19 of the
443 complaints about the 1998 Plymouth Voyager are about the
steering — 4% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
79,500 miles.
DROVE THROUGH A PUDDLE. SERPENTINE BELT FELL OFF, CAUSING LOSS OF POWER STEERING. COMPLETED REPAIR AS PER TSB 07-02-99. DID NOT CORRECT ISSUE. A KNOWN ISSUE WITH 1996 - 2000 PLYMOUTH/DODGE CARAVANS 3.3L AND 3.8L. VERY DANGEROUS, HAPPENS ON WET/SNOW CONDITIONS. BOTTOM THIRD OF HARMNIC BALANCER IS NOT GUARDED FROM ROAD MOISTURE. CHRYSLER REDESIGNED IN 2001. GATES AFTER MARKET KIT SOLVES PROBLEM GAT 38379K, COST $120-$220 WITH OUT LABOR. DOES THIS MEET THE CRITERIA FOR A RECALL?
NHTSA complaint #10449144 — an unverified report by a vehicle owner.
at 170,000 milesLitchfield, MI
STEERING
1998 PLYMOUTH GRAND VAN 3.3 MOTOR. AFTER GOING THREW A RAIN PUDDLE OR GOING THREW SNOW THE BELT WILL COME OFF. IT WILL LEAVE YOU STUCK ON THE SIDE OF THE ROAD!. HAVE TRIED TO HAVE IT REPAIRED 3 OR 4 TIMES AND IT STILL DOES IT. IT IS A KNOWN PROBLEM BY PLYMOUTH. THEY NEED TO FIX THIS!!!!
NHTSA complaint #10227805 — an unverified report by a vehicle owner.
at 58,000 milesColorado Springs, CO
STEERING
IT IS JUNE OF 2003 AND THE CAR IS CURRENTLY IN THE SHOP AGAIN FOR THE TRANSMISSION PROBLEM. IT HAS HAD A POWER STEERING PUMP FAILURE, SERPENTINE BELT FAILURE TIMES 5 AND NOW A COMPUTER PROBLEM. I HAVE CONTACTED CHRYSTLER CORP AT LEAST 5 TIMES REGARDING THE PROBLEMS WITH THIS CAR. THEIR ANSWER IS WELL, IF YOU DON'T LIKE THE CARE TRADE IT IN.
NHTSA complaint #10070075 — an unverified report by a vehicle owner.
at 87,000 milesWadena, MN
STEERING:RACK AND PINION:RACK
STEERING WHEEL LOCKS UP WHEN TURNING LEFT OR RIGHT. *AK DEALER REPLACED STEERING RACK AND PERFORMED ALIGNMENT ON VEHICLE.
NHTSA complaint #10059697 — an unverified report by a vehicle owner.
at 72,000 milesLOS Angeles, CA
STEERING
1998 PLYMOUTH VOYAGER LOSES SERPENTINE BELT ,OVER HEATS AND LOSES POWER STEERING WHENEVER IT RAINS. I HAD THE BELT TENSIONER REPLACED TWICE IT HAS NOT HELPED NOW VAN IS AT ANOTHER CHRYSLER DEALERSHIP, WHERE THEY SAY IT IS THE POWER STEERING PUMP AND PULLEY. THEY ARE CHARGING ME $400.00 DOLLARS TO DO THIS WORK AND I BELIEVE THIS IS A MANUFACTURING DEFECT THAT SHOULD BE ACKNOWLEDGED AND ADDRESSED.
NHTSA complaint #10018372 — an unverified report by a vehicle owner.
Conifer, CO
STEERING:HYDRAULIC POWER ASSIST SYSTEM
THE INTERIOR LIGHT DID NOT COME ON. THE DRIVERS SIDE WINDOW FAILED INTERMITTENTLY. THE DASH LIGHTS FLICKERED. OCCASIONALLY THE HORN WOULD FAIL. METAL FRAGMENT CUT THROUGH THE POWER STEERING AND CAUSED NOISE WHEN STEERING. THE DOOR HANDLE DIDN'T OPEN SMOOTHLY. THE DEALER REPLACED FRONT STRUTS AND REAR SHOCK ABSORBERS. ALSO, REPLACED LEAKING ENGINE VALVE COVER GASKET, ENGINE BELT AND TENSIONER. . *AK *NLM
NHTSA complaint #10015884 — an unverified report by a vehicle owner.
Conifer, CO
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
THE INTERIOR LIGHTS DID NOT COME ON, THE DASH BOARD LIGHTS FLICKERED, THE DRIVER'S WINDOW STOPPED WORKING, AND THERE WAS A CRUNCHY NOISE COMING FROM THE STEERING COLUMN, IT WAS DETERMINED THE POWER STEERING LINES LEAKED, THE FRONT STRUTS AND SUSPENSION WERE REPLACED, AT TIMES THE HORN DID NOT WORK, AND LATER THE CONSUMER RECEIVED A RECALL NOTICE REGARDING THE CLOCK SPRING ASSEMBLY NEEDED TO BE REPLACED. THIS IS A COURTESY COPY TO NHTSA (CC) THE LETTER IS ADDRESSED TO DAIMLER CHRYSLER.*PH ALSO THE VALVE COVER GASKETS WERE REPLACED.
