2011 Toyota Tacoma headlight problems

EXTERIOR LIGHTING

1.) Headlights are yellowing. 2.) Hard to see at night. 3.) Everyone has the same problem. The government should mandate going back to glass headlights for safety reasons. Buffing them only lasts a short period of time and the elderly can't afford to buy new OEM headlights every 6 years as they are very, very expensive. This is a safety issue, as yellow lenses equal more nighttime accidents, fact. This should have been addressed years ago.

NHTSA complaint #11555787 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

The contact owns a 2011 Toyota Tacoma. The contact stated that the driver's and passenger's side headlights were inoperable. Upon inspection, the contact noticed that the headlight assemblies were extremely hot and had melted. The vehicle was taken to the dealer where it was diagnosed that the driver's and passenger's side headlight assemblies needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 210,000.

NHTSA complaint #11480199 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

MY DAYLIGHT RUNNING LIGHT KEEPS BURNING OUT AND SPLITTING THE LENS. IT'S THE SECOND SET OF LIGHT I'VE HAD TO REPLACE THEM.

NHTSA complaint #11383014 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

BOTH LEFT SIDE AND RIGHT SIDE DAY TIME RUNNING LIGHT LENS INSIDE HEAD LIGHT ASSEMBLY ARE BURNED AND DISCOLORED. HEAD LIGHT ASSEMBLY LENS ARE CRACKED.

NHTSA complaint #11375750 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

I HAVE HAD TO REPLACE MY HEADLIGHTS 4 TIMES IN TWO YEARS.

NHTSA complaint #11268724 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE RUNNING LIGHTS ARE RUNNING TOO HOT BURNING THE HEADLAMP AND BURNING THE CONNECTING WIRES

NHTSA complaint #11132222 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

DAYTIME RUNNING LIGHTS BUBBLING AGAIN AFTER RECALL AND REPLACEMENT. NOTICED IT YESTERDAY (8/15/18). THE TRUCK HAS 80,812 MILES AND THE RECALL NOTICE SAID WARRANTY ONLY GOOD UNTIL 5 YEARS OR 70,000 WHICHEVER COMES FIRST. SEEMS TO ME THEY PUT NEW BAD ONES IN WHEN THEY REPLACED THEM UNDER THE RECALL. NOT SURE EXACTLY WHEN THEY STARTED BUBBLING AGAIN.

NHTSA complaint #11120365 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

HEADLIGHTS ARE FORMING CRACKS IN LENSES, AND THEY ARE GROWING.

NHTSA complaint #11098374 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THIS IS A COMPLAINT WITH TOYOTA. I BOUGHT MY 2011 TOYOTA TACOMA PRE RUNNER SPORT BRAND NEW. THIS IS A COMPLAINT WITH TOYOTA. I BOUGHT MY 2011 TOYOTA TACOMA PRERUNNER SPORT BRAND NEW. ABOUT A YEAR AGO, I NOTICED MY AMBER "DAYTIME RUNNING LIGHTS" WERE BECOMING DISCOLORED, IT HAD THE APPEARANCE OF THE BULB BECOMING HOT, MELTING AND DISCOLORING MY AMBER LENSES. AT THAT TIME IT WAS JUST STARTING TO TURN COLORS. LAST WEEK A MAN AT THE GAS STATION POINTED AT MY DRIVERS SIDE RUNNING LIGHT AND SAID I SHOULD HAVE THAT LOOKED AT BEFORE IT BURNS THROUGH OR CAUSES A FIRE. UPON HIS COMMENT I NOTICED IT HAD BECOME NOTICEABLY WORSE, TO THE POINT I DO NOT FEEL LIKE THE VEHICLE IS SAFE TO DRIVE WITH THE RUNNING LIGHTS ON, YOU CAN NOT TURN THEM OFF DURING DAYTIME DRIVING, IT IS A SAFETY MATTER. I IMMEDIATELY CONTACTED MY TOYOTA DEALERSHIP SERVICE REP IN TRACY, CA, TRACY TOYOTA, HE SAID THERE WAS NOTHING THEY COULD DO AND GAVE ME THE TOYOTA CORPORATE OFFICE 800 NUMBER. TODAY I TALKED TO TWO EMPLOYEES WHO WERE SYMPATHETIC BUT ULTIMATELY SAID NOTHING CAN BE DONE BY THEM AND I WAS TOLD BY THEM A LETTER WAS MAILED OUT REGARDING THIS DEFECT, THE LETTER CONFIRMS IT AS A KNOWN DEFECT AND THE LETTER SHOWS TOYOTA HAS ACKNOWLEDGED IT AS SUCH. MY WARRANTY HAS SINCE EXPIRED. I NEVER RECEIVED THE LETTER AND THEY REFUSE TO PAY TO REPAIR FOR THIS DEFECT. THIS PROBLEM STILL EXISTS FOR 2011 TOYOTA TACOMAS. I HAVE TO PAY OUT OF POCKET TO REPLACE BOTH HEADLIGHT RUNNING LIGHT ASSEMBLIES, I AM REQUESTING TOYOTA TO REIMBURSE ME THE COST AS I WILL KEEP THE RECEIPT AND ASK FOR THE DAMAGED PARTS. THIS DEFECT DIMINISHES THE SAFETY FUNCTION OF A DAYTIME RUNNING LIGHT AND COULD CAUSE A FIRE AS WELL.

