69 of the
338 complaints filed about the Mercedes Benz GLE 350
are about the engine —
20% of everything owners reported.
The worst model year for it is 2020.
I keep getting coolant level low. I add coolant fluid into the tank and the warning message comes up again. I see no leaks under my vehicle so not sure if there’s a leak inside the tank itself or air leak somewhere but I’ve gotten that warning message about 10 or more times. Also as im driving the blind spot sensor just randomly goes off without a car or anything being next to me.
NHTSA complaint #11753409 — an unverified report by a vehicle owner.
At approximately 87,000 miles, my 2021 GLE350 (M264 2.0T engine) experienced a severe engine misfire resulting in a flashing check engine light, rough idle, engine shaking, significant loss of power, and near-stall condition. The vehicle was taken to Speedhaus Automotive (Newbury Park, CA) where all four ignition coils and spark plugs were replaced. Total repair cost was approximately $635. This failure pattern is consistent with the documented M264 exhaust valve seat wear issue acknowledged by Mercedes-Benz technicians. A Mercedes dealer service report on an identical 2021 GLE350 explicitly states: "COMMON ISSUE FOR EXHAUST VALVE SEATS TO WEAR — KNOWN ISSUE WITH 260 AND 264 MOTORS." Mercedes-Benz has extended the warranty on the M260 engine (transverse variant) for this identical failure mode but has not extended it for the longitudinally-mounted M264 despite the same defect being present. Repair costs for full cylinder head failure on the M264 are being quoted at $6,000–$13,000. I am requesting NHTSA investigate whether a safety recall is warranted for the M264 engine across all affected GLE350, GLC300, C300, and E350 vehicles.
NHTSA complaint #11741934 — an unverified report by a vehicle owner.
The engine in my 2020 Mercedes-Benz GLE 350 experienced catastrophic internal failure while driving. No warning lights or check engine indicators came on. Prior to failure, the vehicle began making a loud metallic knocking/rattling sound during acceleration, similar to “rocks shaking in a box.” Shortly afterward, the engine suddenly stalled while driving and would no longer run. The vehicle still had electrical power but the engine would not restart. The vehicle was towed to Mercedes-Benz of Las Vegas for inspection. The dealer diagnosed the engine as seized and documented metal debris in the oil filter and oil/metal debris underneath the vehicle, indicating catastrophic internal engine damage. The dealer stated that the engine replacement was required.The failed engine and vehicle are currently located at Mercedes-Benz of Las Vegas and are available for inspection upon request.The vehicle stalled unexpectedly while being driven on a public roadway, causing sudden loss of engine power and creating a potentially dangerous traffic situation. The violent shaking and knocking before failure also caused concern that the vehicle could lose control or stop operating completely in traffic, which it ultimately did. A sudden engine seizure and stall while driving creates a significant safety hazard because the driver may lose the ability to accelerate, maneuver safely, or clear traffic. This could increase the risk of collision, especially at highway speeds or in heavy traffic conditions. Mercedes-Benz of Las Vegas inspected the vehicle and confirmed catastrophic engine failure. The dealer documented that the engine was seized and that metal debris was found in the oil filter and underneath the vehicle. The dealer advised that the engine required replacement and provided an estimated repair cost exceeding $27,000. The dealer has not yet identified the root cause of the failure. No dashboard warning lights, oil pressure warnings, or check engine lights illuminated.
NHTSA complaint #11740729 — an unverified report by a vehicle owner.
We were traveling to our son’s college graduation, driving on a rural interstate and suddenly all of the vehicle’s warning lights lit on the dash and the car started losing, and then completely lost power. The car was no longer operational. We were stranded on the roadside of a remote but busy 2-lane interstate for 2 hours until a tow truck could arrive and take the car to the closest car repair shop which was 45 minutes away. This was an incredibly dangerous situation and we were fortunate to be alongside the shoulder, although we were still close to the tractor trailers and cars on the interstate. (Because we were stranded in such a remote place, we had no other options to get to our son’s graduation. We were unable to attend because of this.) The rural repair shop the car was initially towed to could not determine the problem. A few days later we found a 2nd tow truck that agreed to bring the vehicle several hundreds of miles back to our home city. This car is a 2020 model, and has around 55,000 miles. It has been meticulously maintained by a certified Mercedes mechanic. There were no issues with the car and no indication that there might be a problem. Our mechanic has thoroughly inspected the vehicle and said that the engine has completely seized and the only option is to replace it. We have no idea why this happened. If requested, the vehicle is available for inspection.
