26 of the 2,854 complaints filed about the Mini Cooper are about the suspension — 1% of everything owners reported. The worst model year for it is 2003.
26
Complaints
1%
Share of all complaints
0
Crashes
0
Fires
SUSPENSION
The traction control light with antilock brake warning illuminated. Therefore my antilock brakes are inop along with traction control.
NHTSA complaint #11582706 — an unverified report by a vehicle owner.
SUSPENSION
What component or system failed or malfunctioned, and is it available for inspection upon request? CONTROL ARMS AND BUSHINGS How was your safety or the safety of others put at risk? CONSTANT CREAKING AND CLUNKING OF FRONT SUSPENSION Has the problem been reproduced or confirmed by a dealer or independent service center? MANY OTHER OWNERS OF THE SAME YEAR AND GENERATION HAVE THIS SAME ISSUE Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NOT YET Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO
NHTSA complaint #11552701 — an unverified report by a vehicle owner.
SUSPENSION
Engine motor mount sheared, allowing motor to interact with and bounce directly on the frame, and stressing the other connections and components. Dealer indicated this is a very common problem for this car model and is likely a design issue, and even had another example of a sheared mount on display in order to show others with the same issue.
NHTSA complaint #11549149 — an unverified report by a vehicle owner.
SUSPENSION
Front Upper Arm Bushing on both the Driver’s and Passenger sides needed to be replace after less than 25,000 miles. Bushing failure causes upper arms of suspension to whack against the body and greatly effect handling, could lead to accidents.
NHTSA complaint #11480935 — an unverified report by a vehicle owner.
SUSPENSION
Car only has 48000,00 miles and tie rods need replaced This is not normal ware for a car. My Ford Fusion has 98000.00 and just now needs tie rods. This has to be a defect
NHTSA complaint #11438591 — an unverified report by a vehicle owner.
SUSPENSION
Engine Mount and right control arm bushings have cracked and need to be replaced below 60,000 miles and only being 4 years old.
NHTSA complaint #11420895 — an unverified report by a vehicle owner.
SUSPENSION
WHEN DRIVING 2 MONTHS AGO,WAS DRIVING WITH MY MOM 9/13/1015,ALL 4 MILESTAR TIRES BUSTED,DEALER REPLACED THEM WITH CHARGING ME 150.00 DEDUCT,NOW SAME PROBLEM OCCURED 11/25/2015,RIGHT PASSAGER SAME BRAND BUSTED,NOW MY CAR IS IN SHOP AGAIN MISSING WORK,STUCK IN FORT MYERS RIGHT NOW,IF IT WASN'T FOR MY FAMILY I WOULD NOT BE HERE WITH THESE TIRES,THE NAME OF THE TIRES MILE-STAR
NHTSA complaint #10807118 — an unverified report by a vehicle owner.
SUSPENSION
I HAVE HEARD FROM MORE THEN 3 DOZEN OTHER INDIVIDUALS OWNING BOTH THE MINI COOPER AND MINI COOPER S RANGING FROM YEARS 2006 TO 2010 THAT THERE HAVE BEEN PROBLEMS REGARDING THE AIR CV JOINT AXEL AND/OR POWER ARM CONTROL A CONSTANT PROBLEM REGARDING THE GENERAL MODULE ELECTRONIC COMPONENT. THIS ISN'T JUST A COINCIDENCE AND MAY END UP BEING THE CAUSE OF SERIOUS ACCIDENTS IF ONE OR TWO OF THESE COMPONENTS ARE DEFECTIVE. FOR THIS MANY CONSUMERS TO BE HAVING THE SAME ISSUES, SAME SOUNDS AND REVISITED VISITS TO MINI DEALER SHOPS AROUND THE GLOBE SOMETHING IS NOT RIGHT AND NEEDS TO BE INVESTIGATED. I KNOW FOR ONE THING THIS CONTROL ARM IS A HUGE PROBLEM IF IT FAILS CONSIDERING IT'S LOCATION COULD BE THE CAUSE OF MANY SERIOUS ACCIDENTS AND POSSIBLE DEATHS DEPENDING ON THE SPEED AND SEVERITY OF THE ACCIDENT WHEN IT TAKES PLACE. MY VEHICLE IS CURRENTLY NOT ON THE ROAD DUE TO THE SEVERITY OF THE NOISE AND REACTION TO THE VEHICLE WHEN BEING OPERATED AND IT IS A SCARY THING. THEY WANT TO CHARGE A ABSURD AMOUNT OF MONEY TO FIX SOMETHING THAT QUITE FRANKLY MAY HAVE BEEN SOMETHING RECALLED A LONG TIME AGO, AND WASN'T BECAUSE A LOT OF CONSUMERS ARE NOT AWARE OF THIS PROCESS SUCH AS MYSELF UNTIL RECENTLY WHEN AN ATTORNEY FRIEND OF MINE STARTED TO DIG AROUND A BIT AFTER HEARING MY STORY AND THE STORIES OF MANY OTHERS I HAVE SPOKEN TOO.