NHTSA complaint #11092384 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE INNER DAYTIME RUNNING LIGHT/TURN SIGNAL LENS BECOMES DISTORTED AND BUBBLED WITH A BROWN, SCORCHED RESIDUE WHICH OBSCURES AND/OR DIMINISHES THE RUNNING LIGHT AND TURN SIGNAL FUNCTIONS TO ON-COMING TRAFFIC. ADDITIONALLY, THE INNER LENS IS CRACKED AND/OR SEPARATED. TOYOTA DID OFFER A WARRANTY EXTENSION ON THIS DEFECT SO IT HAS BEEN ACKNOWLEDGED AS A PROBLEM. THIS WARRANTY EXTENSION HAS SINCE EXPIRED ALTHOUGH THE PROBLEM STILL EXISTS FOR THESE VEHICLES.

NHTSA complaint #11078773 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

TL* THE CONTACT OWNS A 2011 TOYOTA TACOMA. WHILE DRIVING WITH THE DAYTIME RUNNING LAMPS ILLUMINATED, THE CONDENSATION ON THE HEADLIGHTS SPLIT AND MELTED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (PREMIER TOYOTA , 5601 NATIONAL RD E, RICHMOND, IN 47374) WHERE IT WAS DIAGNOSED THAT THE HEADLIGHT/TURN SIGNAL ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND OPENED CASE NUMBER: [XXX]. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 25,000. *TT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #11076376 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

MY DAYTIME RUNNING LIGHTS QUIT WORKING BECAUSE THEY GOT TOO HOT AND BURNED THE LENS AND BULB SOCKET. THIS CAUSED MY FRONT AND REAR RIGHT BLINKERS TO CEASE WORKING AND COULD HAVE HAD DISASTROUS RESULTS.

NHTSA complaint #11045356 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

PURCHASED NEW TOYOTA TACOMA 2011 FROM LOCAL DEALER. PROBLEM IS WITH DAYTIME RUNNING LIGHTS GETTING TOO HOT AND BURNING AND CRACKING LENS. CUSTOMER SERVICE SAYS THEY SENT OUT WARRANTY POLICY BULLETIN (POL14-03) , BUT I NEVER RECEIVED NOTICE. THEY ALSO SAY BOTH WARRANTIES THEY CREATED BECAUSE OF THIS PROBLEM, HAVE EXPIRED, AND WILL NOT PAY FOR REPAIRS. I AM WORRIED THEY MAY START A FIRE BECAUSE OF THE OVERHEATING.

NHTSA complaint #11025324 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

[XXX] LIGHTNING/ELECTRICAL I WANT TO REPORT SAFETY ISSUES WITH MY TOYOTA TACOMA. WHEN I BOUGHT TACOMA IN SAN ANTONIO, BRAND NEW IN 2011, A FEW MONTHS LATER THE DAYTIME RUNNING LIGHT (DRL) AND TURN SIGNAL LENS BECOME DISTORTED, BUBBLED, AND CRACKED. I DID A GOOGLE SEARCH, AND IT WAS AN EXTREMELY COMMON ISSUE WITH MANY OWNERS COMPLAINTS. I TOLD MY DEALERSHIP AND IT WAS "NORMAL" AND I WAS REQUIRED TO PAY TO GET IT FIXED. EARLIER THIS YEAR WHEN I WAS AT MOUNTAIN STATES TOYOTA IN DENVER TO GET THE OIL CHANGE, I INQUIRED ABOUT THE SAME ISSUE. THE EMPLOYEE TOLD ME THAT IT WAS A VERY COMMON ISSUE, AND THAT TOYOTA WILL FIX IT FOR FREE. I WAS TOLD THAT A LETTER WAS MAILED OUT TO EVERY PERSON THAT OWNS A 2011 TOYOTA TACOMA. HOWEVER, THERE WAS A TIME LIMIT TO GET IT DONE AND IT ALREADY ALREADY PASSED. I WANT TO EMPHASIZE THAT I NEVER RECEIVED A LETTER FROM TOYOTA. IN ADDITION, MY TRUCK HAS ALWAYS HAS ELECTRICAL ISSUES SINCE I BOUGHT THE TRUCK. INTERMITTENTLY, WHEN I DRIVE MY TRUCK, EVERY ELECTRICAL COMPONENTS AND LIGHTS, INCLUDING FROM THE INSTRUMENTAL PANEL WOULD SHUT DOWN AND INSTANTLY START BACK UP, AND MY STEERING WHEEL WOULD MOMENTARILY LOCK UP. I CALLED TOYOTA HEADQUARTER, AND THE LADY I SPOKE TO SAID THAT THERE WAS A TIME LIMIT WHEN I COULD GET IT FIXED, AND THAT IT HAS NOW EXPIRED. AND THAT THERE WAS NOTHING SHE CAN DO ABOUT IT. I ONLY WANT TOYOTA TO FIX THIS ISSUE FREE OF CHARGE, BECAUSE I NEVER RECEIVED THAT LETTER THEY TOLD ME THEY SENT OUT, AND I DO NOT KNOW WHY THEY PUT A TIME LIMIT ON IT. IF TOYOTA REFUSES TO GET IT FIXED, I WANT TO PUT TOYOTA ON NOTICE THAT I WANT TO INITIATE ARBITRATION WITH TOYOTA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'

