Owners have filed 54 complaints
about the 2024 Lexus TX with NHTSA between 2024 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 1 of 3 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 66
Against the median year of the Lexus TX. 50 means typical for this
model; 100 means roughly double.
Severity — 77
14.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — not reported
Too few complaints recorded a mileage to measure this.
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2024peak 6Sep 2026
Recalls on the 2024 Lexus TX
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
26V162000
BACK OVER PREVENTION:SOFTWARE
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2025 Lexus NX350, NX250, 2023-2026 RX350, and 2024-2026 TX350 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Risk: A rearview image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
25V744000
BACK OVER PREVENTION:DISPLAY FUNCTION
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Risk: A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
25V595000
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.
Risk: An instrument panel display that does not show critical information can increase the risk of a crash or injury.
24V461000
AIR BAGS:SIDE/WINDOW:CURTAIN
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024 Toyota Grand Highlander, Grand Highlander Hybrid, Lexus TX350, TX500 Hybrid, and TX550 Hybrid+ vehicles. The driver and passenger side curtain air bags may not unroll as intended and could partially deploy outside of an open window. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 226, "Ejection Mitigation."
Risk: An improper deployment of the side curtain air bag can reduce occupant protection during a crash, increasing the risk of injury.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202546970,480 units in Canada
Visual System
Issue: On certain vehicles, a software problem could cause the combination meter in the instrument panel not to display when the vehicle is started. As a result, you may not be able to see certain information about the vehicle, including the speedometer, fuel gauge, warning lights and malfunction tell-tales. Note: This recall only affects vehicles equipped with a 12.3-inch display. Safety Risk: Warnings, tell-tales and gauges that don't display could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and advise you to take your vehicle to a dealership to update the combination meter software. Alternatively, certain eligible vehicles will be sent a wireless over-the-air software update, which you can install yourself. For certain vehicles, the dealer will also inspect and, if necessary, replace the combination meter.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 18,000 milesVilla Rica, GACrash1 injured
SEAT BELTS
The contact owns a 2024 Lexus TX. The contact stated that while driving at 41 MPH, a vehicle ran a stop sign while distracted and hit the contact's vehicle. The contact was able to swerve and avoid a head-on collision. The contact's vehicle was struck on the right driver's side toward the rear bumper. The vehicle was pushed off the road, where it came to a stop. The driver-side and passenger-side air bags did not deploy. The driver-side and passenger-side air bags did not deploy. The driver-side seatbelt did not lock as intended. From the impact, the contact was propelled over the center console. The contact was taken to the hospital by ambulance. The contact suffered a concussion and sustained injuries to the neck, both knees, hip, her back, and right foot. The contact was scheduled for physical therapy and suffers from post-concussion syndrome. A police report was filed. There were no passengers in the vehicle. The vehicle was towed to Mayfield Wrecker Service, and then it was towed to the dealer. The cosmetic part was repaired on the vehicle. However, the safety issues were not repaired. The vehicle is at the residence. The insurance company was contacted. The contact related the failure of the side curtain air bags to NHTSA Campaign Number: 24V461000 (Air Bag). However, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 18,000.
NHTSA complaint #11697253 — an unverified report by a vehicle owner.
at 18,000 milesVilla Rica, GACrash1 injured
AIR BAGS
The contact owns a 2024 Lexus TX. The contact stated that while driving at 41 MPH, a vehicle ran a stop sign while distracted and hit the contact's vehicle. The contact was able to swerve and avoid a head-on collision. The contact's vehicle was struck on the right driver's side toward the rear bumper. The vehicle was pushed off the road, where it came to a stop. The driver-side and passenger-side air bags did not deploy. The driver-side and passenger-side air bags did not deploy. The driver-side seatbelt did not lock as intended. From the impact, the contact was propelled over the center console. The contact was taken to the hospital by ambulance. The contact suffered a concussion and sustained injuries to the neck, both knees, hip, her back, and right foot. The contact was scheduled for physical therapy and suffers from post-concussion syndrome. A police report was filed. There were no passengers in the vehicle. The vehicle was towed to Mayfield Wrecker Service, and then it was towed to the dealer. The cosmetic part was repaired on the vehicle. However, the safety issues were not repaired. The vehicle is at the residence. The insurance company was contacted. The contact related the failure of the side curtain air bags to NHTSA Campaign Number: 24V461000 (Air Bag). However, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 18,000.
