2006 Subaru Forester engine problems

ENGINE

Five years ago my "check engine" light came on and the cruise control light came on and it would not work. I took it to Suberu in Fort Worth and they couldn't find the problem bu tsaid my gas cap was not sealing. God new one but didn't help. This year when I went to get it checked for regisration they woudn't pass it. Took it to mechanic who installeda new Evaprotive Vapor Canister for $920. That didn't work but wouldn't try again. Later another mecanic said the problem was "Not enough driving". (less that 100 miles a month. I have been driving the car with the check engine on an no cruise control for 6-7 years with no trouble, so it is a fault of the car's systems. I can't get it registered because of this problem. I can disconnedt the negative battery post briefly and the light goes off for a day or two. So what can you do for me? I love the car but hate the problem. I am 90, but that's not the problem.

NHTSA complaint #11431652 — an unverified report by a vehicle owner.

ENGINE

As I was going down the road my car sped up and my foot was off the gas pedal as the pedal was stuck-I managed to stop my car but not before it reached 75 mph in a 50 I was originally going 50

NHTSA complaint #11431144 — an unverified report by a vehicle owner.

ENGINE

UPON START UP IN COLD WEATHER THERE IS A VERY STRONG SMELL OF FUEL INSIDE THE CABIN OF THE CAR. IT MADE MYSELF AND MY DAUGHTER FEEL VERY ILL. HAD TO EXIT MY 2006 SUBARU FORESTER XT. INSPECTED ENGINE UNDER THE HOOD TO FIND LEAKING FUEL LINES. GOOGLED THE PROBLEM TO DISCOVER IT IS REACURRENT WITH THIS MAKE/MODEL/YEAR AS EVIDENT BY SIMILAR COMPLAINTS IN SUBARU FORUMS, GOOGLE SEARCH, AND FB PAGES. THIS IS A DANGER TO HEALTH AND SAFETY AND SHOULD BE RECALLED. VEHICLE IS UNDER 100,000 MILES. LEAKING FUEL DRIPS DIRECTLY ONTO THE ENGINE CYLINDER AND CLOSE PROXIMITY TO THE TURBOCHARGER ON THE PASSENGER SIDE. THERE IS SIGNIFICANT RISK OF ENGINE FIRE! HEALTH AND SAFETY RISK ALSO FROM THE FUEL FUMES IN THE ENGINE CABIN. SUBARU DEALERSHIP QUOTED $1,300. TO FIX.

NHTSA complaint #10936146 — an unverified report by a vehicle owner.

ENGINE

PURCHASED IN AK IN 2006. APPROXIMATELY 13,000 MILES ON ENGINE. PAPERWORK LISTED ENTRY-POINT: HAWAII. CURRENT 2016 MILEAGE: LESS THAN 60,000. WELL-MAINTAINED VEHICLE. --- IN COLD WEATHER, DESPITE BEING GARAGED, INTERMITTENT STRONG SMELL OF FUEL IN GARAGE AND UPON START-UP. SOMETIMES THE ODOR IS PRESENT BEFORE STARTUP. OTHER TIMES ODOR NOT PRESENT UNTIL ENGINE STARTS. GOES AWAY WHEN ENGINE WARMS. USED TO BE IN ONLY VERY COLD WEATHER, THEN IN 2015 IT HAPPENED IN COLD BUT NOT AS COLD WEATHER. RECENTLY, IN 2016, IT HAPPENED IN GARAGE IN WARM WEATHER STATE, SO COLD WEATHER NO LONGER NECESSARY VARIABLE. AGAIN, IT IS INTERMITTENT. THIS ISSUE FIRST BECAME NOTICEABLE IN WINTER OF 2014.

NHTSA complaint #10863822 — an unverified report by a vehicle owner.

