2000 Toyota Tundra transmission problems

POWER TRAIN

MY FRAME IS RUSTED ON MOST IN TO AN I NO YALL HAD A RECALL BUT I DON'T KNOW IF ITS STALL GOOD FOR THIS TRUCK

NHTSA complaint #11408327 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE THE BRAKE PEDAL WAS DEPRESSED TO THE FLOORBOARD, THE VEHICLE FAILED TO STOP. THE VEHICLE WAS PLACED INTO NEUTRAL IN ORDER TO BE STOPPED. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND NOTICED THAT THE FRAME WAS RUSTED. THE CONTACT ALSO MENTIONED THAT THE SHIFTER WAS NOT FUNCTIONING PROPERLY. THE CONTACT MENTIONED THAT THE GEAR SELECTOR WOULD NOT MOVE TO THE DESIRED GEAR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SAFE TO DRIVE DUE TO THE RUST, AND THAT THE BRAKE LINE AND SHIFTER CABLE NEEDED TO BE REPLACED. GRAHAM TOYOTA (1515 W 4TH ST, MANSFIELD, OH 44906, (419) 529-1800) WAS CALLED AND STATED THAT THE FRAME WAS PREVIOUSLY REPAIRED PER AN UNKNOWN RECALL. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 117,000.

NHTSA complaint #11270720 — an unverified report by a vehicle owner.

POWER TRAIN

THIS VEHICLE WAS PART OF AN EARLIER RECALL FOR CORROSION OF THE FRAME AND COMPONENT PARTS. TOYOTA REPLACED THE FRAME ALONG WITH A CORRODED LEAKING GAS TANK. APPROXIMATELY ONE WEEK AGO WE NOTICED AN OIL LEAK FROM OUR REAR DIFFERENTIAL. UPON INSPECTION BY OUR LOCAL MECHANIC HE DETERMINED THE REAR DIFFERENTIAL HOUSING IS CORRODED THIS CAUSING A LEAK. THIS VEHICLE IS KNOWN FOR ITS SEVERE CORROSION OF FRAME AND COMPONENT PARTS. WE DISCUSSED OUT CONCERNES OVER THE WIDE SPREAD CORROSION WITH CORPORATE TOYOTA WHEN THE FRAME WAS REPLACED. I CONTACTED CORPORATE TOYOTA YESTERDAY TO DISCUSS THE CURRENT ISSUE AND WAS TOLD THEY WOULD ONLY CONSIDER OUR CLAIM AFTER THE VEHICLE WAS INSPECTED BY A TOYOTA DEALER AT OUR COST. I WAS ALSO INFORMED THAT IT WAS VERY UNLIKELY THAT TOYOTA WOULD REPAIR THE VEHICLE BECAUSE OF THE AGE. THIS VEHICLE IS MECHANICALLY SOUND AND WE INTEND TO KEEP IT, HOWEVER THE CORROSION ISSUE IS PREMATURELY ENDING THE LIFE OF THE VEHICLE. I CONTACTED THE LOCAL TOYOTA DEALER AND WAS TOLD BY THE SERVICE MANAGER THAT THEY HAVE SEEN THIS ISSUE AND ADDRESS IT WITH SPRAY ON EPOXY TO STOP THE OIL LEAK. THEY COULD NOT CONFIRM THAT WOULD WORK ON OUR VEHICLE UNTIL THEY INSPECT IT. WE BELIEVE TOYOTA SHOULD INSPECT THE DAMAGE FREE OF CHARGE DUE TO THE KNOWN ISSUE THEY HAVE WITH CORROSION. THE BRAKE COMPONENT ATTACHED TO THE REAR DIFFERENTIAL ARE ALSO SHOWING EXCESSIVE CORROSION AND WE ARE CONCERNED THESE COMPONENTS WILL FAIL CAUSING AN ACCIDENT.

NHTSA complaint #11083297 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE FAILED TO ACCELERATE BEFORE AN UNKNOWN LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE CLEANED OUT. THE REPAIRS WERE MADE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 147,000. THE VIN WAS UNAVAILABLE.

NHTSA complaint #10721996 — an unverified report by a vehicle owner.

