Owners have filed 34 complaints
about the 2013 Toyota FJ Cruiser with NHTSA between 2012 and 2026.
The largest single group is the body & structure.
Across this model's run it ranks 5 of 8 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 11
Against the median year of the Toyota FJ Cruiser. 50 means typical for this
model; 100 means roughly double.
Severity — 30
5.9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
64% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2013 compares with every other Toyota FJ Cruiser
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
428.6%
1,000 – 9,999 miles
214.3%
10,000 – 24,999 miles
214.3%
25,000 – 49,999 miles
17.1%
50,000 – 74,999 miles
17.1%
75,000 – 99,999 miles
321.4%
100,000 – 149,999 miles
17.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2012peak 6May 2026
Recalls on the 2013 Toyota FJ Cruiser
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
14V475000
EQUIPMENT:OTHER:LABELS
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
Risk: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
13V163000
EXTERIOR LIGHTING
Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."
Risk: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
13V123000
EQUIPMENT:OTHER:LABELS
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Risk: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
13V098000
SEAT BELTS:FRONT:ANCHORAGE
Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
Risk: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202172355,683 units in Canada
Electrical
Issue: This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. Note: This recall only affects the following block heater/cord part numbers: C014003034 PK5A408J09 PU14000904 C014003151 PK5A408J13 PU14000905 C014000885 PK5A489J11 PU14000907 C014000888 PK5A489J22 PU14000909 C014000907 PK5A410H00 PU14000911 C014100904 PU14000900 PU14000913 C014100907 PU14000901 PU14003571 C014100911 PU14000902 PK5A489J14 PK5A408J05 PU14000903 Safety Risk: Engine block heater wiring that overheats or melts could create the risk of a fire. Corrective Actions: Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.
Recall 201308416,058 units in Canada
Seats And Restraints
On certain vehicles, due to insufficient strength of the access door (rear door) panels, cracks may develop if the access doors are repeatedly and forcefully closed over an extended period of time. As the driver and front passenger seat belt retractors are mounted in the access door panels, if cracks occur in the panel around the lower retractor anchor, the seat belt retractors could become detached. This could increase the risk of injury to an occupant in the event of a crash. Correction: Dealers will inspect the rear door panels for cracks or separation. Depending on the results of the inspection, the dealer will repair as necessary.
Reports where the owner recorded a crash, a fire, an injury or a death.
Mesa, AZCrash3 injured
AIR BAGS
I had a car accident on Feb 10, 2025 and my air bag did not deploy
NHTSA complaint #11648412 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Friendship, MD
SUSPENSION
Please consider opening or expanding an investigation into frame, underbody, brake-line, and suspension-mount corrosion affecting Toyota FJ Cruisers. I own a 2013 Toyota FJ Cruiser 4WD. A professional inspection found multiple fluid leaks, heavy rust, rusted exhaust, leaking rear shocks, and brake line/hose concerns. After reviewing the condition, the mechanic essentially declined to repair it and recommended scrapping the vehicle. The attached photos show conditions that appear safety-relevant: rust perforation through underbody structural metal near a bracket/crossmember area; severe corrosion around brake lines and fittings; widespread scaling near suspension and frame components; a leaking rear shock; and badly deteriorated exhaust connections. This is not just appearance rust. Also note the contrast between the observable condition of the vehicle versus the problems hidden beneath. This rust is clearly outpacing normal wear and tear. The safety risk is straightforward. At interstate speeds, a corroded brake line could fail during emergency braking. A weakened shock mount, suspension bracket, or crossmember could fail when the vehicle hits a pothole, uneven bridge plate, or highway debris. In dense, aggressive traffic, especially where vehicles travel 70+ mph, any sudden loss of braking, stability, or rear-end structural integrity could cause a spinout, rollover, or multi-vehicle crash. I understand Toyota has previously addressed severe corrosion on other truck platforms. I urge NHTSA to review whether the FJ Cruiser has a similar pattern of premature or excessive structural corrosion. Owners may not know the vehicle is unsafe until a mechanic refuses repair or a component fails. Please review consumer complaints, inspection photos, and corrosion-related failures before this becomes a fatal incident.
NHTSA complaint #11736593 — an unverified report by a vehicle owner.