NHTSA complaint #11697253 — an unverified report by a vehicle owner.
at 10,750 milesCanton, MSCrash1 injured
AIR BAGS
The contact owned a 2024 Lexus TX350. The contact stated while driving 15-20 MPH from a complete stop and making a left turn, another vehicle who was driving at an undisclosed speed, crashed into the front passenger's side end of the vehicle, causing the front end of the vehicle to separate. The contact shifted into park(P), and the vehicle stopped on the road. The other vehicle continued to accelerate and veered off into a ditch. The contact did not recall whether there were warning lights illuminated after the incident. The contact stated that several messages indicating the brake system, the Advance Autosonic detection, the Intelligence alert, the ABS, the parking brake, the electric power steering, the electronic stability control systems malfunctions, and other malfunctions were displayed on the vehicle mobile app. The contact stated that the front driver's side air bag and the knee air bag failed to deploy as intended and partially deployed. The contact sustained whiplash and hit her knees against the dashboard during the incident. The contact sustained neck, hips and legs pain. The ambulance transported the contact to the hospital, where a CT scan and X-Rays were performed, and the contact was informed that an internal neck injury was found. Additionally, the contact's legs had become swollen between the knees and the ankles. The contact stated that she was in the process of receiving further medical assistance. A police report was filed but the contact did not have the police report information available. The vehicle was towed and totaled by the insurance company. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 10,750.
NHTSA complaint #11629239 — an unverified report by a vehicle owner.
Port St Lucie, FLCrash
UNKNOWN OR OTHER
On 3 different occurrences. Regarding rear-left gate foot sensor. Vehicle rear lift-gate as closed when feet are planted on ground while unloading groceries from the vehicle. This claim has also been confirm with dealership as Diagnostics Technician was able to duplicate issue. First incident hit spouse on the head. Second time hit myself. 3rd was able to dodge lift-gate closing down. Treasure Coast Lexus Diagnostics technician advised to disable feature and when needed to enable. That doesn't resolve the safety issue as the occurrence of lift-gate closing could still occur when feature is enabled. New vehicle purchase 5/21/2024. Its at dealership waiting for repairs.
NHTSA complaint #11595746 — an unverified report by a vehicle owner.
Port St Lucie, FLCrash
ELECTRICAL SYSTEM
On 3 different occurrences. Regarding rear-left gate foot sensor. Vehicle rear lift-gate as closed when feet are planted on ground while unloading groceries from the vehicle. This claim has also been confirm with dealership as Diagnostics Technician was able to duplicate issue. First incident hit spouse on the head. Second time hit myself. 3rd was able to dodge lift-gate closing down. Treasure Coast Lexus Diagnostics technician advised to disable feature and when needed to enable. That doesn't resolve the safety issue as the occurrence of lift-gate closing could still occur when feature is enabled. New vehicle purchase 5/21/2024. Its at dealership waiting for repairs.
NHTSA complaint #11595746 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Morton, IL
ENGINE
I am reporting a severe, systemic vehicle performance discrepancy on my Lexus TX 500h (2.4L Turbo Hybrid powertrain). The vehicle is officially labeled with an EPA rating of 27 MPG combined. However, under normal, conservative driving conditions, the vehicle routinely achieves only 20 to 21 MPG—a consistent 20%+ shortfall from the manufacturer's certified window sticker metrics. This has drastically limited the vehicle's safe total driving range to under 300 miles per tank. The shortfall persists despite cautious driving in Eco Mode and after passing the engine break-in period. This issue matches a widespread pattern reported by numerous other owners in consumer forums, pointing to a potential defect in the vehicle’s fuel management software or hybrid battery management logic. I request that NHTSA log this tracking data to investigate whether the manufacturer misrepresented the vehicle's real-world operational capabilities or fuel-system integration.
