2003 KIA Sedona brake problems

SERVICE BRAKES

TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING 35 MPH, THE BRAKE PEDAL SEIZED HALFWAY DOWN WHEN IT WAS DEPRESSED. AS A RESULT, THE CONTACT SWERVED ONTO THE SIDEWALK AND STOPPED 30 YARDS IN A PARKING LOT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ELECTRIC COMPUTER BRAKING MODULE DID NOT ALLOW THE BRAKES TO STOP COMPLETELY; THEREFORE, THE COMPUTER REACTED AS IF THE VEHICLE WERE TRAVELING ON ICE. THE DEALER (MORITZ KIA HURST, 110 NE LOOP 820, HURST, TX 76053, (817) 591-7063) STATED THAT THERE WAS NO RECALL FOR THE FAILURE. THE MANUFACTURER STATED THAT THEY WOULD HAVE THE DEALER INSPECT THE VEHICLE FOR FREE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 115,800.

NHTSA complaint #11121586 — an unverified report by a vehicle owner.

SERVICE BRAKES

ABS LIGHT ON FRONT BRAKES ON DRIVERS SIDE NOT WORKING RIGHT

NHTSA complaint #10744840 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT STATED THAT WHEN DRIVING APPROXIMATELY 25 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE FRONT DRIVER SIDE BRAKE FAILED TO RESPOND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A MECHANIC, WHERE IT WAS DIAGNOSED THAT THE ABS SYSTEM FAILED TO ALLOW BRAKE FLUID TO RUN THROUGH. IN ADDITION, THE OUTLET VALVE BECAME STUCK IN THE LOCK POSITION AND THE ABS UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. MA 10/22/2015 UPDATED 9/27/2017

NHTSA complaint #10692897 — an unverified report by a vehicle owner.

SERVICE BRAKES

I BOUGHT A 2003 SEDONA USED IN 2007 WITH ABOUT 50000 MILES AND HAVE NOTHING BUT PROBLEMS EVER SINCE. 1ST IN 7/08 I WENT TO A LOCAL SHOP (NOT KIA) BECAUSE MY ENGINE SEEMED VERY LOUD. THE MECHANIC TOLD ME I NEEDED NEW MOTOR MOUNTS N THAT IT WAS KIND OF UNUSUAL FOR A CAR TO NEED THEM SO SOON. I DID CALL KIA N ASK THEM ABOUT THIS AND WAS BASICALLY TOLD TO BAD FOR YOU. SO I HAD THEM FIXED ($556.36). NOT EVEN A FEW WEEKS LATER MY AC WAS BLOWING HOT. SAME MECHANIC TOLD ME MY AC WAS OUT N THAT ONE OF THE HOSES NEEDED REPLACED. HAD TO WAIT A FEW YEARS BUT HAD IT REPLACED ($1050.72). HAD MY 1ST BRAKE JOB DONE IN 2008 EVER SINCE I'VE HAD TO HAVE MY BRAKES REPLACE 2-3 YEARLY PLUS HAD TO HAVE NEW CALIPERS. NO ONE CAN TELL ME WAY THE BREAKPADS WEAR OUT SO QUICKLY. I DONT DRIVE A UNUSUAL AMOUNT. I'VE HAD TO REPLACE 2 INTERIOR DOOR HANDLE AND NOW HAVE A BROKEN EXTERIOR HANDLE. MY AIR BAG LIGHT STAYS ON WHILE I DRIVE WHICH SCARES ME READING OTHERS AIRBAG STORIES. WHEN I TRY TO FILL MY CAR WITH GAS THE PUMP WILL CLICK OFF AFTER A DOLLAR OR 2 LIKE ITS FULL BUT ITS NOT. AND JUST A WEEK OR SO AGO I WAS OB THE HIGHWAY WITH THE CRUUSE CONTROL ON ALL OF A SUDDEN I SMELT THIS OVERPOWERING SMELL OF GAS. I PULLED OVER AND CHECKED BUT DIDNT SEE ANYTHING WRONG. CONTINUED DRIVING AGAIN SMELLED GAS TRIED TURNING OFF THE AC DIDNT HELP. TRIED TURNING OFF THE CRUISE CONTROL THE SMELL INSTANTLY STOPPED. I HOPE THAT SOMETHING CAN B DONE TO HELP ME AND THE OTHERS WITH KIAS. I HAVE SOME OF MY REPAIR PAPERWORK. IF YOU HAVE QUESTIONS FOR ME PLEASE CALL ME.

