Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
18.3%
10,000 – 24,999 miles
433.3%
25,000 – 49,999 miles
433.3%
50,000 – 74,999 miles
216.7%
75,000 – 99,999 miles
18.3%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
May 2021peak 11Feb 2026
Complaints that involved harm
Reports where the owner recorded a crash, a fire, an injury or a death.
Paris KY, KYCrash
POWER TRAIN
When pulling into a shopping center parking space, my mother applied the brakes to slow down, but the vehicle seemed to surge and hit the car in front. It then surged again and pushed that car into another. No airbags deployed, and no one was injured, but someone could have been hurt either by the van itself or one of the other 2 vehicles. The dealer is scheduled to look at the vehicle, but stated on the phone that they "hadn't heard of this happening". There were no warning lights showing. My daughter stated that after the impact, she looked at my mother's feet, and her foot was clearly on the brake. I looked on the internet later, and found several threads of people complaining about their Toyota Sienna hybrids doing similar things.
NHTSA complaint #11656450 — an unverified report by a vehicle owner.
Paris KY, KYCrash
SERVICE BRAKES
When pulling into a shopping center parking space, my mother applied the brakes to slow down, but the vehicle seemed to surge and hit the car in front. It then surged again and pushed that car into another. No airbags deployed, and no one was injured, but someone could have been hurt either by the van itself or one of the other 2 vehicles. The dealer is scheduled to look at the vehicle, but stated on the phone that they "hadn't heard of this happening". There were no warning lights showing. My daughter stated that after the impact, she looked at my mother's feet, and her foot was clearly on the brake. I looked on the internet later, and found several threads of people complaining about their Toyota Sienna hybrids doing similar things.
NHTSA complaint #11656450 — an unverified report by a vehicle owner.
Lexington, KYCrash
UNKNOWN OR OTHER
When breaking, mostly during downhill, the brakes feel like they simply “let go” for an instant. Most times this is very short and It feels like a typical downshift during breaking in an ICE car. However, last time it really gave me a lurch and I almost ended up falling off a cliff face. Many reports all over the internet but nothing from Toyota.
NHTSA complaint #11597424 — an unverified report by a vehicle owner.
Lexington, KYCrash
SERVICE BRAKES
When breaking, mostly during downhill, the brakes feel like they simply “let go” for an instant. Most times this is very short and It feels like a typical downshift during breaking in an ICE car. However, last time it really gave me a lurch and I almost ended up falling off a cliff face. Many reports all over the internet but nothing from Toyota.
NHTSA complaint #11597424 — an unverified report by a vehicle owner.
Mount Vernon, NYCrash
SERVICE BRAKES
I have this car for 1 year, and I’ve have problems when I am driving and I have use the brake the car stop and keeping going forward ,I already had a accident hitting a car in front me,I’ve see a lot complain about this problems and the Toyota is not getting fixed and keeping saying that is the driver fault,I work as a driver I need this problem get fix.
NHTSA complaint #11572459 — an unverified report by a vehicle owner.
Mount Vernon, NYCrash
FORWARD COLLISION AVOIDANCE: WARNINGS
I have this car for 1 year, and I’ve have problems when I am driving and I have use the brake the car stop and keeping going forward ,I already had a accident hitting a car in front me,I’ve see a lot complain about this problems and the Toyota is not getting fixed and keeping saying that is the driver fault,I work as a driver I need this problem get fix.
NHTSA complaint #11572459 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Chula Vista, CA
AIR BAGS
Subject: Vehicle Safety Complaint – Recall 23TA15 | VIN [XXX] Hello, I am submitting a formal vehicle safety complaint regarding Safety Recall 23TA15 for my 2021 Toyota Sienna (VIN [XXX] ). Please find my detailed complaint and supporting documentation attached. This matter involves lack of disclosure and/or delayed notification of a safety recall, resulting in family safety exposure and loss of use. Thank you for your review and assistance. Sincerely, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11715682 — an unverified report by a vehicle owner.
