67 of the
1,219 complaints filed about the Toyota FJ Cruiser
are about the transmission —
5% of everything owners reported.
The worst model year for it is 2007.
67
Complaints
5%
Share of all complaints
2
Crashes
1
Fires
Transmission & Drivetrain complaints by model year
I purchased my beloved 2013 FJ Cruiser from Wellesley Toyota 6.5 years ago and have really enjoyed it. I have had it serviced religiously at McGee Toyota of Hanover since my purchase and expected to continue to enjoy it for many years to come and was just informed by McGee Toyota that the frame is severly rusted out throughout. My truck only has 158K miles on it and I expected this to last at least twice as long. This appears to be the same issue Toyota experienced with the Tundra and Tacoma with premature rusting on their vehicles due to a manufacturing issue. There are numerous complaints online about this issue and even a current class action lawsuit. I have alerted Toyota Corporate of this and they are not standing behind their product.
NHTSA complaint #11717366 — an unverified report by a vehicle owner.
The fj cruiser is a common issue for rot/ rust on the frame of the vehicle, I have clean the frame often during the winter months and my frame is continuously rusting and rotting the frame of the vehicle I have decided to not drive the vehicle till the frame is either replaced or repaired due to the safety concern of driving it on the road, numerous others have same incidents of the holes in the frame due to rust the manufacturer did not put any kind of corrosion treatment on the frame to stop this from happening the frame flexes when accelerating and is not safe for anyone to including my passengers or other people on the road
NHTSA complaint #11577448 — an unverified report by a vehicle owner.
recently purchased used from dealership. Excessive rust on lower frame and other components (transmission and power steering lines) as well as suspension. This is not a flood vehicle. Initially took it to Toyota for repairs of the lines and trans. The quote was too high, so I took it to local shops for repair. The local shops were surprised by the amount of rust. Trans was fixed but the shops refused to fix other components that attached to the frame because they fear they will cause more damage. Visited several FJ Cruiser forums and frame rust issues are incredibly common with the FJ, to the point where there are class action lawsuits. Toyota needs to step up and fix this issue for FJ owners!
NHTSA complaint #11425444 — an unverified report by a vehicle owner.
FROM ACCELERATION; BETWEEN 30MPH AND 45MPH MY VEHICLE SHUDDERS AND SHAKES. I BELIEVE THE ISSUE IS COMING FROM THE TRANSMISSION AND OR DIFFERENTIAL OF MY VEHICLE.
NHTSA complaint #11395818 — an unverified report by a vehicle owner.
I PURCHASED THE CAR FROM AN INDIVIDUAL ON DEC. 12, 2020. LESS THAN 30 DAYS AGO. I BROUGHT IT TO THE BODY SHOP TO SEE IF THEY COULD FIX THE RATTLING SOUND THAT CAME FROM WHEN I HIT A BUMP. THE CARS BODY IS IN GREAT CONDITION. THE MILEAGE WHEN I BOUGHT THE CAR WAS 183,800. I ASSUMED I MAY NEED TO DO SOME WORK ON THE CAR, BUT THE BODY SHOP TOLD ME THAT THE SOUND I WAS HEARING WAS DIFFERENT PARTS OF THE UNDERCARRIAGE THAT HAD RUSTED SO BADLY THAT THEY WHERE CLOSE TO FALLING OFF. INCLUDING THE GAS TANK. THEY TOLD ME THAT FJ CRUISERS WHERE KNOWN FOR RUSTY UNDER BOTTOMS AND THAT I WOULD BE A SAFETY RISK TO MYSELF AND OTHERS IF I DROVE THE CAR. THEY ALSO SAID THE CAR WAS BEYOND NORMAL REPAIR. I WILL ATTACHED PHOTOS THEY SENT ME. I HAVE DRIVEN THE CAR 1,500 MILES AND IT IS CONSIDERED UNDRIVABLE AND UNFIXABLE. I GOT A SECOND OPINION. WITHOUT KNOWING THE RESULTS OF THE FIRST OPINION THEY CAME TO THE EXACT SAME CONCLUSION. EXCEPT THEY TOLD ME TO REACH OUT TO YOU.
NHTSA complaint #11387313 — an unverified report by a vehicle owner.
SEVERE RUST ISSUES. ENTIRE REAR DIFFERENTIAL REQUIRED REPLACEMENT. ALL POWER STEERING AND AUTOMATIC TRANSMISSION LINES NEEDED REPLACEMENT, FUEL LINES ARE NEXT FUEL TANK STRAPS RUSTED AND BROKE OFF, TANK FELL DOWN. BRAKE PAD PINS REQUIRED CUTTING OFF. PROTECTION PLATES RUSTED OFF. EXHAUST SYSTEM COMPONENTS REQUIRED REPLACEMENT DUE TO RUST. ENTIRE FRAME AND ENGINE COMPARTMENT COVERED IN RUST. ALL THESE ITEMS HAVE CAUSED MULTIPLE SAFETY ISSUES. MULTIPLE STRAPS AND CONNECTIONS FOR VARIOUS COMPONENTS ARE NO LONGER USABLE DUE TO RUST.
NHTSA complaint #11375036 — an unverified report by a vehicle owner.
THERE IS RUST ON THE VEHICLE FRAME THAT IS FAR WORSE THAN REASONABLE FOR A VEHICLE OF THIS AGE. THIS IS A KNOWN PROBLEM WITH THESE VEHICLES FROM THIS TIME AND IS KNOWN TO BE CAUSED BY COMPROMISES THAT TOYOTA MADE IN THE MANUFACTURING PROCESS.