NHTSA complaint #10533434 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING APPROXIMATELY 20 MPH THE LEFT REAR WHEEL SEPARATED FROM THE VEHICLE. HE WAS ABLE TO PULL OVER ON THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE GARAGE. THE MANUFACTURER DID NOT TAKE A REPORT. THE ESTIMATED COST FOR THE REPAIR WAS $400.00. THE WHEEL BEARING SEALS, BREAK DRUM, AND MOUNTAIN PLATE MIGHT NEED TO BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 130,000.

NHTSA complaint #10297424 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

HOSES, LINES CORRODED LEAKING COOLANT ALL OVER THE GARAGE AND CAR OVERHEATING ONLY 4 YEARS OLD. BREAK LINES IN REAR VERY CORRODED AND READY TO FAIL. REPLACE ASAP, MECHANIC SAYS.

NHTSA complaint #10266112 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

I HAVE A 2003 KIA SEDONA AND I HAVE HAD NOTHING BUT ISSUES. ANYWHERE FROM HAVING TO REPLACE THE ALTERNATOR, WHICH I WILL SAY WAS A PAIN IN THE BUTT...TO MAJOR ISSUES WITH THE BRAKES. FROM READING MANY DIFFERENT SITES THIS IS NOT AN UNCOMMON ISSUE!!!!!!!!!!!! IT IS JUST SO FRUSTRATING THAT YOU PURCHASE A VAN BECAUSE THEY SAY IT IS GREAT THEN YOU GET THIS PIECE OF JUNK. THE SAD THING IS MOST PEOPLE WHO OWN THESE ARE YOUNG COUPLES WITH CHILDREN AND CAN NOT AFFORD THE REPAIRS BUT HAVE TO PAY FOR THEM AND WE ARE STUCK WITH THESES TRASH BOXES BECAUSE WE HAVE CHILDREN AND CAN NOT AFFORD TO GO OUT AND TRADE IT IN, LOSE OUR BUTTS BECAUSE THEY ARE NOT WORTH THE MONEY WE OWE ON THEM. I CAN NOT AFFORD TO KEEP FIXING THIS HEAP OF JUNK BUT I AM STUCK WITH IT. I HOPE THAT SOMETHING GETS DONE WITH THESE...THEY ARE WORTHLESS AND MY CHILDREN ARE PAYING FOR IT!!!!!!!!!!!!!!!!!!!!!!!!!!!! I HAVE NOT HAD A VEHICLE SO BAD IN MY LIFE...I AM TIRED OF REPLACING THE BRAKES, ROUTERS, AND NOW THE CALIPERS!!!!!!!!!!!!!

NHTSA complaint #10246852 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE

TL*THE CONTACT OWNS A 2003 KIA SEDONA. SHE RECEIVED A RECALL NOTICE FOR THE WHEEL BEARINGS, BRAKE LIGHTS, AND THE VEHICLE SPEED CONTROL. THE DEALER REFUSED TO HONOR HER RECALL NOTICE SINCE THE VIN WAS NOT INCLUDED. THE CONTACT PROVIDED THE DEALER WITH COPIES OF THE RECALL NOTICE WITH HER VEHICLE INFORMATION LISTED AND THEY DECLINED TO REPAIR THE RECALL. THE MANUFACTURER ADMITTED THAT HER VEHICLE IS INCLUDED IN THE RECALLS BASED UPON THE VIN. THE CONTACT RETURNED TO THE DEALER; HOWEVER, THEY DID NOT HONOR THE RECALL AFTER CONFIRMING THAT SHE RECEIVED APPROVAL FROM THE MANUFACTURER. SHE IS CURRENTLY RESPONSIBLE TO ASSUME THE COST FOR REPAIRS RELATED TO THE RECALLS. THE FAILURE AND CURRENT MILEAGES WERE 79,291. THE NHTSA CAMPAIGN ID NUMBER(S) ARE: 03V158000 , 05V013000 , 05V232000.

