21 of the 60 complaints about the 2020 Nissan Rogue Sport are about the engine — 35% of everything reported for this model year. Half of the failures with a mileage on record happened before 20,000 miles.
21
Complaints
0
Crashes
0
Fires
0
Injuries
Filed with NHTSA, in their own words.
ENGINE
Daughter was driving and smoke starting coming out of car. Had to pull over on side of the road - which is unsafe. The radiator Fan Assembly needs replaced, PCV valve needs replaced, CVT fluid which has been confirmed by Ted Russel Nissan in Knoxville, TN. No warnings went off for her to be prepared. This is a known issue and a class action lawsuit was filed in 2026.
NHTSA complaint #11758183 — an unverified report by a vehicle owner.
ENGINE
The vehicle’s air conditioning began turning on and off intermittently while driving. I initially had the issue inspected by an independent mechanic, who checked the refrigerant and confirmed that the freon level was normal. After further inspection, the mechanic determined that the radiator cooling fan was not operating properly. The failed cooling fan appears to be affecting the vehicle’s cooling system and air conditioning operation. A malfunctioning radiator cooling fan can create a safety concern because it may prevent the engine from receiving adequate cooling, potentially leading to engine overheating, especially during extended driving or in hot conditions. The vehicle could potentially become disabled while being driven if the engine overheats. The problem was reproduced and confirmed by an independent service center. The cooling fan assembly is available for inspection upon request. The vehicle has not been inspected by Nissan, police, or an insurance representative to my knowledge. Prior to the failure being identified, the primary symptom was the air conditioning repeatedly turning on and off unexpectedly. There were no known warning lights or messages prior to the issue. The refrigerant was checked and found to be at an appropriate level, which led the mechanic to further investigate the cooling system and identify the nonfunctioning radiator fan. Unkown whether the fan failure is related to a larger manufacturing or design defect. However, I am concerned because premature radiator cooling fan failures have been reported on Nissan Rogue Sport vehicles, and a class action lawsuit was filed in July 2026 concerning premature fan failures and engine overheating in certain 2017 to 2022 Rogue Sport models. As of mid 2026, Nissan has not issued an official recall for the radiator cooling fan assembly in the Rogue or Rogue Sport. Had to pay an excessive amount of money to get this repair
NHTSA complaint #11757323 — an unverified report by a vehicle owner.
ENGINE
I have a 2020 Nissan roque sport with under 70K miles. Started experiencing loud shaking and rattle when turning off car, seems to be the radiator cooling fan. There is a current class action lawsuit but no official recall. If i turn off A/C 2 minutes before getting to park and turn off car it does not rattle when i turn off i believe it does shake and rattle but with engine running do not feel it. No warnings or engine lights come on, the temparature of car does not rise past 1/2 point.
NHTSA complaint #11750378 — an unverified report by a vehicle owner.
ENGINE
There is oil leaking into the engine. Whole engine needs to be replaced
NHTSA complaint #11747490 — an unverified report by a vehicle owner.
ENGINE
Fan Assembly - Nissan (21481-6MA0B) failed at 68,000 miles. Can can overheat and car will fail. This fan helps cool the AC and radiator.
NHTSA complaint #11702560 — an unverified report by a vehicle owner.
ENGINE
I had to replace my cooling system (fan, radiator, hoses, coolant) on this car after driving it only 30K miles. This led to over heating the car engine and stopped working because of that.. I was told by Nissan dealer it stopped working and they are seeing many of those issues related to the same car that I have. It costs me $1500 to replace it.
NHTSA complaint #11681214 — an unverified report by a vehicle owner.
ENGINE
The engine overheated due to cooling fan malfunctioning.
NHTSA complaint #11679201 — an unverified report by a vehicle owner.
ENGINE
The electric fan motor on the radiator failed. This caused the vehicle to overheat. The cap on the coolant reservoir did not actuate and the coolant reservoir exploded. The mechanical failure of the fan lead to a catastrophic failure of the coolant reservoir. If someone, a service tech or customer was under the hood when this happened they would most likely have died due to the extreme force and heated liquid coming out of the exploded reservior tank.