ENGINE

PURCHASED IN AK IN 2006. APPROXIMATELY 13,000 MILES ON ENGINE. PAPERWORK LISTED ENTRY-POINT: HAWAII. CURRENT 2016 MILEAGE: LESS THAN 60,000. WELL-MAINTAINED VEHICLE.----- UPON ACCELERATION, THE ENGINE SOMETIMES LURCHES AND REVS TOO HIGH TOO FAST, AND THEN SETTLES INTO HOW IT IS SUPPOSED TO FEEL AND SOUND. OTHER TIMES, IT SUDDENLY LOSES POWER INSTEAD, LURCHING DOWN LIKE WE'VE TAKEN OUR FOOT OFF THE GAS (BUT WE HAVEN'T BECAUSE WE ARE ON A HIGHWAY OR FREEWAY!), VERY BRIEFLY AND THEN RECOVERS.ONE TIME, JUST A FEW WEEKS AGO, IT FELT LIKE I'D LOST ALL POWER AND THE CAR WAS GOING TO STOP IN THE MIDDLE OF THE BUSY HIGHWAY, BUT IT IMMEDIATELY RECOVERED AND THEN FELT NORMAL.

NHTSA complaint #10863825 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

WHEN THE TEMP GETS INTO THE TEENS OR LOWER GAS LEAKS IN AND AROUND THE ENGINE. THIS IS DANGEROUS!! I HAVE FOUND FUEL NEAR AREA THAT GET VERY HOT, AND I AM WORRIED ABOUT MY FAMILY STARTING ON FIRE. SOA RECALLED A FEW YEARS TO REPAIR THIS ISSUE, BUT NOT ALL THAT ARE AFFECTED.

NHTSA complaint #10684241 — an unverified report by a vehicle owner.

ENGINE

I TOOK MY CAR IN BASED ON A RECALL SENT BY MY DEALERSHIP FOR MY 2006 SUBARU FORESTER LL BEAN MODEL ORIGINAL OWNER. THEY COMPLETED TO SERVICE RECALLS ON MY VEHICLE NONE OF WHICH ARE LISTED ON THIS WEBSITE.WVL22 AND WVU31. THE WVU31 WAS TO REPROGRAM MY ECM. AS I WAS DRIVING HOME AFTERWARDS THE CHECK ENGINE LIGHT IMMEDIATELY CAME ON AND MY CRUISE LIGHT BEGAN TO FLASH. I CALLED THE DEALER IMMEDIATELY WHO ADVISED IT WAS SAFE TO DRIVE IF THE CHECK ENGINE LIGHT WAS SOLID AND NOT FLASHING WHICH IT WAS. HE DENIED IT COULD BE RELATED TO THE WVU31 REPROGRAM OF THE ECM BUT I ADVISED THAT MY VEHICLE WAS FINE NOT DUE FOR ANY SERVICE AND HAD NO ISSUES PRIOR TO BRINGING TO THE DEALERSHIP FOR THE REPROGRAM. I NOW HAVE TO RETURN THE CAR TO THE DEALERSHIP AND THEY SAID ONLY "IF THE CHECK ENGINE LIGHT IS RELATED TO THE RECALL" WOULD THEY FIX IT. I BELIEVE THIS IS DEFINITELY CAUSED BY THE REPROGRAM OF THE ECM AND THERE ARE A MULTITUDE OF COMPLAINTS ON A WEBSITE REGARDING MANY PEOPLE COMPLAINING THAT WITHIN MILES OF DRIVING AFTER THE WVU31 REPROGRAM FIX THAT THE SAME THING HAPPENED AND THEY WERE ALL TOLD THAT THEY HAD TO FIX SOMETHING OR REPAIR SOMETHING AT A COST. THIS IS UNCONCEIVABLE AS I NOW HAVE TO RETURN TO A DEALERSHIP THAT IS OUT OF MY WAY, MISS WORK AND RETURN THE VEHICLE AND ONLY HOPE THAT THEY DO NOT CLAIM IT IS ANOTHER PROBLEM. IF THEY DO THEN I AM STUCK WITH ANOTHER REPAIR. I BELIEVE THAT THIS WVU 31 REPROGRAM IS DEFECTIVE AND IS CAUSING ISSUES THAT ARE LEADING TO ADDITIONAL AND UNNECESSARY REPAIRS. MY CAR WAS JUST FINE AND BELIEVE HAD I DONE NOTHING AS I AM PLANNING TO BUY A NEW CAR THIS YEAR IT WOULD HAVE BEEN FINE. BUT I TRIED TO DO THE RIGHT THING AND TAKE IT IN FOR SERVICE DUE TO THE RECALL NOTICE. I BELIEVE THIS IS TOTALLY ERROR PRONE.