Chula Vista, CA
AIR BAGS
This complaint is submitted to supplement and clarify a prior NHTSA submission regarding Safety Recall 23TA15 for VIN [XXX] . The prior submission was brief and did not fully capture the timeline and circumstances described below. I purchased a 2021 Toyota Sienna (VIN [XXX] ) from Avondale Toyota on [XXX]. At the time of purchase, I was not informed of any active or pending safety recall affecting the vehicle. After returning from Arizona to San Diego with my family, I attempted to list the vehicle on a rental platform on December 26, 2026. At that time, the platform flagged the VIN as having an active safety recall (Safety Recall 23TA15) and prevented the listing. This was the first time I became aware that the vehicle was subject to a safety recall. Despite multiple attempts to obtain clarification from Toyota Brand Engagement regarding the VIN-specific recall activation date, Toyota declined or failed to provide written confirmation. Whether the recall was active prior to the sale or applied shortly thereafter, the vehicle was placed into use without proper disclosure, warning, remedy, or guidance. As a result, my family and I unknowingly operated the vehicle, including interstate travel from Arizona to San Diego, without awareness of a potential safety risk. Had appropriate disclosure or timely notification been provided, I would not have used the vehicle or exposed my family to potential harm. In addition, the recall rendered the vehicle unavailable for its intended business use, resulting in loss of use and financial impact while the remedy was unavailable. I am submitting this supplemental complaint to ensure the full timeline, safety exposure, and lack of disclosure related to Safety Recall 23TA15 are accurately documented. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11715699 — an unverified report by a vehicle owner.
Lakewood, NJ
ELECTRICAL SYSTEM
I was driving my Toyota Sienna on a busy 6 lane highway in the second to the left lane, on a bridge. Suddenly without any warning AT ALL, my vehicle lost all power and came to an abrupt halt in the middle of high speed traffic. My wife and children were all in the car and we were in imminent danger of getting hit by another vehicle. It took the police approximately 10 minutes to arrive during which we were in life threatening danger. After the vehicle stopped a message on the dashboard read Hybrid System Failure. The police tried to push our vehicle to a safe spot but the wheels wouldn't turn and the car had to be towed. Upon inspection by the mechanic it appears that there is a broken shaft in the transmission that may have caused this problem. I want to emphasize that there was NO WARNING at all and we did not have a chance to move to safety.
NHTSA complaint #11715113 — an unverified report by a vehicle owner.
Lakewood, NJ
ENGINE
I was driving my Toyota Sienna on a busy 6 lane highway in the second to the left lane, on a bridge. Suddenly without any warning AT ALL, my vehicle lost all power and came to an abrupt halt in the middle of high speed traffic. My wife and children were all in the car and we were in imminent danger of getting hit by another vehicle. It took the police approximately 10 minutes to arrive during which we were in life threatening danger. After the vehicle stopped a message on the dashboard read Hybrid System Failure. The police tried to push our vehicle to a safe spot but the wheels wouldn't turn and the car had to be towed. Upon inspection by the mechanic it appears that there is a broken shaft in the transmission that may have caused this problem. I want to emphasize that there was NO WARNING at all and we did not have a chance to move to safety.
NHTSA complaint #11715113 — an unverified report by a vehicle owner.
Lakewood, NJ
FUEL/PROPULSION SYSTEM
I was driving my Toyota Sienna on a busy 6 lane highway in the second to the left lane, on a bridge. Suddenly without any warning AT ALL, my vehicle lost all power and came to an abrupt halt in the middle of high speed traffic. My wife and children were all in the car and we were in imminent danger of getting hit by another vehicle. It took the police approximately 10 minutes to arrive during which we were in life threatening danger. After the vehicle stopped a message on the dashboard read Hybrid System Failure. The police tried to push our vehicle to a safe spot but the wheels wouldn't turn and the car had to be towed. Upon inspection by the mechanic it appears that there is a broken shaft in the transmission that may have caused this problem. I want to emphasize that there was NO WARNING at all and we did not have a chance to move to safety.
NHTSA complaint #11715113 — an unverified report by a vehicle owner.