NHTSA complaint #10214353 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:ANTILOCK

TL*THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING 25 MPH, THE VEHICLE FAILED TO BRAKE AT A SAFE DISTANCE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES TO REPLACE THE BRAKE PADS AND THE ROTOR. THE DEALER STATED THAT THE CONTACT IS DRIVING THE VEHICLE IMPROPERLY AND CAUSING THE BRAKES TO WEAR OUT. THE CONTACT STATED THAT THE AIR BAG INDICATOR DOES NOT APPEAR ON THE DASHBOARD. THE CURRENT MILEAGE IS 100,000 AND FAILURE MILEAGE WAS 96,283.

NHTSA complaint #10193387 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

CAR HAS BEEN HUGE HEADACHE BOUGHT NEW IN 2003 HAS BEEN TOWED TWICE FOR LEAKING COOLANT LINES THAT RUSTED OUT. LAST TIME WAS ON VACATION KIA HAS NOT RETURNED ON PHONE CALL OR E-MAIL AS IT COST ME 300 DOLLARS AND CAR IS UNDER BUMPER TO BUMPER WARRANTY HAS 34K MILES . DRIVERS DOOR HANDLE BROKE AND AIRBAG LIGHT WAS ON FIXED BY DEALER. ONE BRAKE PAD LINING FELL OFF AT 25K MILES REPLACED MYSELF. MOST IMPORTANT WE HAD A REAR TIRE BLOW OUT AT 60 MPH IN THREE LANES OF TRAFFIC. TIRE SHREDDED APART WITH 28K MILES AND WAS NEW YORK INSPECTED 2 MONTHS EARLIER. OTHER BACK TIRE BUBBLED OUT ON ONE SIDE AND MADE THE CAR SHUDDER. REPLACED TIRES MYSELF BUT PLEASE INVESTIGATE THIS CAR NOW I AM REALLY WORRIED AFTER READING ABOUT THE AIRBAGS NOT DEPLOYING.

NHTSA complaint #10167006 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

DT*: THE CONTACT STATED THAT THE VEHICLE EXPERIENCED CONTINUOUS BRAKE PROBLEMS. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES WHO REPAIRED OR REPLACED THE BRAKES AND ROTORS EVERY TIME PROBLEMS REOCCURRED. THE DEALER DETERMINED THAT THE PROBLEMS WERE DUE TO NORMAL WEAR AND TEAR ALTHOUGH THE VEHICLE'S PROBLEMS OCCURRED 2 MONTHS AFTER THE VEHICLE WAS PURCHASED. THE MANUFACTURER WAS CONTACTED AND WOULD NOT STATE THE CAUSE OF THE PROBLEM. THE CONTACT BELIEVES THAT THE PROBLEMS ARE A MANUFACTURER DEFECT.

NHTSA complaint #10164018 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

DT*: THE CONTACT STATED THAT THE VEHICLE EXPERIENCED CONTINUOUS BRAKE PROBLEMS. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES WHO REPAIRED OR REPLACED THE BRAKES AND ROTORS EVERY TIME PROBLEMS REOCCURRED. THE DEALER DETERMINED THAT THE PROBLEMS WERE DUE TO NORMAL WEAR AND TEAR ALTHOUGH THE VEHICLE'S PROBLEMS OCCURRED 2 MONTHS AFTER THE VEHICLE WAS PURCHASED. THE MANUFACTURER WAS CONTACTED AND WOULD NOT STATE THE CAUSE OF THE PROBLEM. THE CONTACT BELIEVES THAT THE PROBLEMS ARE A MANUFACTURER DEFECT.

NHTSA complaint #10164018 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

2003 KIA SEDONA DEVELOPED PROBLEMS WITH THE BRAKE EQUIPMENT.*MR THE CONSUMER NOTICED LOUD NOISES AND BRAKE PEDAL FADE WHEN THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO THE DEALER ON THREE DIFFERENT OCCASIONS BUT EACH TIME THE PROBLEM PERSISTED.