POWER TRAIN

NOV 2, 2011 I TOOK MY 2000 TUNDRA TO LARRY H MILLER PEORIA FOR A " ADF INSPECTION FRAME TUNDRA" THEY SAID THE RUST HAS NOT PERFORATED ANY METAL YET , THE INSPECTION PAPER DID NOT GET TO TOYOTA HEADQUARTERS STATING THE TRUCK HAS RUST BUT JUST NOT ENOUGH YET. I CALLED CUSTOMER SERVICE. THE LADY I SPOKE TO SAID THE RECALL WAS GOOD FOR 15 YEARS FROM THE TIME OF FIRST USE.(JAN 2001) NOW THEY ARE TELLING ME THAT MY TRUCK IS NOT PART OF THAT RECALL AND IT ENDED IN APRIL 2012. I WAS GIVEN 2 CASE NUMBERS FROM TOYOTA. ALL THE SERVICE REPS SAID YES MY TRUCK IS ELIGIBLE FOR THE REPLACEMENT FRAME. I WAS GIVEN A SPECIAL CASE MANAGER..HE ALSO ASSURED ME MY TRUCK IS GOOD FOR REPLACEMENT.. I RECEIVED A CALL TODAY FROM HIM WITH ALL THE INFORMATION , HE TOLD ME MY TRUCK WAS PART OF THE BUY BACK PROGRAM AT 1.5% OF KELLEY BLUE BOOK. I TOLD HIM I DID NOT WANT A BUYBACK FOR MY TUNDRA I WANTED IT REPAIRED. HE THEN SAID HE WAS SORRY HE THOUGHT MY TRUCK WAS A TACOMA NOT A TUNDRA HE PUT ME ON HOLD TO TALK WITH HIS SUPERVISOR TOLD ME SORRY , TOYOTA WILL NOT REPLACE THE FRAME BUT WILL GIVE ME A $ 2500 CREDIT AT A FRANCHISED TOYOTA DEALER FOR PARTS OR SERVICE... MY TRUCK IS UNSAFE TO DRIVE I HAVE APPROX 10 MARBLE SIZE HOLES IN THE FRAME. MOTOR AND TRANNY FINE ONLY 136000 MILES . I PAID 12,000.00 CASH FOR MY TRUCK I GOT IT WITH 56,000 MILES ON IT. TOYOTA TOOK RESPONSIBILITY STATING YES THE FRAMES ARE BAD...AND THEY WOULD FIX THE PROBLEM.. NOW THEY ARE NOT.

NHTSA complaint #10668194 — an unverified report by a vehicle owner.

POWER TRAIN

THIS VEHICLE HAD A RECALL BECAUSE OF THE EXCESSIVE RUSTING OF THE FRAME. I BROUGHT MY TRUCK IN MARCH OF 2013 AND WAS TOLD THE FRAME DIDN'T NEED TO BE REPLACED BUT ONLY NEEDED TO BE "UNDER COATED" WHICH THEY DID. SHORTLY THEREAFTER THIS "UNDERCOATING" STARTED PEELING OFF IN LARGE SHEETS. I BROUGHT THE TRUCK BACK TO HAVE IT INSPECTED AND THE LOCAL DEALERSHIP CONFIRMED THAT THERE WAS PERFORATION OF THE FRAME. THERE IS A HOLE IN THE FRAME APPROX. 2 INCHES IN DIAMETER. TOYOTA CALLED ME BACK AND I WAS TOLD THEY HAD DONE WHAT WAS REQUIRED FOR THE RECALL AND THEY WOULDN'T BE DOING ANYTHING ELSE. OBVIOUSLY THIS WAS A BIG ENOUGH CONCERN THAT A RECALL WAS DECLARED AND IT APPEARS THAT TOYOTA HAS TAKEN THE POSITION THAT AS LONG AS THEY MAKE A TOKEN EFFORT IT DOESN'T MATTER IF THEY CORRECT THE PROBLEM. I PULL A BOAT WITH THIS TRUCK AND AM NOW CONCERNED THAT IF THE FRAME FAILS IT COULD CAUSE A SERIOUS ACCIDENT.

NHTSA complaint #10660737 — an unverified report by a vehicle owner.

