Owners have filed 11 complaints
about the 2019 KTM 790 Adventure R with NHTSA between 2020 and 2024.
The largest single group is the brakes.
Across this model's run it ranks 2 of 3 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 27
Against the median year of the KTM 790 Adventure R. 50 means typical for this
model; 100 means roughly double.
Severity — 0
0% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
100% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2019 compares with every other KTM 790 Adventure R
Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade:
A
B
C
D
F
ungraded
What breaks on a 2019 KTM 790 Adventure R
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Brakes
545.5%
Median failure at 3,030 miles
Engine & Cooling
218.2%
Fuel & Propulsion
19.1%
Suspension
19.1%
Median failure at 10,000 miles
Steering
19.1%
Median failure at 10,000 miles
Electrical System
19.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jun 2020peak 5Apr 2024
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Katy, TX
ENGINE
At only 9000 miles, intake camshaft and follower catastrophically damaged. Routine valve clearance check at 4th oil change (much more frequent than recommended). KTM ultimately provided the parts as “goodwill”, but refused to cover labour. Numerous other reports of similar failures being reported in group forums. Also note that clutch also failed catastrophically at 3k miles. Similar situation where KTM covered parts under “goodwill”, but not labour. Similarly: there have been hundreds of others sharing stories of same failure. Bike was purchased while I was living in Texas, but failures occurred in Canada, where I have relocated and imported the bike.
NHTSA complaint #11581180 — an unverified report by a vehicle owner.
Stanwood, WA
ELECTRICAL SYSTEM
The Display screen that offers all the info for the motorcycle has condensation inside. The motorcycle is always garaged other than when it's being ridden. There is still condensation inside the display. Sometimes vital motorcycle information isn't visible, such as ABS mode, Traction control mode, speed, rpm, etc. Vehicle has not been inspected. Through the forums I have heard many stories of others having the same issue and dealers replacing the screen in some cases if the condensation is bad enough but the issue usually returns.
NHTSA complaint #11448739 — an unverified report by a vehicle owner.
Lincoln, IL
ENGINE
Hello, I purchased this motorcycle new in July 2019. It currently has 9,100 miles. Since new it takes a minimum of 3-4 times to start and stay running at first start of the day. After that it starts easy and on the first try. Temperature at first start has been anywhere from upper 30's° to upper 70's°. Altitude from 500' - 4,500', basically starts the same in all instances. It seems as if it's only running on one cylinder and then "chuffs" and dies. Repeat, repeat, repeat. When it finally "catches" R.P.M. will rise up around 1,500ish R.P.M. and run smoothly. On its first few attempts the engine will barely make it to 900-1,000 R.P.M. before dying. Thank you for your assistance with this issue.
NHTSA complaint #11445681 — an unverified report by a vehicle owner.
Lincoln, IL
FUEL/PROPULSION SYSTEM
Hello, I purchased this motorcycle new in July 2019. It currently has 9,100 miles. Since new it takes a minimum of 3-4 times to start and stay running at first start of the day. After that it starts easy and on the first try. Temperature at first start has been anywhere from upper 30's° to upper 70's°. Altitude from 500' - 4,500', basically starts the same in all instances. It seems as if it's only running on one cylinder and then "chuffs" and dies. Repeat, repeat, repeat. When it finally "catches" R.P.M. will rise up around 1,500ish R.P.M. and run smoothly. On its first few attempts the engine will barely make it to 900-1,000 R.P.M. before dying. Thank you for your assistance with this issue.
NHTSA complaint #11445681 — an unverified report by a vehicle owner.
Venice, CA
SERVICE BRAKES
AT APPROX 5K MILES MY FRONT BRAKE STARTED GRABBING AND PULSING AT LOW SPEEDS UNDER CONSTANT LEVER PRESSURE. IT EVENTUAL GOT SO BAD THAT I FELT I COULDNT SAFELY CONTROL THE BIKE WHEN USING THE FRONT BRAKE AT LOW SPEEDS. THE DEALER WAS ABLE TO GET A WARRANTY REPLACEMENT OF THE DISKS AND PADS. APPROXIMATELY 5K MILES LATER THE PROBLEM HAS REOCCURED. THIS TIME KTM REFUSED TO COVER THE COST SO THE DEALER SUGGESTED I TRY A 3RD PARTY DISK AND PAD REPLACEMENT. ONLINE AT ADVRIDER.COM, A MOTORCYCLE FORUM THERE ARE 16 PAGES OF POSTS INCLUDING VIDEO'S WITH SEVERAL INSTANCES OF RIDERS HAVE THEIR FRONT BRAKES LOCK UP WHILE RIDING AND NOT BEING APPLIED RESULTING IN THE RIDER BEING THROWN OFF THE BIKE. I THINK THE PROBLEM IS VERY DANGEROUS AND COULD RESULT IN RIDERS BEING KILLED.
