283 of the
4,006 complaints filed about the Mazda MAZDA3
are about the body and structure —
7% of everything owners reported.
The worst model year for it is 2010.
The contact owns a 2012 Mazda Mazda3. The vehicle was transported from the east to Texas, and the vehicle was bought used. The contact stated that the dashboard was sticky and that a gap was between the instrument panel and cover. The contact stated that a small to medium bubble had started to form. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000. The VIN was not available.
NHTSA complaint #11704211 — an unverified report by a vehicle owner.
On July 1, 2025, I was involved in a severe rear-end collision while driving my 2024 Mazda3 manual hatchback. The impact was forceful enough to shatter the rear windshield, leave a deep dent in the tailgate, and bend the trailer hitch mount under the vehicle by several inches. Despite this, none of the airbags deployed, and there were no airbag warning lights before or after the crash. After the incident, I checked my vehicle’s VIN on NHTSA’s recall lookup tool and discovered that Recall 7525E had been issued on June 6, 2025, for a critical airbag sensing system defect (SAS module), which can disable airbag deployment after battery depletion or improper power conditions. According to Mazda and NHTSA documents, this defect can completely disable airbag function, increasing the risk of injury in a crash. As of July 11, 2025, I have not received any recall notice from Mazda by mail, email, phone, or dealer contact—despite being the registered owner. Mazda’s documentation shows that: Dealers were notified as early as June 3, 2025 Owner letters are not scheduled until July 28, 2025 This means that I was driving a defective vehicle without knowledge of a serious safety issue at the time of the crash. I believe that: Mazda failed in its legal obligation to notify me in a timely and adequate manner. The non-deployment of airbags in my crash is consistent with the failure described in Recall 7525E. Other affected Mazda owners may remain unaware and at significant risk. I respectfully request that NHTSA: Investigate whether Recall 7525E was the cause of airbag failure in this incident. Determine whether Mazda’s recall notification practices met regulatory requirements. Ensure immediate outreach to affected owners to prevent further injury or risk. I am also seeking legal counsel due to the serious safety implications and potential liability arising from this defect. I will be retaining all documentation, vehicle records, photos, and post-
NHTSA complaint #11672644 — an unverified report by a vehicle owner.
The car has had a lot of issues. The inside driver side glass for the display dash fogged up and had to be replaced. The first replacement didn’t fix it and I had to threaten legal action to get Mazda to replace the glass a second time before it finally resolved the issue. The car (which is washed and waxed weekly), got rust on it in year 3. Mazda repaired it and promised it would not return. 14 months later the rust is back and Mazda won’t repair it. I have escalated with no avail. I have had to replace the air conditioning fan for over $1K. I bought the car brand new with 59 miles on it, I have kept up on every maintenance and kept records and today it has 18,000 miles and I am told the transmission needs replaced. 18,000 miles on a garage kept car? This is not right!
NHTSA complaint #11609228 — an unverified report by a vehicle owner.
A bolt head underneath the car snapped for the steering mechanism. The problem was indicated by a clanking noise I heard for many 1000s of miles. It's been as long as I remember, but I had no idea what it really meant. It's 2.7 years old with 30,653 miles right now. There were no warnings. The wheel could have come off at any moment I was driving it. The bolt was likely over-torqued or had a manufacturing defect causing it to snap. I have pictures for when the car was propped up at a technician. One side is completely non rusted. The other side is showing rust ONLY from where the bolt was covering, so rust is an unlikely cause.
NHTSA complaint #11572078 — an unverified report by a vehicle owner.
I was driving on the highway and decided to switch int the left lane so I sped up and heard a big bang and what sounded like my bumper being dragged against the ground. I see on my dashboard that there’s an electrical and engine malfunction so I pullover and pop the hood. A bunch of smoke comes out and i see a little fire so me and my friends run and call the police. The police and firefighters arrived just as the fire was getting large and it had engulfed the front right side of my car. If the notification that there was a malfunction didn’t come on, I feel as if we could’ve been hurt much worse or even have died. I’m not much of a person that knows about cars and it sounded like my bumper was scraping and by the amount of times i’ve scraped my bumper, i believed it until I saw my notification. The vehicle is still being inspected for cause of fire and this vehicle has never had this problem before.
NHTSA complaint #11545514 — an unverified report by a vehicle owner.
The contact owns a 2013 Mazda Mazda3. The contact received notification of NHTSA Campaign Number: 16V644000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted, and the contact was informed that the part for the recall repair was not yet available. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11540603 — an unverified report by a vehicle owner.
