Owners have filed 81 complaints
about the 2012 Mini Cooper Countryman with NHTSA between 2012 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 1 of 3 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 74
Against the median year of the Mini Cooper Countryman. 50 means typical for this
model; 100 means roughly double.
Severity — 100
22.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 78
46% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2012 compares with every other Mini Cooper Countryman
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
715.2%
1,000 – 9,999 miles
36.5%
10,000 – 24,999 miles
715.2%
25,000 – 49,999 miles
1021.7%
50,000 – 74,999 miles
715.2%
75,000 – 99,999 miles
613.0%
100,000 – 149,999 miles
36.5%
150,000+ miles
36.5%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Aug 2012peak 4Jun 2026
Complaints that involved harm
Reports where the owner recorded a crash, a fire, an injury or a death.
Bronx, NYFire
UNKNOWN OR OTHER
On the evening of [XXX] at approximately [XXX] my 2012 Mini Cooper S all 4 burst into flames. The car was parked in front of my building for 6 days (we don't use the car very much) in front of my building when the all of a sudden the head lights started flashing followed by the car cabin filling with grey smoke then followed by black smoke then there was a flash (spark?) and the entire cabin the became engulfed in flames. All of this has been captured by our building security camera. I reported the incident the following day to Mini/BMW customer care. I've been sharing emails with Thomas Lula who is investigating the "thermal event" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11577096 — an unverified report by a vehicle owner.
Bronx, NYFire
ELECTRICAL SYSTEM
On the evening of [XXX] at approximately [XXX] my 2012 Mini Cooper S all 4 burst into flames. The car was parked in front of my building for 6 days (we don't use the car very much) in front of my building when the all of a sudden the head lights started flashing followed by the car cabin filling with grey smoke then followed by black smoke then there was a flash (spark?) and the entire cabin the became engulfed in flames. All of this has been captured by our building security camera. I reported the incident the following day to Mini/BMW customer care. I've been sharing emails with Thomas Lula who is investigating the "thermal event" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11577096 — an unverified report by a vehicle owner.
Hummelstown, PACrash
EXTERIOR LIGHTING
My 2012 Mini Countryman has had failed signal lighting. My dealer has diagnosed the issue as a failed FRM module which I have been informed that NHTSA issued in conjunction with Mini USA a warranty extension to service this module's failure. While as an owner of this car for the past 9 years, I received not notice from Mini. I recently appealed for warranty coverage of this part. Mini USA has denied coverage of my failed FRM module stating the warranty was only good for 10 years from in-service date. My vehicle went in-service 8/12/2012, or ten years and ten months. Mini is adamantly denying good will to replace this part and my car is off the road do to no working turn signals.
NHTSA complaint #11531545 — an unverified report by a vehicle owner.
Hummelstown, PACrash
ELECTRICAL SYSTEM
My 2012 Mini Countryman has had failed signal lighting. My dealer has diagnosed the issue as a failed FRM module which I have been informed that NHTSA issued in conjunction with Mini USA a warranty extension to service this module's failure. While as an owner of this car for the past 9 years, I received not notice from Mini. I recently appealed for warranty coverage of this part. Mini USA has denied coverage of my failed FRM module stating the warranty was only good for 10 years from in-service date. My vehicle went in-service 8/12/2012, or ten years and ten months. Mini is adamantly denying good will to replace this part and my car is off the road do to no working turn signals.
NHTSA complaint #11531545 — an unverified report by a vehicle owner.
Visalia, CAFire
ENGINE
Our Mini Cooper Countymen S was being towed behind our motorhome. I. saw smoke coming from the car I stopped and the car started to catch on fire. I got out motorhome disconnect just in time before the Mini was consumed by fire, it was a total loss. The Fire Investigator stated he believed the fire started in the right side of the engine compartment.