NHTSA complaint #10130249 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

WE'VE HAD MANY PROBLEMS W/ KIA SEDONA. THE BIGGEST HAS BEEN BRAKES/ROTORS. WE NOTICED A LOUD GRINDING NOISE & VIBRATION NOT EVEN A YEAR AFTER WE GOT IT, ESPECIALLY WHEN GOING DOWNHILL. CONTACTED DEALER & THEY REPLACED THE ROTORS AT 13,000 MILES. NOT EVEN 4,000 MILES LATER THEY WERE BACK IN THE SAME CONDITION. TOOK THE VAN TO A BRAKE SERVICE CENTER (NOT THE DEALER) TO HAVE THE BRAKE PADS CHANGED & WAS TOLD THE ROTORS WERE WARPED. I EXPLAINED TO THE MAN WHAT WE HAD BEEN THROUGH & HE FELT STRONGLY THAT IT WAS A DEFECT. CONTACTED OUR DEALER AGAIN AND TOOK THE VAN IN. WAS NOT EVEN THERE 10 MINUTES, THEY DID NOT WANT TO HEAR IT! WOULD NOT DO ANYTHING FOR US! SO FAR, WE ARE TOLD WE CAN ONLY PURCHASE ROTORS DIRECTLY FROM THE MANUF. & SO FAR, THE ROTORS THAT HAVE BEEN ON THIS VAN FROM THE MANUF. HAVE NOT BEEN GOOD! I'VE TALKED TO SEVERAL OTHER KIA SEDONA OWNERS & THEY HAVE EXPRESSED THE SAME PROBLEM WITH THEIR VEHICLE!! WE ARE SORRY FOR TRYING A KIA! THE AIRBAG LIGHT CAME ON APPROX. 3 WKS AGO AND STAYS ON ALL THE TIME THAT THE VAN IS ON! I TOOK IT IN FOR SERVICE AND WAS TOLD THERE'S A DEFECT IN THE PASSENGER SIDE SEAT BELT BUCKLE BUT THEY HAD NONE IN STOCK SO HAD TO ORDER IT. WAS TOLD THAT THE AIRBAG PROBABLY WOULD NOT DEPLOY IF WE'RE IN AN ACCIDENT BUT THEY DID NOT SEEM TO MIND LETTING US DRIVE AROUND LIKE THAT FOR AN UNDETERMINED AMOUNT OF TIME. SAID THEY WOULD SEND A CARD IN THE MAIL WHEN THEY GET THE PART IN! THE PASSENGER'S SIDE WINDOW STARTED NOT WORKING! ABOUT EVERY OTHER DAY IT WOULD JUST STOP! I TOLD THE SERVICE DEPT ABOUT THIS AT THE SAME TIME I TOOK THE VAN IN FOR THE AIRBAG LIGHT & WAS TOLD, WELL ITS NOT DOING IT RIGHT NOW SO WE CAN'T DO ANYTHING ABOUT IT! THE WINDOW IS STILL GIVING US PROBLEMS BUT ABOUT EVERY DAY NOW INSTEAD OF EVERY OTHER! WE'VE TRIED TO TRADE THIS VEHICLE IN A FEW TIMES & WE CAN ONLY GET ABOUT HALF OF WHAT WE OWE ON IT! WE WERE EVEN TOLD ABOUT A WEEK AGO THAT THERE ARE MAJOR PROBLEMS WITH THE CLEARCOAT ON IT!

NHTSA complaint #10128995 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

2003 KIA SEDONA HAS PROBLEMS WITH ABS SYSTEM, STALLING AND ABS LIGHT FLASHING ON THE DASHBOARD.***NO ANSWER REQUIRED***. *MR THE ABS LIGHT FLASHED WHEN IT RAINED ON WHEN THE ROADS WERE WET. THE DEALER WAS UNABLE TO DUPLICATE THE CONSUMERS CONCERNS.

NHTSA complaint #10119169 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

THE ACCELERATOR PEDAL AND BRAKE PEDAL ARE LEVELED TOO CLOSE TOGETHER, CAUSING THE DRIVER TO HIT BOTH PEDALS AT THE SAME. TIME, MAKING IT DIFFICULT TO CONTROL THE SPEED OF THE VEHICLE. *AK THE CONSUMER STATED THAT THE HARDER SHE PRESSED ON THE BRAKE THE HIGHER THE ENGINE REVVED UP.