POWER TRAIN

TRUCK FAILED ANNUAL INSPECTION DUE TO EXTREME RUST OF FRAME AND CROSS MEMBERS TO THE POINT OF FRAME PERFORATION AND IMMINENT FAILURE. FRAME DIRECTLY UNDER DRIVER'S SEAT RUSTED THROUGH WHERE IT JOINS THE CROSS MEMBER UNDER THE TRANSMISSION. FRAME IN FRONT OF PASSENGER REAR TIRE EXTREMELY RUSTED WHERE IT JOINS THE CROSS MEMBER. THE INSPECTOR STATED THIS WAS A MORE IMMINENT CONCERN THAN THE RUSTED THROUGH PORTION UNDER THE DRIVER BECAUSE IT HAD A GOOD CHANCE OF BREAKING WITH THE NEXT POTHOLE. LEAF SPRINGS FOR DRIVERS REAR TIRE ALSO EXTREMELY RUSTED. REAR DIFFERENTIAL HOUSING RUSTED THROUGH ON THE TOP WITH OIL LEAKING OUT. EXHAUST HEAT SHIELDS AND HANGERS RUSTED AWAY COMPLETELY. THERE WAS NO MENTION OF THE REAR CROSS MEMBER OVER THE SPARE TIRE OR THE GAS TANK STRAPS BEING AN ISSUE. THEY COULD BE BUT WERE NOT THE IMMINENT CONCERN AT THIS POINT. I HAD JUST REPLACED THE RADIATOR/TRANSMISSION COOLER DUE TO RUSTING THROUGH AND ANTI-FREEZE ENTERING THE TRANSMISSION AND TRANSMISSION FLUID IN THE COOLING SYSTEM. THERE WERE OTHER ISSUES THAT ARE APPARENTLY COMMON WITH THE TUNDRA - LEAKING/CRACKED MANIFOLDS, ETC. THE TRUCK IS AT THE LOCAL DEALER PENDING REPAIR. TECHNICIAN STATED IT WAS THE WORST CASE OF UNDERCARRIAGE RUST HE HAD SEEN.

NHTSA complaint #10565727 — an unverified report by a vehicle owner.

POWER TRAIN

PREVIOUS COMPLAINT NOT CORRECT. TOOK VEHICLE TO TOYOTA NEWBURGH NY FOR SAFETY RECALL REPLACE FRAME WAS TOLD AT TIME HAD TO DO POWER STEERING AS LEAKING AND RUST AND ENTIRE COST I HAD TO PAY THOUGH COMPAIN STATES THEY ARE RESPONSIBLE OR THEY WOULDN'T PASS INSPECTION, I SHOWED THEM. NO OTHER CHOICE BUT TO DO & HOPE TO RECOUPE LATER, YEAH RIGHT. TRUCK WENT IN COMPLETE FRAME WAS DONE REMARKABLE FAST, OBVIOUS WHY, AS I DROVE HOME THE TRUCK HAD NOT BEEN PUT BACK ON FRAME CORRECT THAT WAS CLEAR TO THE EYE BUT DRIVING IT THE CHALLENGE TO REMAIN ON ROAD SAFE.THE DEALER NYS CERTIFIED INSP. SITE ALSO PASSED THIS VEHICLE. THE TRUCK HAS SO MANY MORE SAFETY ISSUES AFTER COMPLETION ITS A JOKE THANKS NHTSA. NOT TO MENTION THE MALFUNCTION OF MANY COMPONENTS THAT WORKED PRIOR, CALLED DEALER AND COMPLAINED, THEY ALSO INFORMED ME AS REPLACE BEING DONE THAT THE EXHAUST HANGING BY THREAD DUE TO RUST BRACKETS ETC THE COST TO REPAIR $6000.00 IF I BRING IT BACK THEY WILL SURELY VIOLATE ME AGAIN, I CANT AFFORD $/AGGRAV. NHTSA HAS DONE NOTHING FOR ME BUT THEY CONTINUE TO COMPAIN ON THE UTMOST IMPORTANCE WE AS CONSUMERS ARE THESE TRUCKS NEED BE TAKEN OFF THE ROAD. TOYOTA CORP. N DEALER LAUGHED WHEN I STATED CALLING NHTSA GO AHEAD THEY WONT DO ANYTHING, FILLED W TOYOTA CUSTOMER HOTLINE ANYWAY KNOWING THEY ARE IN BED WITH NHTSA. MY ? WHO & WHERE ARE THESE FINES BILLLIONS OF $ GOING, SURELY NOT TO THE OWNERS OF VEHICLES. MR. STRICKLAND I DARE U TO DO YOUR TAXPAYING JOB & GET ME N OTHERS RESULTS TAKE THESE AND ANY OTHER VEHICLES OFF THE ROAD BEFORE MY OR HEY MAYBE YOUR FAMILY IS INVOLVED IN FATALITY. ARE ROADS ARE NOT SAFE, THIS AGENCY IS FAILING EVERYONE THAT TRAVELS OVER THE ROAD. ANY ATTORNEY WILLING TAKE PRIVATE CASE I GOT DOCUMENTS N SOME [XXX] NHTSA STINKS BIG IN THIS WHO DO U REPRESENT WHO RU ACCOUNTABLE TO I WANT ANSWERS MR.STRICKLAND CONTACT INFO NOWHERE WHY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10492320 — an unverified report by a vehicle owner.

