Owners have filed 42 complaints
about the 2016 Mercedes Benz Sprinter 2500 with NHTSA between 2016 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 6 of 13 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 48
Against the median year of the Mercedes Benz Sprinter 2500. 50 means typical for this
model; 100 means roughly double.
Severity — 12
2.4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
74% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2016 compares with every other Mercedes Benz Sprinter 2500
Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade:
A
B
C
D
F
ungraded
What breaks on a 2016 Mercedes Benz Sprinter 2500
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Airbags
921.4%
Median failure at 22,000 miles
Acceleration & Cruise Control
511.9%
Median failure at 42,800 miles
Brakes
49.5%
Median failure at 35,000 miles
Steering
49.5%
Other & Unspecified
37.1%
Median failure at 35,000 miles
Seat Belts
37.1%
Median failure at 23,500 miles
Electrical System
37.1%
0 crashes, 1 fires · median 93,000 mi
Engine & Cooling
37.1%
Median failure at 175,000 miles
Wheels
24.8%
Median failure at 35,000 miles
Body & Structure
24.8%
Doors, Latches & Locks
12.4%
Median failure at 2,500 miles
Stability & Traction Control
12.4%
Median failure at 24,000 miles
Lights
12.4%
Transmission & Drivetrain
12.4%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
15.3%
10,000 – 24,999 miles
631.6%
25,000 – 49,999 miles
736.8%
50,000 – 74,999 miles
210.5%
150,000+ miles
315.8%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
May 2016peak 4Aug 2026
NHTSA investigations into the 2016 Mercedes Benz Sprinter 2500
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
The Office of Defects Investigation (ODI) analyzed complaint data provided by Daimler Vans USA, LLC (Daimler) as well as complaints submitted to ODI from consumers to identify incidents related to Rear Wheel Speed Sensors (RWSS) failures. ODI's analysis identified 6,710 incidents of RWSS failure (unique VINs) in MY 2012-2018 Mercedes- Benz and Freightliner Sprinter vehicles upfitted to campers or recreational vehicles (RVs) representing 81 percent of all Sprinter RWSS reports. Complaint and warranty analysis indicated that the majority of incidents (approximately 99%) were related to RWSS mois...
Recalls on the 2016 Mercedes Benz Sprinter 2500
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201945523,448 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the passenger-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Owners will be notified by mail and instructed to take their vehicle to a dealer to have the passenger-front airbag module replaced. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected. Additional note: This recall supersedes recall 2018-648.
Recall 201945426,050 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the driver-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Owners will be notified by mail and instructed to take their vehicle to a dealer to have the driver-front airbag module replaced. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected. Additional note: This recall supersedes recall 2016-159.
Recall 2017463138 units in Canada
Label
On certain vehicles, the unloaded vehicle weight (UVW) label located within the engine compartment, which may be required by intermediate and final-stage manufacturers, may be incorrect. Correction: A production change has been undertaken to remedy this error and has been deemed to be non-safety related. Under a Service Campaign Bulletin, dealers will replace the label with a revised one that contains the correct vehicle weight data.
Recall 2017295193 units in Canada
Label
On certain vehicles, the tire pressure label located on the B-pillar may not contain the correct front axle tire pressure information. Incorrect tire pressure could lead to tire failure, resulting in loss of vehicle control increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect, and if necessary, replace the tire pressure label.
Recall 201711858 units in Canada
Structure
On certain vehicles, the bracket for the intermediate bearing of the drive shaft may not have been welded correctly during assembly. The retaining function of the bracket may be compromised, potentially causing it to become loose. In the event of a frontal crash the bracket may become loose and the drive shaft could damage the fuel system, allowing a fuel leak to occur. Fuel leakage, in the presence of an ignition source, could result in a fire. Correction: Dealers will fix the bracket of the intermediate bearing of the drive shaft with three additional rivets.
