117 of the
2,686 complaints filed about the Mercedes Benz E350
are about the suspension —
4% of everything owners reported.
The worst model year for it is 2014.
The failure was when I hit the brakes hard in an emergency braking situation and the car very eratically and violently veered to the left. There was no warning and thank God there was no car coming in the left lane otherwise it would have been a broad side hit. I was doing 55 mph. We had the car inspected at a local shop and the left rear tie rod link was completely severed from the suspension sub-frame because of rust. The brake lines above the sub frame were also severely rusted and leaking. I called my closest dealer and they said the rusted frame replacement is covered under extended warrenty but not the brake lines which had the same issue, severe corrosion and a potential catostrophic failure! Mercedes Road Side Assistance was called to tow the car 70 miles to the closest shop.
NHTSA complaint #11752742 — an unverified report by a vehicle owner.
While braking from highway speeds or any other speed, the vehicle becomes unstable and pulls to the left, making it difficult to maintain control. During hard braking, the vehicle does not track straight and requires steering correction to remain in its lane, creating a significant safety hazard. To diagnose the problem, the vehicle was inspected by an independent mechanic. An alignment was performed, and the suspension and braking systems were inspected. The mechanic determined that the rear subframe has severe rust and corrosion. The rusted rear subframe is available for inspection upon request. Despite the alignment and inspection of the suspension and brakes, the unsafe braking behavior remains. There were no warning lights or messages indicating this condition before it was discovered. The problem has been reproduced multiple times under similar braking conditions. This condition puts the driver, passengers, and other motorists at risk because the vehicle can become difficult to control during braking, particularly at highway speeds or during an emergency stop. Based on the mechanic's inspection, the severely corroded rear subframe is the source of concern and should be investigated as a safety-related defect. I have also contacted Mercedes-Benz USA regarding this safety issue and requested assistance, but I have not yet received a response.
NHTSA complaint #11751828 — an unverified report by a vehicle owner.
The rear subframe is defective and subject to premature corrosion and failure of parts that connect to the rear suspension. Due to the fracturing of the joints connecting to the suspension, my car was at risk of going out of control when needing to brake at higher speeds. The way the suspension component broke also risked damage to the gas tank if the car was driven over a large bump or pot hole. The problem was diagnosed by an independent repair service. The corrosion is not visible to an owner. It does not impact any body panels - only structural parts visible when the vehicle is on a lift. Mercedes Benz has provided an extended warranty for unlimited miles and 20 years to any owner of this model for a range of years and models. This was communicated to Mercedes Benz dealerships on March 10, 2023. However, since the vehicle is not subject to recall, I do not know how this was communicated to an owner. I did not receive anything alerting me to the problem. Mercedes Benz has my phone number on file.
NHTSA complaint #11750938 — an unverified report by a vehicle owner.
Vehicle subframe corrosion (manufacturer extended warranty offered). Rear brake lines corroded/leaking. Vehicle leaks fuel; steel fuel line corroded. Vehicle has about 105k miles. Minor fire started when yard maintenance came in contact with fuel saturated ground where vehicle had been parked/moved out of the way just prior. With rear suspension subframe springs corroded, vehicle bottom can contact road surface while driving, scraping steel exhaust with fuel present. EXTREMELY dangerous. Local Sunbury Ohio Mercedes dealership inspected then offered subframe replacement. Stated it was leaking fuel and not hydraulic fluid we originally thought. Brake, suspension and fuel line corrosion repairs were quoted in excess of $4,000, which was a "great deal" according to them "because the subframe would already be removed and would make it much easier."
NHTSA complaint #11749054 — an unverified report by a vehicle owner.
The failed component is a fuel pump, and it is available for inspection upon request. My safety and the safety of others was put at risk due to the following: 1) Sudden engine stalling 2) Dangerous power loss while accelerating 3) Potential fire risks; a damaged fuel pump assembley can cause fuel leaks and overheating due to insufficient fuel supply can increase the risk of explosion or fire. 4) Gas fumes from a fuel leak are highly harmful and dangerous. They are toxic to inhale causing dizziness, headaches, nausea or respitory issues.
NHTSA complaint #11735613 — an unverified report by a vehicle owner.
Brake line is thoroughly corroded, went to a repair shop, when they brought it back down, the Subframe collapsed. Mercedes has a 20 yr warranty on the subframe so they will cover that but want another $3K to fix the brake line that was obviously tied to the same mfr issue that the sub frame was in regards to rusting. Dealer won't take any responsibility for anything but the subframe.
NHTSA complaint #11683155 — an unverified report by a vehicle owner.
