Toyota Pickup engine problems

ENGINE

TRUCK HAS 186000 MILES AND OVER THE YEARS I HAVE HAD TO REPLACE THE HEAD GASKETS AND SEALS FOUR TIMES. BASICALLY SPENDING 3200 DOLLARS THREE TIMES AFTER THE WARRANTY WORK WAS DONE THE FIRST TIME. THIS IS A MAJOR ISSUE WITH THIS VEHICLE.

NHTSA complaint #10681063 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 1994 TOYOTA PICKUP. THE VEHICLE WAS REPAIRED UNDER A SILENT RECALL FOR THE HEAD GASKET, BUT THE FAILURE RECURRED. THE CONTACT STATED THAT HEAVY WHITE SMOKE WAS COMING FROM THE EXHAUST. THE DEALER DIAGNOSED THAT THE PASSENGER SIDE HEAD GASKET FAILED. THE MANUFACTURER WAS CONTACTED BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 43,000 AND THE CURRENT MILEAGE WAS 108,000.

NHTSA complaint #10423073 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

TL*THE CONTACT OWNS A 1994 TOYOTA PICKUP. THE CONTACT TOOK HER VEHICLE TO PEP BOYS TO HAVE A NEW CLUTCH AND EXHAUST INSTALLED. THE MECHANIC DISCOVERED A DEFECT AND ATTEMPTED TO TOW THE VEHICLE TO A DEALER; HOWEVER, THE TOW DRIVER WOULD NOT TRANSPORT THE VEHICLE BECAUSE THE FRAME WAS FAULTY. THE DEALER CONFIRMED THAT THE FRAME WAS RUSTED AND UNSAFE. THE CURRENT AND FAILURE MILEAGES WERE 75,000. UPDATED 6/01/09 *CN THE CONSUMER STATED A NEW CLUTCH AND EXHAUST SYSTEM. UPDATED 06/02/09.

NHTSA complaint #10268645 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL*THE CONTACT OWNS A 1991 TOYOTA PICKUP. THREE MONTHS AFTER THE VEHICLE WAS PURCHASED, THE CONTACT NOTICED EXTREME RUSTING ON THE CHASSIS UNDERNEATH THE VEHICLE. HE STATED THAT IT WAS SO RUSTED THAT THERE IS STRUCTURAL DAMAGE. THE OIL AND FUEL LINES WERE RUSTED AND FELL OFF IN THE MIDDLE OF THE ROAD. THE VEHICLE IS CURRENTLY PARKED AND UNABLE TO BE DRIVEN. THE CONTACT STATED THAT THEY HAVE NEVER HEARD OF THIS TYPE OF FAILURE. THEY INFORMED THE CONTACT THAT THEY WOULD SEND OUT A REPRESENTATIVE TO INSPECT THE VEHICLE, BUT NEVER DID. THE FAILURE MILEAGE WAS 73,000. UPDATED 12/5/08 *CN THE OIL PAN HAS A RUST HOLE. UPDATED 12/09/08.

NHTSA complaint #10246841 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

I BEGAN TO HAVE ISSUES W/ENGINE AND NOTIFIED PRIOR OWNER AND ADVISED ME RECEIVED NOTICE OF RECALL FOR HEAD GASKET, IMMEDIATELY CALLED LOCAL DEALER REGARDING RECALL AND THEY CLAIMED VEHICLE HAD BEEN SERVICED ALREADY (IN ANOTHER STATE) AND NOTHING THEY COULD DO, BUT OWNER STATE THAT IS FALSE HE OWNED VEHICLE AT THAT TIME AND HE HAD NEVER TOOK IN FOR SERVICE RECALL. IN THE MEANTIME CONDITION GOT WORSE, AND NOW LEAKING WATER AND HEAD GASKET NEEDS REPLACED. THE DEALER WON'T SERVICE IT, TOYOTA CUSTOMER CARE IS NONRESPONSIVE. ALL I GET FROM THEM IS EMAIL THANKING ME FOR CONCERN AND HOPE IT WAS RESOLVED, IN THE MEANTIME I NOW DON'T HAVE A VEHICLE TO DRIVE AND CAN'T AFFORD TO HAVE IT REPAIRED. I COULD UNDERSTAND THEY NOT FIXING IT BECAUSE OF DAILY USE OR NO WARRANTY ETC. BUT I HAVE SEEN MANY MANY COMPLAINTS ON SEVERAL WEB SITES REGARDING THE HEAD GASKET THIS ENGINE. SO IT IS AN OBVIOUS ISSUE THEY SHOULD AT LEAST LOOK AT IF NOT REPAIR.