NHTSA complaint #11762981 — an unverified report by a vehicle owner.
Morton, IL
FUEL/PROPULSION SYSTEM
I am reporting a severe, systemic vehicle performance discrepancy on my Lexus TX 500h (2.4L Turbo Hybrid powertrain). The vehicle is officially labeled with an EPA rating of 27 MPG combined. However, under normal, conservative driving conditions, the vehicle routinely achieves only 20 to 21 MPG—a consistent 20%+ shortfall from the manufacturer's certified window sticker metrics. This has drastically limited the vehicle's safe total driving range to under 300 miles per tank. The shortfall persists despite cautious driving in Eco Mode and after passing the engine break-in period. This issue matches a widespread pattern reported by numerous other owners in consumer forums, pointing to a potential defect in the vehicle’s fuel management software or hybrid battery management logic. I request that NHTSA log this tracking data to investigate whether the manufacturer misrepresented the vehicle's real-world operational capabilities or fuel-system integration.
NHTSA complaint #11762981 — an unverified report by a vehicle owner.
Escondido, CA
UNKNOWN OR OTHER
I had my foot on the brakes waiting at a red light. The car just started jerking back and forth. It didn’t stop until I released my foot off the brake.
NHTSA complaint #11761621 — an unverified report by a vehicle owner.
Amarillo, TX
UNKNOWN OR OTHER
I am filing this complaint regarding my 2024 Lexus TX. A road rock/debris entered through the vehicle’s factory front grille and struck/punctured the A/C condenser, causing the air conditioning system to stop functioning properly. The repair cost is approximately $2,500. The factory grille has large openings that leave the condenser vulnerable to direct impact from normal road debris. Lexus does not have a protective screen or guard that can be installed to prevent this type of damage. This design flaw has affected many other Lexus TX owners and I think they need to offer up more protective measures to avoid this from happening over and over again.
NHTSA complaint #11760559 — an unverified report by a vehicle owner.
Phoenix, AZ
UNKNOWN OR OTHER
Strong smell of gas coming from around the car and near rear end of car. Usually after a drive. The smell does not happen after every drive. I brought up the smell to my husband a number of times within the year…and finally took to JD Auto in Arizona in June but the gas smell could not be replicated and no source or defect could be visually seen. No recall for this has been reported by Lexus. dealership. No check engine light has been recorded. Worried that there is some internal issue that could cause huge problems. I do have children who have also reported smelling the gas in the back seat.
NHTSA complaint #11758619 — an unverified report by a vehicle owner.
Phoenix, AZ
FUEL/PROPULSION SYSTEM
Strong smell of gas coming from around the car and near rear end of car. Usually after a drive. The smell does not happen after every drive. I brought up the smell to my husband a number of times within the year…and finally took to JD Auto in Arizona in June but the gas smell could not be replicated and no source or defect could be visually seen. No recall for this has been reported by Lexus. dealership. No check engine light has been recorded. Worried that there is some internal issue that could cause huge problems. I do have children who have also reported smelling the gas in the back seat.
NHTSA complaint #11758619 — an unverified report by a vehicle owner.
Waikoloa, HI
STRUCTURE:BODY:HOOD
On two occasions while driving my hood has become open due to windy conditions coming from the Makua side of the highway as I’m driving on the Queen Kaahumanu Highway Today was the second incident except that I was heading south The first time that happened I was driving north and it occurred probably about a few months ago, but I dismissed it I know for a fact that I did not open the engine compartment I will download my front camera files and see if I can find a record
NHTSA complaint #11739417 — an unverified report by a vehicle owner.
Waikoloa, HI
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
On two occasions while driving my hood has become open due to windy conditions coming from the Makua side of the highway as I’m driving on the Queen Kaahumanu Highway Today was the second incident except that I was heading south The first time that happened I was driving north and it occurred probably about a few months ago, but I dismissed it I know for a fact that I did not open the engine compartment I will download my front camera files and see if I can find a record
NHTSA complaint #11739417 — an unverified report by a vehicle owner.
Greensboro, NC
UNKNOWN OR OTHER
I have 2024 Lexus TX 350 and the winshield cracked from the smallest rock and spread across the entire winshield. Seems to be a flaw in material.