NHTSA complaint #10109168 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

WHEN APPLYING THE BRAKES FROM LOW SPEEDS, THE PEDAL INTERMITTENTLY WENT TO THE FLOOR. AS A RESULT EXTENDED STOPPING DISTANCE OCCURRED. *JB KIA REPLACED THE BRAKES AND THE CONSUMER HAD NOT EXPERIENCED A BRAKE PROBLEM SINCE.

NHTSA complaint #10096550 — an unverified report by a vehicle owner.

PARKING BRAKE

I'VE HAD MANY PROBLEMS WITH MY 2003 KIA SEDONA. THE EMERGENCY BRAKE HAS NEVER BEEN RIGHT. THE BRAKES WERE REPLACED AT 13K MILES, AGAIN AT 24K MILES (FRONT & BACK) AND I'M SURE THEY NEED TO BE REPLACED AGAIN AT 40K MILES. AT 22K MILES I TOOK THE VAN TO THE SHOP FOR BRAKES ONLY TO BE TOLD THAT BOTH WHEEL BEARINGS, THE LEFT STRUT (THEY REFUSED TO REPLACE BOTH STRUTS SINCE IT WAS WARRANTY BUT IF I WAS PAYING FOR THE REPAIRS THEY WOULD RECOMEND REPLACING IN PAIRS) AND THE POWER STEERING PUMP WAS GOING OUT (WHICH THE MANAGER SAID HE WAS DOING ME A FAVOR BY TELLING ME ABOUT). I HAVE ALSO COMPLAINED OF THE A/C TAKING FOREVER TO COOL DOWN, HAD A SENSOR REPLACED FOR THE GAS TANK AFTER THE CHECK ENGINE LIGHT CAME ON AND SERVICE TO THE DRIVERS SEATBELT. THEN YESTERDAY DURING A STORM I WENT THROUGH A PUDDLE ABOUT 4 OR 5 INCHES DEEP WHICH SPLASHED WATER ON MY VAN FOR A COUPLE OF SECONDS AND ABOUT 50 FEET DOWN THE ROAD THE VAN DIED AND COULD NOT BE RESTARTED. UPON HAVING IT TOWED TO THE KIA DEALER I WAS TOLD THAT MY AIRFILTER HAD GOTTEN WET AND THAT THERE WAS "DISH SOAP" IN MY AIRFILTER WHICH WOULD BE CONSIDERED CUSTOMER DAMAGE AND NOT COVERED BY WARRANTY. I ALSO COMPLAINED ABOUT MORE NOISES COMING FROM THE FRONT AND A GRINDING NOISE WHEN I BEGIN ACCELERATION IN LOW GEARS. THEY REQUESTED I MAKE AN APPOINTMENT FOR SERVICE ON THOSE ISSUES. IN ADDITION, I PURCHASED THIS VEHICLE ON 4/23/03, WHEN I TRIED TO FILE A COMPLAINT ABOUT MY SERVICE ON THE WHEEL BEARING, ETC WITH KIA THEY HAD NO RECORD OF ME EVER PURCHASING THIS VAN. APPARENTLY IN THEIR MINDS MY VAN WAS SOLD TO SOMEONE ELSE ON 2/27/03. THIS MEANS IF THERE IS EVER A RECAL OR SERVICE NOTICE SENT OUT I WOULD NOT RECEIVE THEM. IN ADDITION THEY HAD MY WARRANTY EXPIRATION DATE SET AT 2/27/03. I SPOKE WITH SEVERAL PEOPLE CONCERNING THIS ISSUE AND WAS ASSURED THAT THIS WOULD IMMEDIATELY BE CORRECTED, HOWEVER YESTERDAY WHEN I CALLED FOR ASSISTANCE I WAS TOLD THAT THE VAN WAS STILL LISTED AS BEING SOLD TO ANOTHER PERSON.

