85 of the
1,827 complaints filed about the Mazda CX-9
are about the electrical system —
5% of everything owners reported.
The worst model year for it is 2018.
The contact owns a 2022 Mazda CX-9. The contact stated that the vehicle was being operated with the front driver's side seat warmer activated to the highest heat level. After driving for several hours, the vehicle was parked. While exiting the vehicle, the contact experienced pain in the rear thigh area of each leg. Upon inspect the contact discovered that the rear thigh area of both legs had sustained burning and blistering despite having pants on as a barrier during the failure. During the injuries, the contact was wearing pants. The contact was later treated at the local urgent care center for first-degree burns and blistering caused by excessive heat from the seat warmer. The manufacturer was notified of the injuries and advised to have the vehicle examined by the local dealer. The vehicle was taken to the local dealer, who was unable to detect a failure in the operation of the seat warmer, and no problem was found. The contact inquired about the temperature of the seat warmer and what its highest temperature level is; however, that information was not provided, and the manufacturer stated that it is the temperature at which the occupant felt comforable with. No further information was available. The failure mileage was 53,000.
NHTSA complaint #11728503 — an unverified report by a vehicle owner.
The liftgate (trunk) opens sporadically. The system keeps trying to open the truck and it's causing a parasitic drain on my battery. I was stranded 2 hours from my home due to this. My trunk would sporadically beep three times, that is the only warning I received. There are safety recalls for other year of Mazda cx-9 but not my specific even though I am having the same issue.
NHTSA complaint #11725165 — an unverified report by a vehicle owner.
The information screen is getting 'spider cracks" spreading across the face and turning opaque making the information unreadable. Mazda is apparently aware of this defect and issued a TSB for earlier models. Dealers were unhelpful and quoted $1000 - $3000 to repair depending on the VIN.
NHTSA complaint #11714995 — an unverified report by a vehicle owner.
Passenger seat heater either had a grounding issue or shorted out, causing to seat to start smoldering and catching fire, destroying the seat. There has been recalls and lawsuits for this specific issue on this model in other years, but not for this model year.
NHTSA complaint #11713860 — an unverified report by a vehicle owner.
The contact owns a 2019 Mazda CX-9. The contact stated that a State Inspection was performed on the windshield for cracks. The contact stated that while driving in the rain, the front windshield wipers turned on independently with the switch in the off position. The contact was unable to turn off the windshield wipers. The contact pulled over to the side of the road and turned off the vehicle. When the vehicle was restarted, the front windshield wipers had turned off. The contact stated that the failure persisted and worsened. The contact stated that occasionally the windshield wipers failed to turn off. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact purchased and replaced a sensor. Upon investigation, the contact became aware that the on and off switch for the front windshield wipers related to the sensor located on the front windshield. The contact stated that the sensor controlled the on and off switch and failed to function as intended. The contact stated that the OEM windshield provided protection against the sensor malfunctioning; however, if the front windshield was replaced with a non-OEM windshield, the windshield wipers would fail to operate as designed. The manufacturer was not made aware of the failure. The failure mileage was 56,199.
NHTSA complaint #11706077 — an unverified report by a vehicle owner.
[XXX] 2018 MAZDA CX-9 GRAND TOURING 89014 MILES Date: 9/11/2025 To: Mazda North American Operations Attn: Customer Experience Center 7755 Irvine Center Drive Irvine, CA 92618 USA Subject: Formal Complaint Regarding Safety and Technical Issue – 2018 Mazda CX-9 Dear Mazda Customer Experience Team, I am writing to formally lodge a complaint regarding a serious safety and technical issue I have experienced with my 2018 Mazda CX-9. After a recent inspection conducted by Mazda Koch 33, it was brought to my attention that the engine wiring harness is defective and may potentially cause a fire or result in burns, posing a severe safety risk to me, my passengers, and others on the road. This issue is deeply concerning and unacceptable, especially considering Mazda’s reputation for reliability and safety. A fault in the engine wiring harness, particularly one that has the potential to ignite or burn, should be treated with the utmost urgency. It is troubling that such a critical component could present such danger. My vehicle has been serviced and maintained regularly, and I was not made aware of any recall or technical service bulletin that addressed this defect until the inspection. Given the nature of the defect, I believe this may be a manufacturer defect, and I request that Mazda: Immediately investigate and confirm whether this issue falls under an existing recall or known defect. Take full responsibility for replacing or repairing the affected wiring harness at no cost to me. Provide assurances in writing that my vehicle is safe to operate. Offer compensation or a loaner vehicle if the repair process renders my vehicle unusable for any period of time. Please consider this a formal request for immediate corrective action. I expect a prompt response within 10 business days of the date of this letter. If I do not receive a satisfactory resolution, I will be compelled to escalate this matter further through consumer protection agencies, such as the INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATI
NHTSA complaint #11686751 — an unverified report by a vehicle owner.