NHTSA complaint #11330423 — an unverified report by a vehicle owner.
REAR DIFFERENTIAL CARRIER IS BAD. THIS IS A KNOWN PROBLEM TO TOYOTA; BAD GEARS IN 2007 MODELS. THEY CORRECTED IT IN 2010 WITH UPGRADED GEARS. THIS SHOULD HAVE BEEN RECALLED BY TOYOTA SINCE THEY WERE AWARE OF THE PROBLEM.MY FJ HAS ONLY 80,000 MILES AND NO REAR END SHOULD GO OUT AT THIS LOW MILEAGE.THE REPAIRS FOR THIS AT TOYOTA SERVICE CENTER IS $4,000.00.
NHTSA complaint #11321139 — an unverified report by a vehicle owner.
WHEN I CRUISE ON A HIGHWAY AROUND 70MPH, MY CAR SUDDENLY LOST POWER. I WAS VERY SCARED BUT TRIED TO MOVE THE CAR TO CURB, THEN THE CAR DIED. ONE MINUTE LATER I TRIED TO RESTART THE CAR BUT FAILED. I CALLED THE ROAD ASSISTANCE SERVICE. WHEN THEY CAME AND POURED IN ONE GALLON GAS IN THE CAR, THEN THE CAR WAS STARTED. THE PROBLEM IS THAT BEFORE THE CAR DIED, THE FUEL INDICATOR POINTER POINTED AT THE A QUARTER POSITION. THE FUEL EMPTY WARNING LIGHT WAS NOT ON.
NHTSA complaint #11316513 — an unverified report by a vehicle owner.
THE FRAME ON MY FJ CRUISER IT LITERATELY ROTTING TO NOTHING. AS ARE MOST PRODUCED FROM 2007 - 2012 I HAVE BEGGED TOYOTA FOR HELP AND A RESOLUTION LIKE WITH THE TUNDRA AND TACOMA FRAME ROTTING ISSUES. THIS IS A MAJOR SAFETY ISSUE AND SOMEONE IS GOING TO GET HURT OR KILLED. MY CONTROL ARE IN ROTTING AWAY FROM THE FRAME. AS YOU CAN SEE IN THE PICTURE THE THIS IS BAD BAD. FJ CRUISER WAS STATIONARY.
NHTSA complaint #11231070 — an unverified report by a vehicle owner.
WENT TO GAS STATION TODAY TO FILL UP MY FJ WITH GAS AND THE FUEL TANK STRAPS BROKE IN 2 PLACES. THE BOLTED AND PINNED CONNECTIONS ARE STILL THERE BUT THE ACTUAL STRAPS HAVE DETERIORATED AND SNAPPED RIGHT IN HALF. THE FUEL TANK IS NOW HANGING DOWN COMPLETELY IN THE REAR. FIRST THE REAR DIFFERENTIAL MANUFACTURER'S DEFECT WHICH THEY WOULD NOT PAY FOR AT ALL, NOW THE FRONT SEAT BELT DOES NOT WORK AT ALL AND NOW THE FUEL TANK IS ABOUT TO FALL OFF ON THE ROAD. WHAT A HAZARD.
NHTSA complaint #11088881 — an unverified report by a vehicle owner.
I HAD TO REPLACE THE DRIVE SHAFT AT 105K MILES. IT WAS WORE OUT INTERNALLY AND MAKING A HUGE JOLT. THERE IS NO REASON A DRIVE SHAFT SHOULD WEAR OUT AT THIS MILEAGE. I HAVE NOT BEEN HAPPY WITH THIS VEHICLE AND HAVE OWNED MANYTOYOTAS. THEY USUALLY HOLD UP BETTER THAN THIS. WHEN BRAKING OR HITTING THE GAS AFTER BEING STOPPED IT WAS A JOLT LIKE YOU HAD BEEN REAR ENDED. I HAVE READ ONLINE THAT A LOT OF DIS ARE HAVING THIS ISSUE. IT SHOULD BE RECALLED
NHTSA complaint #11042900 — an unverified report by a vehicle owner.
WHEN STOPPING AT A RED LIGHT OR STOP SIGN, THE AUTOMATIC TRANSMISSION HAS NOT DOWN SHIFTED TO FIRST GEAR. SO WHILE STOPPED, THE CAR WILL SUDDENLY LUNG FORWARD AS IF HIT FROM BEHIND. THIS IS EXTREMELY DANGEROUS FOR PEDESTRIAN CROSSING IN FRONT OF THE CAR. THERE IS A VERY REAL POTENTIAL FOR THE CAR TO HIT A PERSON WHEN IT LUNGES FORWARD. SINCE REALIZING THIS PROBLEM, I INTENTIONALLY HOLD DOWN THE BRAKE HARDER THAN I SHOULD HAVE TOO. THERE ARE OTHER ISSUES WITH THE TRANSMISSION BUT I THOUGH THAT PARTICULAR ISSUE IS VERY DANGEROUS. THE VEHICLE HAS APPROX 70,000 MILES AND ALTHOUGH THIS PROBLEM WAS HAPPENING FROM TIME TO TIME, IT IS BECOMING MORE FREQUENT TO WHERE I HAVE TO ASSUME IT EVERY TIME I COME TO A STOP.
NHTSA complaint #11030662 — an unverified report by a vehicle owner.