NHTSA complaint #10230000 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

HEAD GASKET REPLACED BY TOYOTA (SPECIAL SERVICE CAMPAIGN V06) AT 109,574 MILES. REPLACEMENT HEAD GASKET FAILED SUDDENLY AT 189,000 MILES, DRIVING ON LEVEL GROUND (40 MPH), AND WITHOUT WARNING (NO OVERHEATING OR LEAKS). UNDRIVABLE AND HAD TO BE TOWED. PLENTY OF COMPLAINTS ON THE INTERNET ABOUT REPEATED HEAD GASKET FAILURES ON THESE PICKUPS (1990-95). CALLED TOYOTA CORP, BUT THEY REFUSE TO REPLACE THE GASKET AGAIN AT NO COST BECAUSE THEY CLAIM THAT THESE VEHICLES WERE "FIXED" WITH THE REPLACEMENT GASKET. THIS TRUCK DOES NOT HAUL OR PLOW AND HAS BEEN MECHANICALLY WELL MAINTAINED. THE HEAD GASKET REPLACEMENT SHOULD NOT HAVE FAILED. AFTER READING MANY COMPLAINTS ABOUT THIS PROBLEM ON THE INTERNET, THIS ISSUE MOST CERTAINLY NEEDS TO BE INVESTIGATED AND RECALLED BY TOYOTA!

NHTSA complaint #10209644 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

WITHOUT WARNING, VEHICLE STALLED AT 25 MPH. AFTER TOWING TO DEALERSHIP AND WAITING OVER 7 WEEKS WAS TOLD HEAD GASKET BLOWN AND HEADS WARPED. THEN CHARGED OVER $4220.00 FOR REPAIRS ALREADY DONE.

NHTSA complaint #10186661 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

I OWN A 94 TOYOTA 4RUNNER AND A 94 TOYOTA SR5 PICKUP TRUCK. BACK IN '98 I RECEIVED A RECALL NOTICE I BROUGHT BOTH MY VEHICLES TO FRED ANDERSON TOYOTA IN RESPONSE TO THE RECALL. THEY REPLACED THE HEAD GASKETS ON BOTH VEHICLES. RECALL NOTICE: A 3VZ-E HEAD GASKET REPLACEMENT JUNE 26, 1998 VEHICLE: TOYOTA TRUCK 4X4 MILEAGE: 46,623 JULY 17, 1998 VEHICLE: TOYOTA 4RUNNER MILEAGE: 38,037 THE BEGINNING OF FEBRUARY 2006 OF THIS YEAR, MY TOYOTA PICKUP TRUCK BLEW A HEAD GASKET WHEN I CRANKED IT UP ONE AFTERNOON. DENSE SMOKE AND RADIATOR FLUID FLOWED FROM THE TAILPIPE AND THE ENGINE WAS VIBRATING. LESS THAN 12 HOURS AFTER THE HEAD GASKET BLEW IN MY PICKUP TRUCK, THE VERY NEXT MORNING I STARTED MY WIFE'S 4RUNNER TO MAKE A TRIP INTO TOWN. IMMEDIATELY WHEN I STARTED IT, DENSE SMOKE AND RADIATOR FLUID FLOWED FROM THE TAILPIPE AND THE ENGINE WAS VIBRATING EVEN WORST THAN BEFORE. I IMMEDIATELY TURN THE TRUCK OFF. TOYOTA OPENED A CASE# 200602060829. I WAS TOLD THEY WOULD CALL CHAN COLEMAN AT SANFORD TOYOTA AND TRY TO GET A SPECIAL PRICE. I CALLED CHAN AND WAS TOLD I WOULD NEED TO SPEAK WITH SOMEONE IN HIS SERVICE DEPARTMENT. HE TRANSFERRED ME TO SERVICE AND WAS QUOTED A PRICE OF $1,600 PER VEHICLE TO REPAIR. I HAD BOTH VEHICLES TOWED AND REPAIRED BY A LOCAL REPAIR SHOP. BELOW ARE THE DATES AND MILEAGE FOR THE REPAIRS. FEBRUARY 16, 2006 VEHICLE: TOYOTA TRUCK 4X4 MILEAGE: 120,000 FEBRUARY 4, 2006 VEHICLE: TOYOTA 4RUNNER MILEAGE: 102,000 I WAS TOLD BY THE MECHANIC AT THE LOCAL REPAIR SHOP THAT THE REASON THE HEAD GASKETS WERE BLOWING WAS BECAUSE OF A CASTING DESIGN FLAW WITH THE ENGINE HEADS AND NOT THE HEAD GASKETS. THE HEADS HAD DIMPLES WHICH OVER TIME WOULD CAUSE THE HEAD GASKET TO BLOW. THE HEADS ON BOTH MY VEHICLES HAD TO BE RESURFACED TO REMOVE THE DIMPLES. I CALLED TOYOTA WITH THIS INFORMATION BUT WAS TOLD THEY SHOW BOTH MY VEHICLES WERE FIXED IN ACCORDANCE TO THE RECALL AND IT IS A ONE TIME FIX ONLY AND THE OWNER NEEDS TO TAKE RESPONSIBILITY AT SOME POINT.