NHTSA complaint #11739738 — an unverified report by a vehicle owner.
While driving at night all error light showed up. I slowed down to the side of the road and while I was slowing down the engine died. I tried to start the car which worked but when I pressed the gas the engine died again. Tried it two more times with the same results. Then turned the car and waited a bit with the engine running. slowly started driving and was able to get home driving 20 mph. The next day took it to a shop that said that the battery was weak and they replaced the battery. Drove out of the shop and started hearing nosies from the engine. Immediately came back and was advised to take it to the dealer. Towed it to the dealer that checked it and said that they found metal in the oil filter and that I need to install a new engine. I read online and found many complains about the same engine issue with 2021 Mercedes GLE 350. Mercedes refuses to take responsibility that they built a faulty engine.
NHTSA complaint #11719430 — an unverified report by a vehicle owner.
Cooling system failure due to cracked coolant line beneath intake manifold at 57,000 miles. Part # 264-200-42-01. Sudden coolant loss can cause engine overheating and potential engine stall while driving, posing safety risks. The original part was plastic and has been superseded by manufacturer to metal, suggesting design inadequacy. This was confirmed by Mercedes Benz dealership and also by MB USA. There have been multiple reports by other owners online, indicating this has been a common problem on a 2020 GLE 350. There was also an article in Jan 2022 stating that Mercedes had sent a letter to 800,000 owners informing them of a defect, but no there was no recall due to part shortage. https://www.insurancejournal.com/news/international/2022/01/05/648140.htm Yes, dealership has diagnosed it and confirmed this is the problem. There was a warning lamp/message stating low coolant level, which prompted me to take the vehicle to the dealership. Car has been serviced regularly at the Mercedes dealership. Strong risk of overheating.
NHTSA complaint #11717671 — an unverified report by a vehicle owner.
This is regarding a 2021 gle 350. The car was parked overnight and in the morning was unable to start or crank . I had to tow the vehicle to the service center that has maintained the car since purchased date and they told Me there’s a problem with the engine and I will need a new engine costing $28,000 dollars., the car has 42,000 miles and has an impeccable service history with Mercedes Benz. They did not tell me any specific engine part that’s faulty. There was no warning lights, check engine lights. Had I been driving this car and it happened it could have been catastrophic.
NHTSA complaint #11717456 — an unverified report by a vehicle owner.
There is a known issue with the Cylinder Heads on specific models of Mercedes vehicles. Symptoms of M264 Cylinder Head Failure If your GLE 350 is experiencing these symptoms, it may be covered under the extension: Check Engine Light (MIL): Often triggered by misfire codes. Rough Idle: Noticeable shaking or uneven idling when stopped. Loss of Power: Potential stalling or significant power reduction during acceleration. Low Compression: Diagnostic tests often reveal low pressure in one or more cylinders. This is not being addressed my Mercedes USA where Mercedes Canada has offered an extended warranty. Using social media I have comprised a list of over a hundred impacted owners. Many more exist. What this does is cost catastrophic failure of the engine leaving the driver stranded in whatever lanes they were traveling in. I am disabled and for me this created a life threatening situation. When reaching out to MBUSA the answer is simply "not warranty exists" where MB Canada has extended the warranty to an additional 15k miles from notice. My engine blew. The replacement cost is near $20,000 dollars. The mileage on my engine was 65k. Many others are impacted and a class action lawsuit is the only other course of action it seems. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11709741 — an unverified report by a vehicle owner.
Check engine light came on. Called dealership on a Thursday and again on Monday after it stayed on all weekend. Was told to bring in vehicle for diagnostics and to have a ride home. Half way to the dealership the car spuddered and I had to coast to the shoulder of the road. After a few minutes, I restarted the vehicle and drive slowly to the dealership, barely making it it the shop. The service advisor indicated it could be the cylinder head even before running diagnostics because it had happened to numerous other customers. It was a defective cylinder head. The repair bill was over $10,000 but Mercedes offered a $3,500 assistance credit. After doing some research on the internet, this appears to be a widespread issue.
NHTSA complaint #11707431 — an unverified report by a vehicle owner.
