32 of the 104 complaints about the 2009 Pontiac G5 are about the fuel system — 31% of everything reported for this model year. Half of the failures with a mileage on record happened before 96,000 miles.
32
Complaints
1
Crashes
0
Fires
0
Injuries
Filed with NHTSA, in their own words.
FUEL/PROPULSION SYSTEM
All gauges on dash starting going up and down, Anti theft light, power steering light, low fuel light. Car slipping or having hard time going and possibly the key transponder ignition / chip key anti theft shut down.
NHTSA complaint #11729573 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2009 Pontiac G5. The contact stated that while operating the vehicle, the odor of fuel was present. Upon inspection, it was discovered that fuel had leaked from above the fuel tank. The cause of the failure was not determined. The local unknown dealer and manufacturer were notified of the failure however, no assistance was offered. The contact was informed that the vehicle was not included in the NHTSA campaign number: 12V459000 (Fuel System, Gasoline). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 129,000.
NHTSA complaint #11420893 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
My 2009 Pontiac G5 was driven to work this morning 6-10-21and parked in a Michigan State vehicle garage. Security notified me at work that my vehicle had a puddle of gas under and near a rear tire. I removed vehicle frome parking garage and parked it in a remote open parking lot. A gas leak in a car is dangerous, and a safety issue for me and others , especially in a parking garage!!! The vehicle has always been maintained as I am the original owner of the car. The car will be delivered to the dealer for inspection on 6/14/21. There are no recalls on this car . Opon my own investigation after the incident, there are numerous complaints logged into NHTSA of a rust issue of the fuel line where it is clamped near the fuel tank. There is also reports of crack developing at the intank fuel pump connection. ALL Cobalts,G5 's and other variations of this vehicle should be recalled immediately and inspections of the fuel system be reported back to NHTSA. Was there a fire? My answer is "NOT YET".
NHTSA complaint #11420402 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LINE LEAKAGE - GAS LEAKS OUT QUICKLY UNTIL THE TANK IS EMPTY. THE CAR IS UNDRIVABLE IN THIS CONDITION, WHICH SEEMS TO BE A HUGELY COMMON PROBLEM WITH THE 2009 PONTIAC G5. A MASSIVE GAS LEAK IS A SAFETY CONCERN.
NHTSA complaint #11390665 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LEAKING FROM FUEL LINES ON DRIVER SIDE JUST IN FRONT OF REAR WHEEL WELL.
NHTSA complaint #11360279 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LEAKING FROM THE FUEL LINE ON THE DRIVER SIDE.
NHTSA complaint #11350722 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LINES CORRODED AT LEFT REAR WHEEL CAUSING A MAJOR FUEL LEAK.
NHTSA complaint #11344292 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LEAK. OVER DRIVERS SIDE REAR WHEEL . FUEL FEED LINE IN AREA COVERED WITH MOON TAPE BEHIND HEAT SHIELD. PREVIOUSLY REPORTED A FUEL LEAK ON FEED LINE JUST BEYOND THE FUEL FILTER. NOW HAVE TWO FUEL LEAKS. FUEL RETURN LINE ALSO LOOKS CORRODED .
NHTSA complaint #11343619 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LINE IS LEAKING OVER DRIVERS REAR WHEEL ( FORWARD OF FUEL FILTER) FUEL LEAKS WHEN CAR IS RUNNING AND CONTINUES TO LEAK UNTIL FUEL LINE IS EMPTY.
