2001 Saturn LS engine problems

ENGINE

Recall bulletin #06074a ,timing chain engine stall. I called gm,and gm arbitration and they said I have no recallcs. This car only has 28,700 miles on it!! My Vin fits the criteria of the recall,and I went to the dealership and they confirmed it,but GM does not acknowledge it! page 4, dealer recall responsibility-all. 2nd paragraph Dealers are to service All vehicals subject to this recall, regardless of milage,age of vehical,vehicle, ownership as of Jan ,2008. I'm the 2nd owner,and there is no documentation that this recall was preformed, 2 others were repaired. I have the car fax for this vehicle. My repair shop said it will cost @ $ 1000.00 to repair it. I'd be happy with a repair or a restoration check from Gm. I started a "Gm service request claim" # 9-7361453168. They never called me back,they canceled/ closed the request and did not approve the recall!! I'm at a loss at what to do at this point.Any help would be appreciated! Thankyou,Charlie

NHTSA complaint #11454788 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

WELL FIRST MY ENGINE CONTROL MONITOR IS SENDING A BUNCH OF RANDOM OFF CODES FROM MA'S AIR SENSOR VOL LOW TO CRANKSHAFT SENSOR VOLUME LOW TO O2 SENSORS TO TRANSMISSION CODES, MY SIDE AIRBAG ON DRIVER SIDE BLUE UP OUT OF NO WERE MY KEY FOB STOPPED READING AND NOW MY CAR WON'T START I KNOW ALL OF A SUDDEN IT'S SENDING OFF CODES FOR CAMSHAFT SENSOR AND O2 SENSORS I BELIEVE THERE SHOULD BE A RECALL ON THE ECM IT'S A VERY EXPENSIVE REPLACEMENT THAT SEEMS TO BE A COMMON FAILURE IT'S DANGERS AND DEFECTIVE.MY CAR LOCKED UP IN MIDDLE OF I BUSY INTERSECTION DO TO THESE CODES AND LOW VOLTAGE READINGS MY NAME IS [XXX] I LIVE AT [XXX] MY #[XXX] ACCIDENT DATE 10/17/2017 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #11035138 — an unverified report by a vehicle owner.

ENGINE

IGNITION PROBLEMS WITH ONLY 88,000 MILESDOES MY CAR FIT THE GM RECALL.

NHTSA complaint #10909580 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 SATURN LS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 20 MPH, THE AIR BAG AND THE ENGINE WARNING INDICATORS ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE AIR BAG WAS REMOVED AND NOT REPLACED WITH ANOTHER. THE CONTACT WAS UNCERTAIN OF THE LOCATION OF THE AIR BAG THAT WAS REMOVED. THE FAILURE PERSISTED AFTER THE REPAIR. IN ADDITION, THE ENGINE OIL LEAKED ONTO THE GROUND. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,726. UPDATED 09/08/16*LJ

NHTSA complaint #10873833 — an unverified report by a vehicle owner.

ENGINE

DRIVING DOWN IN CONGESTED MORNING TRAFFIC ON HIGHWAY WHEN ENGINE SHUT OFF. WITH ENGINE OFF, BRAKES HARD TO PUSH AND STEERING VERY DIFFICULT. VEHICLE COASTED TO STOP. ENGINE WOULD NOT RESTART. IT JUST TURNED OVER. SHOP SAID TIMING CHAIN SNAPPED AND ENGINE HAD TO BE REPLACED.

NHTSA complaint #10860136 — an unverified report by a vehicle owner.

ENGINE

VEHICLE STALLED WHILE DRIVING AND WOULD NOT TURN BACK OVER. FOUND OUT LATER IT WAS TIMING CHAIN FAILURE. THE VEHICLE WAS TRAVELING AT HIGHWAY SPEED IN SOURT CAROLINA.

NHTSA complaint #10840050 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 SATURN LS. WHEN THE VEHICLE WAS STARTED, IT IMMEDIATELY STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V519000 (ENGINE) THE MANUFACTURER WAS NOTIFIED OF FAILURE. THE FAILURE MILEAGE WAS 62,000.

NHTSA complaint #10766360 — an unverified report by a vehicle owner.