NHTSA complaint #11383590 — an unverified report by a vehicle owner.
at 10,000 milesRedding, CA
STEERING
MY BIKE HAS HAD AND STILL DOES HAVE MULTIPLE PROBLEMS SHOCK FAILED TWICE, REAR BRAKE HOSE MELTED AND MADE BRAKES UNUSABLE WHILE I WAS ON A TRIP IN MEXICO FRONT BRAKES EXPERIENCED PULSATING SENSATION THAT PROGRESSIVELY GOT WORSE, KTM REPLACE THE BRAKE ROTORS AND FRONT WHEEL HUB, THE COUNTER SHAFT SPROCKET LEAKED OIL, KTM REPAIRED IT, BUT IT'S LEAKING AGAIN, THE ENGINE USES A QUART OF OIL EVERY 150 MILES A BOLT ON THE STEERING HEAD BROKE WHILE I WAS RIDING CAUSING A LOOSE SENSATION IN THE STEERING
NHTSA complaint #11382801 — an unverified report by a vehicle owner.
at 10,000 milesRedding, CA
SUSPENSION
MY BIKE HAS HAD AND STILL DOES HAVE MULTIPLE PROBLEMS SHOCK FAILED TWICE, REAR BRAKE HOSE MELTED AND MADE BRAKES UNUSABLE WHILE I WAS ON A TRIP IN MEXICO FRONT BRAKES EXPERIENCED PULSATING SENSATION THAT PROGRESSIVELY GOT WORSE, KTM REPLACE THE BRAKE ROTORS AND FRONT WHEEL HUB, THE COUNTER SHAFT SPROCKET LEAKED OIL, KTM REPAIRED IT, BUT IT'S LEAKING AGAIN, THE ENGINE USES A QUART OF OIL EVERY 150 MILES A BOLT ON THE STEERING HEAD BROKE WHILE I WAS RIDING CAUSING A LOOSE SENSATION IN THE STEERING
NHTSA complaint #11382801 — an unverified report by a vehicle owner.
at 2,000 milesHarrisburg, PA
SERVICE BRAKES
THE MOTORCYCLE FRONT BRAKES STARTED PULSING AND GRABBING DURING BRAKING AT ALL SPEEDS. IT WAS MORE NOTICEABLE AT SPEEDS BELOW 20MPH WHEN COMING TO A COMPLETE STOP.
NHTSA complaint #11382783 — an unverified report by a vehicle owner.
at 10,000 milesRedding, CA
SERVICE BRAKES
MY BIKE HAS HAD AND STILL DOES HAVE MULTIPLE PROBLEMS SHOCK FAILED TWICE, REAR BRAKE HOSE MELTED AND MADE BRAKES UNUSABLE WHILE I WAS ON A TRIP IN MEXICO FRONT BRAKES EXPERIENCED PULSATING SENSATION THAT PROGRESSIVELY GOT WORSE, KTM REPLACE THE BRAKE ROTORS AND FRONT WHEEL HUB, THE COUNTER SHAFT SPROCKET LEAKED OIL, KTM REPAIRED IT, BUT IT'S LEAKING AGAIN, THE ENGINE USES A QUART OF OIL EVERY 150 MILES A BOLT ON THE STEERING HEAD BROKE WHILE I WAS RIDING CAUSING A LOOSE SENSATION IN THE STEERING
NHTSA complaint #11382801 — an unverified report by a vehicle owner.
at 4,060 milesWashington, DC
SERVICE BRAKES
ALL THREE BRAKE ROTORS (2 FRONT, 1 REAR) ARE COMING LOOSE FROM THEIR SUPPORT POINTS WITH THE VEHICLE HAVING JUST OVER 4,000 MILES ON IT. THERE IS NO WAY TO TIGHTEN THE ROTORS. OTHER RIDERS HAVE REPORTED CATASTROPHIC BRAKING FAILURES AS A RESULT. A VIDEO OF THE LOOSE ROTORS IS AVAILABLE HERE: HTTPS://PHOTOS.APP.GOO.GL/WH9RTBWQKG9T6TYN9
NHTSA complaint #11372614 — an unverified report by a vehicle owner.
at 1,200 milesBerkeley, CA
SERVICE BRAKES
WARPED FRONT ROTORS CAUSE STRONG PULSING WHEN FRONT BRAKE APPLIED WHICH IS DESTABILIZING WHEN ON CURVY MOUNTAIN ROADS OR AT HIGHWAY SPEEDS AND SUDDEN BRAKING REQUIRED. FRONT ROTORS WARPED WITH 1200 MILES ON THE ODOMETER AND KTM REFUSED TO REPLACE UNDER WARRANTY SAYING THIS IS A "WEAR ITEM". ROTOR THICKNESS IS WEAR BUT WARPING IS NOT WEAR, ESPECIALLY ON A NEW BIKE. HAVING DONE MORE RESEARCH ONLINE SINCE MY FIRST ATTEMPT TO GET ROTORS REPLACED LAST YEAR, I SEE IT HAS AFFECTED NUMEROUS OTHER OWNERS, SOME OF WHICH HAVE SUCCESSFULLY HAD ROTORS REPLACED UNDER WARRANTY OTHERS NOT. I BROUGHT INTO DEALER AGAIN LAST MONTH TO SEE IF THEY WOULD REPLACE BUT AGAIN WAS REFUSED. NOT SURE WHY SOME DEALERS / OWNERS HAVE BEEN SUCCESSFUL GETTING WARRANTY DONE BUT SEEM LIKE A KNOWN ISSUE TO KTM AND SHOULD BE RECALL. THANKS FOR YOUR ATTENTION TO THE MATTER
NHTSA complaint #11331598 — an unverified report by a vehicle owner.