Mini Cooper seat problems

SEATS

The seatbelt and air bag warning light for the passenger front seat stays on.

NHTSA complaint #11698274 — an unverified report by a vehicle owner.

SEATS

there is a leak which affected the control unit fuel pump. the leak is ongoing throughout many of these cars yet there has not been a recall to fix it. more than $3k in damages. It's something a modern car should not be facing.

NHTSA complaint #11647364 — an unverified report by a vehicle owner.

SEATS

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.

NHTSA complaint #11644968 — an unverified report by a vehicle owner.

SEATS

On almost all r56 model mini coopers the passenger seat occupancy sensor has a major malfunction that causes it to fail and pop up an airbag sensor light even when someone is sitting in the seat, Mini USA did not issue a recall but rather a reimbursement form for owners in 2017 the last year of production for that car and did not publicly disclose this. I feel as though this should be a recall as it is common enough for bypass devices to be normal for this car

NHTSA complaint #11630094 — an unverified report by a vehicle owner.

SEATS

Passenger occupancy sensor malfunctions all the time and there are hundreds of claims regarding this issue but was never addressed by the manufacturer The same issue prompted a recall in older models but has not been corrected in newer ones

NHTSA complaint #11621760 — an unverified report by a vehicle owner.

SEATS

As per NHTSA there was a recall the replace OC3 SEAT OCCUPANCY MAT but I never received recall notice and just passed 10 years with 40K millage and started getting air bag light, dealer is not replacing it under warranty, if they was a recall they should have replaced my seat earlier so that I would not have this issue today. is there a way to extend warranty to longer time or recall all the cars and replace them so that we do not have to spend 2k to replace it? "01 11 16_OC3 SEAT OCCUPANCY MAT: LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES"

NHTSA complaint #11617003 — an unverified report by a vehicle owner.

SEATS

The passenger occupancy seat sensor is defective (as reported by many other owners of this vehicle model). The sensor is very costly to replace in terms of parts ($1,500) and labor ($1,500) and MINI does not sell the sensor separately as it is embedded in the seat foam. The defective sensor does not recognize a passenger sitting in the passenger seat and deactivates the passenger airbag which is an essential, lifesaving device fitted to a small vehicle. When involved in a major vehicle collision, without a working airbag, the risk of fatality drastically increases. The sensor is also responsible for NOT deploying the airbag if a passenger under 100lbs is sitting in the seat ie. a child. Again, this is a massive safety concern especially due to other owners resorting to a cheap aftermarket bypass module which will always deploy the airbag. This solution could seriously injure or cause fatalities for passengers under 100lbs. Other MINI models with the same electronic occupancy sensor problems have had recalls issued by the NHTSA and has not issued recalls for vehicles with the same issue consistently. It is the NHTSA's responsibility to hold the manufacturer accountable for ALL vehicle models with similar defects impacting the safe and consistent operation of life preservation devices such as airbags especially when repair costs for these defective devices are cost prohibitive for vehicle owners to replace.

NHTSA complaint #11577181 — an unverified report by a vehicle owner.

SEATS

trouble code: 93C3 ACSM/MRS: Seat-occupancy detector, passenger

NHTSA complaint #11544198 — an unverified report by a vehicle owner.

SEATS

Passenger seat occupancy sensor failure. This is a very common fault in the R56 series Mini Cooper. The manufacture has not initiated a recall. There are vendors selling "bypass" kits which will cause unsafe air bag deployment in an infant is in the seat.

NHTSA complaint #11530391 — an unverified report by a vehicle owner.

SEATS

There is a known issue with the passenger seat occupancy sensor that trips the airbag/seatblet lights and, I assume, doesn't turn off the airbag in the applicable situations.

NHTSA complaint #11516087 — an unverified report by a vehicle owner.

SEATS

BMW issued a Recall 15V-205 Safety Recall, to cover the Airbag sensor in the passenger seat of my vehicle, a 2006 Mini Cooper S. The failure error was in the airbag sensor in the passenger seat, and the system warned of potential hazard with the passenger airbag. My car had a recall fix in 2018 for this fault. Now some 4 years later the same fault has arisen in the same sensor and system. I returned to BMW Mini who carried out the previous recall to have this fixed again. They said that while their repairs and parts generally carry an 8-year warranty, they do not warrant Recall repairs. They wanted over $2,000 to fix this issue. As this is a repeat of the original fault, and the car has under 100,000 miles I believe it should be covered, as their repair and or part has again failed. The date below is when I took it for the recall and was refused the warrenty repair.

NHTSA complaint #11514006 — an unverified report by a vehicle owner.

SEATS

i Purchased the car in Dover Pa . INspection sticker had same milage as on car so i shoulda knew he slapped a sticker on . drove 150 miles dash lit ip like chrismas tree. 1st thing left window wont work , then left lock wont work had to lock from passenfger dide. then door wont open at all . have to get ou t passenger door . know that wont open have to put down passenger window pull handel to get out . car is possessed light work whren they want does all kinda crazt stuff . batter has problems . charge and still cant start it . and hatch locks so i cant get to battery. power steering leaking going bad . timing belt making noise . no power on hills .cracking noise in right front pulls to right had . hazard to me ive been locked inside three times could get out of car i coulda sat in heat and died or cold and froze . cant get out of car when it ts electric doors dont work . car sucks . this has been gradual thing these events from feb to may . now i just hate the car

NHTSA complaint #11493892 — an unverified report by a vehicle owner.