NHTSA complaint #11338531 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
AROUND 127000 MILES I NOTICED A STRONG SMELL OF GASOLINE, AND A SMALL DRIP FROM UNDER MY CAR, AFTER TAKING A CLOSER LOOK I NOTICED THAT IT WAS GAS, AND IT WAS COMING FROM THE RETAINING CLIP THAT HOLDS THE FUEL/BRAKE LINES IN PLACE, I WAS NOT FINANCIALLY STABLE TO HAVE THIS REPAIRED AT THE TIME, AND IT WASN'T LEAKING TO BAD SO I LEFT IT GO, AFTER ABOUT 2-3 MORE WEEKS I WAS DRIVING AND NOTICED THAT I COULD LITERALLY SEE MY FUEL GAUGE DROPPING, I IMMEDIATELY PULLED OVER AND INSPECTED THE PROBLEM AREA AND SEE THAT THE CAR WAS DUMPING FUEL AND A VERY HIGH PRESSURIZED RATE, I ALSO TOOK NOTE THAT THE GAS WAS BEING SPRAYED ONTO THE HOT EXHAUST THAT IS ABOUT 4-6? AWAY FROM THE FUEL LINES, I GOT THE CAR HOME AND PARKED IT, AFTER DOING HOURS OF RESEARCH I SEEN THAT 95% OF THIS YEAR AND MODEL OF GM HAVE THIS ISSUE DUE TO THE HEAT SHIELDING ON THE FUEL LINES AFTER SEARCHING MY VIN IT SAYS THAT MY VEHICLE HAS NO ACTIVE RECALLS BUT I'VE SEEN COMPLAINT AFTER COMPLAINT ABOUT THIS ISSUE, NOT ONLY THAT IT IS EXTREMELY DANGEROUS THAT GAS IS BEING STAYED OUT UNDER PRESSURE WHICH IS CAUSING IT TO VAPORIZE AND BECOME EVEN MORE OF A FIRE HAZARD, NOT TO MENTION IT IS INCHES AWAY FROM THE EXHAUST AND DIRECTLY BELOW THE FUEL TANK... THIS ISSUE SHOULD DEFIANTLY BE ADDRESSED WITH GM AND BE SUBMITTED FOR RECALL IN MY OPINION, THIS ISSUE ONLY HAPPENS WHEN THE VEHICLE IS ON OR THE KEY IS TURNED TO THE ON POSITION AND THE FUEL PUMP IS PRIMED AND RUNNING TO CHARGE THE FUEL LINES, AFTER THE VEHICLE IS TURNED OFF THE LEAK STOPS AFTER THE FUEL LINE HAS DRAINED ONTO THE GROUND CAUSING ANOTHER FIRE HAZARD AND A ENVIRONMENTAL HAZARD MAKING IT AN ISSUE TO START THE CAR AGAIN DUE TO NO GAS BEING IN THE LINES, IN MY CASE I HAVE TO TURN THE KEY TO ON AND GIVE THE FUEL PUMP ABOUT 15 SECONDS TO PRIME AND PUMP GAS INTO THE LINES, THIS ISSUE HAS MADE IT IMPOSSIBLE TO DRIVE AS I DUMP A GALLON OF FUEL EVERY 2-3 MILES.
NHTSA complaint #11323940 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
MAJOR FUEL LEAK IN THE MAIN FUEL LINE BETWEEN TANK AND ENGINE DIRECLTY IN FRONT OF THE LEFT REAR WHEEL AND NEAR THE EXHAUST. THE LINE CORRODED FROM BEING COVERED WITH POOR INSULATION TAPE THAT ALLOWED MOISTURE BEHIND. EVAP LINE BAD TOO AND NOW CAUSING CHECK ENGINE LIGHT
NHTSA complaint #11312134 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
LEAK AT FUEL LINE AT HOLDING CLIP RIGHT AFTER GAS TANK. WHEN KEY IS TURNED ON AND FUEL PUMP START TO RUN. HAD THE SAME PROBLEM WITH A 2006 COBALT 2 YEARS AGO. IT IS LIKE THE SAME CAR
NHTSA complaint #11257935 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2009 PONTIAC G5. THE CONTACT SMELLED A FUEL ODOR AFTER DRIVING THE VEHICLE AND NOTICED FUEL LEAKING FROM THE FUEL PUMP. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 12V459000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT NOTHING COULD BE DONE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.
NHTSA complaint #11133290 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LINE IS LEAKING UNDERNEATH,BEHIND DRIVERS DOOR & IN FRONT OF REAR WHEEL.ALONG WITH THE CHEVY COBALT (THE EQUIVALENT TO MY PONTIAC G5), THIS AN ALL TOO COMMON PROBLEM AS I HAVE RESEARCH NUMEROUS COMPLAINTS OF THIS SAME LEAK FROM THE SAME LOCATION. THIS IS A POTENTIAL FIRE HAZARD & I AM HAVING DIFFICULTY FINDING THE REPLACEMENT FUEL LINES.