NHTSA complaint #10660712 — an unverified report by a vehicle owner.

ENGINE

WHEN I TOOK MY CAR IN FOR IT'S 90000 MILE SERVICE, I WAS SHOWN THAT THERE WAS OIL LEAKING FOR THE DRIVERS SIDE HEAD GASKET. I WAS INFORMED THAT THIS IS A COMMON PROBLEM FOR SUBARU FORESTERS FROM THE LATE 1990S THRU 2009. APPEARS TO BE A FAULTY DESIGN, WHICH SUBARU HAS NOT OWNED UP TO. MY ONLINE SEARCH LOCATED A LARGE NUMBER OF COMPLAINTS BY SUBARU FORESTER OWNERS ON THIS DESIGN FLAW.

NHTSA complaint #10462745 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

HEAD GASKET LEAKING OIL CONFIRMED BY DEALER IN SEPTEMBER 2011.

NHTSA complaint #10428463 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

VEHICLE WAS REPAIRED SEVERAL MONTHS AGO PURSUANT TO A SAFETY RECALL INVOLVING THE FUEL FILTER. AS A RESULT, THE CATALYTIC CONVERTERS WERE DAMAGED AND REQUIRED REPLACEMENT, CONDUCTED AS PART OF THE RECALL. RECENTLY, THE VEHICLE UNEXPECTEDLY OVERHEATED AND CAUSED SIGNIFICANT DAMAGE TO THE ENGINE, WITHOUT ANY CHECK ENGINE SENSOR OR OTHER INDICATOR SIGNIFYING SUCH A PROBLEM.

NHTSA complaint #10343081 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

HEAD GASKET LEAKING OIL AGAIN (5000MILES LATER) AFTER BEING REPAIRED BY SUBARU DEALER WHILE CAR WAS UNDER WARRANTY. CAN SMELL HOT OIL AFTER A LONG DRIVE ON FREEWAY AND HAVE SEEN WISPS OF SMOKE COMING FROM UNDER HOOD. THERE IS THE POTENTIAL FOR AN UNDERHOOD OIL FIRE IF LEAK GETS WORSE.

NHTSA complaint #10314406 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

ENGINE LIGHT, FAILURE OF CRUISE CONTROL. DEALER REPLACED AIR PUMP (PART #14828AA030) AND ENGINE CONTROL MODULATOR. DEALER DISCOUNT 50% "GOODWILL." PART WAS 4,611 OUT OF WARRANTY. ONE WEEK LATER SAME PROBLEM RETURNED, DEALER STATES CAR NEEDS OXYGEN VALVES AND THERE IS A NATIONAL BACK ORDER ON PARTS. SUBARU IS OFFERING THE PARTS FOR FREE (INDICATING THERE IS A KNOWN PROBLEM) BUT WANTS TO CHARGE LABOR ~$500. PARTS MAY BE UNAVAILABLE FOR SEVERAL WEEKS. FIRST SERVICE FAILED TO PROPERLY DIAGNOSE PROBLEM.

NHTSA complaint #10273692 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

I HAVE A HESITATION WHEN ACCELERATING FROM A STOP CAUSED BY MY VEHICLE'S DRIVE BY WIRE THROTTLE BODY. THIS HESITATION IS ONGOING DESPITE AN ECM REPROGRAMMING DONE BY THE DEALER ON 12/16/08. IT IS BAD ENOUGH THAT I'M AFRAID I'M GOING TO GET INTO A COLLISION SOMETIME.

NHTSA complaint #10252993 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

HEAD GASKET LEAK ON THE DRIVER'S SIDE CYLINDER HEAD OF A 2006 SUBARU FORESTER X. MOM'S CAR (ALSO A 2006 SUBARU FORESTER X) HAS IDENTICAL HEAD GASKET LEAK BUT ON THE PASSENGER'S SIDE CYLINDER HEAD. THERE IS THE POSSIBILITY OF OIL DRIPPING ON THE HOT EXHAUST MANIFOLD. MY CAR HAS HAD THE HEAD GASKETS REPLACED UNDER WARRANTY. HER CAR IS YET TO BE REPAIRED.