Recall 201644512 units in Canada
Seats And Restraints
On certain vehicles the lower seat belt anchorage bolts for the rear bench seat may not have been torqued to specification during assembly. This could cause the seat belts to fail to adequately restrain occupants in a crash, increasing the risk of injury and/or damage to property. Correction: Dealers will inspect the bolt torque of the seat belt anchorages, and tighten as necessary.
Recall 201619227 units in Canada
Structure
On certain vehicles, the paint used on the body structure may contain a defect that could allow the top layer to separate. In the event of a crash, this could allow the windows to peel away from the vehicles due to insufficient adhesion in between the layers of paint, increasing the risk of injury. Correction : Dealers will renew the paintwork of the affected areas.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 11,000 milesJupiter, FLFire
ELECTRICAL SYSTEM
RV TRANSFER SWITCH CAUGHT FIRE WHILE SLEEPING. 5100 SERIES TRANSFER SWITCH.*DT CONSUMER STATED DIDN'T KNOW WHY IT HAPPENED BUT COULD OF BEEN THE VIBRATION WHICH MAY HAVE LOOSEN THE SCREWS.
NHTSA complaint #11360859 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Danville, CA
UNKNOWN OR OTHER
The door latch and or roller failed which prevents the door from closing properly. Since the door does not close all the way, there is the risk that it opens while driving. This is a recurring issue I have on this vehicle and triggered a lemon-law buyback.
NHTSA complaint #11757000 — an unverified report by a vehicle owner.
Brownsville, TX
STEERING
The power steering system lost it's fluid and pump is cavitating. It's available for inspection. The vehicles can be steered at the moment, but if it were to fail completely, it could cause loss of control at highway speeds. The problem is ongoing but hasn't been presented to a dealer or independent service center. No, the this hasn't been inspected. There were no warning lamps or messages or symptoms prior to failure. NOTE: there is an existing recall for 2015-2020 Sprinter vans for this issue, however upon contacting the dealership, the 2016 model doesn't currently fall under this recall.
NHTSA complaint #11667211 — an unverified report by a vehicle owner.
Brownsville, TX
STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID
The power steering system lost it's fluid and pump is cavitating. It's available for inspection. The vehicles can be steered at the moment, but if it were to fail completely, it could cause loss of control at highway speeds. The problem is ongoing but hasn't been presented to a dealer or independent service center. No, the this hasn't been inspected. There were no warning lamps or messages or symptoms prior to failure. NOTE: there is an existing recall for 2015-2020 Sprinter vans for this issue, however upon contacting the dealership, the 2016 model doesn't currently fall under this recall.
NHTSA complaint #11667211 — an unverified report by a vehicle owner.
Live Oak, FL
EXTERIOR LIGHTING
The primary issue is the seal on the air conditioning unit, which is on top of the Sprinter van. Prior to purchasing it, we read multiple reviews that the seal breaks frequently and water pours into the cabin. It is a known defect and quite prevalent. Whenever we drive through rain and the seal is intact, we get drips of rain. When the seal needs to be replaced, gallons of water pour into the cabin. Replacing the seal costs thousands of dollars and we've replaced it a few times. We travel with buckets and a dozen bath towels in case we drive through rain. Seals for the air conditioning unit only last about a year before a new one is needed. Our local dealership is aware that this a widespread problem on Sprinters but Mercedes is refusing to to fix the issue. Secondly, the interior lights do not work. We've had them replaced and they quickly stop working. I'm not certain how prevalent this issue is in other Sprinters, but it is an issue that does not appear to have a long-time fix on our model.
NHTSA complaint #11605186 — an unverified report by a vehicle owner.
