prior to the time that such corrosion would normally be expected. In certain cases, excessive corrosion in this vicinity may result in the left or right rear suspension lower link bracket becoming detached from the frame, which can affect vehicle handling and potentially cause a crash resulting in property damage or personal injury. Correction: Inspection and repairs will be provided free of charge for vehicles that are ten years old or less. For vehicles over ten years old, GM of Canada will offer the same free remedy, but only if the vehicle is presented to a GM dealer no later than twelve (12) months after the owner notification letter mailing date.

2002 Isuzu Rodeo Recall 2010341 8 Oct 2010 3,876 units in Canada

Suspension

Certain vehicles operated in areas of heavy road de-icing material usage (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador) may experience excessive corrosion in the vicinity of the left or right forward mounting point bracket for the rear suspension lower link, prior to the time that such corrosion would normally be expected. In certain cases, excessive corrosion in this vicinity may result in the left or right rear suspension lower link bracket becoming detached from the frame, which can affect vehicle handling and potentially cause a crash resulting in property damage or personal injury. Correction: Inspection and repairs will be provided free of charge for vehicles that are ten years old or less. For vehicles over ten years old, GM of Canada will offer the same free remedy, but only if the vehicle is presented to a GM dealer no later than twelve (12) months after the owner notification letter mailing date.

2001 Isuzu Rodeo Recall 2003247 14 Oct 2003 2,976 units in Canada

Lights And Instruments

Certain vehicles fail to conform to CMVSS 135 "Passenger Car Brake System". The brake warning lamp may not illuminate in the event of decreased brake fluid level. Correction: Dealer will replace the current brake fluid warning circuit diode with a newly designed diode.

2000 Isuzu Rodeo Recall 2003247 14 Oct 2003 2,976 units in Canada

Lights And Instruments

Certain vehicles fail to conform to CMVSS 135 "Passenger Car Brake System". The brake warning lamp may not illuminate in the event of decreased brake fluid level. Correction: Dealer will replace the current brake fluid warning circuit diode with a newly designed diode.

2002 Isuzu Rodeo Recall 2003247 14 Oct 2003 2,976 units in Canada

Lights And Instruments

Certain vehicles fail to conform to CMVSS 135 "Passenger Car Brake System". The brake warning lamp may not illuminate in the event of decreased brake fluid level. Correction: Dealer will replace the current brake fluid warning circuit diode with a newly designed diode.

2001 Isuzu Rodeo Recall 2000298 15 Dec 2000 86 units in Canada

Fuel System

On certain vehicles, a fuel return hose may not contain the desired ozone protection which could result in the hose having a reduced life expectancy. Over time, the hose may deteriorate and leak fuel. Correction: Dealers will inspect the fuel return hose date code and replace the hose if required.

1999 Isuzu Rodeo Recall 2000085 24 Mar 2000 2,416 units in Canada

Suspension

On certain vehicles, paint may have been applied unevenly on the rear axles. In cases where the paint was too thick, the allotted drying time may have resulted in insufficient paint hardness. Should this occur on the surface that contacts the rear axle lower link bracket bolt head and/or nut, the nut may later loosen. If the nut should detach fully separation of the lower link from the rear axle could occur. This may result in loss of vehicle control and a possible crash. Correction: Dealers will remove the rear axle lower trailing link nuts and bolts and replace them with new self-lock nuts and bolts.

1998 Isuzu Rodeo Recall 2000085 24 Mar 2000 2,416 units in Canada

Suspension

On certain vehicles, paint may have been applied unevenly on the rear axles. In cases where the paint was too thick, the allotted drying time may have resulted in insufficient paint hardness. Should this occur on the surface that contacts the rear axle lower link bracket bolt head and/or nut, the nut may later loosen. If the nut should detach fully separation of the lower link from the rear axle could occur. This may result in loss of vehicle control and a possible crash. Correction: Dealers will remove the rear axle lower trailing link nuts and bolts and replace them with new self-lock nuts and bolts.