NHTSA complaint #11132019 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I WENT IN TO GET AN OIL CHANGE DONE FOR MY CAR AND ONE OF THE WORKERS SAID THAT THEY HAD TO STOP BECAUSE THEY WERE SMELLING GAS COMING FROM THE DRIVER SIDE REAR OF MY CAR. I THEN LATER FIND OUT THAT MY CAR HAS A FUEL LINE LEAK. I DID SOME RESEARCH AND FOUND THAT MY CAR HAS NOT BEEN THE ONLY ONE AS IT ALSO HAPPENS TO CHEVY COBALTS, WHICH MY CAR IS PRETTY MUCH A COPY OF.
NHTSA complaint #11113910 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LINE RUSTED AT RETAINING BRACKET AND LEAKING FUEL
NHTSA complaint #11113232 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2009 PONTIAC G5. WHILE DRIVING VARIOUS SPEEDS, A FUEL ODOR EMITTED THROUGH THE VENTS. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AT THE CONTACT'S RESIDENCE AND DIAGNOSED THAT FUEL WAS LEAKING FROM EITHER THE FUEL PUMP OR THE FUEL TANK. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.
NHTSA complaint #11080700 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2009 PONTIAC G5. WHILE DRIVING 50 MPH, THE CONTACT NOTICED A STRONG FUEL ODOR INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER (AUTONATION CHEVROLET SOUTH CLEARWATER, 15005 US HWY 19 N, CLEARWATER, FL 33764) WHERE IT WAS DISCOVERED THAT FUEL WAS LEAKING UNDERNEATH THE ENGINE. THE DEALER WANTED TO REPAIR THE FAILURE. THE DEALER CONTACTED GENERAL MOTORS AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-222-1020 AND STATED THAT THE CONTACT WOULD HAVE TO PAY FOR THE REPAIR. CASE NUMBER: 8/343/2735498 WAS PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
NHTSA complaint #11033091 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
CRACKED FUEL RETURN LINE AT FUEL PUMP. THIS ISSUE WAS REPORTED AND RECALLED ON THE 2007, 2008, AND SOME 2009 G5 MODELS. SYMPTOMS: WHEN THE CAR IS SHUT OFF, FUEL STARTS DRIPPING ONTO THE GARAGE FLOOR FROM THE REAR OF THE CAR.
NHTSA complaint #11003470 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
VEHICLE STATIONARY - EXPERIENCED A HARD START POST DRIVING, AFTER DRIVING I SMELLED A STRONG GASOLINE VAPOR. BASED ON THE SYMPTOMS AND THE MAKE, MODEL, YEAR, THIS APPEARS TO BE A FUEL LEAK OF SOME SORT CAUSED BY A DETERIORATING PLASTIC TUBE IN THE FUEL LINE WHICH SHOULD BE COVERED BY RECALL HTTPS://WWW.USATODAY.COM/STORY/MONEY/CARS/2012/09/29/GENERAL-MOTORS-RECALL/1602747/
NHTSA complaint #11000105 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
GAS IS LEAKING (FAIRLY STEADY FLOW) NEAR REAR DRIVER-SIDE TIRE WHEN ENGINE IS RUNNING, IN PARK OR DRIVE, STOPS LEAKING ONCE CAR IS OFF. THIS APPEARS LIKE IT SHOULD BE COVERED BY #12191B, BUT ACCORDING TO GM MY VIN IS NOT IN SYSTEM AS BEING COVERED. GM WILL NOT COVER UNLESS I TAKE CARE IN FOR DIAGNOSTICS. I WONT TAKE CAR IN FOR DIAGNOSTICS SINCE IT COULD CATCH FIRE UNTIL I KNOW THAT IT WILL BE COVERED. VEHICLE HAS A LITTLE OVER 100K MILES.
NHTSA complaint #10960387 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LEAKING FROM REAR OF CAR. STRONG GASOLINE SMELL INSIDE CAR. VERY POOR GAS MILAGE LEAKS PARKED OR DRIVING.