ENGINE

CAR IS 2001 SATURN L200 WITH LESS THAN 100,000 MILES AND THE TIMING CHAIN BROKE AS THE CAR WAS PULLING INTO THE DRIVEWAY. MY VIN IS NOT COVERED BY THE TIMING CHAIN RECALL ISSUED BY GM, SO I NOW HAVE A COMPLETELY UNUSABLE CAR WHICH IS RATED IN GOOD CONDITION OTHER THAN THE TIMING CHAIN UNLESS I WANT TO SPEND THE 1000 PLUS TO FIX IT. GM/NHTSA ISSUED RECALL NUMBER 07V519000 FOR OTHER SIMILAR SATURNS IN YEAR AND MODEL FOR THE TIMING CHAIN, WHY NOT ALL OF THEM IN THE SAME YEARS? AFTER SPEAKING WITH GM AND RESEARCHING THE PART NUMBER, MY CHAIN WAS BUILT IN THE SAME WILMINGTON DELAWARE PLANT WITH THE MANUFACTURE DEFAULT DIAGNOSIS AS THE OTHER RECALLED TIMING CHAINS BELONGING TO OTHER 2001, 2002, 2003 SATURN L SERIES CARS. THIS NEEDS TO BE A COVERED RECALL FOR THIS CAR AS WELL AS THERE IS OBVIOUSLY AN ISSUE WITH THESE CHAINS BREAKING IN THE CARS- THANK GOODNESS I WAS ONLY PULLING INTO THE DRIVEWAY WHEN IT BROKE RATHER THAN DRIVING IN HEAVY TRAFFIC ON THE ROAD. MAKE THIS RIGHT GM- AND COVER THIS REPAIR FOR THIS CAR.

NHTSA complaint #10734985 — an unverified report by a vehicle owner.

ENGINE

WHILE DRIVING MY CARS IDLE DROPPED AND STALKED MY CAR IN THE MIDDLE OF A TURN. I GOT IT RESTSRTED AND MADE IT HOME. THE NEXT DAY DRIVING OUT OF TOWN WITH INFANT IN THE BACK IT STALLED AGAIN. THIS TIME LEAVING US STRANDED IN A INTERSECTION. KIND PEOPLE PUSHED US OFF THE BUSY ROADWAY I HAD TO HAVE IT TOWED MY HUSBAND DISCOVERED IT WAS MY IAC VALVE. TO REPLACE THIS ITS OVER 150 DOLLARS IT CONTINUES TO LEAVE ME STRANDED WHEN I TURN AND WHEN IM IN A INTERSECTION! MY INTERIOR ON MY DRIVERS SEAT HAS SUNK TO BELOW THE METAL SEAT FRAME I HAVE TO SIT ON PILLOWS TO SEE PROPERLY!

NHTSA complaint #10725219 — an unverified report by a vehicle owner.

ENGINE

REPLACED WATER PUMP, TIMING CHAIN AND PULLEYS AT APPROXIMATELY 90K MILES. APP. 10K MILES LATER, TIMING CHAIN BROKE AND HAD TO BE REPLACED AGAIN. MULTIPLE ISSUES WITH SUSPENSION, FUEL SENSORS, OIL FILTER CASING.

NHTSA complaint #10721624 — an unverified report by a vehicle owner.

ENGINE

WE DROVE THE CAR TO EAT. WHEN WE CAME BACK OUT THE CAR WOULD NOT START. WE HAD IT TOWED TO THE MECHANIC AND HE TOLD US THE TIMING CHAIN JUMPED A COUPLE OF TEETH. IT ALSO BENT SOME OR ALL THE VALUES. THE SAME MAKES AND MODELS HAVE HAD RECALLS FOR THIS ISSUE. OUR CAR WAS NOT UNDER RECALL FOR SOME REASON. WHAT IF I WAS DRIVING 70 MPH AND THIS HAPPENED WE COULD OF BEEN IN A HUGE WRECK.

NHTSA complaint #10704804 — an unverified report by a vehicle owner.

ENGINE

GOOD AFTERNOON, I AM A THE ORIGINAL SATURN OWNER WHO NEVER RECEIVED RECALL INFORMATION REGARDING MY 2001 SATURN L SERIES. I HAVE EXPERIENCED VARIOUS PROBLEMS THAT DIRECTLY CORRELATE TO THE RECALL LISTED BELOW: RECALL 07V519000-PERTAINING TO ENGINE AND ENGINE COOLING POTENTIAL NUMBER OF UNITS AFFECTED: 20,514 SUMMARY: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.2L 4-CYLINDER ENGINE, LINKS IN THE ENGINE'S TIMING CHAIN CAN SEPARATE. CONSEQUENCE: IF A TIMING CHAIN LINK SEPARATES WHILE THE ENGINE IS RUNNING, THE ENGINE WILL STALL AND WILL NOT RESTART INCREASING THE RISK OF A CRASH. REMEDY: DEALERS WILL REPLACE THE TIMING CHAIN FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 15, 2008. OWNERS MAY CONTACT SATURN AT 1-800-972-8876. THE RECALL LISTED ABOVE HAS EFFECTED OUR VEHICLE ON TWO DIFFERENT OCCASIONS; THE FIRST OF WHICH WAS FIXED OUT OF OUR OWN POCKET FOR $4,614.29 ON 9/18/12. I HAVE RECEIPTS TO PROVE THESE REPAIRS. ALSO, THIS RECALL EFFECTED OUR VEHICLE A SECOND TIME ON 12/4/2014. UNFORTUNATELY, DUE TO OUR CURRENT CIRCUMSTANCES WE ARE UNABLE TO FIX THIS VEHICLE OUT OF OUR OWN POCKET AGAIN. WE LOVE THIS CAR, AND HOPE YOU CAN BE OF ASSISTANCE. THANK YOU IN ADVANCE.