NHTSA complaint #11022801 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

MY HEADLIGHT ASSEMBLY LENS WERE DISTORTED AND BUBBLED ON BOTH SIDE OF THE VEHICLE. TOYOTA REPLACED THE HEADLIGHTS TWICE ON THE RIGHT & 1 ON THE LEFT. NOW THE ONE ON THE RIGHT IS DISTORTED AND BUBBLED AGAIN AND TOYOTA REFUSED TO REPLACE IT BECAUSE IT IS OUTSIDE THE 5 YEARS/70,000 MI WARRANTY. THIS IS A POTENTIAL FIRE HAZARD AND A DEFECT FROM THE DESIGN. PLEASE SEE ATTACHED PICTURE FOR REFERENCE.

NHTSA complaint #11020006 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

DAY TIME RUNNING LIGHTS ARE TOO HOT. THE BULBS HAVE MELTED AND BUBBLED THE PLASTIC HOUSING. CALLED TOYOTA AND THEY SAID IT WAS OUT OF WARRANTY AND THAT A NOTICE WAS SENT OUT ABOUT THIS ISSUE WHICH I NEVER RECEIVED. TOOK MY TRUCK TO TWO DIFFERENT DEALERSHIPS AND WAS NEVER TOLD ABOUT ANY ISSUE. TOYOTA WILL NOT COVER ANY REPAIRS OR REPLACEMENTS.

NHTSA complaint #11006740 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE PLASTIC HEADLIGHT HOUSING OVER THE DAYTIME RUNNING LIGHTS IS MELTING / BUBBLING. THE TRUCK HAS ONLY 40,000 MILES. TOYOTA WILL NOT REPLACE OR REPAIR UNDER WARRANTY ENHANCEMENT. POSSIBLE FIRE HAZARD.

NHTSA complaint #11004273 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE RUNNING LIGHT LENS ON DRIVER'S SIDE IS FOGGED AND CRACKED. TOYOTA ISSUED A VOLUNTARY RECALL AND SENT ME A LETTER THAT THEY WOULD REPLACE PART UP TO 5 YEARS OR 70,000 MILES. I HAVE 65,000 MILES BUT MY TRUCK IS GREATER THAN 5 YEARS OLD, AND THEY WOULD NOT REPLACE THE PART AFTER I CONTACTED THEM. ACCORDING TO MY LOCAL DEALER THIS WILL EVENTUALLY HAPPEN TO THE OTHER SIDE AS WELL.

NHTSA complaint #11001301 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE BULBS IN THE DAYTIME RUNNING LIGHTS ARE MELTING THE LENSES.

NHTSA complaint #10991610 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

REAR LEAF SPRINGS HAVE BROKEN AND THE FRONT HEAD LIGHT COVERS HAVE CRACKED.

NHTSA complaint #10934900 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

WRONG RUNNING LIGHTS WERE INSTALLED AT THE FACTOR. NOW THE HEADLIGHTS ARE CRACKED AND FOGGY AND THE LIGHT IS WEAK AND DEFUSED MAKING IT DANGEROUS AT NIGHT. T DEALER THAT I TOOK IT TO TOLD ME THE TIME LIMIT FOR REPAIR HAD EXPIRED AND THEY WOULD NOT PAY FOR THE REPAIR.

NHTSA complaint #10821664 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE RUNNING LIGHTS AREA DEVELOPED CRACKS AND A ROUND SHAPE CLOUDY AREA IN FRONT OF THE LIGHT BULB LIKE IT MELTING THE PLASTIC.