NHTSA complaint #10252931 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL*THE CONTACT OWNS A 2006 SUBARU FORESTER. THE AIR BAG CONTROL MODULE FAILS TO ACTIVATE AT LEAST ONCE PER WEEK. ON EACH OCCASION, THE PASSENGER SIDE AIR BAG OFF LIGHT ILLUMINATES. THE OCCUPANT DETECTION SENSOR DOES NOT RECOGNIZE A PASSENGER SITTING IN THE FRONT PASSENGER SEAT. THE PASSENGER SIDE AIR BAG ALSO DOES NOT ACTIVATE WHEN THE VEHICLE IS STARTED APPROXIMATELY ONCE OUT OF 20-30 STARTS. THE CONTACT'S WIFE WEIGHS 120 LBS AND IS 5'5 INCHES TALL. SHE SITS ERECTLY WITH THE SEAT BACK NEARLY VERTICAL. THE FAILURES HAVE BEEN REPORTED AND INVESTIGATED BY THE DEALER AND MANUFACTURER. THE MANUFACTURER STATED THAT THE "OCCUPANT PROTECTION SYSTEM IS WORKING AS ITS DESIGNED INTENT AND AS SUCH WE ARE UNABLE TO RECOMMEND A REPAIR OR MODIFICATION". THE CURRENT MILEAGE WAS 28,000 AND FAILURE MILEAGE WAS 13,421. UPDATED 01/03/08 *BF OIL WAS LEAKING ONTO THE EXHAUST SYSTEM, THE ENGINE WOULD SURGE AND SAG DURING SLIGHT DOWNGRADES WITH THE THROTTLE HELD JUST OFF IDLE AND SPEED HELD CONSTANT, THE SPEED CONTROL OVER AND UNDER SHOOTS ON SLIGHT GRADES, IT WOULD NOT GO TO FULL THROTTLE, OR TO CLOSED THROTTLE WHEN SPEED CONTROL WAS ACTIVATED. UPDATED

NHTSA complaint #10210649 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

THERE ARE TWO PROBLEMS WITH THE 2006 SUBARU FORESTER THAT I HAVE. IT HAS LESS THAN 5000 MILES ON IT AND CONTINUALLY FAILS TO START, WHETHER FROM A COLD START OR A WARM START. THE ENGINE WILL ATTEMPT TO CRANK BUT WILL NOT CATCH AND ACTUALLY TURN OVER. THIS ISSUE HAS HAPPENED MULTIPLE TIMES. I TOOK THE CAR INTO THE DEALERSHIP AND THEY STATED THAT I HAD TO HOLD THE IGNITION SWITCH IN THE ACC POSITION TO "PRIME THE LINES." I'VE NEVER HEAD OF HAVING TO PRIME A CAR IN THIS DAY AND AGE. HOWEVER, I SINCE HAVE TRIED DOING THAT AND THE ISSUE STILL PERSISTS. ALSO, THE CARE WILL SURGE IN POWER AT VARIOUS SPEEDS. WHEN I LET UP ON THE GAS WHEN TRYING TO SLOW DOWN ,THE CAR WILL ACTUALLY REV UP. THIS HAPPENED IN THE SNOW THE OTHER DAY AND I ALMOST COMPLETELY LOST CONTROL OF THE CAR. IF THAT CAR IS GOING TO SURGE LIKE THIS IT COMPLETELY NEGATES THE PURPOSE OF HAVING ALL WHEEL DRIVE. THIS IS A GRAVE SAFETY CONCERN. I THOUGHT SUBARU'S WERE SUPPOSED TO BE GOOD CARS. I GUESS I THOUGHT WRONG. I'VE TAKEN THE CAR IN FOR THE SURGE ISSUE AND THE DEALERSHIP SAID THERE WAS NOTHING THEY COULD DO AND THAT THERE WERE NO RECALLS FOR THE PROBLEM.

NHTSA complaint #10174190 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

DT*: THE CONTACT STATED WHILE PULLING OUT AT VARIOUS SPEEDS THE VEHICLE HESITATED WITHOUT WARNING. THE HESITATION OCCURRED INTERMITTENTLY EACH TIME. UPON INSPECTION THE DEALERSHIP WAS UNABLE TO REMEDY THE PROBLEM. THE MANUFACTURER WAS NOT ALERTED.

NHTSA complaint #10160189 — an unverified report by a vehicle owner.