Live Oak, FL
STRUCTURE:BODY
The primary issue is the seal on the air conditioning unit, which is on top of the Sprinter van. Prior to purchasing it, we read multiple reviews that the seal breaks frequently and water pours into the cabin. It is a known defect and quite prevalent. Whenever we drive through rain and the seal is intact, we get drips of rain. When the seal needs to be replaced, gallons of water pour into the cabin. Replacing the seal costs thousands of dollars and we've replaced it a few times. We travel with buckets and a dozen bath towels in case we drive through rain. Seals for the air conditioning unit only last about a year before a new one is needed. Our local dealership is aware that this a widespread problem on Sprinters but Mercedes is refusing to to fix the issue. Secondly, the interior lights do not work. We've had them replaced and they quickly stop working. I'm not certain how prevalent this issue is in other Sprinters, but it is an issue that does not appear to have a long-time fix on our model.
NHTSA complaint #11605186 — an unverified report by a vehicle owner.
Oyster Bay, NY
WHEELS
Had 2 rims develop cracks causing loss of air pressure in tires. 1st occurred at approx. 45000 miles (2019), 2nd occurred at 110000 (2023). Both failures occurred to area of rim where welds to lock in center (with lug holes) on outer rim (where tire sits) are situated. Both failures manifested as small air leak then suddenly crack increases in size dramatically to where tire can only hold air for a few hours before deflating fully
NHTSA complaint #11567265 — an unverified report by a vehicle owner.
Cincinnati, OH
ENGINE
The check engine light came on in the Sprinter van. There is a Hissing noise coming from the engine when accelerating. The Sprinter van loses speed when on the highway. The vehicle could not keep up with traffic on the road. The Mercedes Benz dealer, Ft. Mitchell, Kentucky has inspected the vehicle and stated that it has a defective intake manifold. This vehicle has 140,000 miles at this time. At this time the van has not been repaired, the cost is $3132.77
NHTSA complaint #11532688 — an unverified report by a vehicle owner.
Honolulu, HI
AIR BAGS
The contact owns a 2016 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 19V003000 (Air Bags), 19V004000 (Air Bags), and 20V663000 (Steering) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11526686 — an unverified report by a vehicle owner.
Honolulu, HI
STEERING
The contact owns a 2016 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 19V003000 (Air Bags), 19V004000 (Air Bags), and 20V663000 (Steering) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11526686 — an unverified report by a vehicle owner.
Sioux Falls, SD
VEHICLE SPEED CONTROL
There is a known issue and recall for wheel speed sensors on Mercedes Sprinter 3500 models. However, this same issue applied to 2500 models also. Along with other RV owners, I have just experienced this problem. I was in city traffic when all the sudden multiple warning lights came on: "ESP, visit workshop", "Brake force distribution, visit workshop", ABS warning light, ESP, warning light, collision prevention malfunction warning light, check engine light with fault code U0416. The presence of all these errors, beeping, red messages sounds extremely scary to any driver. The fact that it says brake force distribution isn't working properly suggests a hazardous condition that could lead to a crash if brakes are not working properly. Since this is being caused by a failing wheel speed sensor, these should all be replaced and the recall expanded to include other models like mine.
NHTSA complaint #11440448 — an unverified report by a vehicle owner.
Sioux Falls, SD
ENGINE
My 2016 Sprinter is suffering from a failing EGR valve that's causing intermittent power loss. The issue started after only 25000mi on the odometer. No errors are shown, nothing indicates malfunction. The problem is quite severe and presenting itself through random power loss. When accelerating the car will jerk and lose acceleration force suddenly. Driving uphill is the worst and producing constant jerking. Once moving at a good speed it's less notable but still present. The main safety concern is that the behavior is unpredictable and in situations where it's necessary to accelerate into a road with traffic, this can lead to a hazardous when the car doesn't accelerate as intended. In multiple occasions I was unable to properly speed up and get moving and thus blocking traffic behind me and forcing them to slow down or change lanes. The Mercedes dealer diagnosed a malfunctioning EGR valve on the edge of failing completely which would put the Sprinter in "limp home mode" which has limited power output to prevent further damage. Since this is a known issue and the EGR valves have been failing frequently with various Sprinter models, these should be recalled and replaced! Currently, it's not even possible to get this issue addressed. The EGR valves are back-ordered and not available for 6 MONTHS! That's 6 months of limping through traffic with the potential of the valve failing completely. Unacceptable!