NHTSA complaint #10924485 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2009 PONTIAC G5. WHILE DRIVING AT AN UNKNOWN SPEED, A FUEL ODOR ENTERED THE VEHICLE. THE CONTACT NOTICED FUEL LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V459000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #10908633 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2009 PONTIAC G5. THE CONTACT NOTICED A STRONG FUEL ODOR COMING FROM THE REAR OF THE VEHICLE. THE CONTACT WAS EXPERIENCING THE SAME FAILURES LISTED IN NHTSA CAMPAIGN NUMBER: 12V459000 (FUEL SYSTEM). THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA complaint #10850171 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2009 PONTIAC G5. WHILE THE VEHICLE WAS PARKED, THERE WAS A STRONG FUEL ODOR COMING FROM THE VEHICLE. IN ADDITION, THERE WAS FUEL LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V459000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #10785549 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2009 PONTIAC G5. WHILE DRIVING AT APPROXIMATELY 45 MPH, THERE WAS A STRONG ODOR OF FUEL WITHIN THE VEHICLE. THE CONTACT PULLED OVER TO OBSERVE THE VEHICLE AND NOTICED FUEL LEAKING UNDERNEATH THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V459000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 101,000. UPDATED 02/12/2016*LJ UPDATED 02/17/16.8JB
NHTSA complaint #10785610 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
I HAVE A 2009 PONTIAC G5. THE FUEL PUMP CRACKED RECENTLY AND I HAD TO HAVE IT TOWED AND REPLACED AT THE NEAREST SHOP. I BROUGHT IN THE RECALL FOR THE FUEL PUMP TO MY GMC DEALER, AS I SAW IT ONLINE, AND MY RECEIPT OF THE REPLACEMENT FUEL PUMP. THE DESCRIPTION OF THE RECALL MATCHES MY VEHICLE AND I AM TOLD I AM UNABLE TO RECEIVE REIMBURSEMENT BECAUSE THE RECALL IS "VIN SPECIFIC". MY CAR MATCHES THE EXACT DETAIL OF THE RECALL, BUT THE RECALL IS NOT APPLIED TO MY VIN?! I'D LIKE TO KNOW WHY! I HAVE THE CARFAX TO SHOW THAT MY VEHICLE APPLIES TO THE STANDARDS OF THE RECALL. I'D LIKE CONTACTED IMMEDIATELY ON THIS SITUATION.
NHTSA complaint #10566543 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
CAR STARTED SMELLING OF GAS. THEN GARAGE SMELLED OF GAS. THEN THE FUEL ECONOMY BECAME INACCURATE. THEN GAS STARTED DRIPPING FROM UNDER CAR. THEN GAS STARTED STREAMING UNDER CAR. THEN TOLD GM DEALER AND WAS TOLD THERE WOULD BE NO REMEDY UNTIL GM RECALLS TAKE EFFECT. NOW, 8 MONTHS LATER NO REPAIR OFFERED. CAR IS UNSAFE AND LEAVES ME STRANDED REGULARLY AS IT POURS GAS OUT OF CAR. I WILL TAKE CAR BACK TO DEALER AND EXPECT IMMEDIATE REPAIR.
NHTSA complaint #10478801 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THERE IS A HUGE LEAK IN MY GAS LINE. I SEE THAT THIS WAS A DEFECT IN THE OLDER MODELS OF THE G5 AND THEY WERE RECALLED FOR IT, BUT THERE IS NO RECALL FOR MY YEAR MODEL AND I AM HAVING THE SAME KIND OF PROBLEM AS STATED IN THOSE OLDER MODEL RECALLS FOR THE GAS LINE. I AM AFRAID TO DRIVE THE VEHICLE AND I AM HAVING A HARD TIME GETTING IT SERVICED, NOT AT MY EXPENSE BECAUSE OF THIS DEFECT. IT STARTED AFTER I HAD TAKEN MY VEHICLE TO GET TWO RECALL ITEMS DONE ON IT RECENTLY (A WEEK AGO). I AM NOT SAYING THAT THIS IS THE CAUSE, BUT I HAD NEVER HAD A PROBLEM WITH THIS VEHICLE OTHER THAN THIS TIME. I WOULD LIKE SOMEONE TO CHECK INTO THERE BEING A POTENTIAL FIRE HAZARD IN THE FUEL LINE OF THE NEWER MODEL 2009 PONTIAC G5'S AS WELL.
NHTSA complaint #10469953 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2009 PONTIAC G5. THE CONTACT STATED THAT THE FUEL TANK WAS LEAKING FUEL. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE FAILURE WAS A MANUFACTURER'S DEFECT AND OFFERED NO ASSISTANCE. THE VEHICLE WAS THEN TAKEN TO A PRIVATE MECHANIC FOR REPAIR. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 76,000. UPDATED 09/05/12
NHTSA complaint #10468860 — an unverified report by a vehicle owner.