NHTSA complaint #10011563 — an unverified report by a vehicle owner.
at 14,000 milesRichmond, KY
STEERING
WHEN DRIVING AT LOW SPEEDS AND BRAKES ARE APPLIED,VEHICLES' STEERING WHEEL WILL TIGHTEN, MAKING IT DIFFICULT TO STEER. THIS ALMOST CAUSED SEVERAL ACCIDENTS. THE DEALERSHIP HAVE REPLACED THE RACK AND PINION 3 TIMES AND THE POWER STEERING PUMP ONCE, BUT PROBLEM STILL EXITS.
NHTSA complaint #10004652 — an unverified report by a vehicle owner.
Panama City, FL
STEERING
TENSIONER FREEZES UP AND HAS TO BE REPLACED. THIS HAS HAPPENED TWICE IN ONE YEAR. EACH OF THE TWO DIFFERENT DEALERS CHARGED ME DIFFERENT AMOUNTS,ONE CHARGED 106.00 AND THE OTHER CHARGED 275.00. I HAVE BEEN TOLD THIS CAN BE VERY DANGEROUS BY THE DEALER AND NEEDS TO BE FIXED. I WONDER WHY THEN IF IT IS SO DANGEROUS AND SO MANY PEOPLE ARE HAVING THE SAME PROBLEM IT HAS NOT BEEN RECALLED.
NHTSA complaint #10000051 — an unverified report by a vehicle owner.
N. Augusta, SC
STEERING:HYDRAULIC POWER ASSIST SYSTEM
WHILE DRIVING POWER STEERING WENT OUT WITH ANY WARNING. VOLTAGE REGULATOR HAD OVERHEATED, AND ALTERNATOR WAS NOT CHARGING. SERPENTINE BELT GOT WET, RESULTING IN BELT COMING OFF THE PULLEY. THIS HAPPENS EVERYTIME SERPENTINE BELT GETS WET. PLEASE DESCRIBE DETAILS.
NHTSA complaint #8019054 — an unverified report by a vehicle owner.
Warfordsburg, PA
STEERING:RACK AND PINION
WHILE DRIVING 40 MPH DRIVING PIN BROKE OFF, CAUSING LOSS OF CONTROL.
NHTSA complaint #8014170 — an unverified report by a vehicle owner.
Stow, OH
STEERING:HYDRAULIC POWER ASSIST SYSTEM
SERPENTINE BELT SLID OFF DUE TO A BOLT NOT HOLDING TENSION. LACK OF TENSION RESULTED IN TOTAL STEERING FAILURE IMMEDIATELY AND ENGINE OVERHEATING FROM LACK OF COOLING FAN OPERATION. THIS WAS SECOND OCCURRENCE. PLEASE PROVIDE DETAILS.
NHTSA complaint #8009788 — an unverified report by a vehicle owner.
Roseville, MI
STEERING:HYDRAULIC POWER ASSIST:PUMP
BELT FOR THE POWER ASSISTED STEERING HAS DISCONNECTED FROM THE BELT TENSIONER THREE TIMES DURING NORMAL OPERATION. WHEN THIS PROBLEM OCCURS, STEERING CONTROL OF THE VEHICLE BECOMES VERY LIMITED. DEALERSHIP HAS DIAGNOSED THE PROBLEM AND MADE ALL REPAIRS TO THE VEHICLE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.
NHTSA complaint #8002247 — an unverified report by a vehicle owner.
Orange, CA
STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
A SENSOR WITHIN TRANSMISSION ASSEMBLY LOCKS UP WHICH CAUSES VEHICLE TO GO INTO NETURAL WHILE DRIVING. PLEASE GIVE ANY FURTHER DETAILS.
NHTSA complaint #891890 — an unverified report by a vehicle owner.
Winter Haven, FL
STEERING:HYDRAULIC POWER ASSIST:PUMP
IN RAIN OR GOING THROUGH PUDDLE OF WATER AT LOW OR HIGH SPEEDS WATER WILL CAUSE POWER ASSIST BELT TO SLIP, CAUSING LOSS OF STEERING.
NHTSA complaint #884936 — an unverified report by a vehicle owner.
Toms River, NJ
STEERING:RACK AND PINION
INTERMITTENTLY STEERING BECOMES DIFFICULT WHEN MAKING A TURN. DEALER HAS INSPECTED VEHICLE AND WILL REPLACE RACK AND PINION. *AK *SLC
NHTSA complaint #875488 — an unverified report by a vehicle owner.
Boonton, NJ
STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
BODY TAR INSULATION MELTED BETWEEN PANEL ON SEAT BELT MECHANISM, CAUSING IT TO JAM AT TIMES.
NHTSA complaint #735040 — an unverified report by a vehicle owner.
Addis, LA
STEERING: STEERING WHEEL/HANDLE BAR
WHILE DRIVING HEARD A POPPING NOISE AND TOOK VEHICLE TO THE DEALERSHIP, AND WAS INFORMED THAT THE STEERING COLUMN NEEDS TO BE REPLACED.
NHTSA complaint #837372 — an unverified report by a vehicle owner.
Blythe, CA
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
POWER STEERING HOSE FAILED.
NHTSA complaint #607693 — an unverified report by a vehicle owner.