NHTSA complaint #11489819 — an unverified report by a vehicle owner.
at 180,000 milesFolly Beach, SCFire
ENGINE
The contact owned a 2012 Mini Cooper S Countryman. The contact stated while she was at a standstill in traffic, she saw smoke exiting from under the hood. The contact stated no warning light was illuminated. The contact was able to park on the emergency lane and exit the vehicle before the vehicle was engulfed in flames. The contact did not sustain any injuries nor seek medical attention. A police report was filed. The insurance company deemed the vehicle a total loss. The vehicle was towed to a towing lot. The contact spoke to the local dealer and made them aware of the failure. The vehicle was not diagnosed. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V248000 (ENGINE AND ENGINE COOLING), however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 180,000.
NHTSA complaint #11440756 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Tulsa, OK
UNKNOWN OR OTHER
My 2012 MINI Countryman (R60) experienced a complete electrical shutdown and engine failure while operating due to a severe manufacturing defect. Authorized dealership Jackie Cooper MINI of Edmond diagnosed the vehicle under RO# [XXX] and confirmed in writing that the "JBE electronic connectors are heavily corroded" and "The FRM has water/corrosion damage," providing a repair estimate of $4,700 (including a specific $1,055.84 charge to replace the FRM and clean the sunroof drains). Water entering the footwell area through defective, shrinking sunroof drainage structures is the exact identical failure mechanism, component (FRM3 Module), and extreme safety/fire hazard covered under mandatory safety recall NHTSA Campaign 23V-337. However, MINI has improperly excluded the R60 Countryman model from active coverage despite it utilizing the identical electrical infrastructure and drainage engineering layout. Releasing this vehicle into traffic presents a catastrophic risk of a highway vehicle fire or sudden total loss of vehicle control and lighting at high speeds. NHTSA must expand Recall 23V-337 to include the 2012 MINI Countryman to protect consumers from these documented structural water-ingress fires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11745835 — an unverified report by a vehicle owner.
Tulsa, OK
EXTERIOR LIGHTING
My 2012 MINI Countryman (R60) experienced a complete electrical shutdown and engine failure while operating due to a severe manufacturing defect. Authorized dealership Jackie Cooper MINI of Edmond diagnosed the vehicle under RO# [XXX] and confirmed in writing that the "JBE electronic connectors are heavily corroded" and "The FRM has water/corrosion damage," providing a repair estimate of $4,700 (including a specific $1,055.84 charge to replace the FRM and clean the sunroof drains). Water entering the footwell area through defective, shrinking sunroof drainage structures is the exact identical failure mechanism, component (FRM3 Module), and extreme safety/fire hazard covered under mandatory safety recall NHTSA Campaign 23V-337. However, MINI has improperly excluded the R60 Countryman model from active coverage despite it utilizing the identical electrical infrastructure and drainage engineering layout. Releasing this vehicle into traffic presents a catastrophic risk of a highway vehicle fire or sudden total loss of vehicle control and lighting at high speeds. NHTSA must expand Recall 23V-337 to include the 2012 MINI Countryman to protect consumers from these documented structural water-ingress fires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11745835 — an unverified report by a vehicle owner.
Tulsa, OK
ELECTRICAL SYSTEM
My 2012 MINI Countryman (R60) experienced a complete electrical shutdown and engine failure while operating due to a severe manufacturing defect. Authorized dealership Jackie Cooper MINI of Edmond diagnosed the vehicle under RO# [XXX] and confirmed in writing that the "JBE electronic connectors are heavily corroded" and "The FRM has water/corrosion damage," providing a repair estimate of $4,700 (including a specific $1,055.84 charge to replace the FRM and clean the sunroof drains). Water entering the footwell area through defective, shrinking sunroof drainage structures is the exact identical failure mechanism, component (FRM3 Module), and extreme safety/fire hazard covered under mandatory safety recall NHTSA Campaign 23V-337. However, MINI has improperly excluded the R60 Countryman model from active coverage despite it utilizing the identical electrical infrastructure and drainage engineering layout. Releasing this vehicle into traffic presents a catastrophic risk of a highway vehicle fire or sudden total loss of vehicle control and lighting at high speeds. NHTSA must expand Recall 23V-337 to include the 2012 MINI Countryman to protect consumers from these documented structural water-ingress fires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11745835 — an unverified report by a vehicle owner.