POWER TRAIN

THE STEEL FITTING IN THE RADIATORS TO TRANSMISSION COOLER RUSTED OFF, DUMPING ANTIFREEZE AND TRANSMISSION FLUID ON THE ROAD, IN DOING SO ANTIFREEZE GOT INTO THE TRANSMISSION AND TRANSMISSION FLUID GOT INTO THE ENGINE. COST OF REPAIRS $1150. NEXT THE REAR AXLE HOUSING RUSTED A HOLE IN. COST OF REPAIRS $1900. NEXT FRONT EXHAUST PIPES WITH CONVERTERS ARE RUSTED OUT A LEAKING EXHAUST.TOYOTA HAS A RECALL FOR RUST ON THIS TRUCK BUT DOESN'T COVER THESE PROBLEMS THAT ARE DANGEROUS

NHTSA complaint #10385288 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

TL* THE CONTACT OWNS 2000 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. WHILE ATTEMPTING TO START THE VEHICLE, THE CONTACT ALSO ATTEMPTED TO SHIFT INTO PARK AND THE GEAR SHIFTER FRACTURED IN HIS HAND. PRIOR TO THE FAILURE, THE CONTACT NOTICED THAT THE GEAR SHIFT SELECTOR WOULD NOT FULLY SHIFT INTO PARK. THE CONTACT STATED THE SHIFTER WAS RUSTED FROM THE INSIDE OF THE STEERING COLUMN. THE DEALER INSPECTED THE VEHICLE AND ADVISED THE CONTACT THAT THE FAILURE WAS CAUSED BY TWO COMPONENTS THAT WOULD NEED REPAIRS. THE CONTACT WAS UNABLE TO RECALL THE NAME OF THE COMPONENTS. THE MANUFACTURER WAS CONTACTED BUT WOULD PROVIDE NO ASSISTANCE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 180,000.

NHTSA complaint #10365788 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 45-50 MPH HE HEARD A LOUD NOISE AND THE LEFT REAR SPRING BROKE WHICH CAUSED THE VEHICLE TO STOP IMMEDIATELY. HE ENGAGED THE ACCELERATOR PEDAL AND HEARD ANOTHER LOUD NOISE AND COASTED THE VEHICLE INTO A PARKING LOT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER ADVISED HIM THAT IT WOULD BE 3 MONTHS BEFORE THEY COULD REPAIR HIS VEHICLE BECAUSE OF THE BACK LOG OF RECALLS. THE DEALER PERFORMED THE RECALL WORK ON HIS VEHICLE ON AUGUST 23, 2010; RECALL 09V444000, STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS. AS HE WAS DRIVING FROM THE DEALERSHIP HE ENGAGED THE BRAKES AND THE BRAKE PEDAL WENT TO THE FLOOR; HE INFORMED THE SERVICE MANAGER OF THE FAILURE. THE SERVICE MANAGER ADVISED THE TECHNICIANS TO CLEAN, ADJUST THE REAR BRAKES AND RELIEVE SOME TENSION ON THE PARKING BRAKE CABLE. THE FOLLOWING DAY THE DEALER ADVISED HIM THAT THE TRANSMISSION WAS FAILING AND NEEDED TO BE REPLACED. THE VEHICLE REMAINED AT THE DEALER WAITING FOR THE PARTS TO BE AVAILABLE. THE FAILURE MILEAGE WAS 102,168 AND THE CURRENT MILEAGE WAS 102,192.