Friendship, MD
STRUCTURE:BODY
Please consider opening or expanding an investigation into frame, underbody, brake-line, and suspension-mount corrosion affecting Toyota FJ Cruisers. I own a 2013 Toyota FJ Cruiser 4WD. A professional inspection found multiple fluid leaks, heavy rust, rusted exhaust, leaking rear shocks, and brake line/hose concerns. After reviewing the condition, the mechanic essentially declined to repair it and recommended scrapping the vehicle. The attached photos show conditions that appear safety-relevant: rust perforation through underbody structural metal near a bracket/crossmember area; severe corrosion around brake lines and fittings; widespread scaling near suspension and frame components; a leaking rear shock; and badly deteriorated exhaust connections. This is not just appearance rust. Also note the contrast between the observable condition of the vehicle versus the problems hidden beneath. This rust is clearly outpacing normal wear and tear. The safety risk is straightforward. At interstate speeds, a corroded brake line could fail during emergency braking. A weakened shock mount, suspension bracket, or crossmember could fail when the vehicle hits a pothole, uneven bridge plate, or highway debris. In dense, aggressive traffic, especially where vehicles travel 70+ mph, any sudden loss of braking, stability, or rear-end structural integrity could cause a spinout, rollover, or multi-vehicle crash. I understand Toyota has previously addressed severe corrosion on other truck platforms. I urge NHTSA to review whether the FJ Cruiser has a similar pattern of premature or excessive structural corrosion. Owners may not know the vehicle is unsafe until a mechanic refuses repair or a component fails. Please review consumer complaints, inspection photos, and corrosion-related failures before this becomes a fatal incident.
NHTSA complaint #11736593 — an unverified report by a vehicle owner.
Friendship, MD
SERVICE BRAKES
Please consider opening or expanding an investigation into frame, underbody, brake-line, and suspension-mount corrosion affecting Toyota FJ Cruisers. I own a 2013 Toyota FJ Cruiser 4WD. A professional inspection found multiple fluid leaks, heavy rust, rusted exhaust, leaking rear shocks, and brake line/hose concerns. After reviewing the condition, the mechanic essentially declined to repair it and recommended scrapping the vehicle. The attached photos show conditions that appear safety-relevant: rust perforation through underbody structural metal near a bracket/crossmember area; severe corrosion around brake lines and fittings; widespread scaling near suspension and frame components; a leaking rear shock; and badly deteriorated exhaust connections. This is not just appearance rust. Also note the contrast between the observable condition of the vehicle versus the problems hidden beneath. This rust is clearly outpacing normal wear and tear. The safety risk is straightforward. At interstate speeds, a corroded brake line could fail during emergency braking. A weakened shock mount, suspension bracket, or crossmember could fail when the vehicle hits a pothole, uneven bridge plate, or highway debris. In dense, aggressive traffic, especially where vehicles travel 70+ mph, any sudden loss of braking, stability, or rear-end structural integrity could cause a spinout, rollover, or multi-vehicle crash. I understand Toyota has previously addressed severe corrosion on other truck platforms. I urge NHTSA to review whether the FJ Cruiser has a similar pattern of premature or excessive structural corrosion. Owners may not know the vehicle is unsafe until a mechanic refuses repair or a component fails. Please review consumer complaints, inspection photos, and corrosion-related failures before this becomes a fatal incident.
NHTSA complaint #11736593 — an unverified report by a vehicle owner.
Marshfield, MA
POWER TRAIN
I purchased my beloved 2013 FJ Cruiser from Wellesley Toyota 6.5 years ago and have really enjoyed it. I have had it serviced religiously at McGee Toyota of Hanover since my purchase and expected to continue to enjoy it for many years to come and was just informed by McGee Toyota that the frame is severly rusted out throughout. My truck only has 158K miles on it and I expected this to last at least twice as long. This appears to be the same issue Toyota experienced with the Tundra and Tacoma with premature rusting on their vehicles due to a manufacturing issue. There are numerous complaints online about this issue and even a current class action lawsuit. I have alerted Toyota Corporate of this and they are not standing behind their product.
NHTSA complaint #11717366 — an unverified report by a vehicle owner.
Marshfield, MA
STEERING
I purchased my beloved 2013 FJ Cruiser from Wellesley Toyota 6.5 years ago and have really enjoyed it. I have had it serviced religiously at McGee Toyota of Hanover since my purchase and expected to continue to enjoy it for many years to come and was just informed by McGee Toyota that the frame is severly rusted out throughout. My truck only has 158K miles on it and I expected this to last at least twice as long. This appears to be the same issue Toyota experienced with the Tundra and Tacoma with premature rusting on their vehicles due to a manufacturing issue. There are numerous complaints online about this issue and even a current class action lawsuit. I have alerted Toyota Corporate of this and they are not standing behind their product.
NHTSA complaint #11717366 — an unverified report by a vehicle owner.
Marshfield, MA
SUSPENSION
I purchased my beloved 2013 FJ Cruiser from Wellesley Toyota 6.5 years ago and have really enjoyed it. I have had it serviced religiously at McGee Toyota of Hanover since my purchase and expected to continue to enjoy it for many years to come and was just informed by McGee Toyota that the frame is severly rusted out throughout. My truck only has 158K miles on it and I expected this to last at least twice as long. This appears to be the same issue Toyota experienced with the Tundra and Tacoma with premature rusting on their vehicles due to a manufacturing issue. There are numerous complaints online about this issue and even a current class action lawsuit. I have alerted Toyota Corporate of this and they are not standing behind their product.