NHTSA complaint #11735662 — an unverified report by a vehicle owner.
San Antonio, TX
UNKNOWN OR OTHER
Starting in drive with the brakes depressed, when trying to accelerate with the gas pedal, the vehicle will not activate the engine from electric mode(EV). The car will not accelerate even with the gas pedal fully depressed. It has happened four times so far. Safety issue because when I’m pulling out into traffic to make a left or right turn, the car will not accelerate and therefore can get hit by oncoming traffic, especially when I am trying to merge into a lane with oncoming traffic. The car crawls and will not accelerate. My car is a hybrid vehicle. It almost feels as if the non electric engine doesn’t kick on when it is supposed to. The car will crawl for about 5-10 seconds before the engines engages and kicks on the acceleration. There are no warning lights or indication that anything is malfunctioning when this happens. I have not taken the vehicle in to the dealer yet.
NHTSA complaint #11730468 — an unverified report by a vehicle owner.
San Antonio, TX
ENGINE
Starting in drive with the brakes depressed, when trying to accelerate with the gas pedal, the vehicle will not activate the engine from electric mode(EV). The car will not accelerate even with the gas pedal fully depressed. It has happened four times so far. Safety issue because when I’m pulling out into traffic to make a left or right turn, the car will not accelerate and therefore can get hit by oncoming traffic, especially when I am trying to merge into a lane with oncoming traffic. The car crawls and will not accelerate. My car is a hybrid vehicle. It almost feels as if the non electric engine doesn’t kick on when it is supposed to. The car will crawl for about 5-10 seconds before the engines engages and kicks on the acceleration. There are no warning lights or indication that anything is malfunctioning when this happens. I have not taken the vehicle in to the dealer yet.
NHTSA complaint #11730468 — an unverified report by a vehicle owner.
Venice, FL
STRUCTURE:BODY
I am a loyal Lexus owner since 1998 and have always recommended Lexus vehicles to my family and friends. In over 25 years of ownership, I have never experienced an issue like this. While driving under normal road conditions, my new 2024 RX 350’s AC condenser was punctured by small road debris, causing a refrigerant leak and loss of air conditioning. The condenser is located directly behind the front bumper, leaving it exposed to minor debris, which I believe is a design vulnerability. Damage at such low mileage suggests this may affect other vehicles of this model. Reduced AC performance could impact driver comfort and visibility in extreme heat, and operating the system with low refrigerant may cause further mechanical damage. I am submitting this complaint to request that NHTSA review this as a potential design defect affecting multiple vehicles. I have also contacted Lexus for warranty repair.
NHTSA complaint #11728125 — an unverified report by a vehicle owner.
Venice, FL
ENGINE
I am a loyal Lexus owner since 1998 and have always recommended Lexus vehicles to my family and friends. In over 25 years of ownership, I have never experienced an issue like this. While driving under normal road conditions, my new 2024 RX 350’s AC condenser was punctured by small road debris, causing a refrigerant leak and loss of air conditioning. The condenser is located directly behind the front bumper, leaving it exposed to minor debris, which I believe is a design vulnerability. Damage at such low mileage suggests this may affect other vehicles of this model. Reduced AC performance could impact driver comfort and visibility in extreme heat, and operating the system with low refrigerant may cause further mechanical damage. I am submitting this complaint to request that NHTSA review this as a potential design defect affecting multiple vehicles. I have also contacted Lexus for warranty repair.
NHTSA complaint #11728125 — an unverified report by a vehicle owner.
Venice, FL
FUEL/PROPULSION SYSTEM
I am a loyal Lexus owner since 1998 and have always recommended Lexus vehicles to my family and friends. In over 25 years of ownership, I have never experienced an issue like this. While driving under normal road conditions, my new 2024 RX 350’s AC condenser was punctured by small road debris, causing a refrigerant leak and loss of air conditioning. The condenser is located directly behind the front bumper, leaving it exposed to minor debris, which I believe is a design vulnerability. Damage at such low mileage suggests this may affect other vehicles of this model. Reduced AC performance could impact driver comfort and visibility in extreme heat, and operating the system with low refrigerant may cause further mechanical damage. I am submitting this complaint to request that NHTSA review this as a potential design defect affecting multiple vehicles. I have also contacted Lexus for warranty repair.