my 2018 MAZDA CX-9 safety issue SCBS / SBS, LAS / LDWS, MASTER AND/OR HBC WARNING LIGHTS Forward sensing camera (FSC) stops functioning cause my car run rough even depress accelration and those light came on dashbaord -Forworad smart city brake support malfunction -smart brake system -front camera sensor malfunction
NHTSA complaint #11685844 — an unverified report by a vehicle owner.
I am submitting this recall request because my vehicle has experienced repeated incidents of a serious safety issue. While driving—most often on the highway—a warning appears that says “Smart System Brake Malfunction.” Immediately after, the car begins braking on its own without driver input. This has happened multiple times and, based on online reports, it appears to be affecting many Mazda vehicles across different models and years. Each time, I have been forced to pull over, turn off the car, and restart it to temporarily resolve the issue. This is extremely dangerous, especially at highway speeds, as it creates a high risk of rear-end collisions and sudden loss of vehicle control. When reported to Mazda, the concern was dismissed as a “sensor issue,” but the repeated nature and widespread reports suggest a potential systemic defect that requires urgent investigation and recall.
NHTSA complaint #11682407 — an unverified report by a vehicle owner.
Infotainment screen (LCD) of Mazda CX-9 2018 has developed what looks like discoloration/scratching/frost in corner of screen about 2 years ago and it is continuing to spread over last 6 months. This screen is used for hands-free bluetooth/calling (which is now the law in Iowa) and the back-up camera which allows for safe backing. If screen is unreadable, these safety functions cannot be performed properly. I take my car into Mazda dealership for maintenance/oil changes and it has never been addressed as an issue, but I'm concerned.
NHTSA complaint #11673548 — an unverified report by a vehicle owner.
Vehicle randomly displays "smart brake system malfunction," "forward smart city brake malfunction" and " front radar system malfunction." This has been going on for at least a year. I will be driving on a highway, trying to accelerate and these messages will pop up. I'm not able to accelerate when these messages pop up and I have to turn on my hazard lights and pull over to the side of the road. The only thing that clears these warnings are for me to completely shut down my car and restart it. Luckily I have been able to get over to the side of the road on the highway without an accident, but these warning lights pop up when it's sunny out and there is no reason for the car to act the way it does. I took my car to the dealer the first time it happened and paid several hundred dollars for them to tell me that they don't know why it happened. There are several forums posted online with people having the same issues. Online posts say to make sure the sensors are clean and that the malfunction can activate if it's too hot, rainy, snowing or foggy? In my experience, it has happened only when it has been sunny. When the system decides to malfunction, the car will not accelerate, and it could make it easier for the car to be hit by another car. It's like the car just shuts down.
NHTSA complaint #11662517 — an unverified report by a vehicle owner.
Starting [XXX], through [XXX], we began receiving multiple "Critical Vehicle Malfunction" alerts (46 alert messages)via the Mazda app, including "Parking Brake Malfunction" and "Electric Parking Brake Malfunction." During this time, the vehicle experienced delayed starts and eventually required a jump-start. We brought it to the dealership multiple times to show the messages, before our 3-year/36,000-mile B2B warranty expired, but the issues were dismissed until the battery was finally replaced. At just over 36,000 miles (currently 39,646), a new issue emerged a “thud” sound from the steering wheel. The dealer diagnosed it as a failed u-joint shaft, which was deemed non-serviceable and not covered under warranty. I inquired about potential causes or prevention—no clear answer was known. I found relevant NHTSA TSBs (06-001/20 & 06-001/24) related to steering issues and escalated to Mazda USA. Mazda agreed to cover 50% as a goodwill gesture, leaving me to pay about $500. Two weeks later, the part arrived and was installed—but it did not fix the issue. The dealership now says it’s a failed bearing within the Electric Power Steering (EPS) unit, which requires complete replacement at a cost of over $2,000. Only one part is available in the U.S., with another two-week wait. The original (misdiagnosed) part was already sent back to Mazda. My out-of-pocket cost is now $1,151 and rising. Given the early warning alerts, misdiagnoses, and the fact that EPS controls several safety-critical functions (steering, cruise, lane assist, etc.), I believe this is a fundamental system failure that should be fully covered under warranty or as a safety-related goodwill repair. I respectfully request that Mazda assume full financial responsibility for the replacement and any related work. Thank you for your consideration. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11661072 — an unverified report by a vehicle owner.