NHTSA complaint #10786266 — an unverified report by a vehicle owner.
SUSPENSION
TL* THE CONTACT OWNS A 2015 MINI COOPER. WHILE DRIVING AT HIGHWAY SPEEDS, THE CONTACT NOTICED AN ABNORMAL ROARING NOISE FROM THE REAR DRIVER SIDE OF THE VEHICLE. WHEN MAKING A TURN OR DRIVING OVER BUMPS AND DIPS IN THE ROAD, THE TIRES LOST TRACTION WITH THE ROAD AND CAUSED THE VEHICLE TO SKIP. THE VEHICLE WAS TAKEN TO THE DEALER AND DIAGNOSED AS A SUSPENSION FAILURE. THE VEHICLE WAS REALIGNED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 9,000. UPDATED 09/09/15*LJ UPDATED 11/27/2017
NHTSA complaint #10734534 — an unverified report by a vehicle owner.
SUSPENSION
MY CAR WOULD MAKE A NOISE AT THE REAR OF THE CAR WHEN I DROVE ON A BUMPY STREET, I TOOK THE CAR TO THE DEALER AND AFTER THERE INSPECTION , THEY SAID THE REAR SWAY BAR LINKS HAD TO BE REPLACED. I AM CONCERNED THAT IF THE ORIGINAL PARTS WERE DEFECTIVE, MAYBE THE NEW PARTS WILL ALSO BE DEFECTIVE... THE CAR IS UNDER WARRANTY, THE DEALER IS MAKING THE REPAIRS...UPDATED 10/15/15 *BF THE DEALER STATED THE REAR SWAY BAR LINK WAS NOT THE PROBLEM CAUSING THE NOISE. UPDATED 10/20/15
NHTSA complaint #10692115 — an unverified report by a vehicle owner.
SUSPENSION
THE LEFT REAR CONTROL ARM BROKE IN HALF. I NOTICED MY CAR WAS NOT REVERSING CORRECTLY AS IF THE REAR WHEEL WAS DRAGGING. I EXITED THE CAR AND ELEVATED IT WITH A FLOOR JACK TO FIND THE REAR CONTROL ARM ON THE DRIVER'S SIDE BROKEN IN HALF.
NHTSA complaint #10671717 — an unverified report by a vehicle owner.
SUSPENSION
THIS MINI COOPER A 2003 W/130K MILES DRIVEN BY A YOUNG FEMALE. SHE HAD NO IDEA HER WHEEL WAS GOING TO FALL OFF THE DRIVER SIDE FRONT. SHE HAD CALLED FOR A CHECK ENGINE LIGHT ON AND INTERMITTENT BATTERY FAILURE. IT WAS ASK THAT I DRIVE THE CAR AND LISTEN TO A POP COMING FROM THE WHEEL SECTION. THE POP WAS THE ENTIRE WHEEL ASSEMBLY MOVING FORWARDS AND BACK BUMPING THE WHEEL WELLS AS THE CAR WENT FORWARD. NEEDLESS TO SAY I DIDN'T DRIVE FAR NOR DID I ACCELERATE FASTER THAN 10 MPH. I TOLD THE PARENT OF THE DRIVER THAT THE CAR WAS NOT DRIVABLE UNDER ANY CONDITION AND THAT IT NEEDED IMMEDIATE ATTENTION. THE LOWER CONTROL ARM BUSHING RUBBER WAS COMPLETELY GONE. I DO NOT KNOW IF THIS IS A DEFECT. THIS PART IS A MOUNT AND IT'S HOLDING MANY COMPONENTS OF THIS CAR TOGETHER. IT IS NOTHING LIKE I HAVE SEEN BEFORE USED AS A MOUNT. I HAVE SEEN THE RUBBER WORN FROM THIS TYPE PART BUT THEY WERE NOT BEING USED AS A MOUNT. WHEN THE RUBBER ON THIS PART DETERIORATES IT CAUSES THE MOUNT TO BE UNSTABLE RESULTING IN THE WHOLE WHEEL ASSEMBLY MOVING LIKE A SWING FORWARDS AND BACKWARDS WHILE DRIVING. IN A TRAFFIC SITUATION THIS COULD BE DEVASTATING TO MORE THAN JUST THE DRIVER OF THIS CAR BUT ALSO TO THE CARS DRIVING NEAR IF THE WHEEL WERE TO COME OFF IN THEIR TRAFFIC. NEEDLESS TO SAY THE MINI COOPER WOULD IMMEDIATELY FAIL IN TRAFFIC WITH THE BRAKE CYLINDERS HITTING THE ROAD CAUSING FLYING SPARKS, IF REAR ENDED IT WOULD MORE THAN LIKELY FLIP. THIS IS A DANGEROUS SCENARIO. THIS CAR WAS PURCHASED SECOND HAND AS ARE A LOT OF CARS. THIS IS NOT A PART ON ANYONE'S CHECK LIST AND NOT ONE YOU CONSIDER TO BE ONE OF THIS TYPE OF FAILURE. I AM FILING THIS COMPLAINT BUT I AM NOT THE OWNER OF THIS CAR. I AM MERELY CONCERNED AT THE IMPLICATIONS OF THE DETERIORATION OF THE RUBBER AND WHAT THOSE IMPLICATIONS MEAN TO THE OTHER PURPOSE THIS PART IS SUPPOSE TO PERFORM AND CAN'T WHEN THE RUBBER IS GONE.