The contact owns a 2022 Mercedes-Benz GLE 350. The contact stated that while driving 60 MPH, the vehicle hesitated and failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light illuminated. The contact pulled over to the side of the road and turned off the vehicle. After waiting a few minutes, the vehicle was restarted; however, the contact noticed an abnormal sound coming from the engine while driving. The check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that a cylinder head had cracked. The vehicle was not repaired. The vehicle remained at the dealer unrepaired. The manufacturer was made aware of the failure. The failure mileage was approximately 57,000.
NHTSA complaint #11705385 — an unverified report by a vehicle owner.
The contact owns a 2020 Mercedes-Benz GLE350. The contact stated that while driving at various speeds, the vehicle failed to accelerate as intended while the accelerator pedal was depressed. The check engine warning light was illuminated. In addition, the contact stated that while the vehicle was stopped, the vehicle was idling low. The vehicle was taken to a local dealer, where it was diagnosed with a misfire in cylinder #4. The vehicle was not repaired. Upon further investigation, the contact related the failure to a NHTSA recall; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
NHTSA complaint #11704672 — an unverified report by a vehicle owner.
Original owner of a 2021 GLE, purchased on April 21, 2021. The vehicle is currently 4 years and 6 months and 22 days old with approximately 49,000 miles. Despite meticulous adherence to all scheduled maintenance performed and no warning lights activated the vehicle suddenly shutdown and would not restart. According to MB maintenance department it suffered a catastrophic and complete engine failure. This type of premature and total engine failure in a properly maintained, low-mileage vehicle is clearly a defect in material or workmanship. This is a serious safety defect that rendered the vehicle completely inoperable with no warning. Issues are resulting from valve guide wear issues, camshaft codes, valve openness, and no-compression symptoms, camshaft, timing chain, etc.
NHTSA complaint #11704589 — an unverified report by a vehicle owner.
Cylinder head is defective and needs replacing. It is at the dealer for service at the tune of $7700. The car will not accelerate and sounds like it is in the wrong gear. Upon searching the Internet it seems like there are tons as in 1000’s of 2020, 2021 and 2023 Mercedes GLE 350s all having the same problem. There should be a recall as most cars are seeing this problem at 20,000 to 30,000 miles and at times when it is replaced, it turns around and happens again. Starting misfiring in October and continued to get worse.
NHTSA complaint #11701359 — an unverified report by a vehicle owner.
we own a Mercedes-Benz GLE 350 model 2021. Our vehicles engine has stopped running on two different occasions, resulting in a very scary near miss accident situation. The first time this happened was it 22,000 miles, the engine shut off as a result of a failure in the engine cylinder head valve that burned up, causing the car to shut off in the middle of an intersection. The second incident happened at 56,000 miles where the vehicles engine shut off. This was also in the middle of an intersection, this time turning left in front of traffic. The reason why the engine turned off was because the lower part of the engine lost a rod bearing.this is what the dealership told us which cause the engine to have low compression and turn off. In both incidences, the check engine light did not come on. There was no warning. There are several people that have exactly the same problem with their vehicle and have also had the same two situations with two separate repairs made to their cars. People online are calling these Covid engines because the materials that were used to build the engines were made during Covid and they have defects. The GLA 350 model year 2021 appears to be the only year the GLE 350’s are having these issues. Mercedes-Benz refuses to acknowledge any of these issues and is not willing to help properly fix the engines. The only way to properly fix the engine is to completely replace it because it is full of defective parts and after the engine has failed the engines cannot be repaired.. This leaves us with no alternative to try and repair the vehicle ourselves so we are 100% relying on Mercedes to do the right thing and fix the problems that they caused to this 2021 model year GLE 350.
NHTSA complaint #11700231 — an unverified report by a vehicle owner.
The contact owns a 2021 Mercedes-Benz GLE350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the cylinder head. The vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 74,000.
NHTSA complaint #11699818 — an unverified report by a vehicle owner.