SEATS

The airbag occupancy detection switch in the passenger seat is defective. This is occurring so often on Mini Coopers (R56 models from 2007-2013) that a passenger occupancy defeat switch is being openly sold and YouTube videos are available showing how to fit this device. This disables the occupancy detector switch, causing grave danger of death to infants or children seated in the passenger seat during a collision. MINI is currently charging nearly $1,000 to rectify this common fault. This defect has been confirmed multiple times by MINI, including on my vehicle on 7/8/2022. The component has been inspected by the manufacturer and confirmed to be defective. There were warning lights displayed on the central console, as well as on the driver tachometer every time the car is started. This warning cannot be defeated. This Youtube video (and many others…) have been posted more than 3 years ago about the issue, showing how to disable the warning. This one has over 74,000 views! https://youtu.be/gDlmtygUipM It is WELL overdue that you do something about this clear, present and deadly danger to children! Thank you.

NHTSA complaint #11473082 — an unverified report by a vehicle owner.

SEATS

SEAT BACK MECHANISM FAILED. COULD NOT LATCH IN PLACE. FAILED WITH NO WARNING WHILE DRIVING. MOTOR MOUNT BROKEN WITH MILAGE ONLY AT 56,000 MILES.

NHTSA complaint #11470154 — an unverified report by a vehicle owner.

SEATS

Passenger side airbag light on with no one in seat, had it checked, the repair shop stated that there is a seat sensor fault, the code is 93c3(passenger seat occupancy detector). I have done some research on this and it seems that this a common problem, but there hasn't been any recalls by Mini, and if there is an accident the airbag may not deploy. I was told to by the dealer that it will cost $2300 for parts and labor.

NHTSA complaint #11458234 — an unverified report by a vehicle owner.

SEATS

MY AIR BAG WARNING LIGHT IS ALWAYS ON. THE MACHANIC SAID I NEED TO REPLACE THE WHOLE PASSENGER SEAT TO REPLACE THE AIRBAG SENSOR. A NEW SEAT WILL COST $1500 AND LABOR WILL COST $500. I WAS NOT IN AN ACCIDENT.

NHTSA complaint #11404715 — an unverified report by a vehicle owner.

SEATS

I HAVE A 2010 MINI COOPER HARDTOP. THIS IS AN ONGOING PROBLEM OF THE LAST THREE YEARS. THE PASSENGER AIRBAG ALERT GOES ON WHEN I HAVE A PASSENGER IN THE SEAT SAYING PASSENGER AIRBAG IS OFF. I'VE TAKEN IT TO A REPAIR SHOP AND THEY WILL NEED TO DISMANTLE THE SEAT TO SEE IF THE SENSOR IS DEFECTIVE AND REPLACE. I SEE THAT OTHER MODELS OF MINI COOPERS HAVE HAD RECALLS FOR THIS DEFECT IN SEAT SENSORS. MODELS IN YEARS BEFORE AND AFTER 2010. IT IS AN EXPENSIVE PROCEDURE, AND DANGEROUS IF I HAVE A PASSENGER.

NHTSA complaint #11376890 — an unverified report by a vehicle owner.

SEATS

THE PASSENGER SEAT OCCUPANCY DETECTOR IS BROKEN. THIS IS APPARENTLY A COMMON PROBLEM WITH BMWS AND MINI COOPERS. SOME MODELS HAVE BEEN RECALLED. BUT MANY HAVE NOT, INCLUDING MINE. THE SYMPTOM IS THAT SEAT BELT AND AIRBAG WARNINGS LIGHT UP.

NHTSA complaint #11315369 — an unverified report by a vehicle owner.

SEATS

WARNING LAMP FOR "AIRBAG SYSTEM FAILED" ILLUMINATED ONE DAY WHILE DRIVING ON A STRAIGHT STREET "IN TOWN" APPROX 25MPH. AT FIRST LIGHT WENT OFF IF I BUCKLED PASSENGER SEATBELT (EVEN WHEN SEAT WAS EMPTY) NOW IT WON'T GO OFF EVEN DOING THAT... ALSO DOESN'T MATTER IF DRIVING AT HIGH OR LOW SPEEDS, ROAD TYPES, TURNING, STOPPING, PARKED, DRIVING, PASSENGER IN RIDER'S SEAT, NO RIDING PASSENGER, ETC, IT WILL ILLUMINATE (& I NEVER PLACE ANYTHING ON MY PASSENGER SEAT). TOOK TO A MECHANIC - HE CHECKED & PROVIDED CODE 9435. STATED AIRBAGS MIGHT NOT DEPLOY WHEN THIS WARNING LAMP IS ILLUMINATED. SAID THIS IS A COMMON PROBLEM WITH MINI COOPERS & IS A SAFETY ISSUE THAT HE THINKS PROBABLY SHOULD BE COVERED UNDER A RECALL. CONTACTED MINI DEALERSHIP - SAID NO RECALL FOR MY VEHICLE. FROM WHAT I HAVE FOUND THERE ARE ALMOST 100,000 OTHER MINIS THAT HAVE HAD A RECALL FOR THIS SAME PROBLEM, HOWEVER, THEY TELL ME MY VEHICLE IS NOT INCLUDED IN THE RECALL - WANT TO CHARGE ME MINIMALLY $65 JUST TO RE-DIAGNOSE THE CODE, THEN LABOR & PARTS TO FIX! CALLED MINI CUSTOMER SERVICE - TOLD ME NO RECALL FOR MY VEHICLE & THEY REFERRED ME HERE.

NHTSA complaint #11063326 — an unverified report by a vehicle owner.

SEATS

PASSENGER SEAT GOT WET WINDOW LEFT OPEN WHILE PARKO

NHTSA complaint #11047291 — an unverified report by a vehicle owner.