NHTSA complaint #10353470 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE A 2000 TOYOTA TUNDRA AND IT HAS A PROBLEM THAT WHEN THE CAR GETS HOT THE ENGINE WILL STALL OUT AND DIE WITHOUT WARNING. IT CREATES NO OMD II ERRORS AND THE CHECK ENGINE LIGHT NEVER APPEARS. THE ECM FUSE BLOWS ON OCCASION BUT REPLACING IT DOES NOT LEAD TO A RUNNING VEHICLE. IT FAILS TO START UNTIL THE ENGINE COMPARTMENT COOLS DOWN. THERE IS FIRE FROM THE SPARK PLUGS AND THERE IS FUEL PRESSURE IN THE FUEL RAIL. WE HAVE REPLACED ALL THE RELAYS AND FUSES IN THE ECM AND EFI CIRCUITS AND ALL FINGERS ARE NOW POINTING TO THE ECM CONTROLLER ITSELF. WE JUST CHANGED OUT THE FUEL PUMP AND ARE LOOKING AT REPLACEMENT OF ALL THE IGNITION COILS (8) AND ALL THE FUEL INJECTORS (8). BUT SINCE ALL OF THESE COMPONENTS SEAM TO BE WORKING THAT WOULD MAKE LITTLE SINCE. THE RECENT RECALL FOR THE ECM ON THE MATRIX & COROLLA INDICATE THAT THERE MAY HAVE BEEN PROBLEMS WITH THE MANUFACTURE OF ECM UNITS FOR A MUCH LONGER PERIOD OF TIME SINCE MY TUNDRA IS EXHIBITING THE SAME PROBLEM. THIS PROBLEM HAS BEEN GETTING WORSE FOR OVER 5 YEARS NOW AND THE TOYOTA DEALERS AND OTHER TOYOTA SPECIALTY SHOPS CANNOT FIND THE PROBLEM SINCE THERE ARE NO ENGINE CODES AND THE FACT THAT IT WILL START AND RUN FINE AFTER IT COOLS DOWN. I HAVE BEEN WAITING FOR IT TO DIE AND NOT START AT ALL TO HOPE TO FIND THE PROBLEM.

NHTSA complaint #10352245 — an unverified report by a vehicle owner.

POWER TRAIN

I HAVE A 2000 TOYOTA TUNDRA WHICH HAS HAD NUMEROUS PROBLEMS WITH THE FRONT AND REAR BRAKES. THE FRONT BRAKES WERE "REPAIRED" WITHIN THE FIRST 4,000 MILES OF DRIVING BUT THE FRONT DISC ROTORS CONTINUE TO WARP WITHIN 10-15,000 MILES OF ADDITIONAL "REPAIRS". THE REAR BRAKES ARE FREQUENTLY BATHED IN OIL FROM LEAKING REAR-ED SEALS CAUSED, I'M TOLD, BY PLUGGED REAR-END VENTS. THE VENT HAS BEEN CLEANED OR REPLACED AND THE REAR SEALS REPLACED FIVE TIMES IN THE HISTORY OF THE CAR (NOW 109,000 MILES). THE BIAS BETWEEN THE BRAKES IS EXTREMELY FAVORING THE FRONT BRAKES AND THE ABS HAS NOT WORKED FOR SOME TIME. PANIC BRAKING, ESPECIALLY IN RAIN-SOAKED OR SNOW-COVERED SURFACES ENTIRELY IS ENTIRELY INSUFFICIENT AND DANGEROUS. I HAVE BEEN VERY DISAPPOINTED BY TOYOTA'S RESPONSIVENESS TO THESE PROBLEMS AND SEEMING INABILITY TO FIX THESE PROBLEMS. I'VE READ NUMEROUS SIMILAR COMPLAINTS FROM OTHER TUNDRA OWNERS. THIS IS A PERVASIVE, PERSISTENT AND LIFE-THREATENING DESIGN FLAW THAT IS, APPARENTLY, UNFIXABLE.

NHTSA complaint #10346646 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:CENTER SUPPORT BEARING

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE WOULD EXHIBIT EXCESSIVE SHAKING. THE DEALER STATED THAT THE VEHICLE NEEDED NEW TIRES. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR A SECOND OPINION AND THEN TAKEN BACK TO THE DEALER FOR FURTHER DIAGNOSTIC TESTING. THE DEALER STATED THAT THE DRIVESHAFT CENTER BEARING NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE FRAME WAS COVERED WITH SEVERE CORROSION AND RUST. THE FUEL TANK WAS BARELY ATTACHED TO THE VEHICLE. THE CONTACT REFERENCED NHTSA RECALL CAMPAIGN ID NUMBER 09V444000 (STRUCTURE: FRAME AND MEMBERS: UNDERBODY SHIELDS) BUT WAS UNABLE TO CONFIRM IF HIS VIN WAS INCLUDED IN THE RECALL. THE DRIVESHAFT CENTER BEARING WAS REPLACED BY THE DEALER WHO ALSO CLASSIFIED THE VEHICLE AS CONDEMNED. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.