NHTSA complaint #10664125 — an unverified report by a vehicle owner.
SUSPENSION
2005 MINI COOPER 2-DOOR CONVERTIBLE: THE LEFT REAR UPPER AND LOWER (ORIGINAL/FACTORY) CONTROL ARMS (METAL STRUT) FAILED WHILE DRIVING ON A MAIN ROAD; WARNING SIGN WAS A SLIGHT NOISE FROM THE REAR LEFT TIRE, WHICH WENT AWAY WHEN TURNING THE WHEEL SLIGHTLY LEFT, THEN CAME BACK WHEN TURNING THE WHEEL SLIGHTLY TO THE RIGHT. (SOUNDED LIKE INTERMITTENT RUBBING/ TIRE ISSUE.) THE CAR WAS DRIVING NORMALLY AND THE TIRE LOW PRESSURE INDICATOR LIGHT WAS NOT ILLUMINATED. WHILE TURNING OFF MAIN ROAD TO INVESTIGATE, SECOND CONTROL ARM FAILED AND CAR CAME DOWN TO REST ON REAR TIRE AND WOULD NOT ROLL FORWARD. UNEXPECTED AND COMPLETE FAILURE WITH CLEAN FRACTURE TO BOTH CONTROL ARMS. NO COLLISION OCCURRED TO THE VEHICLE/PART. VEHICLE NOT RUSTED. GOOGLE SEARCH BRINGS UP MANY OTHER MINI COOPER POSTS OF THIS CONTROL ARM FAILING UNEXPECTEDLY AND WITHOUT WARNING. CONSUMER IS VERY CONCERNED THAT THIS COULD HAVE HAPPENED WHILE ON THE HIGHWAY (THAT THEY HAD RECENTLY EXITED). OTHERS POSTING ONLINE HAVE EXPERIENCED 'UNCONTROLLED 180 SPINS' WHEN THEIRS FAILED. CONSUMER CONCERNED THAT THE ORIGINAL FACTORY CONTROL ARMS ON OTHER SIDE MAY EXHIBIT SAME UNEXPECTED FAILURE IN THE FUTURE. NOT CLEAR IF THIS IS A DESIGN FLAW OR MATERIALS/PARTS BAD BATCH. MINI COOPER DEALERSHIP EMPLOYEE MENTIONED THE SAME FAILURE (TO HIS PERSONAL CAR) WITH NO WARNING RECENTLY. ONLINE POSTS OF CONSUMERS WITH THE SAME UNEXPECTED FAILURE: HTTP://WWW.MINI2.COM/FORUM/FIRST-GENERATION-FAULTS-FIXES/80969-REAR-SUSPENSION-FAILURE.HTML HTTP://WWW.MINI2.COM/FORUM/FIRST-GENERATION-FAULTS-FIXES/108796-REAR-CONTROL-ARM-ISSUES.HTML HTTP://WWW.MINI2.COM/FORUM/FIRST-GENERATION-FAULTS-FIXES/69981-BROKEN-PART-UNDERSIDE-WHATS-CALLED.HTML HTTP://WWW.PSMINI.ORG/FORUM/EXPENSIVE-REPAIR-CONTROL-ARM-BUSHINGS-AND-STRUTS_TOPIC6569.HTML
NHTSA complaint #10519389 — an unverified report by a vehicle owner.
SUSPENSION
RIGHT REAR LOWER TRAILING ARM BROKE WHILE DRIVING. THERE WAS NO IMPACT WITH ANY OBJECT, IT BROKE ON ITS OWN.
NHTSA complaint #10454479 — an unverified report by a vehicle owner.