NHTSA complaint #10704483 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THIS VEHICLE HAS 2 FRONT DAYTIME RUNNING LIGHTS. THE LIGHTS IN THIS AREA ARE OVERHEATING AND CAUSING THE LIGHTING CASE TO HAVE A "BUBBLE" IN THE BULB CASING. THIS IS CAUSING DAMAGE TO BOTH DRIVER AND PASSENGER HEADLAMPS. THIS IS CAUSED WHEN AS SOON AS THE VEHICLE IS TURNED ON AND WHEN PARKED OR DRIVING.

NHTSA complaint #10604444 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE DAYTIME RUNNING LIGHTS HAVE BURNED INTO THE INNER AREAS OF MY HEADLIGHT ASSEMBLIES AND IT CONTINUES TO GET WORSE. SEEING AS THEY CANNOT BE TURNED OFF AND THEY CONTINUE TO GET WORSE I FEAR THEY MAY ONE DAY CAUSE A FIRE OR FURTHER DAMAGE. I HAVE TALKED TO THE DEALER, TOYOTA CORPORATE AND THEY WILL DO NOTHING AND SHOW NO CONCERN FOR THE ISSUE, I DRIVE ALOT OF MILES AND PURCHASED A TOYOTA DUE TO DEPENDABILITY. WHEN THE PROBLEM WAS 1ST TALKED TO WITH TOYOTA THE TRUCK WAS ONLY 1 1/2 YEARS OLD BUT HAD AROUND 40,000 MILES TO WHICH THEIR EXCUSE WAS THAT IT IS OUTSIDE THE WARRANTY PERIOD. PLEASE NOTE THAT TOYOTA KNOWS THIS IS AN ISSUE AS THEY HAVE ISSUED A TSB STATING THE PROBLEM EXISTS AND THE MODEL YEAR 2012 AND FORWARD THESE ARE RE-DESIGNED TO ELIMINATE THIS PROBLEM. HOWEVER THERE ARE THOUSANDS OF THESE TRUCKS ON THE ROADS FRM 2005 TO 2011 THAT HAD THE DTRL OPTION AND THE OWNERS CAN DO NOTHING TO STOP THIS ISSUE FROM OCCURRING OR GUARANTEE THEIR AND THEIR FAMILIES SAFETY. WHEN I TALKED TO TOYOTA THEY DID OFFER TO REPLACE 1 ASSEMBLY IF I PAID FOR THE OTHER AT A COST OF $450? WHY SHOULD I BE REQUIRED TO PAY TO FIX THEIR POORLY ENGINEERED PARTS THAT THEY KNOW ARE AN ISSUE? YOU CAN FIND AFTERMARKET LIGHT ASSEMBLIES FOR AROUND $80 ONLINE AND I CANNOT BELIEVE THAT IT COSTS TOYOTA $450 TO PRODUCE THIS ASSEMBLY, THEY WERE NOT MAKING ME A DEAL AND PAYING FOR 1, I WAS PAYING FOR BOTH! TOYOTA SHOULD RECALL THESE ASSEMBLIES AND REPLACE AS AT THIS POINT IT SHOWS THAT TOYOTA HAS NO PLANS OF DOING THE RIGHT THING AND CORRECTING THE KNOWN PROBLEM WITHOUT BEING TOLD THEY HAVE TO.

NHTSA complaint #10592975 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

LOOKS LIKE BURN MARKS FROM THE AMBER DRIVING LIGHTS. ALSO, THERE ARE BUBBLES AND CRACKS IN THE HEADLIGHT COVERS.

NHTSA complaint #10577579 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

MY DAYTIME RUNNING LIGHT BULBS ARE BEGINNING TO MELT THE LENSES. THE DRL ARE A SAFETY ITEM AND TOYOTA HAS NOT ISSUED A RECALL FOR THIS. I FEEL AS THE TRUCK AGES THE DRL WILL CONTINUE TO MELT AND WILL NOT BE AS VISIBLE TO OTHER DRIVERS. ALSO IF THE HEADLAMP ASSEMBLIES BUILD UP ENOUGH HEAT IT COULD POSE A FIRE RISK.

NHTSA complaint #10567068 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TOOK VEHICLE IN TO DEALER FOR OTHER WORK. WAS TOLD BY SERVICE ADVISOR THAT TECHNICIAN FOUND MY HEADLIGHTS TO BE MELTING. SERVICE ADVISOR SHOWED ME PROBLEM AND SAID IT WAS DAYLIGHT RUNNING LIGHTS. THEY WERE CRACKED AND BURNED AS WAS THE ASSEMBLY. I WAS QUOTED A PRICE OF $1300 TO REPLACE THEM. I PURCHASED THE VEHICLE NEW AND HAVE HAD IT FOR 2 1/2 YEARS. THIS IS A HAZARD AND A DANGER AND THEY SHOULD BE REPLACED BY TOYOTA AT THEIR COST.

NHTSA complaint #10559333 — an unverified report by a vehicle owner.