NHTSA complaint #10328616 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

8/3/2009 - STEERING RACK LOST ALL FLUID WHILE DRIVING ON A HIGHWAY. ABLE TO MAINTAIN CONTROL, BROUGHT TO MECHANIC WHO REPLACED STEERING RACK. 09/08/2009 - FRONT BRAKE LINES CORRODED THRU AND LOST ALL BRAKE FLUID WHILE DRIVING,BROUGHT TO MECHANIC WHO REPLACED FRONT AND REAR BRAKE LINES AS ALL REQUIRED REPLACEMENT. 09/11/2009 - SHIFT CABLE FAILED (CORROSION) - ABLE TO GET OFF THE ROAD AND TOWED TO MECHANIC. FRAME AND UNDERBODY OF THIS TRUCK HAVE EXCESSIVE CORROSION WHICH LED TO THESE FAILURES. THE INTEGRITY AND SAFETY OF THIS VEHICLE IS QUESTIONABLE.

NHTSA complaint #10293725 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

AT 78,000 MILES THE TRANSMISSION BEGAN MAKING A NOISE AND VIBRATION THAT UPON FIRST IMPRESSION SOUNDED AND FELT LIKE RUNNING INTO A POTHOLE. THE TRUCK WOULD ALSO, INTERMITTENTLY FAIL TO GO INTO REVERSE GEAR. AFTER DROPPING THE TRANSMISSION PAN IT WAS DETERMINED THAT THE PAN HAD SEVERAL CLUMPS OF METAL SHAVINGS AND THE TRANSMISSION HAS TO BE REPLACED. THIS IS AN EGREGIOUS MECHANICAL FAILURE ON A VEHICLE WITH LOW MILEAGE AND WELL MAINTAINED.

NHTSA complaint #10283800 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE

I HAVE A 2000 TOYOTA TUNDRA THAT I BROUGHT IN 2005 WHEN I WAS IN NY. I HAVE MOVED TO CT SINCE. I WAS HAVING MY REAR BRAKES ADJUSTED 2 YEARS AGO WHEN MY MECHANIC TOLD ME THAT MY REAR END HOUSING WAS LEAKING GEAR OIL. I HAD TO REPLACE THE WHOLE REAR END HOUSING COSTING ME $1,500. LAST WEEK I WAS HAVING THE FRONT BRAKES REPLACED AND SAME MECHANIC TOLD ME THAT MY FRAME BEHIND THE DRIVER'S DOOR WAS RUSTED THROUGH. I KNOW THAT THE 2000 TACOMAS WERE INVOLVED IN A RECALL ABOUT RUSTED FRAMES. I ALSO KNOW THAT THE 2000 TUNDRA AND 2000 TACOMA HAVE THE SAME FRAME. I DON'T UNDERSTAND HOW TOYOTA CAN HAVE A RECALL FOR ONE MODEL AND NO RECALL FOR ANOTHER MODEL EITHER THOUGH BOTH MODELS HAVE THE SAME FAULTY PART?????????

NHTSA complaint #10276099 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLE WOULD STUTTER OR JERK OCCASIONALLY OVER A THREE WEEK PERIOD OF TIME/APPROX 500 MILES OF DRIVING. WHILE TURNING INTO DRIVEWAY VEHICLE SHUT DOWN AND WOULD NOT SHIFT OUT OF DRIVE. TORQUE CONVERTER WAS LOCKED UP REQUIRING A NEW TRANSMISSION.

NHTSA complaint #10269438 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

AT 80,000 MILES MY TRANSMISSION NEEDS TO BE REPLACED . I HAVE NEVER ABUSED THIS VEHICLE IN ANY FORM AND FEEL THAT TOYOTA SHOULD REIMBURSE THE MANY THOUSANDS OF OWNERS WHO SEEM TO BE HAVING THE SAME PROBLEMS WITH THIS MODEL. FOR THE AMOUNT OF MONEY THESE VEHICLES COST IT ONLY SEEMS FAIR THAT TOYOTA SHOULD BE FORCED TO STAND BEHIND THEIR PRODUCTS.