SUSPENSION:FRONT:MACPHERSON STRUT
TL*THE CONTACT OWNS A 2004 MINI COOPER. THE DRIVER WAS DRIVING AT AN UNKNOWN SPEED WHEN THE STEERING WHEEL BECAME VERY STIFF AND DIFFICULT TO TURN. THE VEHICLE WAS PARKED AND SHUT OFF. UPON RESTART THE STEERING WHEEL REMAINED DIFFICULT TO TURN. THE FAILURE AND CURRENT MILEAGES WERE 60,000. THE POWER STEERING PUMP FAILED INTERNALLY. THE POWER RETURN LINE WAS LEAKING. ALSO, BOTH STRUTS WERE LEAKING. UPDATED EVOQ 02/02/11
NHTSA complaint #10375094 — an unverified report by a vehicle owner.
SUSPENSION:FRONT
MY 2003 MINI COOPER HAS ALMOST CAUGHT ON FIRE SEVERAL TIMES, REPLACED TRANSMISSION, ELECTRICAL HARNESS, POWER STEERING PUMP, A/C HOSES AND A/C SERVICE, WHEEL BEARINGS, INJECTION PLUGS ETC....... I STILL CANNOT FIND THE REAL PROBLEM WHY IS CAUSING A SHORT, IT HAS ALMOST CAUGHT ON FIRE SEVERAL TIMES, THIS CAR HAS BEEN THE MOST DANGEROUS CAR I HAVE EVER OWN, I HAVE NEVER SPEND SO MUCH MONEY ON TRYING TO FIX ANY VEHICLE, RIGHT NOW I'M ABOUT $11,500 IN COSTS OF REPAIRS, THIS IS A CRIME TO THE CONSUMER, I HAVE BEEN READING ABOUT A CLASS ACTION LAWSUIT THAT IS IN PROGRESS, I HOPE AND PRAY THAT WE GET JUSTICE FROM THE MAKER OF MINI.
NHTSA complaint #10367312 — an unverified report by a vehicle owner.
SUSPENSION:FRONT:STABILIZER BAR
TL* THE CONTACT OWNS A 2007 MINI COOPER. THE CONTACT STATED WHEN TRAVELING AT ANY SPEED, THERE WAS AN UNUSUAL POP COMING FROM THE FRONT DRIVER'S SIDE, SPECIFICALLY WHEN ATTEMPTING A TURN IN EITHER DIRECTION. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT BOTH FRONT SWAY BAR BUSHINGS WOULD NEED TO BE REPLACED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION MOUNT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 31,000 AND THE CURRENT MILEAGE WAS 40,000.
NHTSA complaint #10345391 — an unverified report by a vehicle owner.
SUSPENSION:REAR
1. NORMAL AROUND TOWN DRIVING. PASSENGER REAR LOWER CONTROL ARM SNAPPED ... STEEL FAILED UNDER STRESS ONE OF SEVERAL MANUFACTURE HOLES PUNCHED INTO THE MEMBER. 2. CAUSED THE VEHICLE TO BECOME INOPERABLE. 3. REQUIRED REPLACEMENT CONTROL ARM. BMW HAS SINCE RE-ENGINEERED THE CONTROL ARM. REPLACEMENT ARMS ARE MADE STRONGER. *** I CAN PROVIDE ONLINE FORUM POSTINGS FROM NORTHAMERICANMOTORING.COM AND MINI2.COM (US AND UK ONLINE FORUMS FOR MINI OWNERS) WHICH DEMONSTRATE THAT THIS MEMBER IS ROUTINELY BREAKING ON OTHER VEHICLES OF THE SAME VINTAGE. PHOTOS OF MY FAILURE AND THE FAILURES OF OTHERS AVAILABLE. MINI IS ROUTINELY DENYING RESPONSIBILITY FOR THIS VEHICLE SAFETY ITEM CITING IMPROPER DRIVING HABITS. ***
NHTSA complaint #10295305 — an unverified report by a vehicle owner.
SUSPENSION:REAR
TL*THE CONTACT OWNS A 2004 MINI COOPER. WHILE DRIVING 50 MPH, THE CONTACT NOTICED A BUMP ON THE REAR DRIVER'S SIDE OF THE VEHICLE. SHE EXAMINED THE VEHICLE AND NOTICED THAT THE REAR DRIVER'S SIDE TIRE WAS DETACHING FROM THE VEHICLE. IN ADDITION, THE LOWER CONTROL ARM SNAPPED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE LOWER CONTROL ARM NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 71,000.
NHTSA complaint #10279557 — an unverified report by a vehicle owner.
SUSPENSION:REAR
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
NHTSA complaint #10274265 — an unverified report by a vehicle owner.