2000 Toyota Tundra equipment problems

TRAILER HITCHES

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE INSPECTING THE VEHICLE, AN INDEPENDENT MECHANIC DIAGNOSED THAT THE ENTIRE FRAME AND REAR PASSENGER SIDE WHEEL HAD EXTENSIVE RUST AND CORROSION. THE CONTACT WAS ADVISED THAT THEY BOTH SHOULD BE REPLACED OR THE VEHICLE MAY FAIL AN INSPECTION. THE VEHICLE WAS INCLUDED IN A MANUFACTURER RECALL, BUT THE MANUFACTURER INDICATED THAT THE STATUTE EXPIRED. THE MANUFACTURER WOULD NOT PROVIDE THE RECALL REMEDY FOR NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE VEHICLE WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 01E041000 (TRAILER HITCHES/TRAILER WIRE HARNESS CONVERTER). THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

NHTSA complaint #10993390 — an unverified report by a vehicle owner.

EQUIPMENT

SUNROOF ORIGINALLY INSTALLED ON MY 2000 TOYOTA TUNDRA MANUFACTURED BY HOLLANDIA TYPE: TVS NR.: 426089 SEPARATED FROM THE VEHICLE WHILE DRIVING ON INTERSTATE 80. GLASS GOT RIPPED-OFF AND ALMOST HIT CARS DRIVING BEHIND ME.

NHTSA complaint #10442103 — an unverified report by a vehicle owner.

TRAILER HITCHES

(1). I PURCHASED A NEW 2000 TOYOTA TUNDRA EXTENDED CAB LIMITED AT PRICE TOYOTA IN DELAWARE. IN FEBRUARY 2009 I OBSERVED RUST THROUGH OF BRACKET FROM BED TO FRAME VISIBLE THROUGH REAR WHEEL WELL. REQUESTED THAT MY WIFE REPORT THIS TO LIBERTY TOYOTA IN NJ DURING ROUTINE 5000 MILE OIL CHANGE. SHE WAS TOLD THAT THIS WAS "NOT A PROBLEM". (2). IN SEPTEMBER 2009 TRUCK WAS AGAIN TAKEN TO LIBERTY TOYOTA FOR 5000 MILE OIL CHANGE, PURCHASE OF 5 NEW TIRES AND ALIGNMENT. LIBERTY TOYOTA SERVICE TOLD MY WIFE THAT THE TRUCK WAS RUSTED TO THE POINT WHERE THEY COULD NO LONGER ALIGN THE VEHICLE AND NO SERVICE WAS PERFORMED. LIBERTY TOOK PHOTOS OF THE UNDERSIDE OF THE TRUCK AND TRANSMITTED THEM TO TOYOTA. APPROXIMATELY TWO WEEKS LATER LIBERTY TOLD MY WIFE THAT TOYOTA'S POSITION WAS THAT BECAUSE OF THE AGE AND MILEAGE (9 YEARS AND 110,000 MILES ) THAT THEY WOULD DO NOTHING TO RESOLVE THIS ISSUE. (3). IN LATE SEPTEMBER 2009 I PURCHASED A 2006 TOYOTA TUNDRA CREW CAB 4 DOOR TUNDRA LIMITED AS A REPLACEMENT VEHICLE FOR MY WIFE A TOYOTA RUNNEMEAD, NJ. ON THAT SAME OCCASION THE 2000 TUNDRA WAS PUT ON LIFT AND INSPECTED WITH A POWERFUL LIGHT. OBSERVED VARIOUS RUST THROUGH OF BRACKETS AND AT LEAST ONE FIST SIZED HOLE THROUGH THE FRAME. THIS WAS WITNESSED BY THE TOYOTA RUNNEMEADE SALES PERSON, GENERAL MANAGER, SALES MANAGER, AND SERVICE MANAGER. ALL AGREED THAT THIS WAS WORST CASE OF RUST THEY HAD SEEN, AND WERE OF THE OPINION THAT THE TRUCK WAS NOT SAFE TO OPERATE. (4). IN OCTOBER 2009 I CONTACTED TOYOTA CUSTOMER SERVICE AND RECEIVED A CASE NUMBER. A FEW DAYS LATER I AGAIN CONTACTED TOYOTA CUSTOMER SERVICE AND WAS TOLD THAT "TOYOTA IS STUDYING THE PROBLEM". THIS SOUNDED LIKE A STALL TACTIC AND GAVE ME LITTLE HOPE FOR ANY VOLUNTARY POSITIVE ACTION FROM TOYOTA. AS OF TODAY 11 NOVEMBER 2009 I HAVE HAD NO FURTHER CONTACT FROM TOYOTA. (5). I HAVE PURCHASED OR HELPED PURCHASE 5 TOYOTA TRUCKS FOR MY FAMILY. TOTAL EXPENDITURE APPROXIMATELY $150,000.