NHTSA complaint #11672029 — an unverified report by a vehicle owner.
ENGINE
The cooling fan is defective and is causing the vehicle to overheat major safety concern for my family .
NHTSA complaint #11671321 — an unverified report by a vehicle owner.
ENGINE
Radiator Fan stopped working.
NHTSA complaint #11670731 — an unverified report by a vehicle owner.
ENGINE
Engine shut off while waiting at a red light when pressing the gas pedal, everything else working find gear shit moving but car like disconnected,then 1 week later shuts off again at a drive through while pressing the brakes , remote start has never worked in the vehicle which is equipped with one, sometimes the screens shuts off while driving having to turn on and off the car multiple times until it works
NHTSA complaint #11662247 — an unverified report by a vehicle owner.
ENGINE
The cooling fan isn't coming on
NHTSA complaint #11661017 — an unverified report by a vehicle owner.
ENGINE
My car just made 50k miles and the cooling fan has gone out. A google search for a more reasonable replacement option (I was quoted almost $1100 for parts and labor) led me to a message board of other owners with the same issue and a class action lawsuit against Nissan. If this is indeed a widespread and known issue, Nissan needs to own up to it and make it right.
NHTSA complaint #11612156 — an unverified report by a vehicle owner.
ENGINE
On Saturday [XXX] while driving on [XXX] while in cruise control mode and set approx. 71 mph I know that my right knee made minimal contact with keyfob and the engine seemed to shut down and the vehicle decelerated immediately, I had no desire to brake due to my seeing my speed was near 30 mph. Traffic was not directly behind and all I was trying to locate was the 4 way hazard to engage which having only recently purchasing [XXX] and I had driven maybe 60 miles I located but with seeing a couple of vehicles approaching and being in the #2 lane my steering was stiff with little chance to get over safely to the #1 lane or to the further left HOV lane, I reached down w/ right hand and made very minimal contact with ignition/ keyfob area and the vehicle had power and was able to regain speed. I absolutely did not attempt to turn the key that was still fully in place. I can not say that other than making contact with no aggressive action or intent was I to believe the vehicle would again be running as it had prior and I proceeded the remainder of my trip (approx. 15-18 miles) with no further issues and without a clue other than I had been made aware of the recall prior to purchase and told it was not anything to be concerned with that the jackknife keyfob seemed to lock in the open position fine, and to just leave it in that position, which I did not agree with that opinion as I read about this safety issue and have brought up on at least 4 occasions prior to and after the sale. We were actually informed by the finance mgr. upon signing there were NO RECALLS on this vehicle, which we made him aware of and he commented that it would be nice if somebody would let him know that! And I informed sales person on two separate occasions as well asking that it receive the final Nissan remedy yet never being taken very seriously and now unhappy with this event when I that my knee making such slight contact is disturbing! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11608101 — an unverified report by a vehicle owner.
ENGINE
Coolant fans went out.
NHTSA complaint #11601589 — an unverified report by a vehicle owner.
ENGINE
My car stopped in the middle of AN EXTREMELY busy road with no warning lights or signs that my engine was over heating due to a faulty fan Giving more research into it there are thousands of people with Nissan rogue’s experiencing the same exact issue and Nissan has not tried to fix the problem They are installing faulty cooling fans in peoples cars and putting them in dangerous situations when their cars overheat in heavy traffic They are going to cause the death of someone when their car stalls on a busy street with no warning or sign I was almost hit by several other cars
NHTSA complaint #11600161 — an unverified report by a vehicle owner.