Columbia, SC
VISIBILITY/WIPER
My front windshield wipers stopped working suddenly while driving in the rain
NHTSA complaint #11622283 — an unverified report by a vehicle owner.
Jacksonville, FL
SERVICE BRAKES
No warning lights have come on and the car is braking on its own. I try to push the gas and it doesn't want to go. The car has around 42k miles on it. I took it to tom bush mini last week, the said the front axle was leaking some fluid, they ordererd the axle, changed all brake pads, changed the brake fluid and said it was good to go, cost about $2300. Got the car back, doing the same thing. Now they said all calipers need to be replaced and the hydro unit dsc needs to be replaced which will cost around $6400 and they can't get the hyro unit dsc or 2 months. If this was the problem why didn't they know last week? It doesn't seem like the car has enough miles to have such a big issues and no part for 2 months. I don't know what to do.
NHTSA complaint #11621018 — an unverified report by a vehicle owner.
at 161,818 milesAlexandria, VA
ELECTRICAL SYSTEM
The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at undisclosed speeds, the vehicle stalled. The fuel tank was a third of the way full. The trunk was locking and unlocking continuously while driving or while the vehicle was parked. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical system). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who determined that there was a short in the footwell module due to water intrusion. The drain was also clogged in the sunroof. The manufacturer was contacted and opened a case. The failure mileage was approximately 161,818.
NHTSA complaint #11609036 — an unverified report by a vehicle owner.
at 161,818 milesAlexandria, VA
ENGINE
The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at undisclosed speeds, the vehicle stalled. The fuel tank was a third of the way full. The trunk was locking and unlocking continuously while driving or while the vehicle was parked. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical system). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who determined that there was a short in the footwell module due to water intrusion. The drain was also clogged in the sunroof. The manufacturer was contacted and opened a case. The failure mileage was approximately 161,818.
NHTSA complaint #11609036 — an unverified report by a vehicle owner.
Bronx, NYFire
UNKNOWN OR OTHER
On the evening of [XXX] at approximately [XXX] my 2012 Mini Cooper S all 4 burst into flames. The car was parked in front of my building for 6 days (we don't use the car very much) in front of my building when the all of a sudden the head lights started flashing followed by the car cabin filling with grey smoke then followed by black smoke then there was a flash (spark?) and the entire cabin the became engulfed in flames. All of this has been captured by our building security camera. I reported the incident the following day to Mini/BMW customer care. I've been sharing emails with Thomas Lula who is investigating the "thermal event" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11577096 — an unverified report by a vehicle owner.
Bronx, NYFire
ELECTRICAL SYSTEM
On the evening of [XXX] at approximately [XXX] my 2012 Mini Cooper S all 4 burst into flames. The car was parked in front of my building for 6 days (we don't use the car very much) in front of my building when the all of a sudden the head lights started flashing followed by the car cabin filling with grey smoke then followed by black smoke then there was a flash (spark?) and the entire cabin the became engulfed in flames. All of this has been captured by our building security camera. I reported the incident the following day to Mini/BMW customer care. I've been sharing emails with Thomas Lula who is investigating the "thermal event" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11577096 — an unverified report by a vehicle owner.
New London, NH
EXTERIOR LIGHTING
There is a recall existing for my car, by VIN mine is not included, however I have the exact same problem. Water in the driver side foot well electrical panel which has caused a fault in the lighting, hazard lights, and battery issue. The car cannot be driven because the hazard lights and daytime running lights will not turn off even with the key out. Running out the battery in the process. The mechanic found water and corrosion inside the electrical housing.
NHTSA complaint #11576223 — an unverified report by a vehicle owner.