NHTSA complaint #11440452 — an unverified report by a vehicle owner.
Sioux Falls, SD
SERVICE BRAKES
There is a known issue and recall for wheel speed sensors on Mercedes Sprinter 3500 models. However, this same issue applied to 2500 models also. Along with other RV owners, I have just experienced this problem. I was in city traffic when all the sudden multiple warning lights came on: "ESP, visit workshop", "Brake force distribution, visit workshop", ABS warning light, ESP, warning light, collision prevention malfunction warning light, check engine light with fault code U0416. The presence of all these errors, beeping, red messages sounds extremely scary to any driver. The fact that it says brake force distribution isn't working properly suggests a hazardous condition that could lead to a crash if brakes are not working properly. Since this is being caused by a failing wheel speed sensor, these should all be replaced and the recall expanded to include other models like mine.
NHTSA complaint #11440448 — an unverified report by a vehicle owner.
at 50,600 milesFredericksburg, VA
VEHICLE SPEED CONTROL
The contact owns a 2016 Mercedes-Benz 2500. The contact stated while driving 21 mph, the vehicle independently accelerated when the brake pedal was depressed. The contact was not able to control the vehicle however, the contact was able to shift the vehicle into neutral to stop the vehicle. The contact stated there was no warning light illuminated. The vehicle was not taken to a local dealer nor an independent mechanic to be diagnosed. The contact was relating the failure to faulty wheel speed sensors. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 50,600.
NHTSA complaint #11424928 — an unverified report by a vehicle owner.
at 50,600 milesFredericksburg, VA
SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR
The contact owns a 2016 Mercedes-Benz 2500. The contact stated while driving 21 mph, the vehicle independently accelerated when the brake pedal was depressed. The contact was not able to control the vehicle however, the contact was able to shift the vehicle into neutral to stop the vehicle. The contact stated there was no warning light illuminated. The vehicle was not taken to a local dealer nor an independent mechanic to be diagnosed. The contact was relating the failure to faulty wheel speed sensors. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 50,600.
NHTSA complaint #11424928 — an unverified report by a vehicle owner.
Cincinnati, OH
STEERING
MY ROOF IS LEAKING. I HAVE BEEN WONDERING WHERE THE STAINS ARE COMING FROM ON MY CEILING. TODAY IS A RAINY DAY IN CINCINNATI. I GO TO PUT MY GROCERY IN THE VAN THE CEILING IS SOAK AND WET. NOW I UNDERSTAND WHY MY DISABLED CHILD AND I STAY SICK AND WHY ITS RUSTING OUT.
NHTSA complaint #11407428 — an unverified report by a vehicle owner.
Cincinnati, OH
STRUCTURE:BODY
MY ROOF IS LEAKING. I HAVE BEEN WONDERING WHERE THE STAINS ARE COMING FROM ON MY CEILING. TODAY IS A RAINY DAY IN CINCINNATI. I GO TO PUT MY GROCERY IN THE VAN THE CEILING IS SOAK AND WET. NOW I UNDERSTAND WHY MY DISABLED CHILD AND I STAY SICK AND WHY ITS RUSTING OUT.
NHTSA complaint #11407428 — an unverified report by a vehicle owner.
Cincinnati, OH
ELECTRICAL SYSTEM
MY ROOF IS LEAKING. I HAVE BEEN WONDERING WHERE THE STAINS ARE COMING FROM ON MY CEILING. TODAY IS A RAINY DAY IN CINCINNATI. I GO TO PUT MY GROCERY IN THE VAN THE CEILING IS SOAK AND WET. NOW I UNDERSTAND WHY MY DISABLED CHILD AND I STAY SICK AND WHY ITS RUSTING OUT.
NHTSA complaint #11407428 — an unverified report by a vehicle owner.