NHTSA complaint #11717366 — an unverified report by a vehicle owner.
Mesa, AZCrash3 injured
AIR BAGS
I had a car accident on Feb 10, 2025 and my air bag did not deploy
NHTSA complaint #11648412 — an unverified report by a vehicle owner.
at 80,000 milesBurke, VA
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
The contact owns a 2013 Toyota FJ Cruiser. Upon having the vehicle inspected by a State Inspector, the contact was informed that there was significant corrosion on the undercarriage of the vehicle. The contact took the vehicle to a dealer and was informed that the corrosion failure was a result of normal wear and tear. The contact was referred to an independent mechanic who specialized in vehicle undercoating to prevent further corrosion damage to the vehicle. Despite the vehicle being treated for the corrosion damage, the contact was recently informed that the corrosion damage had worsened, and that the vehicle was unsafe to drive. The manufacturer was notified of the failure; the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 80,000.
NHTSA complaint #11606446 — an unverified report by a vehicle owner.
Montville, OH
SUSPENSION
I went down the road & hit a bump my car rocked a little so I stopped to check the lug nuts & see if anything was wrong. I did not see anything. So, I continued to go pick my friend up as I was driving down the freeway anytime I hit a bump the car rocked more the faster I went. So I slowed down & watched traffic around me. Picked my friend up, went on the ramp and hit another bump and bam, my vehicle went so high up in the air my friend thought we were going to roll over. I immediately got off the freeway & there was a dealership right there. I asked if they could look at it & they wouldn't, they were too busy. I managed to baby it all the way back to my dealership. They said the control bar came away from the frame that was rotted. I called my insurance co. they said nothing they could do because of wear & tear. They did not view anything but pictures. I called claims & they said my VIN has no recalls that they won't do anything. They did not look at anything. I asked that they call my dealership to have them tell them how serious this could have been. They said my warranty was up in July of 2021. I had no letters to tell me this. I have only had it serviced at the dealership when it was due for service, nowhere else. I found out claims previously have been paid through a lawsuit on frames. Frames should last longer than this even in inclement weather. I also had it fluid filmed. Nobody will do anything & it's scary. Sad they want an accident before they look at things. I hope you can address this some way. Thank You.
NHTSA complaint #11465817 — an unverified report by a vehicle owner.
Brick, NJ
SUSPENSION
Frame rust. Gas tank strap rust. Undercarriage rusted.
NHTSA complaint #11443720 — an unverified report by a vehicle owner.
Brick, NJ
STRUCTURE:BODY
Frame rust. Gas tank strap rust. Undercarriage rusted.
NHTSA complaint #11443720 — an unverified report by a vehicle owner.
Sturgeon Bay, WI
STRUCTURE:BODY
Severely rusted & rotting frame. Diagnosed by Mike’s Automotive, Sturgeon Bay, Wi.
NHTSA complaint #11436206 — an unverified report by a vehicle owner.
Barboursville, WV
UNKNOWN OR OTHER
Severe frame, structural and fuel tank strap rust.
NHTSA complaint #11429121 — an unverified report by a vehicle owner.
Chicago, IL
STRUCTURE:BODY
The frame on my vehicle is incredibly rusty. Upon further research, I've found that this is a chronic problem FJ Cruisers. Many frames have rusted to the point where there is structural damage thereby rendering the vehicle unsafe to drive. I know that Toyota issued a recall for Tacoma trucks for this very issue, and I would like to have a recall issued for the FJ as I'm incredibly concerned for my safety.
NHTSA complaint #11422743 — an unverified report by a vehicle owner.
Sugar Land, TX
UNKNOWN OR OTHER
I purchased a used Toyota FJ Cruiser in June 2019 with 25,441 miles on it from Luv Toyota in Lakewood, NY. The car was purchased sight unseen with cash from a Toyota dealership and shipped to me in Sugar Land, TX. When the vehicle arrived it was covered in frame and total underbody rust. The vehicle is completely unsafe to drive and I have driven it less than 1000 miles since it was purchased 2 years ago. After numerous attempts to receive a refund from Luv Toyota and Toyota Motors Corp I have given up. A 5 year old vehicle with less than 30,000 miles should not be completely rusted out. This is a complete fraudulent transaction. Toyota Corp does not stand by their vehicles or their franchise dealerships.
NHTSA complaint #11419119 — an unverified report by a vehicle owner.
at 144,000 milesClovis, CA
POWER TRAIN
FROM ACCELERATION; BETWEEN 30MPH AND 45MPH MY VEHICLE SHUDDERS AND SHAKES. I BELIEVE THE ISSUE IS COMING FROM THE TRANSMISSION AND OR DIFFERENTIAL OF MY VEHICLE.