NHTSA complaint #10291237 — an unverified report by a vehicle owner.

EQUIPMENT

ON AN EXTREMELY COLD MORNING (-22DEG F) I STARTED MY 2000 TOYOTA TUNDRA ACCESS CAB V8 AND WENT TO TURN ON HEAT. THE TEMPERATURE NOB WOULD NOT TURN EASILY, BUT DID TURN, AND MADE A SNAPPING SOUND. THE HEAT NEVER CAME, THOUGH THE FAN DID WORK AND BLEW COLD AIR. I HAVE BEEN WORKING OVERSEAS AND NOT REQUIRING THE USE OF THE VEHICLE SINCE THIS INCIDENT, AND JUST FOUND THE CAUSE OF THE ERROR. THE CABLES FOR THE HEAT SELECTOR SEIZED AND THE DASH MECHANISM BROKE. AFTER READING MANY OTHER POSTS ON THIS MODEL, AND OTHER TOYOTA MODELS, THEY NEED TO REDESIGN THE CABLE, THE HEAT VALVE, THE METHOD THE CABLE IS SECURED AND ENSURE THAT WATER IS NOT PENETRATING THE CABLE. THE RESULTING PROBLEM IS OFTEN NOT CORRECTED PROPERLY BY THE DEALERS. I EXPECT THAT THIS PROBLEM WILL COST AT A MINIMUM OF $300 FOR THE DASH MECHANISM, $20 FOR EACH CABLE THAT MAY NEED TO BE REPLACED PLUS LABOR COSTS, MORE IF IT IS NOT CORRECTED PROPERLY THE FIRST TIME.

NHTSA complaint #10185397 — an unverified report by a vehicle owner.

TRAILER HITCHES

DT: THE CONTACT STATED NHTSA RECALL 02V050000 CONCERNING THE TRAILER HITCH WAS ISSUED. THIS VEHICLE MANIFESTED THE SAME PROBLEM AS INDICATED IN THE RECALL, BUT THE DEALER REFUSED TO MAKE REPAIRS BECAUSE THE VEHICLE WAS PREVIOUSLY IN A WRECK. THE CONTACT DID NOT UNDERSTAND THIS EXCLUSION BECAUSE THE VEHICLE ONLY SUSTAINED DAMAGE TO THE FRONT END. IT WAS WRECKED BY THE PREVIOUS OWNER AND SOLD TO THE CONTACT BEFORE ANY REPAIRS WERE MADE. THE DEALER WHO REFUSED TO SERVICE THE RECALL WAS THE SAME DEALER WHO SOLD THE VEHICLE TO THE CONTACT AFTER THE ACCIDENT.

NHTSA complaint #10142254 — an unverified report by a vehicle owner.

TRAILER HITCHES

RE; FOLLOW UP NOTIFICATION OF TOYOTA SAFETY RECALL NO. 02V-050. *BF

NHTSA complaint #10113789 — an unverified report by a vehicle owner.

