2008 Mini Cooper Clubman S problems

AIR BAGS

The contact owns a 2008 Mini Cooper S. The contact stated while driving at an undisclosed speed, the air bag warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The contact used an OBD scanner and retrieved a DTC regarding the passenger seat occupant detection sensor. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 15V205000 (Air Bags) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 85,000.

NHTSA complaint #11554956 — an unverified report by a vehicle owner.

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

The contact owns a 2008 Mini Cooper S. The contact stated while driving at an undisclosed speed, the air bag warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The contact used an OBD scanner and retrieved a DTC regarding the passenger seat occupant detection sensor. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 15V205000 (Air Bags) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 85,000.

NHTSA complaint #11554956 — an unverified report by a vehicle owner.

ENGINE

MY 2008 MINI COOPER S CLUBMAN APPEARS TO BE HAVING A PROBLEM WITH THE TIM ING CHAIN TENSIONER AND TIMING CHAIN. THE NOISE IS STEADILY GETTING WORSE. AFTER READING ABOUT THE CLASS ACTION LAWSUITS AROUND THE UNITED STATES I AM NOW AFRAID TO DRIVE THE CAR. IF THE TIMING CHAIN DESIRES TO COME APART ON THE FREEWAY THE SUDDEN LOSS OF STEERING AND BRAKES COULD CAUSE A MAJOR ACCIDENT BY ENGINE SEIZING UP IF THE TIMING CHAIN LET'S GO. ALSO THE DAMAGE TO THE ENGINE WOULD COST SO MUCH IT WOULD NOT BE WORTH FIXING.LEAVING US WITH A $7500 OWED ON A VEHICLE WE CANNOT USE.

NHTSA complaint #11060861 — an unverified report by a vehicle owner.

AIR BAGS

AIR BAG LIGHT ON.

NHTSA complaint #11058459 — an unverified report by a vehicle owner.

ENGINE

I HAVE HAD MAJOR PROBLEMS WITH MY ENGINE EVER SINCE I HAVE HAD MY MINI COOPER S CLUBMAN. THE TURBO IS LOOSE, THERE IS OIL BURNING OFF OF MY ENGINE, AND IT MAKES TERRIBLE SCREECHING SOUNDS THAT COME FROM THE ENGINE. I HAVE JUST LEARNED THAT IT IS COMMON FOR A MINI COOPER TO HAVE PROBLEMS WITH ITS TIMING CHAIN; THUS, CAUSING THIS TERRIBLE SOUND AND ALL THOSE OTHER PROBLEMS. I DID NOT KNOW IT WAS THE TIMING CHAIN, AND NOW THEY ARE HAVING A RECALL ON MOST OF THERE MODELS THAT ARE FROM THE SAME YEAR AS MINE. MY CAR WHENEVER I BRAKE MAKES SCREECHING NOISES THAT COME FROM MY ENGINE, AND I'M WORRIED THAT THIS POOR ENGINE DESIGN WILL CAUSE ME TO GET IN AN ACCIDENT. NOW I HAVE TO POUR MONEY INTO GETTING A NEW TIMING CHAIN, EVEN THOUGH MINI COOPER IS NOW KNOW FOR HAVING TERRIBLE TIMING CHAINS.

NHTSA complaint #10969964 — an unverified report by a vehicle owner.

ENGINE

TIMING CHAIN JUMPED OFF OF DEAD CENTER. HAD TO REPLACE TIMING CHAIR TO NEW UPGRADED ASSEMBLY. COST WAS AROUND $1200.00. UPSET BECAUSE THIS HAS BEEN HAPPENING TO A LOT OF MINI COOPERS. SHOULD HAVE SOME KIND OF RECALL TO CONSUMERS. BMW KNOWS ABOUT THIS.WAS DRIVING HOME FROM OUT OF STATE.

NHTSA complaint #10893396 — an unverified report by a vehicle owner.

ENGINE

THE TIMING CHAIN WAS REPLACED AT 90,000 MILE AND AND NOW NEED TO BE REPLACED AT 104,000 MILES

NHTSA complaint #10860688 — an unverified report by a vehicle owner.

AIR BAGS

AIRBAG WARNING LIGHT WOULD COME ON INTERMITTANTLY WITH A PASSENGER IN THE SEAT. NOW STAYS ON ALL THE TIME WITH OR WITHOUT A PASSENGER. BAD PASSENGER SEAT MATS ARE UNDER RECALL IN MINI COOPER CONVERTIBLES BUT NOT COVERED IN CLUBMAN. $1200 REPAIR IS REQUIRED AND USES SAME PART AS THE CONVERTIBLE. IS RECALL BEING EXPANDED?