NHTSA complaint #11728125 — an unverified report by a vehicle owner.
Saint Augustine, FL
UNKNOWN OR OTHER
The vehicle's lower front fascia exhibits a design flaw, creating an unsafe gap that permits road debris to impact the condenser, leading to air conditioning system damage. This compromise in the A/C system's functionality results in an inability to adequately cool the vehicle's interior, thereby creating potentially unsafe operating conditions, particularly in high-temperature environments. It has been observed that dealerships are declining warranty coverage for these repairs, and the manufacturer has not provided any countermeasures to address this inherent design deficiency.
NHTSA complaint #11720650 — an unverified report by a vehicle owner.
Saint Augustine, FL
ELECTRICAL SYSTEM
The vehicle's lower front fascia exhibits a design flaw, creating an unsafe gap that permits road debris to impact the condenser, leading to air conditioning system damage. This compromise in the A/C system's functionality results in an inability to adequately cool the vehicle's interior, thereby creating potentially unsafe operating conditions, particularly in high-temperature environments. It has been observed that dealerships are declining warranty coverage for these repairs, and the manufacturer has not provided any countermeasures to address this inherent design deficiency.
NHTSA complaint #11720650 — an unverified report by a vehicle owner.
Saint Augustine, FL
ENGINE
The vehicle's lower front fascia exhibits a design flaw, creating an unsafe gap that permits road debris to impact the condenser, leading to air conditioning system damage. This compromise in the A/C system's functionality results in an inability to adequately cool the vehicle's interior, thereby creating potentially unsafe operating conditions, particularly in high-temperature environments. It has been observed that dealerships are declining warranty coverage for these repairs, and the manufacturer has not provided any countermeasures to address this inherent design deficiency.
NHTSA complaint #11720650 — an unverified report by a vehicle owner.
Norwalk, CT
SEATS
The plastic casing holding the driver seat cushion broke/detached itself after a couple of months of driving and even if put back in place it'll continue sliding and moving. It can interfere with my left foot while driving making it a hazard. Lexus reviewed the issue and said it was not covered by warranty.
NHTSA complaint #11697938 — an unverified report by a vehicle owner.
Norwalk, CT
SEATS
I have the exact same issue as this person https://www.clublexus.com/forums/tx-models-2024-present/1025518-new-problems-with-3rd-row-seats.html When I fold the 3rd row seat it leaves a bump under a loose cloth cover. If I remove the cover I see that a plastic attachment linking the spare wheel well to both sides of the trunk is bent. Lexus says that to replace it I need to replace the whole unit and it's also not covered by warrantee.
NHTSA complaint #11697939 — an unverified report by a vehicle owner.
at 18,000 milesVilla Rica, GACrash1 injured
SEAT BELTS
The contact owns a 2024 Lexus TX. The contact stated that while driving at 41 MPH, a vehicle ran a stop sign while distracted and hit the contact's vehicle. The contact was able to swerve and avoid a head-on collision. The contact's vehicle was struck on the right driver's side toward the rear bumper. The vehicle was pushed off the road, where it came to a stop. The driver-side and passenger-side air bags did not deploy. The driver-side and passenger-side air bags did not deploy. The driver-side seatbelt did not lock as intended. From the impact, the contact was propelled over the center console. The contact was taken to the hospital by ambulance. The contact suffered a concussion and sustained injuries to the neck, both knees, hip, her back, and right foot. The contact was scheduled for physical therapy and suffers from post-concussion syndrome. A police report was filed. There were no passengers in the vehicle. The vehicle was towed to Mayfield Wrecker Service, and then it was towed to the dealer. The cosmetic part was repaired on the vehicle. However, the safety issues were not repaired. The vehicle is at the residence. The insurance company was contacted. The contact related the failure of the side curtain air bags to NHTSA Campaign Number: 24V461000 (Air Bag). However, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 18,000.
