Component/system: High-voltage (HV) battery system and power electronics. 2020 Porsche Taycan Turbo, VIN [XXX] . Vehicle available for inspection. Safety risk: Since January 2025, the vehicle has repeatedly displayed a "pull over and park safely" emergency warning and shut off unexpectedly while driving at highway and surface road speeds. Sudden loss of propulsion at speed created serious collision risk. Dealer-confirmed: Porsche Woodland Hills documented (July 2025): "vehicle just shut off on him as he was driving — multiple occurrences." A second shutdown was confirmed August 2025: "vehicle shut off while driving — high voltage battery error." Four or more repair visits under my ownership for this same defect. Fault codes confirmed by authorized Porsche dealers: P0AA600 (HV Battery Voltage System Isolation Fault — highest severity), P0A4000 (Rotor Position Sensor Fault), U178800 (Front Axle Power Electronics Drive Fault), P061B00 (Torque Calculation Fault). November 2025: Porsche Downtown LA isolated all 33 battery modules, found modules 6, 19, and 32 defective — all physically replaced. Vehicle out of service 9+ weeks. Shutdown warning recurred during same visit. Porsche NA (Case #XXX) denied repurchase. Warning lamps: "Pull over and park safely" warning and HV battery error appeared suddenly before each shutdown. No gradual symptoms. Recurring since January 2025. Additional: Prior owner records show HV battery water intrusion (February 2024) requiring full battery removal and reinstallation. In July 2024, dealer cleared "numerous inactive fault codes" without disclosure prior to my purchase. Porsche NA has acknowledged the issue by offering goodwill compensation while refusing repurchase. Cumulative out-of-service days for this defect exceed 75 days across multiple repair visits. I request NHTSA investigate whether this defect exists across other Taycan vehicles and whether a recall is warranted. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11738439 — an unverified report by a vehicle owner.
There are .recalls.on the Vehicle I had been unaware of and I dropped off my vehicle for exterior buffing while person Buffing vehicle he heard a loud explosion and when he looked the vehicle was up in flames the vehicle burned. There was a Risk of someone getting Harm , Killed and Damages to other vehicles on the property in same lot vehicle was being buffed . Police and Fireman were dispatch to location.
NHTSA complaint #11732488 — an unverified report by a vehicle owner.
On March 21, 2026 my Taycan motor wire disconnected from the battery during routine city driving The car was In the Middle lane of [XXX] waiting to turn left onto [XXX] A warning light said Car not drivable , pull over But the car was not functional. Police needed to block [XXX] to allow the car in neutral to slide downhill to A safe location This is the second time this car with undercar exposed wires has had a wire disconnect and disabled driving Clearly some kind of under car wire protection is not properly installed or present INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11727627 — an unverified report by a vehicle owner.
There are currently hundreds (if not thousands) of cars, operating on roads of USA, that at any particular time stop in the middle of the road. The power is cut off and Engine Control Error is displayed on the monitor. This issue has been described many times on Reddit, under Taycan-Engine Control Error threads. The affects 2020-21 Porsche Taycans. As an owner of '21 Taycan, I have run into this issue 8 times in the past 4 months. I have been lucky so far not to cause any incidents. I've brought in my car 3 times to Porsche dealership. The first time, a fix was made, but it did not do anything. The second time I brought it in, I was told that there is a transmission issue, but since the dealership can't replicate this issue, they can't fix it. After the second attempt, I contacted Porsche headquarters, looking for resolution. The customer service requested for me to bring the car back to dealership for additional analysis. After I brought the car to dealership, I waited for over a month and then received an email from Corporate Customer Service- there is nothing wrong with my car. So, I'm still driving a car, that can and will stop at any moment. I warned Porsche corporate that if the next time my car stops for no apparent reason and this leads to an injury or worse, someone at Porsche will be charged with manslaughter. Even though Porsche Corporate knows that these cars are a problem, the company refuses to address this issue and blatantly lies to clients, hoping that no one wants to take on a big corporation. How long will it be, until there is a serious injury or worse happens due to these sudden stops? I have all the communication between myself,orsche corporate and Porsche North Seattle showing the exact dates, when these issues happened, the attempt to fix them, the text message from dealership telling me that there is a transmission issue and lastly the email from Corporate, stating that there are no issues with this car. Please take a look. Thank you.
NHTSA complaint #11725896 — an unverified report by a vehicle owner.
While driving the vehicle, an error message (Engine Control Error) will pop up. The car will come to an immediate stop…forcing the driver to shut off car and restart it. This has happened multiple times and in one instance occurred on the highway. It almost caused a catastrophic accident as the car came to an abrupt stop in the middle lane of the highway. I’ve taken the car to the dealership multiple times and they have not been able to fix it. I’ve read many Taycan message board posts and it seems like this is a common issue amongst multiple years of Taycans. This is a serious safety issue and a recall should be issued with a remedy for this. Due to this, I cannot drive the car on the highway as I’m scared of it happening randomly. This is a known issue and one that should be recalled and handled appropriately by Porsche.
NHTSA complaint #11720540 — an unverified report by a vehicle owner.