NHTSA complaint #10261894 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

THE TRANSMISSION OCCASIONALLY MADE A CLUNKING NOISE AND FELT LIKE THE TIRE HIT A SMALL POTHOLE IN THE ROAD WHEN SHIFTING INTO OVERDRIVE. THIS STARTED AROUND 80,000 MILES. I HAD THE TRANSMISSION FLUID CHANGED AND THE TRANSMISSION PAN DROPPED. THE PAN MAGNETS HAD MOSTLY SMALL METAL SHAVINGS BUT ALSO A FEW LARGER PIECES AROUND 1/4" LONG. NOW AT 85,000 MILES THE TRANSMISSION MAKES A VERY LOUD THUD NOISE AND SHAKES THE TRUCK VIOLENTLY EVERY TIME IT SHIFTS INTO OVERDRIVE. I AM FORCED TO KEEP THE TRUCK IN 3RD GEAR UNTIL I REACH THE FREEWAY AND THEN MUST PRESS THE O/D SWITCH TO SHIFT INTO 4TH GEAR/OVERDRIVE. MY MECHANIC WILL BE REPLACING THE TRANSMISSION NEXT WEEK AS HE HAS BEEN ON VACATION. I CANNOT BELIEVE THAT THE TRANSMISSION MUST BE REPLACED AT ONLY 85,000 MILES! I AM A CAREFUL DRIVER AND CONSCIENTIOUS ABOUT MAINTENANCE.

NHTSA complaint #10260016 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

2000 TOYOTA TUNDRA 2WD 4.7L V8 AUTOMATIC SR5 EXTENDED CAB 1. TRANSMISSION NOISE AND TRANSMISSION "BUMP" WHEN STARTING OUT FROM STOP. IT OCCURRED FROM APPROX 10,000MI (CURRENTLY 93,000 MI) 2. EVENTUAL COMPLETE FAILURE OF THE DEFECTIVE TRANSMISSION OVERDRIVE GEAR AND TRANSMISSION LOCKUP, LEADING TO SKID AND NEAR CRASH. 3. TOYOTA SERVICE PACKED GREASE IN U JOINT. ONLY SOFTENS BUMP AND NOISE FOR 100MI THEN BACK TO SAME PROBLEMS. REPAIR ESTIMATED AT $5000.00+.

NHTSA complaint #10243053 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

MY TOYOTA TUNDRA'S PLANETARY GEAR EXPLODED WITHIN THE TRANSMISSION AND DISABLE THE VEHICLE COMPLETELY. THE TRANSMISSION WAS IN OTHERWISE PERFECT CONDITION. IT LEFT ME STRAND ON 2 SEPARATE OCCASIONS WITHOUT ANY PRE-NOTICE THAT THE TRANSMISSION WAS HAVING ANY ISSUES.

NHTSA complaint #10214085 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

2000 TOYTA TUNDRA AUTOMTIC TRANSMISSION FAILURE.

NHTSA complaint #10213006 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

CHRONIC REAR AXLE SEAL LEAKAGE (LEAKS GEAR LUBE). DEALER HAS ATTEMPTED TO REPAIR MY PROBLEM 3 TIMES SINCE 2005. DEALER CANNOT REPAIR PROBLEM. THIS IS A KNOWN ISSUE WITH TOYOTA TRUCKS AND SUVS USING A SIMILAR REAR AXLE DESIGN. IT IS A FIRE HAZARD SINCE GEAR LUBE LEAKS ONTO HOT EXHAUST PIPING. IT IS A BRAKING HAZARD SINCE GEAR LUBE CONTAMINATES REAR BRAKES AND REDUCES BRAKING POWER. SEALS BEGIN TO LEAK EARLY IN LIFE OF VEHICLE BUT ARE NOT DEALT WITH UNTIL LEAK IS NOTED (AFTER SEALS HAVE BEEN LEAKING FOR SOME TIME) AND PROBLEM IS SEVERE.

NHTSA complaint #10210364 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING 55 MPH, THE GEAR SHIFT INDICATOR SLIPPED OUT OF GEAR AND INTO NEUTRAL. THE MECHANIC STATED THAT THE TRANSMISSION FAILED. AS OF OCTOBER 9, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CONTACT FELT THAT THE TRANSMISSION FAILED PREMATURELY. THE CURRENT AND FAILURE MILEAGES WERE 108,000. UPDATED 10/24/07.

NHTSA complaint #10205260 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

I BROUGHT MY TUNDRA IN FOR AN OIL CHANGE ONLY TO DISCOVER ALL THE GREASE FROM THE INSIDE OF THE RUBBER BOOTS COVERING THE AXLES ENDS HAS COMES OUT. THE RUBBER BOOTS HAD NOT FAILED AND THE CLAMPS WERE STILL INTACT. THE GREASE HAD MADE IT WAY PAST THE CLAMP. I HAD TO HAVE BOTH FRONT AXLES REPLACED AT 73,000 MILES.