NHTSA complaint #10157031 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

MY 1990 TOYOTA PICKUP WAS RECENTLY RECALLED. I TOOK IT TO THE LOCAL DEALERSHIP ON 3/10/2006. I ASSUME THEY FIXED THE PROBLEM. I NOW HAVE A NEW PROBLEM BECAUSE OF TAKING THIS IN. I HAVE A HUGE OIL LEAK, ENOUGH TO WHERE I HAVE TO ADD OIL NEARLY EVERY DAY. I DO NOT HAVE THE MONEY TO FIX THIS (( OR TO KEEP PUTTING IT IN JUST TO HAVE IN MAKE THE MESS IN MY GARAGE AND ALL OVER THE HIGHWAYS)). COULD YOU PLEASE HELP ME? THIS THERE SOME KIND OF VEHICLE REPAIR ASSISTANCE? THANK YOU.

NHTSA complaint #10155251 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

WHILE DRIVING VEHICLE STALLED. CONSUMER WAS UNABLE RESTART VEHICLE. CONSUMER HAD THE VEHICLE TOWED TO THE HOUSE. THEN , CONTACTED THE DEALER, AND MECHANIC DETERMINED THAT HEAD GASKET BLEW OUT.

NHTSA complaint #10087133 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

WHILE DRIVING 35 MPH, THE CONSUMER HEARD A LOUD NOISE COMING FROM THE VEHICLE. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND PULLED OVER. THE CONSUMER NOTICED THAT THE ENGINE HEAD GASKET LEAKED FLUID. THE VEHICLE WAS TOWED TO A GARAGE AND THE MECHANIC DETERMINED THAT THE ENGINE HEAD GASKET NEEDED TO BE REPLACED. *AK

NHTSA complaint #10080163 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

CRACK IN A THIN AREA OF CYLINDER WALL. LOSS OF COOLANT CAUSED OVERHEATING. REPAIR REVEALED STRETCHED TIMING CHAIN WITH BROKEN GUIDES AND THE BEGINNINGS OF DAMAGE TO CHAIN COVER HOUSING. ALSO, THE REAR 2 CYLINDERS WERE CLOGGED WITH BURNED, DRIED OIL. I PURCHASED THE VEHICLE USED AND CHANGED THE OIL EVERY 90 DAYS(MARCH, JUNE, SEPTEMBER, DECEMBER). THE REPAIRMAN SAID IT WAS A FACTORY DEFECT AND NOT OF MY MAKING.

NHTSA complaint #10070802 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

LEAK GENERATED FROM HEAD GASKET, ENGINE WAS RUINED FROM LEAK WHICH WARPED HEADS OF THIS VEHICLE TO ITS MALFUNCTIONING CONDITION. GASKETS WERE WORKED ON BY MAUI DEALERSHIP UNDER WARRANTY. PROBLEM RECURRED.