1998 Isuzu Rodeo Recall 1999203 29 Oct 1999 228 units in Canada

Emissions

Certain V6 Rodeo do not comply with the requirements of CMVSS 1105 - Evaporative Emissions. The rubber purge hose of the Enhanced Evaporative Emission Control System (EVAP) may crack, due to proximity of the exhaust pipe. Correction: Dealers will install an EVAP pipe and hose assembly using a clearance template, and will inspect routing clearances after installation.

1998 Isuzu Rodeo Recall 1999038 15 Mar 1999 793 units in Canada

Electrical

On certain vehicles, the engine wire harness ground connection terminal may fracture due to improper crimping. In a case where the terminal is fractured, the powertrain control module (PCM) may misinterpret the damage as a signal indicating a high vehicle speed. The PCM will then cut the fuel causing a "no-start" condition or an engine stall. Correction: Wire harness will be replaced with a new harness.

1995 Isuzu Rodeo Recall 1997101 20 May 1997 792 units in Canada

Electrical

THE VOLTAGE REGULATOR MAY CONTAIN MANUFACTURING ERRORS IN AN INTEGRATED CIRCUIT. THIS MAY CAUSE EXCESSIVE ELECTRICAL CHARGING OF THE ALTERNATOR (OVERCHARGE), RESULTING IN ENGINE CONTROL MALFUNCTION, AND/OR IN THE WORST CASE, EVENTUAL ENGINE STALL. THE POSSIBLE CAUSE OF THIS CONDITION IS A FAULTY IC REGULATOR IN THE ALTERNATOR. CORRECTION: IC REGULATOR WILL BE REPLACED WITH A NEW IC REGULATOR. WHEN REPAIRS ARE COMPLETED, A PERFORMANCE CHECK WILL BE DONE TO VERIFY PROPER FUNCTIONING OF THE CHARGING INDICATOR LIGHT AND PROPER BATTERY VOLTAGE OUTPUT.

1994 Isuzu Rodeo Recall 1997101 20 May 1997 792 units in Canada

Electrical

THE VOLTAGE REGULATOR MAY CONTAIN MANUFACTURING ERRORS IN AN INTEGRATED CIRCUIT. THIS MAY CAUSE EXCESSIVE ELECTRICAL CHARGING OF THE ALTERNATOR (OVERCHARGE), RESULTING IN ENGINE CONTROL MALFUNCTION, AND/OR IN THE WORST CASE, EVENTUAL ENGINE STALL. THE POSSIBLE CAUSE OF THIS CONDITION IS A FAULTY IC REGULATOR IN THE ALTERNATOR. CORRECTION: IC REGULATOR WILL BE REPLACED WITH A NEW IC REGULATOR. WHEN REPAIRS ARE COMPLETED, A PERFORMANCE CHECK WILL BE DONE TO VERIFY PROPER FUNCTIONING OF THE CHARGING INDICATOR LIGHT AND PROPER BATTERY VOLTAGE OUTPUT.

1994 Isuzu Rodeo Recall 1996164 11 Oct 1996 288 units in Canada

Seats And Restraints

VEHICLES MAY EXHIBIT A CONDITION IN WHICH THERE IS THE POSSIBILITY OF PARTIAL ENGAGEMENT OF THE LATCH PLATE INTO THE TYPE-521 MODEL SEAT BELT BUCKLE (FALSE LATCH). THIS COULD RESULT IN FAILURE OF THE SEAT BELT SYSTEM TO PROVIDE PROPER OCCUPANT RESTRAINT IN THE EVENT OF A CRASH OR SUDDEN STOP. CORRECTION: BELT BUCKLES WILL BE INSPECTED FOR THE AFFECTED LOT NUMBERS AND REPLACED IF NECESSARY.

1991 Isuzu Rodeo Recall 1995129 6 Jul 1995 113,044 units in Canada

Seats And Restraints

THE (Takata) ABS PLASTIC FRONT SEAT BELT RELEASE BUTTONS ON THESE VEHICLES MAY BREAK ALLOWING PLASTIC PIECES TO FALL INTO THE BUCKLE ASSEMBLY. IF THIS SHOULD HAPPEN, A NO LATCH, FALSE LATCH OR FAILURE TO UNLATCH CONDITION COULD OCCUR CREATING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH OR SUDDEN STOP. CORRECTION: FRONT SEAT BELT BUCKLES WILL BE REPAIRED OR REPLACED AS NECESSARY.