While driving, the vehicle’s serpentine/fan belt snapped. The loose belt struck and pulled out a sensor plug. Immediately the engine shut down and was later found to be seized. The vehicle had no prior warnings or known issues and was maintained according to manufacturer recommendations. There were no other warning signs ahead, the car is always maintained. I have records of all the maintenance, and there was not a single Check engine light, or any other kind of issue. Consequence: Engine seized, vehicle not drivable, substantial repair or replacement required. •Condition & maintenance: All services up-to-date, regular oil changes, no previous related issues. •Supporting documentation: Mechanic’s inspection report, service records, tow bill, photos of belt damage and sensor plug. •Impact: Unexpected catastrophic failure at low mileage; potential defect in belt/pulley/auxiliary-system interface posing risk of sudden breakdown. •Request: Investigation of whether this is an isolated failure or a possible defect pattern.
NHTSA complaint #11698005 — an unverified report by a vehicle owner.
Engine Cylinder Head Failure on CPO Mercedes-Benz GLE 350 Vehicle Information: •Make: Mercedes-Benz •Model: GLE 350 •Year: 2020 •Mileage at time of issue: 90,000 Summary of Complaint: The vehicle experienced a premature cylinder head failure, resulting in significant engine damage and repair costs. There were no prior warning lights or diagnostic codes indicating a problem before the failure occurred. The malfunction caused sudden performance issues, including rough idling, misfiring, and loss of power. Details of the Incident: While operating the vehicle under normal driving conditions, the engine began to run roughly and lost power unexpectedly. Diagnostic testing revealed that the cylinder head had failed, which appears to be a mechanical or manufacturing defect rather than wear and tear. The repair estimate from the dealership was approximately $8,900, which is disproportionately high for a vehicle of this age and mileage. Safety Concerns: This type of failure could lead to sudden engine shutdown or loss of power while driving, posing a safety risk to occupants and other drivers on the road. Manufacturer Case Reference: This issue has also been reported to Mercedes-Benz under case number 18281587. Additional Information: After research, it appears that other Mercedes-Benz GLE owners have reported similar issues related to engine component failures, suggesting this may be a broader quality or manufacturing issue that warrants investigation. Requested Action: Requesting that NHTSA investigate potential defects in the engine or cylinder head assembly for the 2020 Mercedes-Benz GLE 350 and determine whether a recall or service bulletin is appropriate.
NHTSA complaint #11696713 — an unverified report by a vehicle owner.
The contact owns a 2021 Mercedes-Benz GLE350. The contact stated that while driving 65-70 MPH, the vehicle was skipping. The contact immediately veered towards an exit ramp. The contact noticed knocking sounds coming from the engine, and the vehicle stalled on the exit ramp. There was smoke coming from underneath the hood. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the engine had imploded and sustained a hole. The dealer determined that the engine needed to be replaced. Additionally, the dealer took the engine apart and informed the contact that the cause of the engine implosion could not be determined even with the assistance of the engineers. The vehicle was not repaired due to the cost. The contact then brought an independent mechanic to the dealer to inspect the vehicle. The mechanic inspected the engine and informed the contact that the failure had occurred due to a lack of engine oil; however, the contact stated that the dealer had performed an oil change on the vehicle 27 days prior to the failure. The manufacturer was notified of the failure but denied assistance in covering the repair. The manufacturer informed the contact that the engineers had not yet determined the cause of the engine implosion. The failure mileage was 69,100.
NHTSA complaint #11695392 — an unverified report by a vehicle owner.
I am writing to express serious concern regarding a potentially dangerous mechanical issue with my Mercedes GLE 350. The vehicle has experienced a complete cylinder head failure, requiring an estimated $7,000 repair. Both an independent service center and an authorized Mercedes service center have confirmed this diagnosis. During the inspection process, Mercedes conducted two diagnostic tests—one costing $250 and a second costing $700—before determining that the cylinder head must be replaced. I was informed by the Mercedes service advisor that the company is aware this issue has affected other GLE 350 vehicles; however, no recall has been issued to date. This failure presents a significant safety risk. The vehicle suddenly loses power without warning, and acceleration becomes severely limited, often not exceeding 20–40 mph even when pressing the accelerator fully. The check engine light illuminates at the time of power loss, leaving the driver unable to maintain safe highway speeds or merge with traffic—posing a serious hazard to both the driver and others on the road. Given that this appears to be a known issue, I am requesting immediate review and investigation by Mercedes-Benz. A recall or formal service campaign should be considered to address this potentially dangerous defect and to ensure the safety of all affected drivers. Thank you for your prompt attention to this matter.
NHTSA complaint #11694542 — an unverified report by a vehicle owner.