New London, NH
ELECTRICAL SYSTEM
There is a recall existing for my car, by VIN mine is not included, however I have the exact same problem. Water in the driver side foot well electrical panel which has caused a fault in the lighting, hazard lights, and battery issue. The car cannot be driven because the hazard lights and daytime running lights will not turn off even with the key out. Running out the battery in the process. The mechanic found water and corrosion inside the electrical housing.
NHTSA complaint #11576223 — an unverified report by a vehicle owner.
Vancouver, WA
ELECTRICAL SYSTEM
The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at approximately 40 MPH, the vehicle stalled. The vehicle was steered to the side of the road. The vehicle was able to restart after several attempts but had not started since. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
NHTSA complaint #11574533 — an unverified report by a vehicle owner.
Scarborough, ME
SEAT BELTS
While traveling on the highway at speed, the forward (retractable) sunroof exploded with no apparent provocation or warning. When the failure occurred there was a loud bang followed by glass forcefully raining down into the front and back seat area of the vehicle. There were no vehicles immediately ahead, and no overpasses or trees from which something could have fallen. The driver immediately slowed but did not swerve and there were no other vehicles close by so there was no secondary incident. The glass from the roof continued to fall on subsequent bumps in the road until all of the loose glass had fallen. The size of the glass pieces varied in size and sharpness greatly, with some pieces being very small clear slivers (causing mild cut to hand when exiting the vehicle). In addition when exiting the vehicle a piece of glass from the sunroof found its way into the driver's seatbelt fastener and as a result can no longer be buckled. The vehicle has not yet been inspected by anyone and is available for inspection on request.
NHTSA complaint #11550092 — an unverified report by a vehicle owner.
Scarborough, ME
VISIBILITY/WIPER
While traveling on the highway at speed, the forward (retractable) sunroof exploded with no apparent provocation or warning. When the failure occurred there was a loud bang followed by glass forcefully raining down into the front and back seat area of the vehicle. There were no vehicles immediately ahead, and no overpasses or trees from which something could have fallen. The driver immediately slowed but did not swerve and there were no other vehicles close by so there was no secondary incident. The glass from the roof continued to fall on subsequent bumps in the road until all of the loose glass had fallen. The size of the glass pieces varied in size and sharpness greatly, with some pieces being very small clear slivers (causing mild cut to hand when exiting the vehicle). In addition when exiting the vehicle a piece of glass from the sunroof found its way into the driver's seatbelt fastener and as a result can no longer be buckled. The vehicle has not yet been inspected by anyone and is available for inspection on request.
NHTSA complaint #11550092 — an unverified report by a vehicle owner.
Anchorage, AK
EXTERIOR LIGHTING
When the vehicle computer detects low voltage all turn signals, lights and instrument cluster immediately fail and do not turn back on. The Foot Well Module (FWM) or Foot Rest Module (FRM) computer becomes corrupt and deletes data from the module. This becomes a major safety hazard as a nighttime failure occurred causing several near accidents due to inability to signal to other vehicles. This is a known issue with Mini and they released an extended service bulletin knowing the factory footrest modules were manufactured incorrectly. Vehicles falling outside the initial warranty period are prone to safety risks when this occurs.
NHTSA complaint #11542960 — an unverified report by a vehicle owner.
Anchorage, AK
ELECTRICAL SYSTEM
When the vehicle computer detects low voltage all turn signals, lights and instrument cluster immediately fail and do not turn back on. The Foot Well Module (FWM) or Foot Rest Module (FRM) computer becomes corrupt and deletes data from the module. This becomes a major safety hazard as a nighttime failure occurred causing several near accidents due to inability to signal to other vehicles. This is a known issue with Mini and they released an extended service bulletin knowing the factory footrest modules were manufactured incorrectly. Vehicles falling outside the initial warranty period are prone to safety risks when this occurs.
NHTSA complaint #11542960 — an unverified report by a vehicle owner.