NHTSA complaint #10200120 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

I BOUGHT MY TRUCK AND ABOUT THREE WEEKS AGO I WAS DRIVING ALONG WHEN IT DIED. ANYTIME I CAME TO A FULL STOP IT DIED. TURNS OUT IT'S THE TRANSMISSION AND A LOT OF OTHER PEOPLE HAVE HAD THE SAME PROBLEM. TOYOTA REFUSES TO ISSUE A RECALL ON THEIR PLANETARY GEAR EVEN THOUGH IT MALFUNCTIONS. THIS FAILURE CAUSED MY TRUCK TO STOP IN A BUSY INTERSECTION AND ALMOST KILLED ME.

NHTSA complaint #10198770 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL*THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE DRIVING 5 MPH, THE VEHICLE STOPPED ACCELERATING. THE DEALER STATED THAT THE SHIFT SOLENOID COULD BE THE CAUSE OF FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE OVERDRIVE GEAR CLUSTER WAS NOT WORKING PROPERLY. AS OF JUNE 27, 2007, THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE IS 145,000 AND FAILURE MILEAGE WAS 144,000.

NHTSA complaint #10194742 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

2000 TOYOTA TUNDRA SHIFT ASSEMBLY FAILURE**CC THE CONSUMER STATED THE SHIFT LEVER BROKE.

NHTSA complaint #10181585 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

DT*: THE CONTACT STATED THE SHIFT LEVER DISINTEGRATED OFF THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO DETERMINED THEY WOULD NEED TO REPLACE A BRACKET TO FIX THE SHIFT LEVER. THE VEHICLE WAS STILL AT THE DEALER AWAITING THE REPAIR WORK. THE CONSUMER STATED THE SHIFTER SHATTERED WITHOUT WARNING AND WAS UNABLE TO PLACE THE VEHICLE IN GEAR. UPDATED 12/18/06. *JB THE CONSUMER STATED THE PROBLEM WITH THE ACCELERATOR BEGAN IN SUMMER OF 2005. HE STARTED THE VEHICLE STEPPED ON THE ACCELERATOR AND NOTHING HAPPENED. HE THEN DEPRESSED THE ACCELERATOR PEDAL TO THE FLOOR AND THE TRUCK LUNGED FORWARD. ONLY BY CAREFULLY PUMPING THE GAS PEDAL UP AND DOWN WAS HE ABLE TO ATTAIN APPROXIMATELY 40 MPH. THE SEARCHED THE INTERNET TO SEE IF OTHERS HAD EXPERIENCED THE PROBLEM. WITHIN IN A SHORT PERIOD OF TIME, HE FOUND SOMEONE ELSE WHO EXPERIENCED THE SAME PROBLEM. IT WAS CAUSED BY A LOOSE CONNECTION WHERE THE ACCELERATOR PEDAL POSITION SENSOR WIRE CONNECTS TO ITS FEMALE CONNECTOR. WHICH WAS LOCATED ON TOP OF THE ENGINE. THE CONSUMER LOOKED AT THE CONNECTOR AND IT SEEMED CONNECTED. HE PUSHED THE CONNECTOR DOWN HARD AND TO HIS ASTONISHMENT IT CLICKED INTO PLACE. WHICH SOLVED THE PROBLEM. THE CONSUMER STATED TWO YEARS LATER, THE SAME PROBLEM PRESENTED ITSELF AGAIN. ONCE HE ARRIVED HOME, HE CLICKED THE ELECTRICAL CONNECTOR SECURELY IN PLACE. HE USED SOME COPPER ELECTRICAL WIRE AND WIRED THE CONNECTOR FIRMLY IN PLACE. THE CONSUMER STATED HIS BEST GUESS TO THE PROBLEM WITH THE CONNECTOR: WAS THE DESIGN OF THE PLASTIC WAS FAULTY. THE PLASTIC TAB WASN'T LARGE ENOUGH TO HOLD IT SECURELY IN THE SOCKET AND OVER TIME, ROAD VIBRATION CAUSED IT TO COME LOOSE. ALSO, THE STARTER FAILED. UPDATED 03/08/10

NHTSA complaint #10174197 — an unverified report by a vehicle owner.