NHTSA complaint #10669411 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 SATURN LS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, A BANGING NOISE EMITTED FROM THE ENGINE BEFORE THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND EXAMINED BY AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TIMING CHAIN HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V519000 (ENGINE). THE FAILURE MILEAGE WAS 170,000.

NHTSA complaint #10653929 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TIMING CHAIN BROKEN, STALLED WHILE DRIVING.

NHTSA complaint #10651419 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 SATURN LS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE VEHICLE OVERHEATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 178,000.

NHTSA complaint #10616235 — an unverified report by a vehicle owner.

ENGINE

JUNE 20, 2014 STARTED ENGINE ON MY 2001 L200 SATURN THEN BACKED IT UP 20FT AND SHUT ENGINE OFF. ALL ATTEMPTS TO RESTART ENGINE FAILED. HAD IT TOWED TO A MECHANIC WHO DIAGNOSED A BROKEN TIMING CHAIN. MECHANIC RECOMMENDED REPLACE ENGINE AT A COST OF $2600.

NHTSA complaint #10609618 — an unverified report by a vehicle owner.

ENGINE

I RECENTLY PURCHASED A 2001 SATURN L-200 SERIES WITH ONLY 75K ORIGINAL MILES. BEST RUNNING VEHICLE I HAD COME ACROSS IN ALONG TIME. I HAD THE CAR A LITTLE UNDER A YEAR AND THE TIMING CHAIN STRETCHED AT 78K. THIS WAS A HORRIFIC INCIDENT BEING THAT I HAD MY CHILDREN IN THE CAR WHEN IT STALLED IN THE MIDDLE OF THE ROAD AND WOULD NOT RESTART. I FOUND OUT THAT THERE WAS A RECALL ON MY SPECIFIC VEHICLE BUT NOT MY VIN AND SATURN WOULD NOT COVER THE EXPENSES. IT WAS CRAZY THAT SATURN WOULD SEND OUT A RECALL ON THE WHOLE SATURN L- SERIES BUT ONLY REPAIR CERTAIN VEHICLES IN THE SERIES BASED ON VIN'S.

NHTSA complaint #10606989 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

I HAVE 2 CHILDREN AND IM A PART TIME SINGLE MOM. I LOVE MY CAR. NEVER HAD ANY PROBLEMS. ONE DAY AFTER WORK. IT SIMPLY WOULDN'T START. THE TIMING CHAIN DEFAULTED ON ME. NOW I AM CAR LESS AND IN DANGER OF LOSING EMPLOYMENT. I HAVE RECENTLY DISCOVERED THAT THERE HAD BEEN A PREVIOUS RECALL ON THIS SPECIFIC VEHICLE AND PART. HOWEVER THERE'S NOTHING I CAN DO. HAD I KNOWN THIS I WOULD HAVE NEVER PURCHASED THE VEHICLE.

NHTSA complaint #10586789 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

WHILE DRIVING HOME MY CAR JUST STOPPED IN THE MIDDLE OF THE ROAD. I HAD NO IDEA WHAT HAPPENED OR WHAT WAS WRONG, IT JUST STOPPED WITH NO WARNING, RIGHT BEFORE IT STOPPED IT MADE A NOISE UNFAMILIAR TO ME BUT IT SOUNDED AS IF THE BRAKES HAD FALLEN OFF OR SOMETHING. I HAD TO GET MY CAR TOWED AT MY OWN COST. I FOUND A MECHANIC THAT WOULD COME OUT AND TAKE A LOOK AT IT BECAUSE I HAD IT TOWED TO MY HOUSE. APPARENTLY MY TIMING CHAIN WAS TO LOOSE AND KEPT HITTING SOMETHING ELSE AND OVER TIME THE CHAIN BROKE AND WHAT IT WAS HITTING WAS DAMAGED SO I HAD TO REPLACE BOTH AND BECAUSE THE ENGINE HAD TO BE DROPPED TO GET TO REPLACE, IT COST ME $1800.00 OUT MY POCKET ALSO THEY INFORMED ME THAT THE RACK AND PINION WILL HAVE TO BE DONE ALSO. IF THIS IS A RECALL ISSUE I WOULD LIKE TO BE REIMBURSED FOR THE COST. THANKS.