EQUIPMENT

PROBLEMS WITH THE BRAKE INDICATOR LAMP ON THE DASH TURNING ON WHEN APPLY BRAKES. THE INDICATOR LIGHT BECOMES ACTIVE WHEN THE WEATHER REACHES A TEMPERATURE OF 32 DEGREE OR LOWER. I REPORTED THIS PROBLEM TO A TOYOTA DEALER WHEN THE VEHICLE WAS UNDER WARRANTY. TOYOTA FOUND NO PROBLEM AT THE TIME OF SERVICE. *NLM

NHTSA complaint #10049132 — an unverified report by a vehicle owner.

EQUIPMENT:APPLIANCE:AIR CONDITIONER

BRAKE VIBRATION AND EXCESSIVE BRAKE WEAR. BRAKES WERE SERVICED AT ABOUT 38,000 MILES DUE TO SEVERE VIBRATION WHEN BRAKING. PROBLEM RETURNED AFTER A COUPLE OF WEEKS. BRAKES REPLACED AGAIN AT 68,000 MILES AND VIBRATION HAS AGAIN RETURNED. THERE IS A VIBRATION AND ROUGH BRAKING WHEN SLOWING DOWN FROM HIGHWAY SPEEDS.

NHTSA complaint #10030333 — an unverified report by a vehicle owner.

EQUIPMENT:APPLIANCE:AIR CONDITIONER

THE VEHICLES BRAKE ROTORS AND DRUMS WERE WARPED AND CAUSED EXTENDED STOPPING DISTANCE WHEN BRAKING. *NLM THERE WAS A VIBRATION WHEN BRAKING, THE TIRE SEEMED TO BE WORN ON THE INSIDE, THE A/C MADE A NOISE WHEN TURNED ON HIGH, AND THE FRONT SEAT BELT DID NOT RETRACT AT TIMES. *SCC

NHTSA complaint #10025119 — an unverified report by a vehicle owner.

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

WHILE DRIVING, CONSUMER CAN SMELL EXHAUST FUMES COMING THROUGH CAB OF VEHICLE. HAVE YET TO CONTACT DEALER. *AK THE CONSUMER WAS COMPLAINING ABOUT ROAD NOISE WHILE HE WAS DRIVING. ALSO THE RADIO WAS OF NO USE BECAUSE HE CAN?T HEAR WHEN THE VEHICLE SPEED WAS ABOVE 40 MPH.

NHTSA complaint #8003635 — an unverified report by a vehicle owner.

TRAILER HITCHES

CONSUMER RECEIVED RECALL NOTICE 01E041000, AND TOOK VEHICLE IN FOR REPAIRS. BUT DEALER STATED PART WAS NOT IN, ALSO DEALER DID NOT CONTACT CONSUMER TO LET HER KNOW WHEN PART WOULD BE IN, AND CONSUMER COULD CALL TO CHECK ON PART . DEALER TOLD CONSUMER TO BRING VEHICLE IN. WHEN CONSUMER TOOK VEHICLE IN, DEALER STATED IT DID NOT NEED PART. *AK

NHTSA complaint #899027 — an unverified report by a vehicle owner.

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

BED IS OFF-CENTER.

NHTSA complaint #738464 — an unverified report by a vehicle owner.

EQUIPMENT:MECHANICAL:CARRIER/RACK

SPARE TIRE RELEASED WHILE VEHICLE WAS IN MOTION AT APPROXIMATELY 55 MPH AND TOWING 5TH WHEEL, CAUSING DAMAGE TO RV TRUCK. COMPLETE ASSEMBLY THAT HOLDS SPARE TIRE HAS ALSO FALLEN OUT, THE ONLY PART LEFT WAS CRANK. THEREFORE DEALER COULD NOT DETERMINE CAUSE.

NHTSA complaint #869240 — an unverified report by a vehicle owner.