NHTSA complaint #11697253 — an unverified report by a vehicle owner.
at 18,000 milesVilla Rica, GACrash1 injured
AIR BAGS
The contact owns a 2024 Lexus TX. The contact stated that while driving at 41 MPH, a vehicle ran a stop sign while distracted and hit the contact's vehicle. The contact was able to swerve and avoid a head-on collision. The contact's vehicle was struck on the right driver's side toward the rear bumper. The vehicle was pushed off the road, where it came to a stop. The driver-side and passenger-side air bags did not deploy. The driver-side and passenger-side air bags did not deploy. The driver-side seatbelt did not lock as intended. From the impact, the contact was propelled over the center console. The contact was taken to the hospital by ambulance. The contact suffered a concussion and sustained injuries to the neck, both knees, hip, her back, and right foot. The contact was scheduled for physical therapy and suffers from post-concussion syndrome. A police report was filed. There were no passengers in the vehicle. The vehicle was towed to Mayfield Wrecker Service, and then it was towed to the dealer. The cosmetic part was repaired on the vehicle. However, the safety issues were not repaired. The vehicle is at the residence. The insurance company was contacted. The contact related the failure of the side curtain air bags to NHTSA Campaign Number: 24V461000 (Air Bag). However, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 18,000.
NHTSA complaint #11697253 — an unverified report by a vehicle owner.
Clayton, NC
UNKNOWN OR OTHER
The AC stopped working and now they are charging me to replace the condenser which is located right in the front behind the grill. They said it was damaged from a rock that hit it. There are thousands of these vehicles that have this poor design where all these condensers are getting hit and having consumers pay for this damage because it is not under warranty. These should be recalled or repaired for free as it is obvious there should be some kind of screen to prevent this as the grill gives no protection.
NHTSA complaint #11689942 — an unverified report by a vehicle owner.
Eureka, MO
VISIBILITY/WIPER
Driving on the highway, heard a very loud pop, followed by a crackling noise above us. Investigated and found the sunroof had spontaneously shattered. On the drive home, the sunroof glass collapsed into the car. The initial incident was very disruptive, and we were lucky that the sun shade was closed, which blocked glass fragments from falling on us. There are no signs of impact from any objects or rocks. There were no cars driving in front of us, and we did not drive beneath an overpass. There were no dents on the car. Photos of the glass after shattering but before collapse dont show a clear sign of an impact point. My best guess is a manufacturing flaw exacerbated by temperature changes. It was a very sunny day, and we had the shade open with cold AC blowing for 30+ minutes. The sun became a distraction, so we closed the shade. I think the heat then built up quickly between the shade and the glass, and caused the glass to shatter.
NHTSA complaint #11689028 — an unverified report by a vehicle owner.
Fresno, CA
TIRES
While driving on highway tire separated frô wheel And flew off leading to loss of control of vehicle.
NHTSA complaint #11683305 — an unverified report by a vehicle owner.
Hayward, CA
UNKNOWN OR OTHER
I was driving on a highway around 65mph, about 1:30PM on May 11, 2025. The temperature outside was about 70 degree F. I heard a very loud noise like a big firecracker exploding. Then I heard the sound of air coming from the sun roof. I opened the sun roof door and found the sun roof was shattered and had a big hole more than a foot in diameter. If I didn't close the sun roof door, I could had been injured by the exploding tempered glasses from the sun roof and lose control of my SUV. I drove to the Lexus dealership and leave my car there overnight since the service department was closed on Sunday. The Lexus service advisor will call me in the morning. I googled the topic about "Lexus sun roof exploding while driving" and found many Lexus car owners had the same problem as mine. Toyota Motors already knew about this issue since 2012 and they refused to fix the issue free of charge for Lexus car owners since they said that the car warranty doesn't covered the sun roof. I believe Toyota Motors is a irresponsible car company. If this issue is not fixed, I believe some Lexus owners might get hurt when their cars' sun roof explode while driving. Toyota Motors should fix the problem free of charge for their customers because this is a defective tempered glass sun roof.
NHTSA complaint #11660305 — an unverified report by a vehicle owner.