I am reporting a safety defect involving (1) sudden loss of propulsion (“turtle mode”/limp mode) while accelerating/merging into traffic and (2) unintended steering movement while driver-assist/lane centering was active (vehicle jerked toward adjacent lane and off roadway). These events create an immediate crash risk. The vehicle has also had repeated charging-related overheating/charging stoppage events, which I believe may present a fire risk when charging in a residential garage. Repairs have been attempted multiple times by an authorized Porsche dealer, but defects persist. Warranty has now expired, and an independent scan shows ongoing network/data bus/12V monitoring faults consistent with continuing electrical/network instability. I am requesting NHTSA review for a potential safety defect investigation/recall.
NHTSA complaint #11717011 — an unverified report by a vehicle owner.
1. Do not charge the car more 80% fire risk. 2. Loss of power stalling,software malfunction. 3. Battery/Electrical: Battery issues,erratic instrument panel gauges or lights. electronic stability control overheating. 4. Miscellaneous Concerns; Battery power loss.
NHTSA complaint #11716441 — an unverified report by a vehicle owner.
The EV had a “Engine Control Error” and suffered engine failure on Jan 6th 2026 at 5:17pm. It happened out of nowhere without any warning at low speed.
NHTSA complaint #11712514 — an unverified report by a vehicle owner.
Made a turn into a street and driving at slow pace (about 20mph) and the vehicle suddenly shuddered and came to complete stop and died in the middle of the road. I had no time to pull over. No warning. It just happened. Fortunately, no oncoming or cars behind me. There was a red dash board warning “Engine Control Error”. I turned off the vehicle and restarted.
NHTSA complaint #11709797 — an unverified report by a vehicle owner.
The vehicle experiences a sudden and dangerous malfunction while driving. Without any prior warning, the vehicle begins to shake and then immediately brakes on its own, coming to an abrupt stop in the middle of traffic. Only after the vehicle has already braked and shut down does an “Engine Control Error” message appear on the display. There is no advance alert and no time for the driver to react or move out of traffic. This is exceptionally concerning especially as this vehicle was being used a primary mode of transportation for my 2 young toddlers who were present in the vehicle during these failures. The vehicle was purchased directly from Porsche as a Certified Pre-Owned vehicle in June 2025, and was represented by Porsche as having passed all safety and mechanical inspections at the time of purchase. Despite this, the vehicle has continued to experience catastrophic failures. Following the initial shutdown incident, the vehicle was towed to Porsche for service on September 2. Porsche stated that the issue had been repaired and assured that the vehicle was safe to operate. However, on September 29, the same failure occurred again. The vehicle shook, abruptly braked in active traffic, shut itself down, and only then displayed the engine control failure message. This shows that the underlying defect was not corrected and continues to pose a serious safety hazard. The problem is severe, unpredictable, and reproducible. It places the driver, passengers, and surrounding motorists at immediate risk because the vehicle becomes immobilized in traffic with no prior warning and no ability to pull over safely. The vehicle has been inspected by Porsche technicians, but the root cause remains unknown, and Porsche has been unable to provide a successful repair or assurance of safety. This pattern strongly indicates a critical defect in the engine control or power-management system that renders the vehicle unsafe for public road use.
NHTSA complaint #11703735 — an unverified report by a vehicle owner.
I was stopped at an intersection waiting for traffic. There was a small opening in traffic, and I accelerated rapidly from a stop while making a left turn to enter traffic when the "engine/motor" suddenly completely died, and the car quickly came to a stop. The dash displayed a message: "Engine Control Error. Park vehicle in a safe place." Had there been a semi-truck that could not stop behind me, there would have been a collision. I turned the car off and then back on, and was able to drive the car. I had it serviced at Hennessy Porsche in Atlanta. They "reprogrammed" the car. I showed them some reports from the Taycan Forum of other incidents where this problem occurred, including one from a mechanic in the UK, which is attached. https://www.taycanforum.com/forum/threads/explained-wna5-drive-system-control-fault.25777/ This report states that once the problem occurs, it cannot be fixed with reprogramming. I have no idea whether he is right, but the post he made includes significant details about the problem. If what happened to me happens again to me or anyone else with this model car, an accident is bound to happen and likely be bad.
NHTSA complaint #11703259 — an unverified report by a vehicle owner.
During my ownership, the vehicle experienced multiple dangerous failures. It suddenly lost power while driving with my 2‑year‑old child onboard, and on another occasion the steering wheel locked for several seconds on the freeway. The car has had numerous recalls, and the dealer later confirmed an EV motor failure but offered no buyback. These defects created serious safety risks and caused significant financial loss, which I believe requires NHTSA’s attention.
NHTSA complaint #11697761 — an unverified report by a vehicle owner.