Stilwell, OK
UNKNOWN OR OTHER
I'VE OWNED THIS CAR 2 YEARS. IN THE SUMMER TIME WHEN WE TURN ON THE A/C THERE IS A BAD ODOR COMING OUT OF THE VENTS. ONLY IN THE SUMMER IT'S NOT A PLEASANT SMELL. DURING THE WINTER TIME LAST YEAR WAS A GASOLINE SMELL BUT THAT GOT FIXED. I WOULD LIKE FOR YOU TO LOOK INTO IT PLEASE IT'S A MOLDY SMELL.
NHTSA complaint #11403650 — an unverified report by a vehicle owner.
at 35,000 milesVancouver, WA
VEHICLE SPEED CONTROL
THE WHEEL SENSORS ON THIS VEHICLE ROUTINELY FAIL. WHEN THEY FAIL AT HIGH SPEEDS(FREEWAY DRIVING) THE CRUISE CONTROL, ABS, STABILITY CONTROL, 4WD IS NO LONGER FUNCTIONAL. IF IT FAILS AT START UP, ALL THE SAME SYSTEMS ARE EFFECTED IN ADDITION YOU CANNOT DRIVE THE VEHICLE OVER 30MPH, IT WILL ACCELERATE ON ITS OWN, IT WILL SURGE ALSO. THIS HAS HAPPENED EVERY YEAR I HAVE OWNED THE VEHICLE. SOMETIMES TWICE A YEAR. EACH WHEEL SENSOR HAS FAILED, SOME TWICE.
NHTSA complaint #11375781 — an unverified report by a vehicle owner.
at 35,000 milesVancouver, WA
WHEELS
THE WHEEL SENSORS ON THIS VEHICLE ROUTINELY FAIL. WHEN THEY FAIL AT HIGH SPEEDS(FREEWAY DRIVING) THE CRUISE CONTROL, ABS, STABILITY CONTROL, 4WD IS NO LONGER FUNCTIONAL. IF IT FAILS AT START UP, ALL THE SAME SYSTEMS ARE EFFECTED IN ADDITION YOU CANNOT DRIVE THE VEHICLE OVER 30MPH, IT WILL ACCELERATE ON ITS OWN, IT WILL SURGE ALSO. THIS HAS HAPPENED EVERY YEAR I HAVE OWNED THE VEHICLE. SOMETIMES TWICE A YEAR. EACH WHEEL SENSOR HAS FAILED, SOME TWICE.
NHTSA complaint #11375781 — an unverified report by a vehicle owner.
at 35,000 milesVancouver, WA
SERVICE BRAKES
THE WHEEL SENSORS ON THIS VEHICLE ROUTINELY FAIL. WHEN THEY FAIL AT HIGH SPEEDS(FREEWAY DRIVING) THE CRUISE CONTROL, ABS, STABILITY CONTROL, 4WD IS NO LONGER FUNCTIONAL. IF IT FAILS AT START UP, ALL THE SAME SYSTEMS ARE EFFECTED IN ADDITION YOU CANNOT DRIVE THE VEHICLE OVER 30MPH, IT WILL ACCELERATE ON ITS OWN, IT WILL SURGE ALSO. THIS HAS HAPPENED EVERY YEAR I HAVE OWNED THE VEHICLE. SOMETIMES TWICE A YEAR. EACH WHEEL SENSOR HAS FAILED, SOME TWICE.
NHTSA complaint #11375781 — an unverified report by a vehicle owner.
at 11,000 milesJupiter, FLFire
ELECTRICAL SYSTEM
RV TRANSFER SWITCH CAUGHT FIRE WHILE SLEEPING. 5100 SERIES TRANSFER SWITCH.*DT CONSUMER STATED DIDN'T KNOW WHY IT HAPPENED BUT COULD OF BEEN THE VIBRATION WHICH MAY HAVE LOOSEN THE SCREWS.