NHTSA complaint #10836407 — an unverified report by a vehicle owner.

AIR BAGS

VEHICLE STARTED HAVING TROUBLE TURNING ON AND WHEN IT DID COME ON A LOUD CLANKING NOISE BEGAN. THE CAR COULD BARELY GO OVER 30MPH. 3 HR. DRIVE TOOK US ALMOST 6 HOURS TO GET TO DEALERSHIP. DEALERSHIP STATES IT IS THE TIMING CHAIN AND THE OIL PAN NEEDS TO BE REPLACED.WE FOUND EXCESSIVE WATER IN THE SPARE WHEEL HUB. THE BRAKE LIGHT SENSOR WOULD NOT GO OFF, AIRBAG LIGHT APPEARED, A KNOCKING NOISE IN THE GAS TANK CONSISTED. ETC.

NHTSA complaint #10731817 — an unverified report by a vehicle owner.

ENGINE

VEHICLE STARTED HAVING TROUBLE TURNING ON AND WHEN IT DID COME ON A LOUD CLANKING NOISE BEGAN. THE CAR COULD BARELY GO OVER 30MPH. 3 HR. DRIVE TOOK US ALMOST 6 HOURS TO GET TO DEALERSHIP. DEALERSHIP STATES IT IS THE TIMING CHAIN AND THE OIL PAN NEEDS TO BE REPLACED.WE FOUND EXCESSIVE WATER IN THE SPARE WHEEL HUB. THE BRAKE LIGHT SENSOR WOULD NOT GO OFF, AIRBAG LIGHT APPEARED, A KNOCKING NOISE IN THE GAS TANK CONSISTED. ETC.

NHTSA complaint #10731817 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

VEHICLE STARTED HAVING TROUBLE TURNING ON AND WHEN IT DID COME ON A LOUD CLANKING NOISE BEGAN. THE CAR COULD BARELY GO OVER 30MPH. 3 HR. DRIVE TOOK US ALMOST 6 HOURS TO GET TO DEALERSHIP. DEALERSHIP STATES IT IS THE TIMING CHAIN AND THE OIL PAN NEEDS TO BE REPLACED.WE FOUND EXCESSIVE WATER IN THE SPARE WHEEL HUB. THE BRAKE LIGHT SENSOR WOULD NOT GO OFF, AIRBAG LIGHT APPEARED, A KNOCKING NOISE IN THE GAS TANK CONSISTED. ETC.

NHTSA complaint #10731817 — an unverified report by a vehicle owner.

ENGINE

THE CAR DEVELOPED ENGINE TROUBLE AT 51,934 MILES. WE CALLED OTTO'S MINI DEALERSHIP AND WERE TOLD THAT THE CAR WAS NO LONGER UNDER WARRANTY. WE THEN TOOK CAR TO A LOCAL REPAIR SHOP AND WERE TOLD THAT THE ENGINE NEEDED REPLACING DUE TO FAULTY TIMING CHAIN THAT RESULTED IN EXTENSIVE DAMAGE TO THE CYLINDER HEAD AND PISTONS. UPON RESEARCHING THIS PROBLEM IT APPEARS THAT IT IS VERY COMMON. WE PROCEEDED WITH THE REPAIR AT THE LOCAL SHOP AND FILED WITH MINI TO REQUEST COVERAGE. COVERAGE WAS DENIED SINCE WE DID NOT HAVE CAR SERVICED AT THE DEALER. THE NATURE OF THIS REPAIR AND THE LARGE NUMBER OF REPORTED ISSUES WOULD SUGGEST ONE TO EXPECT MINI TO STAND BEHIND THEIR PRODUCT.

NHTSA complaint #10678763 — an unverified report by a vehicle owner.