Thornton, CO
ENGINE
I turned on my minivan to drive my kids to school when I heard a sudden loud metal shredding/knocking and shut my van off. All maintenance was performed regularly on the van and no lights were on. I have a hole in my engine block now caused by a thrown rod, and no mechanic can explain why this happened. Oil was in good condition, and nothing indicated this should have happened.
NHTSA complaint #11712404 — an unverified report by a vehicle owner.
Fresno, CA
SEATS
I purchased a 2021 Toyota Sienna from United Access Mobility in Sacramento. The vehicle was sold and delivered with multiple serious pre-existing safety defects. The exhaust system was unsafe. The catalytic converter had been stolen prior to sale and replaced with a non-OEM catalytic converter that was improperly welded and mounted too low. This caused exhaust leaks, loud exhaust noise, poor acceleration, and safety concerns including potential exhaust exposure. Multiple professional repair facilities confirmed the exhaust system defect. The electrical system was defective. The vehicle was sold with the wrong size battery that was not properly secured. This caused electrical instability, warning lights, and vehicle failure. The battery was not adequately supporting the vehicle’s electrical system. The airbag and restraint system showed warnings caused by third-party wiring, indicating potential airbag or seatbelt malfunction. The fuel system was defective. The gas cap was broken and required tools to refuel the vehicle. Structural and body components were unsafe. A bumper bracket was loose and flapped while driving, and the passenger seat was unstable. Accessibility systems were also defective, including lift and door malfunctions affecting safe operation. United Access was notified immediately but did not correct these safety defects. Instead, they attempted to have the vehicle repaired using an extended warranty for pre-existing conditions. The vehicle was not safe to operate at the time of sale.
NHTSA complaint #11711719 — an unverified report by a vehicle owner.
Fresno, CA
SEAT BELTS
I purchased a 2021 Toyota Sienna from United Access Mobility in Sacramento. The vehicle was sold and delivered with multiple serious pre-existing safety defects. The exhaust system was unsafe. The catalytic converter had been stolen prior to sale and replaced with a non-OEM catalytic converter that was improperly welded and mounted too low. This caused exhaust leaks, loud exhaust noise, poor acceleration, and safety concerns including potential exhaust exposure. Multiple professional repair facilities confirmed the exhaust system defect. The electrical system was defective. The vehicle was sold with the wrong size battery that was not properly secured. This caused electrical instability, warning lights, and vehicle failure. The battery was not adequately supporting the vehicle’s electrical system. The airbag and restraint system showed warnings caused by third-party wiring, indicating potential airbag or seatbelt malfunction. The fuel system was defective. The gas cap was broken and required tools to refuel the vehicle. Structural and body components were unsafe. A bumper bracket was loose and flapped while driving, and the passenger seat was unstable. Accessibility systems were also defective, including lift and door malfunctions affecting safe operation. United Access was notified immediately but did not correct these safety defects. Instead, they attempted to have the vehicle repaired using an extended warranty for pre-existing conditions. The vehicle was not safe to operate at the time of sale.
NHTSA complaint #11711719 — an unverified report by a vehicle owner.
Fresno, CA
STRUCTURE:BODY
I purchased a 2021 Toyota Sienna from United Access Mobility in Sacramento. The vehicle was sold and delivered with multiple serious pre-existing safety defects. The exhaust system was unsafe. The catalytic converter had been stolen prior to sale and replaced with a non-OEM catalytic converter that was improperly welded and mounted too low. This caused exhaust leaks, loud exhaust noise, poor acceleration, and safety concerns including potential exhaust exposure. Multiple professional repair facilities confirmed the exhaust system defect. The electrical system was defective. The vehicle was sold with the wrong size battery that was not properly secured. This caused electrical instability, warning lights, and vehicle failure. The battery was not adequately supporting the vehicle’s electrical system. The airbag and restraint system showed warnings caused by third-party wiring, indicating potential airbag or seatbelt malfunction. The fuel system was defective. The gas cap was broken and required tools to refuel the vehicle. Structural and body components were unsafe. A bumper bracket was loose and flapped while driving, and the passenger seat was unstable. Accessibility systems were also defective, including lift and door malfunctions affecting safe operation. United Access was notified immediately but did not correct these safety defects. Instead, they attempted to have the vehicle repaired using an extended warranty for pre-existing conditions. The vehicle was not safe to operate at the time of sale.