NHTSA complaint #10091216 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:DRUM:SHOES/LININGS

I'VE HAD MANY PROBLEMS WITH MY 2003 KIA SEDONA. THE EMERGENCY BRAKE HAS NEVER BEEN RIGHT. THE BRAKES WERE REPLACED AT 13K MILES, AGAIN AT 24K MILES (FRONT & BACK) AND I'M SURE THEY NEED TO BE REPLACED AGAIN AT 40K MILES. AT 22K MILES I TOOK THE VAN TO THE SHOP FOR BRAKES ONLY TO BE TOLD THAT BOTH WHEEL BEARINGS, THE LEFT STRUT (THEY REFUSED TO REPLACE BOTH STRUTS SINCE IT WAS WARRANTY BUT IF I WAS PAYING FOR THE REPAIRS THEY WOULD RECOMEND REPLACING IN PAIRS) AND THE POWER STEERING PUMP WAS GOING OUT (WHICH THE MANAGER SAID HE WAS DOING ME A FAVOR BY TELLING ME ABOUT). I HAVE ALSO COMPLAINED OF THE A/C TAKING FOREVER TO COOL DOWN, HAD A SENSOR REPLACED FOR THE GAS TANK AFTER THE CHECK ENGINE LIGHT CAME ON AND SERVICE TO THE DRIVERS SEATBELT. THEN YESTERDAY DURING A STORM I WENT THROUGH A PUDDLE ABOUT 4 OR 5 INCHES DEEP WHICH SPLASHED WATER ON MY VAN FOR A COUPLE OF SECONDS AND ABOUT 50 FEET DOWN THE ROAD THE VAN DIED AND COULD NOT BE RESTARTED. UPON HAVING IT TOWED TO THE KIA DEALER I WAS TOLD THAT MY AIRFILTER HAD GOTTEN WET AND THAT THERE WAS "DISH SOAP" IN MY AIRFILTER WHICH WOULD BE CONSIDERED CUSTOMER DAMAGE AND NOT COVERED BY WARRANTY. I ALSO COMPLAINED ABOUT MORE NOISES COMING FROM THE FRONT AND A GRINDING NOISE WHEN I BEGIN ACCELERATION IN LOW GEARS. THEY REQUESTED I MAKE AN APPOINTMENT FOR SERVICE ON THOSE ISSUES. IN ADDITION, I PURCHASED THIS VEHICLE ON 4/23/03, WHEN I TRIED TO FILE A COMPLAINT ABOUT MY SERVICE ON THE WHEEL BEARING, ETC WITH KIA THEY HAD NO RECORD OF ME EVER PURCHASING THIS VAN. APPARENTLY IN THEIR MINDS MY VAN WAS SOLD TO SOMEONE ELSE ON 2/27/03. THIS MEANS IF THERE IS EVER A RECAL OR SERVICE NOTICE SENT OUT I WOULD NOT RECEIVE THEM. IN ADDITION THEY HAD MY WARRANTY EXPIRATION DATE SET AT 2/27/03. I SPOKE WITH SEVERAL PEOPLE CONCERNING THIS ISSUE AND WAS ASSURED THAT THIS WOULD IMMEDIATELY BE CORRECTED, HOWEVER YESTERDAY WHEN I CALLED FOR ASSISTANCE I WAS TOLD THAT THE VAN WAS STILL LISTED AS BEING SOLD TO ANOTHER PERSON.

NHTSA complaint #10091216 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:DISC:ROTOR