ENGINE
2020 Nissan Rogue Sport S AWD - The entire car unexpectedly shut down (I.E.: Exactly as if the car was completely off) while driving on two separate occasions, almost causing massive accidents and potential severe injury and/or death for everyone affected. Fortunately, I immediately reacted to get on a shoulder lane and allow the car to slow down, even though the car had no power steering, breaks that malfunctioned, and an electrical system/lights that completely went dead. This is all due to the JackKnife Key recall, which was not properly disclosed by the dealership, and which Nissan refuses to properly address and fix the matter even while acknowledging that an accident could have caused severe bodily injury and/or death. Also, the recall permanent fix is negligent due to the fact that the key fob would have a plastic spacer that would require key fob to have the key out in the open position at all times. The issue is that the key fob was never engineered to be in an open position at all times, so it would most likely break fast. This would require the consumer to now pay thousands of dollars to have a a new key fob made and to replace the affected areas of the key slot. Nissan should be responsible for finding a permanent fix , which should be to replace all affected parts with new ones, instead of inserting a cheap plastic spacer in the key fob which would require it to stay erect 24/7 all in the name of profits. The lives of our family members, kids, loved ones, and anyone affected are more important than Nissan's cheap fix (a cheap plastic spacer that probably costs less than $0.99 to produce, all in the name of increased profits and decreased costs by finding the most unsafest and cheapest solution possible. What if the spacer breaks, since the key will get destroyed being erect 24/7 in someone's pocket all day, and this happens again! Nissan should be mandated to either replace all affected parts with completely new parts or buy the car back above value.
NHTSA complaint #11557784 — an unverified report by a vehicle owner.
ENGINE
ABOUT 50 MILES IN DURING A ROAD TRIP, CVT TRANSMISSION FAILED. SLUGGISH WHEN ACCELERATING, WOULD NOT ACCELERATE PAST 40 MPH. GEAR WOULD NOT RELEASE TO REVERSE OR PUT INTO PARK TO SHUT THE VEHICLE OFF. HAD TO FIND AN OPEN FIELD IN ORDER TO TURN AROUND AND DRIVE BACK HOME DUE TO NOT BEING ABLE TO REVERSE. PROCEEDED BACK WITH FLASHERS ON AT A LOW RATE OF SPEED. WHEN I REACHED HOME, I PUSHED THE BUTTON TO POWER OFF THE VEHICLE, IT GAVE A WARNING THAT IT MUST BE IN PARK FIRST BUT I WAS ABLE TO PUT THE GEAR IN PARK AT THIS POINT. DURING THE TIME OF THE INCIDENT AND RETURNING HOME, THERE WAS NO WARNINGS PRESENT ON THE DASH. IF I HAD BEEN ON THE HIGHWAY AT 75 MPH DURING THIS INCIDENT IT MIGHT HAVE BEEN CATASTROPHIC! I CALLED THE NISSAN DEALERSHIP AND WAS TOLD TO BRING THE VEHICLE IN ON MONDAY. IT IS STILL UNDER WARRANTY AND JUST HIT 50,000 MILES. UPON RESEARCHING, THIS SEEMS TO BE A KNOWN ISSUE WITH ROGUES OF CERTAIN YEARS, MINE INCLUDED IN 2020, WITH NISSAN.
NHTSA complaint #11547740 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
The contact owns a 2020 Nissan Rogue Sport. The contact stated that while his wife was leaving a parking lot, the vehicle stalled with steam coming from the engine. The contact was unaware if there were any warning lights illuminated. The vehicle was initially towed to an independent mechanic who was unable to service the vehicle; the vehicle was towed to a local dealer and the contact was informed that the cooling fan needed to be replaced. The dealer informed the contact that parts were on backorder and the vehicle could not be serviced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 20,000.
NHTSA complaint #11539292 — an unverified report by a vehicle owner.
ENGINE
Cooling fan stopped working. I was told by the Nissan dealership this is a big issue with this specific vehicle and that it’s hard to get the part because this is always an issue. No messages appeared. My AC stopped working and I took it to the dealership were they said if I drive with the cooling fan broken it will explode. How is this not a recall? This has been reproduced by ALL Nissan dealerships and the Nissan dealership is who told me this and diagnosed my car.
NHTSA complaint #11530759 — an unverified report by a vehicle owner.
ENGINE
Vehicle has 61k miles and the a/c began blowing cold and hot intermittently as the car was idle but no engine lights were coming on. 5 days later a mechanic was able to look at vehicle and discovered the one fan responsible for entire car wasn’t not coming on and it was only the air being pushed into the front of vehicle by having it in motion that was turning the fan thus making the vehicle blow cold air when in motion and keeping the engine cooled. No warning lights were coming on and staying on
NHTSA complaint #11528497 — an unverified report by a vehicle owner.