NHTSA complaint #11395818 — an unverified report by a vehicle owner.
at 83,280 milesSomerset, MA
AIR BAGS
BROUGHT CAR INTO DEALER LAST MONTH FOR NEW HORN AS IT WAS A WEAK VOLUME AND WOULD NOT PASS INSPECTION IN MASSACHUSETTS. WAS REPLACED. WORKED FOR A WEEK OR TWO THEN CEASED TO COMPLETELY FUNCTION. BROUGHT BACK IN TODAY AND WAS TOLD BY DEALER CLOCK SPRING/SPIRAL CABLE WAS CORRODING. REMINDED OF OLD RECALL ON VARIOUS PAST TOYOTAS.
NHTSA complaint #11384336 — an unverified report by a vehicle owner.
at 83,280 milesSomerset, MA
ELECTRICAL SYSTEM
BROUGHT CAR INTO DEALER LAST MONTH FOR NEW HORN AS IT WAS A WEAK VOLUME AND WOULD NOT PASS INSPECTION IN MASSACHUSETTS. WAS REPLACED. WORKED FOR A WEEK OR TWO THEN CEASED TO COMPLETELY FUNCTION. BROUGHT BACK IN TODAY AND WAS TOLD BY DEALER CLOCK SPRING/SPIRAL CABLE WAS CORRODING. REMINDED OF OLD RECALL ON VARIOUS PAST TOYOTAS.
NHTSA complaint #11384336 — an unverified report by a vehicle owner.
Diessenhofen, NY
STRUCTURE:BODY
EXCESSIVE RUST ON FRAME, CHASSIS, TIE ROD ENDS AND ALL OTHER METAL PARTS, ALTHOUGH CAR IS MAINTENED PROPERLY, ONLY 40K MILES, GARAGE PARKING, NO OFF-ROAD USAGE AND NO SALT EXPOSED.
NHTSA complaint #11363658 — an unverified report by a vehicle owner.
Andover Township, NJ
STRUCTURE:BODY
THE FRAME AND GAS TANK STRAPS AND REAR BUMPER ARE RUSTING TO AN UNSAFE CONDITION. VEHICLE IS 2013 WITH ONLY 66000MILES. I AM SPENDING COUNTLESS DOLLARS YEARLY TO PREVENT THE RUST AND IT ISN'T GETTING ANY BETTER. OTHER VEHICLES THAT SHARE THE SAME FRAME HAVE HAD RECALLS ON THE FRAME AND THIS VEHICLE SHOULD ALSO BE INCLUDED
NHTSA complaint #11278666 — an unverified report by a vehicle owner.
Brick, NJ
SUSPENSION
SEVERE RUST UNDER CARRIAGE INCLUDING FUEL TANK STRAPS AND SUSPENSION COMPONENTS. NUMBER IS RUSTED AND SKID PLATES. RUST BASICALLY COVERING UNDER VEHICLE. CONCERNED ABOUT INTEGRITY DURING A CRASH
NHTSA complaint #11252836 — an unverified report by a vehicle owner.
Brick, NJ
STRUCTURE:BODY
SEVERE RUST UNDER CARRIAGE INCLUDING FUEL TANK STRAPS AND SUSPENSION COMPONENTS. NUMBER IS RUSTED AND SKID PLATES. RUST BASICALLY COVERING UNDER VEHICLE. CONCERNED ABOUT INTEGRITY DURING A CRASH
NHTSA complaint #11252836 — an unverified report by a vehicle owner.
Brick, NJ
FUEL/PROPULSION SYSTEM
SEVERE RUST UNDER CARRIAGE INCLUDING FUEL TANK STRAPS AND SUSPENSION COMPONENTS. NUMBER IS RUSTED AND SKID PLATES. RUST BASICALLY COVERING UNDER VEHICLE. CONCERNED ABOUT INTEGRITY DURING A CRASH
NHTSA complaint #11252836 — an unverified report by a vehicle owner.
at 61,000 milesShingletown, CA
STRUCTURE:BODY
FRAME RUST, REAR BUMPER RUSH, UNDER CARRIAGE RUST, FRONT LOWER A-ARM RUST, DIFFERENTIAL RUST.
NHTSA complaint #11245781 — an unverified report by a vehicle owner.
at 25,000 milesWest Minster, CO
AIR BAGS
TL* THE CONTACT OWNS A 2013 TOYOTA FJ CRUISER. WHILE A PASSENGER WAS SEATED IN THE FRONT PASSENGER SEAT, THE AIR BAG WARNING INDICATOR FAILED TO ILLUMINATE. THE OVERWEIGHT PASSENGER TRIGGERED THE AIR BAG SENSOR AND CAUSED IT TO FAIL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.
NHTSA complaint #10909738 — an unverified report by a vehicle owner.