About a month ago while driving at low speed (about 25mph), the car started to shake and the following error was displayed - Engine Control Error - Park Vehicle in a Safe Place. I pulled over, shut the car down, waited 30 seconds and restarted it. The same incident happened a week later. Because again I was driving at low speed, I was able to pull over and shut down/restart the car. This incident scared me, because the car was shutting down while driving. If I was driving at high speed, I could be in serious trouble. I contacted Porsche dealership, setup an appointment and brought the car in. I was told that this issue was caused by cooling fans failure and the issue was addressed. I picked up the car a week ago. Since then, I had the same issue happened twice, including tonight. I started looking online for similar issues and found out on Reddit that this is a common issue in 2021 Taycan. It also looks like Porsche doesn't have a fix for this dangerous issue. The car just shuts down in mid drive. So far I've been lucky enough to drive slow on two lane roads, so I was able to pull over. What will happen if car shuts down on the highway, while driving 60mph? Since this looks to be a common occurrence, I believe Porsche should be notified and take ownership of this issue.
NHTSA complaint #11696887 — an unverified report by a vehicle owner.
Engine control error - Park vehicle in a safe space. This error occurred after pressing the accelerator pedal upon switching from Normal to Sport Plus drive mode. When coming to a stop, I tried to accelerate the car but it would jerk. I stopped, put my emergency signal on, turned off and on the car and the error went away.
NHTSA complaint #11684210 — an unverified report by a vehicle owner.
Driving at 45 MPH, and suddenly the car lost the ability to accelerate. It has no power/torque. It seemed to be able to maintain the speed (but not entirely sure or if it was coasting). I had limited areas on the road to turn so took last possible turn to pull over. A shutdown/start corrected the situation. No warning lights or indicators of any kind appeared. Cannot reproduce, which makes this situation more frightening. No other symptoms or warnings before.
NHTSA complaint #11681315 — an unverified report by a vehicle owner.
On April 23, 2024, while decelerating gently at a traffic light, I heard a loud “thump” sound from the rear of my 2021 Porsche Taycan. Immediately, the vehicle lost access to the Reverse (R) and Park (P) gears. I was able to slowly coast into a nearby parking lot, but then all gear positions (Drive, Reverse, Neutral, Park) became completely unresponsive. The vehicle was immobilized and had to be towed. At the time of failure, the vehicle had just under 45,000 miles and had received routine maintenance and a recall inspection at a Porsche Center in March 2024. The factory warranty expired only one day earlier, on April 22. Porsche is refusing to cover repairs or provide a loaner vehicle, even though the failure clearly occurred at extremely low mileage and immediately after warranty expiration. The failure pattern matches the symptoms described in TSB #2209 (NHTSA ID: 10210797) for the 2022 Taycan, which identifies a known defect where the vehicle unexpectedly shifts from D or R into N or P without driver input. While my vehicle is a 2021 model, the behavior is nearly identical — sudden loss of drivability, unexpected gear disengagement, and major safety risk in traffic. This incident could have resulted in a serious accident had it happened in moving traffic. I am submitting this complaint in hopes that NHTSA will investigate whether this known transmission defect also affects 2021 Taycan models, and to ensure Porsche takes responsibility for latent safety defects, regardless of narrowly expired warranty status.
NHTSA complaint #11658019 — an unverified report by a vehicle owner.
I am writing to bring to your urgent attention a recurring and serious issue with my Porsche Taycan (VIN: [XXX] ). On multiple occasions while driving, the vehicle has suddenly lost all power and displayed the error message: "Engine control error. Stop the car in a safe place." When this occurs, the car becomes completely unresponsive and unable to move forward, posing a significant safety risk, especially when it happens in traffic. I am forced to stop, switch off the vehicle, wait for a couple of minutes, and restart it. The error message disappears after restarting, but the issue continues to recur. This has now happened three times in the past two months. I first brought the vehicle to the dealer after the initial incident, and they recommended a software update. However, after the issue reoccurred and I returned to the dealership, they were unable to retrieve any error codes. Despite these efforts, the problem persists. Given the severity of the issue and the risk it poses while driving, I am requesting immediate assistance and a thorough investigation into the root cause of this malfunction. This is not only a mechanical concern but a serious safety issue that requires urgent attention. Please let me know the next steps to have this addressed properly and whether a formal case can be opened for further diagnostics and resolution. Thank you for your prompt attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11657314 — an unverified report by a vehicle owner.
I received a recall notice that my vehicle was affected for a battery cell that needed to be replaced and scheduled a date with Porsche and when I finally took the car in they said it’s not a active recall which seemed odd
NHTSA complaint #11640258 — an unverified report by a vehicle owner.
I bought this car a few weeks ago and drove only 300 miles so far. I was pulling out of my neighborhood onto the Main Street, when I turned then started to accelerate I received an error saying engine control error and my car came to a screeching halt. The accelerator stopped working and the car made some loud grinding noises and no functions were working.luckily nobody was behind me. I turned off the vehicle and when I powered it back on everything is working as normal. This vehicle was just serviced at Porsche a few days ago before the event
NHTSA complaint #11628131 — an unverified report by a vehicle owner.
Sudden power electrical failure while driving on a city avenue. The car suddenly had no power, the engine goes off, the sterring become very stiff and there was a message saying electrical system error
NHTSA complaint #11624450 — an unverified report by a vehicle owner.