NHTSA complaint #11360859 — an unverified report by a vehicle owner.
at 14,000 milesHays, KS
AIR BAGS
WE RECEIVED A SAFETY RECALL (NHTSDA #19V004) INDICATING THE PASSENGER-SIDE AIRBAG IS AFFECTED BY THIS RECALL BASED ON THE DEFECT DECISION OF TK HOLDINGS, INC. ("TAKATA"). AT THE TIME WE WERE BATTLING CANCER AND THE CORONA VIRUS, SO WE DID NOT GET IT SERVICED AND IT REMAINED IN THE STORAGE. IN THE MEANTIME WE RECEIVED NUMEROUS CALLS TO BRING IT IN FOR SERVICE, BUT DID NOT HAVE THE TIME TO GET IT OUT OF STORAGE AND DRIVE 400 MILES TO GET THE RECALL FIXED. NOW THAT WE HAVE THE TIME, WE CALLED MERCEDES DEALER AND MAIN COMPANY, BUT THEY INDICATE THE RECALL DISAPPEARED EVEN THOUGH WE HAVE A LETTER AND RECEIVED MANY CALLS PRIOR TO GET IT CHANGED OUT. THE LETTER INDICATES "THE DEFECT IN YOUR PASSENGER-SIDE AIRBAG INFLATOR MAY CAUSE THE INFLATOR HOUSING TO RUPTURE.A PASSENGER-SIDE INFLATOR RUPTURE DURING DEPLOYMENT COULD RESULT IN METAL FRAGMENTS STRIKING THE FRONT PASSENGER OR OTHER OCCUPANTS, POSSIBLY CAUSING SERIOUS INJURY OR DEATH." SO WE ARE CONCERNED. HOW DID MERCEDES MAKE THIS DISAPPEAR WITHOUT CORRECTING THE PROBLEM?
NHTSA complaint #11350944 — an unverified report by a vehicle owner.
at 24,000 milesMiami, FL
VEHICLE SPEED CONTROL
MY 2016 2500 SPRINTER CONTINUES TO HAVE WHEEL SPEED SENSOR FAILURES EVERY 2K-3K MILES. WHEN THIS HAPPENS THE TRANSMISSION ACTS ERRATICALLY, ANTI-LOCK BRAKE SYSTEM STARTS TO ENGAGE AND DISENGAGE SPORADICALLY AND THE VAN SOMETIME ACCELERATES AND PREVENTS STOPPING. THIS CREATES A VERY DANGEROUS SITUATION, ESPECIALLY WHEN IN THE RAIN OR EVEN HEAVY TRAFFIC. EVNTUALLY ONCE THE SYSTEM DETECTS THE FAILURE IT LIGHTS UP THREE LIGHT ON THE DASH AND DISABLES THE ANTI-LOCK BRAKES, ESP, AND TRACTION CONTROL. THE TRANSMISSION CONTINUES TO SHIFT ERRATICALLY AT TIMES EVEN AFTER LIGHTS COME ON.
NHTSA complaint #11350382 — an unverified report by a vehicle owner.
at 24,000 milesSaint Petersburg, FL
ELECTRONIC STABILITY CONTROL (ESC)
AT 24,000 MILES TWO WHEEL SPEED SENSORS FAILED CAUSING ESP, ABS, AND CHECK ENGINE WARNING LIGHTS TO ILLUMINATE. ALSO THIS DISABLED THE CRUISE CONTROL. VEHICLE SAT OVERNIGHT AND UPON STARTING NO ERROR MESSAGES APPEARED. THE FOLLOWING DAY THESE ISSUES REOCCURRED. TOOK VEHICLE TO MB DEALER FOR DIAGNOSTICS, WHICH CONFIRMED THE SPEED SENSOR FAILURES. COST OF REPAIR $1,100. UNDERSTAND THIS IS A KNOWN, COMMONLY REPORTED PROBLEM WITH SPRINTERS BETWEEN 2013 - 2016. MB SHOULD BE HELD RESPONSIBLE FOR RECALLS AND THE COST OF REPAIRS.
NHTSA complaint #11350521 — an unverified report by a vehicle owner.