Anchorage, AK
ENGINE
When the vehicle computer detects low voltage all turn signals, lights and instrument cluster immediately fail and do not turn back on. The Foot Well Module (FWM) or Foot Rest Module (FRM) computer becomes corrupt and deletes data from the module. This becomes a major safety hazard as a nighttime failure occurred causing several near accidents due to inability to signal to other vehicles. This is a known issue with Mini and they released an extended service bulletin knowing the factory footrest modules were manufactured incorrectly. Vehicles falling outside the initial warranty period are prone to safety risks when this occurs.
NHTSA complaint #11542960 — an unverified report by a vehicle owner.
Pahoa, HI
SEATS
Passenger side airbag light on with no one in seat. The repair shop stated that there is a seat sensor fault code is 93c3(passenger seat occupancy detector). If there is an accident the airbag may not deploy. I was told to by the BMW of Hawaii in Kona that it will cost $2030 for parts and labor.
NHTSA complaint #11531633 — an unverified report by a vehicle owner.
Pahoa, HI
AIR BAGS
Passenger side airbag light on with no one in seat. The repair shop stated that there is a seat sensor fault code is 93c3(passenger seat occupancy detector). If there is an accident the airbag may not deploy. I was told to by the BMW of Hawaii in Kona that it will cost $2030 for parts and labor.
NHTSA complaint #11531633 — an unverified report by a vehicle owner.
Hummelstown, PACrash
EXTERIOR LIGHTING
My 2012 Mini Countryman has had failed signal lighting. My dealer has diagnosed the issue as a failed FRM module which I have been informed that NHTSA issued in conjunction with Mini USA a warranty extension to service this module's failure. While as an owner of this car for the past 9 years, I received not notice from Mini. I recently appealed for warranty coverage of this part. Mini USA has denied coverage of my failed FRM module stating the warranty was only good for 10 years from in-service date. My vehicle went in-service 8/12/2012, or ten years and ten months. Mini is adamantly denying good will to replace this part and my car is off the road do to no working turn signals.
NHTSA complaint #11531545 — an unverified report by a vehicle owner.
Hummelstown, PACrash
ELECTRICAL SYSTEM
My 2012 Mini Countryman has had failed signal lighting. My dealer has diagnosed the issue as a failed FRM module which I have been informed that NHTSA issued in conjunction with Mini USA a warranty extension to service this module's failure. While as an owner of this car for the past 9 years, I received not notice from Mini. I recently appealed for warranty coverage of this part. Mini USA has denied coverage of my failed FRM module stating the warranty was only good for 10 years from in-service date. My vehicle went in-service 8/12/2012, or ten years and ten months. Mini is adamantly denying good will to replace this part and my car is off the road do to no working turn signals.
NHTSA complaint #11531545 — an unverified report by a vehicle owner.
Ringgold, GA
ELECTRICAL SYSTEM
Mini coopers have faulty transmission problems, and well mine today it's transmission went out when I had my AC on, the car stalled in the middle of the highway in the middle of the road with oncoming traffic and refused to budge, like seriously this is highly dangerous on the interstate
NHTSA complaint #11526625 — an unverified report by a vehicle owner.
Ringgold, GA
ENGINE
Mini coopers have faulty transmission problems, and well mine today it's transmission went out when I had my AC on, the car stalled in the middle of the highway in the middle of the road with oncoming traffic and refused to budge, like seriously this is highly dangerous on the interstate
NHTSA complaint #11526625 — an unverified report by a vehicle owner.
Visalia, CAFire
ENGINE
Our Mini Cooper Countymen S was being towed behind our motorhome. I. saw smoke coming from the car I stopped and the car started to catch on fire. I got out motorhome disconnect just in time before the Mini was consumed by fire, it was a total loss. The Fire Investigator stated he believed the fire started in the right side of the engine compartment.
NHTSA complaint #11489819 — an unverified report by a vehicle owner.
Sand Springs, OK
SEAT BELTS
I was driving down the road when a light popped onto my dash, it was the airbag/seatbelt light after some research. From what I've read, this will prevent the airbags from activating in case of a crash, and after talking to other MINI owners it is extremely common.
NHTSA complaint #11476707 — an unverified report by a vehicle owner.