I'VE HAD MANY PROBLEMS WITH MY 2003 KIA SEDONA. THE EMERGENCY BRAKE HAS NEVER BEEN RIGHT. THE BRAKES WERE REPLACED AT 13K MILES, AGAIN AT 24K MILES (FRONT & BACK) AND I'M SURE THEY NEED TO BE REPLACED AGAIN AT 40K MILES. AT 22K MILES I TOOK THE VAN TO THE SHOP FOR BRAKES ONLY TO BE TOLD THAT BOTH WHEEL BEARINGS, THE LEFT STRUT (THEY REFUSED TO REPLACE BOTH STRUTS SINCE IT WAS WARRANTY BUT IF I WAS PAYING FOR THE REPAIRS THEY WOULD RECOMEND REPLACING IN PAIRS) AND THE POWER STEERING PUMP WAS GOING OUT (WHICH THE MANAGER SAID HE WAS DOING ME A FAVOR BY TELLING ME ABOUT). I HAVE ALSO COMPLAINED OF THE A/C TAKING FOREVER TO COOL DOWN, HAD A SENSOR REPLACED FOR THE GAS TANK AFTER THE CHECK ENGINE LIGHT CAME ON AND SERVICE TO THE DRIVERS SEATBELT. THEN YESTERDAY DURING A STORM I WENT THROUGH A PUDDLE ABOUT 4 OR 5 INCHES DEEP WHICH SPLASHED WATER ON MY VAN FOR A COUPLE OF SECONDS AND ABOUT 50 FEET DOWN THE ROAD THE VAN DIED AND COULD NOT BE RESTARTED. UPON HAVING IT TOWED TO THE KIA DEALER I WAS TOLD THAT MY AIRFILTER HAD GOTTEN WET AND THAT THERE WAS "DISH SOAP" IN MY AIRFILTER WHICH WOULD BE CONSIDERED CUSTOMER DAMAGE AND NOT COVERED BY WARRANTY. I ALSO COMPLAINED ABOUT MORE NOISES COMING FROM THE FRONT AND A GRINDING NOISE WHEN I BEGIN ACCELERATION IN LOW GEARS. THEY REQUESTED I MAKE AN APPOINTMENT FOR SERVICE ON THOSE ISSUES. IN ADDITION, I PURCHASED THIS VEHICLE ON 4/23/03, WHEN I TRIED TO FILE A COMPLAINT ABOUT MY SERVICE ON THE WHEEL BEARING, ETC WITH KIA THEY HAD NO RECORD OF ME EVER PURCHASING THIS VAN. APPARENTLY IN THEIR MINDS MY VAN WAS SOLD TO SOMEONE ELSE ON 2/27/03. THIS MEANS IF THERE IS EVER A RECAL OR SERVICE NOTICE SENT OUT I WOULD NOT RECEIVE THEM. IN ADDITION THEY HAD MY WARRANTY EXPIRATION DATE SET AT 2/27/03. I SPOKE WITH SEVERAL PEOPLE CONCERNING THIS ISSUE AND WAS ASSURED THAT THIS WOULD IMMEDIATELY BE CORRECTED, HOWEVER YESTERDAY WHEN I CALLED FOR ASSISTANCE I WAS TOLD THAT THE VAN WAS STILL LISTED AS BEING SOLD TO ANOTHER PERSON.

NHTSA complaint #10091216 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

WHILE DRIVING AT ANY SPEED CONSUMER FELT SEVERE VIBRATION IN THE STEERING WHEEL AND THE BRAKE PEDAL. DEALER CLAIMED THAT THE BRAKE ROTORS OVERHEATED, CAUSING THEM TO WARP.

NHTSA complaint #10063163 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

WHILE DRIVING 45 MPH BRAKES FAILED.

NHTSA complaint #10055584 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:ANTILOCK

CONSUMER COMPLAINED ABOUT A BRAKE PROBLEM. MANUFACTURER ISSUED A RECALL, BUT DEALERSHIP WAS UNAWARE OF THE RECALL AND CONTINUED TO SELL THESE VEHICLES.

NHTSA complaint #10055426 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR

WHEN BRAKING AT SPEEDS OVER 45 MPH THE VEHICLE SHUTTERS AND VIBRATES. FELT LIKE THE ROTOR IS WARPED, BUT THE VEHICLE ONLY HAS 12,000 MILES.

NHTSA complaint #10043257 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

WHILE DRIVING AT 55 MPH THERE WAS A LOUD NOISE, LIKE A MOTORCYCLE, COMING FROM RIGHT BRAKE ON PASSENGER'S SIDE. DEALER HAD INSPECTED VEHICLE AND COULD NOT DUPLICATE OR CORRECT THE PROBLEM.

NHTSA complaint #10039805 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

WHEN BRAKES ARE APPLIED AT 55 MPH VEHICLE SHUTTERS AND SOUDS LIKE BRAKES ARE UNDER A LOT OF PRESSURE.

NHTSA complaint #10026793 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

AIR IN THE BRAKE LINE CAUSED THE BRAKES TO FAIL WITHOUT WARNING. THE LINES WERE SERVICED BUT THE PROBLEM RECURRED. *NLM

NHTSA complaint #10018065 — an unverified report by a vehicle owner.