This vehicle, with 115,000 miles has been discovered to have had the brackets in the subframe for BOTH rear lateral arms rust through and are broken causing a $5,000 repair estimate. The mechanic who found this (42 years as a mechanic) said he has never seen anything like it. This is a car where I had to replace the transmission at 49,000 miles and the control unit at 62,000 miles (over $13,000 in repairs). I saw through AI search that this problem has been reported many times but has not prompted an investigation. This issue should NEVER happen and is a MAJOR SAFETY threat.
NHTSA complaint #11652830 — an unverified report by a vehicle owner.
The contact owns a 2012 Mercedes-Benz E350. The contact stated his wife had noticed that the steering wheel was off-center and turned to the left independently. Additionally, the contact stated while his wife was driving at an undisclosed speed and depressing the brake pedal, the vehicle flipped sideways. The contact's wife was able to exit the highway and pull into a gas station. The contact met his wife at the gas station. The contact stated that while driving approximately 20 MPH, the failure recurred, with the front end shifted to the left and the rear end shifting to the right. The contact returned to the parking lot. The vehicle was towed to the residence. The contact stated that as an independent mechanic, he inspected the vehicle and noticed that the rear subframe was corroded severely inside out and a wheel had detached. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 170,000. The VIN was not available.
NHTSA complaint #11647634 — an unverified report by a vehicle owner.
There was already a recall for my rear subframe that I am now getting done due to rust corroding the metal structure. However, upon the dealers inspection the corrosion is also present on the rear brake lines which cause a safety concern and are charging $4000 to replace the brake lines aside from the warranty repair. It poses a safety hazard if the lines were to fail and have heard of others having the same issue along with rotted rear subframes.
NHTSA complaint #11644847 — an unverified report by a vehicle owner.
The contact owns a 2010 Mercedes-Benz E350. The contact stated while the contact's wife was driving at an undisclosed speed, the brake pedal was depressed, however, the vehicle failed to stop as intended. The contact's wife was able to stop the vehicle from crashing into a concrete curb. The contact stated a nearby independent mechanic assisted the contact, and the vehicle was taken to the independent mechanic. The vehicle was diagnosed with a fractured brake line due to corrosion. The contact was advised to have the vehicle towed to the dealer. The vehicle was towed to the dealer where it was diagnosed with a fractured rear brake line due to corrosion. The contact was informed that the rear brake line needed to be replaced. The vehicle was not repaired. The contact stated that a year ago the rear subframe fractured due to corrosion. The contact stated that the rear subframe was repaired under an unknown recall repair. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 140,000.
NHTSA complaint #11643335 — an unverified report by a vehicle owner.
The contact owns a 2008 Mercedes-Benz E350. The contact stated that after parking the vehicle overnight, the vehicle failed to start the following morning. The contact was able to jumpstart the vehicle. The vehicle was taken to Combels Customs - Collision Repair, Auto Body Shop, where the alternator and the battery were replaced; however, the failure persisted. The contact stated that the speedometer, the clock, and the infotainment system were inoperable. Additionally, the contact stated while driving at various speeds and turning, there was an abnormal knocking sound coming from the rear suspension, and the vehicle was swaying. The contact stated that after opening the sunroof, the sunroof failed to close as needed. The contact was able to close the sunroof manually with assistance. The contact related the failure to NHTSA Campaign Numbers: 08V303000 (Electrical System), 24V874000 (Visibility) and 12V264000 (Suspension). The dealer was notified of the failure and informed the contact the VIN was not included in the recalls. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 116,000.
NHTSA complaint #11635613 — an unverified report by a vehicle owner.
When braking the car pulls hard off the road. inspection showed rear subframe rusted and control arms are not attached securely to frame. Unsafe to drive
NHTSA complaint #11633494 — an unverified report by a vehicle owner.
1. brake lines corroded and broke. i see there were numerous reports sent to you and nothing was done. 2. both driver and passenger seat broke in the same spot...mercedes recognized the issue in their internal bulletins. nothing was done 3. both rear springs broke on their own. no accident. car was really unstable in highway speeds
NHTSA complaint #11631348 — an unverified report by a vehicle owner.
As I went to have my vehicle inspected, the mechanic advised me that it could not be inspected, that the car is totaled because the rear subframe is all rotted and the brackets holding the trailing arms were broke off and said that this was a common problem with these vehicles.
NHTSA complaint #11626631 — an unverified report by a vehicle owner.
Driving on interstate, hit the brakes and noticed the car was swaying hard to the left. After that it progressively got worse. When hitting even the smallest bump or braking I heard a metal on metal ‘thunk’ sound. My daughters were in the car and it was frightening. Upon further inspection by a Mercedes mechanic, the secondary frame had rusted and snapped into. After reading forums online I found it’s very common. They rust from the inside out. There was absolutely NO previous warning.
NHTSA complaint #11611182 — an unverified report by a vehicle owner.