NHTSA complaint #10578865 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 SATURN LS200. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 132,000.

NHTSA complaint #10578601 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 SATURN L100. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE JERKED AND THEN STALLED. THE VEHICLE DID NOT RESTART. THE VEHICLE WAS TOWED TO THE CONTACTS HOUSE WHERE AN INDEPENDENT MECHANIC DIAGNOSED THAT THE TIMING CHAIN, HEAD AND VALVE NEEDED TO BE REPLACED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,183.

NHTSA complaint #10568609 — an unverified report by a vehicle owner.

ENGINE

ENGINE STARTED WITH RATTLING SOUND, ENGINE WAS SHUT OFF. ATTEMPTED TO RESTART ENGINE, WOULD CRANK BUT NOT FIRE.

NHTSA complaint #10567520 — an unverified report by a vehicle owner.

ENGINE

I WAS DRIVING THE VEHICLE DOWN THE FREEWAY AT 65 MPH WHEN THE BATTERY LIGHT CAME ON AND SHUT OFF. WITHIN THE NEXT MINUTE THE COOLANT LIGHT CAME ON AND SHUT OFF AND THEN THE CAR SEIZED RIGHT THERE ON THE FREEWAY. THE CAR WOULD NOT START SO WE HAD TO HAVE IT TOWED. ONCE THE SHOP LOOKED AT IT THEY DIAGNOSED THAT THE TENSIONER HAD BROKE AND THE SERPENTINE BELT HAD MELTED. WE ARE NOW LOOKING AT HAVING TO REPLACE THE ENTIRE ENGINE.

NHTSA complaint #10564422 — an unverified report by a vehicle owner.

ENGINE

UPON STARTING THE VEHICLE THE ENGINE STOPPED AND WAS UNABLE TO BE RESTARTED DUE TO BROKEN TIMING CHAIN WHICH BENT THE VALVES IN THE ENGINE.

NHTSA complaint #10552543 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

VEHICLE WAS COVERED BY SATURN RECALL 07V519000, ENTIRE VALVE ASSEMBLY AND TIMING CHAIN REPLACED BY GM SHOP AT APPROXIMATELY 45,000 MILES AFTER TIMING CHAIN FAILURE WITH BENT VALVES, FAILURE ALSO WAS AT EXPRESSWAY SPEED OF 55 MPH. SAME TYPE OF FAILURE AGAIN OCCURRED ON HIGHWAY AT SPEED OF APPROXIMATELY 65 MPH. VEHICLE WAS TOWED TO INDEPENDENT REPAIR SHOP WHO STATED PROBLEM WAS VALVE FAILURE. TOTAL VEHICLE MILEAGE IS APPROXIMATELY 95,000 MILES.

NHTSA complaint #10549641 — an unverified report by a vehicle owner.

ENGINE

VEHICLE WAS COVERED BY SATURN RECALL 07V519000, ENTIRE VALVE ASSEMBLY AND TIMING CHAIN REPLACED BY GM SHOP AT APPROXIMATELY 45,000 MILES AFTER TIMING CHAIN FAILURE WITH BENT VALVES, FAILURE ALSO WAS AT EXPRESSWAY SPEED OF 55 MPH. SAME TYPE OF FAILURE AGAIN OCCURRED ON HIGHWAY AT SPEED OF APPROXIMATELY 65 MPH. VEHICLE WAS TOWED TO INDEPENDENT REPAIR SHOP WHO STATED PROBLEM WAS VALVE FAILURE. TOTAL VEHICLE MILEAGE IS APPROXIMATELY 95,000 MILES.

NHTSA complaint #10549641 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 SATURN L SERIES. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE CONTACT WAS INFORMED THAT THE TIMING CHAIN WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 127,000.

NHTSA complaint #10545331 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 SATURN LS. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE DECELERATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THE TIMING TENSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE 95,402.

NHTSA complaint #10520748 — an unverified report by a vehicle owner.

ENGINE

I WAS DRIVING MY CAR (2001 SATURN L200) GOING APPROXIMATELY 5 MPH WHEN THE ENGINE OF MY CAR STALLED AND COULD NOT BE RESTARTED. AFTER HAVING THE CAR TOWED TO A DEALERSHIP IT WAS DETERMINED THAT THE TIMING CHAIN FAILED CAUSING CATASTROPHIC DAMAGE TO MY ENGINE.

NHTSA complaint #10520193 — an unverified report by a vehicle owner.