NHTSA complaint #11711719 — an unverified report by a vehicle owner.
Saco, ME
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
The driver’s side door mirror shakes when going down the road. The image in the mirror becomes shaky. The passenger side is fine, this is only on the driver side. I have brought this into the dealer, but they said it is normal. In 30+ years of driving cars, I have never had a car mirror do this.
NHTSA complaint #11706330 — an unverified report by a vehicle owner.
at 30,000 milesShawnee, OK
AIR BAGS
The contact owns a 2021 Toyota Sienna. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS). However, the part to do the recall repair was not yet available. The contact stated that the air bag sensor turned off and failed to function as intended. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue but offered no assistance. The manufacturer advised the contact to stop driving the vehicle. The failure mileage was approximately 30,000.
NHTSA complaint #11695405 — an unverified report by a vehicle owner.
Teaneck, NJ
SERVICE BRAKES
When braking to a stop at low speed (stopping at stop sign or at light), then car accelerates forward even though my foot is on the brake attempting to slow the car down. This unintended acceleration is dangerous and can cause an accident.
NHTSA complaint #11690131 — an unverified report by a vehicle owner.
Matthews, NC
SEATS
2nd row passenger seat recline does not work. My seat is very reclined now causing the 2nd row passenger to not be in the optimal position for SRS airbag performance that may result in possible death due to head impact during a side collision. Toyota likely has enough data to issue a TSB to resolve this issue preventing serious injury or death to one of my children.
NHTSA complaint #11687905 — an unverified report by a vehicle owner.
Casa Grande, AZ
AIR BAGS
It has been 22 months since the recall (NHTSA Number 23V865) and over a year since the expected remedy date. What is the status update? What is causing the delay?
NHTSA complaint #11687887 — an unverified report by a vehicle owner.
Farmville, NC
POWER TRAIN
While driving my 2021 Toyota Sienna Hybrid, the vehicle suddenly displayed a low oil pressure warning, immediately lost power, and entered limp mode. I was able to pull over safely, but the engine then suffered a catastrophic failure — a connecting rod blew through the engine block, leaving large metal fragments inside the engine compartment. The vehicle is completely inoperable. Prior to this event the van sometimes idled rough and shook slightly on startup when transitioning from battery to gasoline engine after sitting, but it drove normally otherwise. I have performed regular oil changes and routine maintenance according to Toyota’s schedule. Safety Concern: This failure happened suddenly and without warning. If it had occurred at highway speeds, it could have caused a serious crash due to loss of power or debris from the engine. This presents a significant safety hazard for drivers and passengers. Toyota has issued TSB T-SB-0104-21 for the 2021 Sienna Hybrid’s A25A-FXS engine addressing “MIL ON with Low Oil Pressure” conditions and DTCs P05202A/P052477 with milky or discolored oil. This suggests Toyota is aware of oil pressure and lubrication issues on this engine family. My catastrophic failure appears consistent with a loss of oil pressure or lubrication. I am filing this complaint to alert NHTSA of a possible defect or safety issue affecting 2021 Toyota Sienna Hybrid engines that can result in sudden catastrophic engine failure.
NHTSA complaint #11687704 — an unverified report by a vehicle owner.
Vancouver, WA
SEATS
I purchased a 2021 Toyota Sienna (VIN: [XXX] ) from an authorized Toyota dealer in June 2024. At the time of sale, I was assured that the open safety recall (23TA15) would be repaired soon. More than a year later, no remedy has been offered, leaving me and my family driving an unsafe vehicle. Toyota’s own phase schedule indicates repairs should already be available in Washington State, yet I have been repeatedly told no repair exists. This has caused serious safety concerns, financial hardship, and loss of trust. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11681746 — an unverified report by a vehicle owner.
