2018 KIA Niro other reported problems

UNKNOWN OR OTHER

I am writing to request assistance regarding a recurring issue with Recall SC276. Approximately two years ago, I had the hydraulic clutch actuator (HCA) replaced by a dealership as part of this recall. Since then, the vehicle has been driven only 10,000 miles, bringing the total mileage to about 45,000. The vehicle recently broke down, and the dealership confirmed that the replacement HCA has failed. Despite this being the same part addressed by the recall, the dealership quoted $1,700 for the repair, and Kia has declined to cover the cost. I believe Kia should be responsible for this replacement, as the recalled part was intended to provide a long-term solution to a safety issue. I would appreciate any help you can provide in ensuring Kia covers the cost of this repair.

NHTSA complaint #11740074 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The vehicle just shut down as I exited. The power and gas pressure decreased. Pulled over to see if my hybrid battery was defective or drained. It wasn’t. A notification popped up and said “Hybrid Control System or Low Voltage DC/DC Converter, Contact dealer for service. Finally got it towed to Kia of Valencia the next day and they said it was “Hydraulic Clutch Actuator” and they want charge me $2200 to fix it. But looking up the part, it says there’s a recall for that exact problem.

NHTSA complaint #11739377 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

hybrid battery warning paid out of pocket for towing, car still at the dealership, loss of income and wages, been treated with awful customer services, and paying out of pocket. Car went in on June 25

NHTSA complaint #11602496 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Nothing has happened yet, but I am very concerned about my car catching on fire due to the recall notice I received. I want it fixed ASAP!

NHTSA complaint #11553924 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

On March 28, 2023 the vehicle HEV warning light came on. I called the dealership where I was informed they did not have any mechanics available to look at it until August. No one to work on Hybrid. I then took it to a mechanic shop, And I was informed to take it to the dealer. I could not drive the vehicle. I called KIA, Temple Hills back, I was told if you tow the vehicle here it will just sit. April 8, 2023 had it towed to another shop, the mechanic stated he thought it was the battery, which I was informed hybrid has 3 batteries, to check with the dealer to see if they had them, or could order one. Called the dealership Temple Hills, stathat they had never heard of a battery for that car. I was told to call back next week, after he spoke with the parts dept. manager. I called back a week later, and was told they knew nothing about a Kia Niro, could not help. The mechanic looked for a battery at other shops, ebay. The one I Paid 600.00dollars for did not work. After being there for 1 month. I called Kia dealership Bowie Md. On June 6, 2023 spoke with Jacob, the advisor. The vehicle was towed there, Jacob refused to give me any updates on the vehicle after 1 month being there, just sitting. I would call him trying to get updates, he informed me that they only had one mechanic, just a whole lot of nothing, the vehicle could catch on fire. Another month passed and I went to the dealership, along with my brother. Jacob was not answering my calls/returning them. Vehicle just sitting there. Jacob, then said the mechanic that worked on the hybrid was out for surgery, he would be in touch. I asked for the Kia Corporate number, which I received. I contacted Kia, corporate on July 13, 2023, spoke with them several times, informing them that the vehicle was not operable, and I was still making car notes/ paying insurance on a vehicle that I was not driving. At the dealership now for 3 months. Jacob, not communicating I can email you documents/fax, all paperwork.

NHTSA complaint #11549759 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My 2018 Kia Niro EX keeps overheating. We purchased the vehicle July 21st 2018. Three months after purchase, the vehicle dies, flashing warning lights and a message appeared to shut the engine off. Our car was towed to the dealership we purchased it from. After over three months, the dealership calls and tells us to pick the car up from them. The entire engine had to be replaced. We sued Kia Motors through the lemon law. We settled for the payment option because the engine was replaced. Now, our hands are tied due to once we took the cash settlement, we were no longer able to take legal action again if we had any additional issues. Over the course of the last three years, we had to have it repaired for a wiring issue, now, our vehicle continually overheats. Our dealership where we purchased the vehicle does not have a hybrid technician to work on it. We have to drive to another location of theirs to have it serviced. That location is over an hour drive. Our car is unable to be driven to have it properly service by the correct technician. There is an online forum, www.kianiroforum.com. This forum explains in detail what type of issue the consumer is experiencing with this vehicle. I am reaching out due to this overheating issue could cause serious harm to someone. We have spoken with Kia corporate headquarters, their advice is to have it looked at by a Kia dealership and they will go from there. We have exhausted all of our options to have these issues looked into and now reaching out to you for assistance. Myself included, it appears this vehicle has many many issues and needs to be brought to someone’s attention that has the power to get something done.

NHTSA complaint #11432667 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

REAR HATCH INDICATOR SUDDENLY COMES ON WHILE DRIVING AND REAR HATCH OPENS ON OWN. EVEN AFTER HARD SLAMMING SHUT HATCH IS NOT LATCHING ALL THE TIME AND RANDOMLY LOOSENING AND OPENING ON ITS OWN. LOUD RATTLE IS ALSO COMING FROM REAR OF VEHICLE. THIS IS A NEWLY PURCHASED AUTOMOBILE.

NHTSA complaint #11129850 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

BOTH THE RIGHT PASSENGER DOOR HANDLE AND REAR DRIVES SIDE DOOR HANDLE HAVE COME OFF, IN BOTH CASES A PASSENGER WAS OPENING THE DOOR TO ENTER THE VEHICLE WHEN THE DOOR HANDLE FAILED AND CAME OFF. THE LAST INCIDENT BACK DOOR OCCURRED 9/7

NHTSA complaint #11128443 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

NO INCIDENT TO REPORT. DESIGN SAFETY ISSUE. THE DESIGN OF THE EMERGENCY LIFTGATE SAFETY RELEASE REQUIRES THE USE OF THE VEHICLE'S MECHANICAL KEY TO EXIT THE VEHICLE THROUGH THE REAR LIFTGATE IN AN EMERGENCY (SEE OWNERS MANUAL PAGE 4-26. THE NEED TO HAVE A KEY IN HAND UTTERLY DEFEATS THE INTENDED CONCEPT OF AN EMERGENCY RELEASE. THIS DESIGN WOULD BE COMPLETELY UNACCEPTABLE FOR THE TRUNK OF A SEDAN AND IT SHOULD ALSO BE UNACCEPTABLE FOR A HATCHBACK OR LIFTGATE. A RELATIVELY INEXPENSIVE FIX WOULD BE TO INSTALL A SIMPLE METAL LEVER IN THE DOOR THROUGH THE SLOT PROVIDED FOR INSERTING THE KEY. I HAVE HAD OTHER VEHICLES WITH SIMILAR EMERGENCY RELEASE MECHANISMS. I DO NOT KNOW HOW WIDE SPREAD THIS IS THROUGH THE INDUSTRY OR IF THERE ARE IN FACT DIFFERENT STANDARDS. I WOULD URGE NHTSA TO REQUIRE MANUFACTURERS TO MAKE ALL DOORS OPENABLE FROM THE INSIDE WITHOUT THE NEED FOR A KEY OR ANY OTHER TOOL, ESPECIALLY WHERE IT IS SPECIFICALLY IDENTIFIED AS AN EMERGENCY MEANS OF EXIT. THANK YOU FOR ALL YOUR EFFORTS TO KEEP THE DRIVING PUBLIC SAFE. SINCERELY (XXXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #11123599 — an unverified report by a vehicle owner.