There has been no accident- the vehicle is my mother in laws vehicle- my concern is while at work she has at times loaded our daughter into the vehicle- I inspected the vehicle one day while as an employee of Les Schwab- the driver cvc axle vibrates so bad from the boot being torn and having no lubrication- these axles power the vehicle forward and if not maintained can snap and cause damage- the wipers no longer work correctly- the tires are 2017 and old and weather cracked- potential to separate while driving or blow out on the heated pavement. upon inspection also found that the front shocks are blown out and bouncing in the mounts under the hood- causing the tires to not have the correct contact patch on the road thus decreasing traction and control- on top of all this the vehicle hasn't been registered since 2020 and has no insurance on the vehicle- again there has been no accident...yet- this is my concern- that if this vehicle continues to remain operational and on the road it not only puts the driver and occupants at risk but also other drivers- kids- teens and anyone that may be on the other end o the crash when the vehicle does snap the cvc axle or blow i out a tire
NHTSA complaint #11538237 — an unverified report by a vehicle owner.
The dashboards should be subject to a recall immediately since badly reduced visibility from glare is a recipe for an accident. The defective (melting) material is so bad that if the sun hits it just right, I can hardly see anything ahead of me; it is an accident waiting to happen. I called my Mazda dealer (Gray Epperson Mazda in Cleveland, TN (423) 303-1333) but said there was nothing they could do now as there was a warranty before but it had expired. I try to drive the car but always trying to avoid sunny conditions, but unfortunately, when I leave at 5pm conditions are worse if it's sunny. I wish Mazda would accept responsibility soon (or they are forced to do so by NHTSA, if needed) so that I wouldn't have to take such a risk.
NHTSA complaint #11522117 — an unverified report by a vehicle owner.
Im having issues with rust the car it’s getting pretty much the car it’s falling apart the under body it’s nothing but rust I’m scared of changing a tire because there’s actually not a good grip where I can lift the car without feeling it’s going to fall apart, the rear or the disks it’s falling by chunks and just yesterday the rear shock plate broke out of place because it’s way too rust same thing with my muffler I don’t feel safe I’m My car which I love, I truly do but I feel like at any minute its just going to break apart right now it’s the shock rear driver side but I feel like next a tire or my brake disks are going to break like I said I don’t even feel safe to change a tire
NHTSA complaint #11508457 — an unverified report by a vehicle owner.
Car emits a very audible squeak when shifting right above 30mph and 40mph, car surges at lower and constant speeds, tach will slowly drop when applying throttle, surge slightly, then function as normal again
NHTSA complaint #11499817 — an unverified report by a vehicle owner.
The dash of the car is melting. It causes a reflection that is bright and impairs visibility. Mazda addressed this problem with extending the warranty. When I called the local dealerships, none of them had the dash to replace per warranty. I made several calls throughout the year and each time was told the dashboard was not available and to try again. Then COVID hit and I did not venture out. When I finally called again, the warranty had expired. Mazda offered me $200 towards replacing the dash. When I called the dealership, it was almost a $1,000 repair. I've then called Mazda again and they asked me to get a diagnosis at a local dealership. I did that and then have had zero response to my many emails and calls from my assigned rep. I have never seen a dash melt and get sticky and shiny like this before. It is literally dripping down. I believe this is a safety defect. And why Mazda had to extend the warranty. But they didn't go far enough because they extended the warranty but did not have the parts to honor such a warranty.
NHTSA complaint #11498572 — an unverified report by a vehicle owner.
The dashboard is melting more and more everyday. Its becoming sticky and very reflective. Sometimes whenever I am driving in the morning the sun will reflect off and blind me making it very hard to safely operate my vehicle.
NHTSA complaint #11481820 — an unverified report by a vehicle owner.
The dashboard in my 2010 Mazda 3 has melted significantly throughout the years. It has become hazardous and tough to operate this vehicle. The dashboard is glossy, sticky, and believe a slight odor. I tried to slow its deterioration by using a sunshade when parked. It not only did not help, the dashboard just ruined each shade with a sticky, tar-like, black residue. No dealership has offered to help me without trying to charge me the total price of replacement, plus their labor costs. I regularly check to see if there has been a new recall, but there has not. I can not sell this car without feeling guilty for endangering others. I am unlikely to return to Mazda as a paying customer since they shy away from treating my family like one. I hope this issue is fixed adequately for me and anyone else suffering from this issue.
NHTSA complaint #11463293 — an unverified report by a vehicle owner.
The contact owns a 2010 Mazda Mazda3. The contact stated that overtime the dashboard had become glossy and sticky due to excessive heat. The contact also stated that on sunny days, the sun would reflect off the glossy surface and would obstruct her vision while driving. The contact notified the dealer of the failure and they informed her that the vehicle was no longer covered under warranty. The manufacturer was notified of the failure and she was informed that unless she had received a notification that her vehicle was under recall or warranty, no assistance could be provided. The vehicle was not repaired. The failure mileage was approximately 60,000.
NHTSA complaint #11428399 — an unverified report by a vehicle owner.