Vancouver, WA
AIR BAGS
I purchased a 2021 Toyota Sienna (VIN: [XXX] ) from an authorized Toyota dealer in June 2024. At the time of sale, I was assured that the open safety recall (23TA15) would be repaired soon. More than a year later, no remedy has been offered, leaving me and my family driving an unsafe vehicle. Toyota’s own phase schedule indicates repairs should already be available in Washington State, yet I have been repeatedly told no repair exists. This has caused serious safety concerns, financial hardship, and loss of trust. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11681746 — an unverified report by a vehicle owner.
Vancouver, WA
UNKNOWN OR OTHER
I purchased a 2021 Toyota Sienna (VIN: [XXX] ) from an authorized Toyota dealer in June 2024. At the time of sale, I was assured that the open safety recall (23TA15) would be repaired soon. More than a year later, no remedy has been offered, leaving me and my family driving an unsafe vehicle. Toyota’s own phase schedule indicates repairs should already be available in Washington State, yet I have been repeatedly told no repair exists. This has caused serious safety concerns, financial hardship, and loss of trust. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11681746 — an unverified report by a vehicle owner.
Brighton, MI
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
2021 Sienna Hybrid Platinum AWD ~65K miles. Safety Issue: Fogging of windows increased, as AC was not working properly. Believe rear AC lines had galvanic corrosion from differing metals, steel bracket with aluminum line-sets causes corrosion hole in refrigerant line set, and leak causing loss of all Freon. No warning lights or messages, AC just stop blowing cold. Vehicle is driven in Michigan on winter roads with road salt, but stored in garage and only 4 years old. $1742 fix to replace line-sets, which can corrode again without proper design fix. Problem confirmed by dealer, and seen in other similar year Sienna's.
NHTSA complaint #11681563 — an unverified report by a vehicle owner.
Gilbert, SC
SERVICE BRAKES
When braking downhill, the car will lurch forward causing me to have to break harder.
NHTSA complaint #11679153 — an unverified report by a vehicle owner.
Westminster, CA
AIR BAGS
It has been almost 2 years and a remedy is not yet available?? I don’t feel safe in this car without this being fixed!
NHTSA complaint #11676761 — an unverified report by a vehicle owner.
Brooklyn, NY
POWER TRAIN
sound coming from engine / transmission other issues with the 2 ruber seals on the minivan keep worping out i looked on all the forms everyone is making the same complaint i toook it to toyota they just put tape and its off again they didnt help for a perminent fix back door is miss alined pasanger side sliding door sometimes does not close takes 3-4 atempts pressing the button
NHTSA complaint #11675599 — an unverified report by a vehicle owner.
Brooklyn, NY
ENGINE
sound coming from engine / transmission other issues with the 2 ruber seals on the minivan keep worping out i looked on all the forms everyone is making the same complaint i toook it to toyota they just put tape and its off again they didnt help for a perminent fix back door is miss alined pasanger side sliding door sometimes does not close takes 3-4 atempts pressing the button
NHTSA complaint #11675599 — an unverified report by a vehicle owner.
Brooklyn, NY
FUEL/PROPULSION SYSTEM
sound coming from engine / transmission other issues with the 2 ruber seals on the minivan keep worping out i looked on all the forms everyone is making the same complaint i toook it to toyota they just put tape and its off again they didnt help for a perminent fix back door is miss alined pasanger side sliding door sometimes does not close takes 3-4 atempts pressing the button
NHTSA complaint #11675599 — an unverified report by a vehicle owner.
Ann Arbor, MI
SERVICE BRAKES
Brake Transition Issues: I have noted frequent jolts of power when braking, which creates at least the sensation of, if not actual acceleration while breaking. Web research suggests this may be linked to the vehicle switching between regenerative and mechanical braking systems, and that the problem is acute with 2021 and 2022 Toyota Siennas, which, if accurate, means Toyota has applied a fix to subsequent model years, but has not systematically addressed the first two years of the current Sienna generation.
NHTSA complaint #11674265 — an unverified report by a vehicle owner.