Smart City Break Malfunction warning light appears while driving. Simultaneously the tire pressure warning appears. Also, at the same time, the temperature reads -20 to -40 degrees. Yes, vehicle is available for inspection. Fearful that car could randomly break while driving putting myself and family in danger since there is a malfunction. Mazda service center says the problem can’t be reproduced so there’s nothing they can do. The problem seems to appear when the outside temperature is 60 degrees Fahrenheit or higher.
NHTSA complaint #11656449 — an unverified report by a vehicle owner.
Vehicle failed to turn off the engine while in park and I was unable to lock vehicle while engine was still running. The ignition button failed to work.
NHTSA complaint #11621833 — an unverified report by a vehicle owner.
1. What component or system failed or malfunctioned, and is it available for inspection upon request? The entire electrical system is malfunctioning. All dashboard service lights (check engine, ABS, etc.) illuminate simultaneously, causing the vehicle to stutter and shut off while driving. The vehicle is available for inspection. 2. How was your safety or the safety of others put at risk? This issue has resulted in a dangerous situation, particularly when the vehicle lost power on the highway with my young children aboard. This sudden loss of control could have led to a severe accident. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Mazda’s service department has not been able to reproduce the problem despite multiple visits. I have provided video evidence, but no conclusive diagnosis or resolution has been achieved. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? Mazda’s authorized technicians have inspected the vehicle several times, but no substantial action has been taken. The vehicle has not been inspected by police or insurance representatives. 5. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? All dashboard lights come on simultaneously without prior warning. The symptoms have been random and intermittent over the past few months. Given the ongoing risk, I request an immediate replacement of my vehicle. Please confirm receipt of this complaint and provide a plan for replacement. Thank you for your prompt attention.
NHTSA complaint #11613534 — an unverified report by a vehicle owner.
As I am accelerating to merge onto the highway from an on-ramp, while the gas pedal is depressed, I will get a series of sensor alerts simultaneously (city brake malfunction, park assist malfunction, lane assist malfunction, etc.) and my gas pedal becomes non-functional at 60-70mph. It is terrifying especially when there is other traffic around my vehicle. This exact issue has happened 6 times within the past 12-18 months at seemingly random intervals but always when I am accelerating onto the highway at 50-70mph. I typically pull off to the side of the highway and turn off the vehicle. After letting it sit off for ~30 seconds, I turn the vehicle back on and all of the sensor alerts have cleared and the vehicle functions properly including the gas pedal and I am able to rejoin the highway. I took the car to the Mazda dealership in my state of Vermont a few months ago to have them diagnose and address the problem. They had never heard of this issue and were unable to find the root cause or fix it. Please help, this is dangerous!
NHTSA complaint #11545342 — an unverified report by a vehicle owner.
The oil light keeps coming on before your initial oil change. Also, the oil is actually low. They have already changed it and I'm having the same problem in less than 2 months.
NHTSA complaint #11537195 — an unverified report by a vehicle owner.
There is a recall for Mazda 2016-2017 infotainment screens where they will show signs of cracking under the plastic and the screen will reboot. I have a 2018 CX-9 and Mazda corporate acknowledged the issue but only offered 15% of the price of a replacement part instead of replacing it. They said my VIN was not part of the original recall. I informed them this was a safety concern and then did not care. Case number - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11536484 — an unverified report by a vehicle owner.
UKNOWN-Seat Heating system in my car gets too hot to the skin where it burns the skin if not turned off. I’m not able to use it often because even on low setting it gets extremely hot.
NHTSA complaint #11522786 — an unverified report by a vehicle owner.