NHTSA complaint #10045157 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

THE DEALER INFORMED THE CONSUMER THE CYLINDER HEAD NEEDED TO BE REPLACED, BECAUSE OF A LEAKING HEAD GASKET. *JB THE CONSUMER WAS ALSO TOLD THE RADIATOR WAS LEAKING FROM THE TOP TANK, THE CLUTCH FLEX LINE AND POWER STEERING PUMP WAS ALSO LEAKING. THE GAS GAUGE WAS INOPERATIVE. THE DRIVE BELT AND TIMING BELTS WERE REPLACED. PH.

NHTSA complaint #10020220 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TRUCK OVER HEATED AND INITIAL DIAGNOSTIC STATED: NEW WATER PUMP, CRACKED HEAD, REBUILT ENGINE. TIMING CHAIN COVER WAS REPLACED, WATER PUMP REPLACED, AND HEAD RESURFACED. UPON HEARING A LOUD RATTLING NOISE FROM THE ENGINE ON FREEWAY, WAS ADVISED TO DRIVE 300+ MILES HOME WITH IT AND TO CALL IF IT WAS STILL THERE IN A FEW DAYS. TOOK TO ANOTHER TOYOTA DEALER WHO HAS FOUND THAT CRANKSHAFT NEEDS TO BE SMOOTHED AND NEW BEARINGS ARE NEEDED (SO FAR...).POSSIBLY MORE LOWER PORTION ENGINE PROBLEMS-CYLINDER HEAD, PISTONS... RECOMMENDED REBUILD ENGINE... *****-DIMS 11 IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS***** 758008.*AK

NHTSA complaint #10006477 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

THIS VEHICLE WAS PART OF THE HEAD GASKET RECALL BY TOYOTA, AS A RESULT THEY REPLACED THE ORGINAL ENGINE BLOCK DUE TO LEAKAGE OF COOLANT INTO THE CYLINDERS. AFTER APPROX. 45,000 MILES OF NORMAL DRIVING USING A CONNECTING ROD EXPLODED WITH NO APPARENT REASON. GIVING NO WARNING SIGNS OF ANY KIND. THE CONNECTING ROD EXPLODED WITH ENOUGH FORCE TO PRODUCE A 3 INCH DIA. HOLE IN THE SIDE OF THE BLOCK AND ESTABLISH A CRACK ALONG THE ENTIRE LEFT SIDE OF THE MOTOR. THIS EXPLOSION OCCURRED AT UNDER 35 MPH. I HAVE TALKED WITH TOYOTA CUSTOMERS RELATIONS AND THEY HAVE TOLD ME TOYOTA ISN'T INTERESTED. AFTER INSPECTION OF THE INSIDE OF THE MOTOR THERE WERE NO VISIUAL REASONS FOR THE CONNECTION ROD TO BLOW UP OIL PUMP WAS IN PERFECT WORKING ORDER WITH PLENTY OF OIL THROUGHOUT THE SYSTEM MY CONCERNS ARE IF THIS CAN HAPPN IN THIS MOTOR AND TOYOTA HAS REPLACED THOUSANDS OF MOTORS IN THEIR HEAD GASKET RECALL, AND THERE WERE DEFECTIVE RODS INSTALLED IN THOSE MOTORS, AT A HIGHER VEHICLE SPEED, GIVEN THE FORCE OF THE EXPLOSION SOMEBODY AT SOME POINT IN TIME IS GOING TO GET HURT. THANK YOU FOR YOUR CONCERN. DT

NHTSA complaint #768603 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

CONSUMER WAS UNABLE TO START VEHICLE .CONTACTED DEALER. TIMMING CHAIN BROKE.*AK

NHTSA complaint #8016489 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

FAN BLOWER SWITCH HAS BURNED OUT 3-4 TIMES IN THE PAST 3 YEARS. PLEASE PROVIDE ADDITIONAL INFORMATION.

NHTSA complaint #8016018 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

VEHICLE STALLS INTERMITTENTLY AT SLOW SPEEDS, VEHICLE HAS NOT BEEN EXAMINED BY DEALER SHIP.*AK

NHTSA complaint #8008667 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

WHILE DRIVING AT STATE SPEED LIMIT AND WITHOUT WARNING COOLANT AND WATER WAS LEAKING AFTER DRIVING A FEW MILES. MECHANIC STATED ENGINE HEAD GASKET NEEDED TO BE REPLACED.

NHTSA complaint #8005090 — an unverified report by a vehicle owner.