ENGINE

THE OIL SUPPLY LINE TO THE TURBO ON THIS CAR LEAKS DUE TO A POOR DESIGN. THE PART(S) USED BY THE MANUFACTURER ARE NOT SUITABLE FOR THE APPLICATION AND FAIL, CAUSING NOT ONLY AN OIL LEAK, BUT A POTENTIAL TURBO FAILURE, AND WORSE, THE POTENTIAL FOR AN ENGINE FIRE, AS THE OIL LEAKS ONTO A HOT TURBO CHARGER AND EXHAUST MANIFOLD/DOWNPIPE. THE OIL LINE USES A COMPRESSION FITTING WHERE IT ATTACHES TO THE TURBO BODY. THIS FITTING USES AN INTERNAL RUBBER O-RING/SEAL THAT IS SUBJECTED TO HIGH HEAT, AND HEAT CYCLES EVERY TIME THE CAR IS RUN. RUBBER SEALS FAIL UNDER THESE CONDITIONS! THE MANUFACTURER (MINI/BMW) IS AWARE OF THE PROBLEM, AND IS DOING NOTHING TO CORRECT IT. (IT'S VERY EXPENSIVE REPAIR) INSTEAD, THE MANUFACTURER IS PROVIDING A "BAND-AID FIX" BY SUPPLYING A "HEAT SHIELD" THAT ATTACHES TO THE FITTING. THIS WILL DO LITTLE-TO-NOTHING TO PREVENT THE RUBBER O-RING FROM FAILING, NOR DOES IT FIX A LINE THAT IS ALREADY LEAKING. THIS FAILURE OCCURS, TYPICALLY, AFTER THE CAR IS OUT OF WARRANTY. IT'S A SERIOUS DESIGN FLAW, AND SHOULD BE A RECALL ITEM DUE TO THE SAFETY ISSUE IT CREATES.

NHTSA complaint #10671191 — an unverified report by a vehicle owner.

ENGINE

THE BANGO FITTING ON TOP OF THE TURBO STARTED RANDOMLY AND EXCESSIVELY LEAKING OIL WHILE IDLING IN MY DRIVEWAY. COULD HAVE CAUSED A FIRE. GOING TO HAVE TO REPLACE THE OIL INTAKE LINE, OIL, AND DO A ENGINE CLEANING. THIS IS VERY DANGEROUS AND COULD HAVE EASILY STARTED A FIRE WITH OIL POURING OVER A HOT TURBO.

NHTSA complaint #10669836 — an unverified report by a vehicle owner.

ENGINE

WE STARTED OUR 2008 MINI CLUBMAN S IN A PARKING LOT AND IT IMMEDIATELY INDICATED A CHECK ENGINE LIGHT (CEL) FOR 'LIMP' MODE. UPON FURTHER INSPECTION, THE UPPER GUIDE RAIL FOR THE TIMING CHAIN HAD SHATTERED. THE ODBII CODES WERE P0300, RANDOM MIS-FIRE, P0301 MIS-FIRE CYLINDER 1, P0303 MIS-FIRE CYLINDER 3 AND P1492, DOWNSTREAM THROTTLE AIR LEAK.

NHTSA complaint #10608012 — an unverified report by a vehicle owner.

ENGINE

I AM DEAF I DRIVE MY 2008 MINI CLUBMAN S MY MOTHER , BROTHER AND FRIEND HEARD MY ENGINE NOISE ENGINE ,I DON'T KNOW I CAN'T HEAR SO I OPEN OIL CAP I SAW BROWN PLASTIC PIECE I FOUND TIMING CHAIN GUIDE IS BAD, THAT IS SHORT LIFE THAT IS WRONG.

NHTSA complaint #10577750 — an unverified report by a vehicle owner.

ENGINE

IN NOVEMBER THE DEALER INFORMED ME MY OIL FEED LINES TO THE TURBO WERE LEAKING AND WOULD NEED TO BE REPLACED SOON. AFTER DOING SOME RESEARCH I HAVE FOUND THE COUPLINGS THAT ATTACHES THESE LINES TO THE TURBO ARE DEFECTIVE. ON THE INTERNET THERE ARE HUNDREDS OF COMPLAINTS ABOUT THIS ISSUE. THE DEALER SAYS THERE IS NOT A RECALL AND WILL COST APPROX: $1200.00. THE DEALER ALSO SAID THE NEW COUPLINGS ARE MANUFACTURED BY A NEW COMPANY AND THE DEFECT HAS BEEN FIXED. WITH SO MANY EFFECTIVE SHOULDN'T MINI BE FIXING THIS ISSUE.

NHTSA complaint #10574919 — an unverified report by a vehicle owner.

ENGINE

I WAS A VICTIM OF THE "DEATH RATTLE" FROM THE TIMING CHAIN TENSIONER FAILURE. LUCKILY FOR ME, I RESEARCHED THE NOISE WHEN I FIRST HEARD IT AND WAS ABLE TO GET IT FIXED BEFORE IT DESTROYED MY ENTIRE ENGINE (ALTHOUGH MINI REFUSED TO PAY FOR THE REPAIRS). BUT OWNERS WHO ARE NOT AWARE OF ISSUE MAY KEEP DRIVING THEIR CAR TO THE POINT OF FAILURE WHICH COULD LEAD TO A FATAL CRASH. IT IS A POORLY MANUFACTURED PART THAT IS CREATING THE PROBLEM WHICH CAN BE EASILY FIXED.

NHTSA complaint #10568041 — an unverified report by a vehicle owner.