1994 Isuzu Rodeo Recall 1994124 29 Jul 1994 2,600 units in Canada

Engine

VEHICLES WITH 3.2 LITRE ENGINES MAY EXPERIENCE DISLODGING OF THE CAMSHAFT END PLUG(S) FROM THE CYLINDER HEADS CAUSING RAPID OIL LOSS. OIL SPILLING ON THE EXHAUST SYSTEM COULD RESULT IN AN ENGINE COMPARTMENT FIRE. CORRECTION: A CAMSHAFT END PLUG RETAINING PLATE KIT WILL BE INSTALLED ON AFFECTED VEHICLES.

1993 Isuzu Rodeo Recall 1994124 29 Jul 1994 2,600 units in Canada

Engine

VEHICLES WITH 3.2 LITRE ENGINES MAY EXPERIENCE DISLODGING OF THE CAMSHAFT END PLUG(S) FROM THE CYLINDER HEADS CAUSING RAPID OIL LOSS. OIL SPILLING ON THE EXHAUST SYSTEM COULD RESULT IN AN ENGINE COMPARTMENT FIRE. CORRECTION: A CAMSHAFT END PLUG RETAINING PLATE KIT WILL BE INSTALLED ON AFFECTED VEHICLES.

1992 Isuzu Rodeo Recall 1993133 22 Sep 1993 2,926 units in Canada

Powertrain

NOTE: VEHICLES EQUIPPED WITH V6 ENGINE AND AUTOMATIC TRANSMISSION. THE AUTOMATIC TRANSMISSION DIPSTICK MUST BE PROPERLY REINSTALLED AFTER CHECKING THE FLUID LEVEL. IF THE DIPSTICK IS NOT LOCKED, LEAKING AUTOMATIC TRANSMISSION FLUID MAY CONTACT THE EXHAUST MANIFOLD AND RESULT IN AN ENGINE COMPARTMENT FIRE. CORRECTION: A WARNING TAG WILL BE INSTALLED TO THE DIPSTICK CAP TO SERVE AS A REMINDER TO ALWAYS LOCK THE DIPSTICK AFTER CHECKING THE FLUID LEVEL AND NOT TO OVERFILL WITH AUTOMATIC TRANSMISSION FLUID.

1991 Isuzu Rodeo Recall 1993133 22 Sep 1993 2,926 units in Canada

Powertrain

NOTE: VEHICLES EQUIPPED WITH V6 ENGINE AND AUTOMATIC TRANSMISSION. THE AUTOMATIC TRANSMISSION DIPSTICK MUST BE PROPERLY REINSTALLED AFTER CHECKING THE FLUID LEVEL. IF THE DIPSTICK IS NOT LOCKED, LEAKING AUTOMATIC TRANSMISSION FLUID MAY CONTACT THE EXHAUST MANIFOLD AND RESULT IN AN ENGINE COMPARTMENT FIRE. CORRECTION: A WARNING TAG WILL BE INSTALLED TO THE DIPSTICK CAP TO SERVE AS A REMINDER TO ALWAYS LOCK THE DIPSTICK AFTER CHECKING THE FLUID LEVEL AND NOT TO OVERFILL WITH AUTOMATIC TRANSMISSION FLUID.

1991 Isuzu Rodeo Recall 1991103 9 Jul 1991 157 units in Canada

Engine

ON VEHICLES WITH AUTOMATIC TRANSMISSION AND V6 ENGINE, OVERFILLING OF TRANSMISSION OIL IN CONJUNCTION WITH HIGH OIL TEMPERATURE, COULD CAUSE OIL TO FLOOD THROUGH THE AIR BLEED GROOVE IN THE OIL LEVEL GAUGE PLUG. LEAKING OIL COULD WET THE EXHAUST MANIFOLD AND RESULT IN AN ENGINE COMPARTMENT FIRE. CORRECTION: DEALERS WILL INSTALL A NEW AUTOMATIC TRANSMISSION DIPSTICK WITH AN IMPROVED PLUG DESIGN AND CLEARER OIL LEVEL MARKS.

Source: Transport Canada Vehicle Recalls Database.