ENGINE

THERMOSTAT FAILURE, AS DIAGNOSED BY DEALER. CAR UNDRIVEABLE. WORLD WIDE BAC KORDER ON THE PART FOR 2007-2010 MINI COOPERS. NO KNOWN DATE OF WHEN THE PART WILL BE AVAILABLE (OR IF) AND THE DEALER IN BEDFORD NH, STATED OVER 17,000 OF THESE PARTS ARE ON BACKORDER. A FAILED THERMOSTAT CAN LEAD TO STRANDED MOTORISTS, ENGINE OVERHEATING AND EXTENSIVE ENGINE DAMAGE. THIS PART IS NOTORIOUS FOR PREMATURE FAILURE. SHOULD THIS NOT BE A RECALLABLE ISSUE?

NHTSA complaint #10542036 — an unverified report by a vehicle owner.

POWER TRAIN

WHILE DRIVING UP AN INCLINE ON A SEMI-RURAL ROAD IN ORANGE COUNTY, CA, MY CAR APPEARED TO BE UNABLE TO SHIFT GEARS (IT IS AN AUTOMATIC TRANSMISSION). MY HEAD LURCHED FORWARD AND BACK AGAIN FORCEFULLY, AND I WAS UNABLE TO DRIVE MORE THAN 20 MPH ON A 60 MPH SPEED LIMIT ROAD FOR THE NEXT MILE, UNTIL I ARRIVED AT MY DESTINATION. LUCKILY NO ONE WAS CLOSE BEHIND ME, OR I COULD HAVE BEEN REAR-ENDED, AND LUCKILY I WAS CLOSE TO MY FINAL DESTINATION. I DRIVE A 2008 MINI COOPER CLUBMAN S, AUTOMATIC WITH PADDLE SHIFTERS. IT IS ABOUT $8,300 TO $9,700 TO REPAIR IT (2 DIFFERENT REPAIR QUOTES OBTAINED).

NHTSA complaint #10532089 — an unverified report by a vehicle owner.

ENGINE

WHILE DRIVING UP AN INCLINE ON A SEMI-RURAL ROAD IN ORANGE COUNTY, CA, MY CAR APPEARED TO BE UNABLE TO SHIFT GEARS (IT IS AN AUTOMATIC TRANSMISSION). MY HEAD LURCHED FORWARD AND BACK AGAIN FORCEFULLY, AND I WAS UNABLE TO DRIVE MORE THAN 20 MPH ON A 60 MPH SPEED LIMIT ROAD FOR THE NEXT MILE, UNTIL I ARRIVED AT MY DESTINATION. LUCKILY NO ONE WAS CLOSE BEHIND ME, OR I COULD HAVE BEEN REAR-ENDED, AND LUCKILY I WAS CLOSE TO MY FINAL DESTINATION. I DRIVE A 2008 MINI COOPER CLUBMAN S, AUTOMATIC WITH PADDLE SHIFTERS. IT IS ABOUT $8,300 TO $9,700 TO REPAIR IT (2 DIFFERENT REPAIR QUOTES OBTAINED).

NHTSA complaint #10532089 — an unverified report by a vehicle owner.

ENGINE

THE THERMOSTAT HOUSING HAD A SMALL CRACK IN IT RESULTING IN EXCESSIVE COOLANT LEAK. DUE TO LACK OF TEMPERATURE GAUGE AND NO WARNING LIGHT, I WAS UNABLE TO TELL THAT MY ENGINE WAS OVERHEATING. THIS PROBLEM IS DUE TO A FAULTY PLASTIC THERMOSTAT HOUSING.

NHTSA complaint #10523674 — an unverified report by a vehicle owner.

ENGINE

OIL LEAK FROM TOP OF TURBO OIL LINE CONNECTOR NEAR BANJO BOLT. THIS IS DUE TO A FAULTY O-RING FROM THE MANUFACTURER.

NHTSA complaint #10523672 — an unverified report by a vehicle owner.

ENGINE

ENGINE HAD A COLD START RATTLE FOR A LONG TIME. THEN WHILE DRIVING, THE RATTLE GOT WORSE AND AFTER BEING DIAGNOSED AT THE DEALERSHIP, IT WAS DUE TO THE PLASTIC TIMING GUIDE BREAKING DUE TO NOT ENOUGH TENSION ON THE TIMING CHAIN. I HAD TO STOP DRIVING IMMEDIATELY AND GET MY CAR TOWED TO THE DEALERSHIP. MY WARRANTY HAD RAN OUT SHORTLY BEFORE THE INCIDENT.

NHTSA complaint #10523673 — an unverified report by a vehicle owner.