2001 Volkswagen Beetle engine problems

ENGINE AND ENGINE COOLING

The contact owns a 2001 Volkswagen Beetle. The contact stated that there was an abnormal exhaust odor inside the cabin of the vehicle. The contact stated that the odor was abnormally strong. The contact stated that exhaust fumes were entering the vehicle through the vents. The contact stated that the check engine warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. Additionally, the contact stated that the rear latch for the hatchback was not locking securely and was also allowing exhaust fumes inside the vehicle. The manufacturer was informed of the failure. The contact researched online and related the failure to Manufacturer Emissions Recall Circular Code: WA000 Reprograming of Engine Control Module and Replacement of Oxygen Sensor (Engine and Engine Cooling). The failure mileage was approximately 70,000.

NHTSA complaint #11631272 — an unverified report by a vehicle owner.

ENGINE

A HUGE AMOUNT OF 2.0L ENGINES (1998-2006) SEEM TO STALL WHEN DRIVING OR STATIONARY AFTER 20 MIN FROM COLD START IN HIGH TEMPS (+75F) . LOSS OF POWER STEERING AND POWER ASSIST BRAKES. IT HAPPENED TO ME 2X WHILE DRIVING 45 MPH. SCARY. DEALERS AND MECHANICS CAN'T LOCATE ISSUES BECAUSE ITS INTERMITTENT. CARS OPERATE NORMAL AGAIN AFTER 10-20 MINS. SEE HTTP://NEWBEETLE.ORG/FORUMS/2-0-LITER-GAS/139065-HOT-WEATHER-STOP-GO-CAR-STALLS-DANGEROUS-2.HTML#POST1508562 FOR A LIST OF DIFFERENT SITES ALL LISTING SIMILAR ISSUES. APPARENTLY, AND ACCORDING TO MY RESEARCH, THE ISSUE STOPPED ON MODEL YR 2007 AND HIGHER.

NHTSA complaint #11091934 — an unverified report by a vehicle owner.

ENGINE

I READ THE RECALL ANNOUNCEMENT IN THE PAPER (NHTSA 17V-509, VW 20AE) REGARDING THE FUEL PUMP CUT OUT. I HAVE COMPLAINED TO VW A NUMBER OF TIMES OVER THE YEARS THAT MY VW ENGINE STOPS WHEN DRIVING BETWEEN 55 AND 65 MPH. THE SERVICE WRITERS RESPONSE WAS THAT THE FUEL PUMP NEEDS TO BE REPLACED - A $1000 ITEM. OTHER MECHANICS THAT I'VE ASKED HAVE SAID THAT IF THAT WAS THE CASE THE ENGINE WOULD NOT GET FUEL AND NOT WORK AND THAT IT WAS PROBABLY SOMETHING ELSE. WHEN I READ THE SYMPTOMS REPORTED IN 20AE, THEY WERE EXACTLY WHAT I HAVE EXPERIENCED MANY TIMES, BUT NOT CONSISTENTLY. AT 65 MPH WHEN THE ENGINE CUTS OUT, THE DECELERATION IS ALMOST IMMEDIATE TO 50 MPH. THE SYMPTOMS STARTED ABOUT 8-10 YEARS AGO. I HAVE NOT DRIVEN THE CAR ON THE FREEWAY SINCE BECAUSE I WAS NEARLY RUN OVER BY A CEMENT TRUCK. THE ARTICLE I READ SAID THAT NO KNOWN CRASHES OR INJURIES WERE CAUSED BY THE PROBLEM. PLEASE CONSIDER EXPANDING THE INVESTIGATION TO INCLUDE THE 2001 NEW BEETLE TO SEE IF THERE WERE ANY SERIOUS INJURIES DUE TO THIS ISSUE. I BELIEVE MY ISSUE IS EXACTLY THE SAME AS THE ISSUE REPORTED IN THE PRESS.

NHTSA complaint #11022212 — an unverified report by a vehicle owner.

ENGINE

DRIVING DOWN THE ROAD ON 3 DIFFERENT MY OCCASIONS CAR OVERHEATED NOW IT WON'T START.

NHTSA complaint #11000801 — an unverified report by a vehicle owner.

ENGINE

CAR WAS ILLEGALLY REPOSSESSED (I OWN THE VEHICLE BUT USED IT AS COLLATERAL IN A SMALL LOAN) NOVEMBER 29, 2016 WHILE I WAS IN ANOTHER STATE. I THEN RECEIVED A EMAIL FROM CARFAX THAT THE ODOMETER WAS CHANGED AND GAVE ME THE NEW MILEAGE. I PURCHASED THE CAR IN MARCH OF 2015 AND THE MILEAGE WAS OVER 155,000 MILES BUT NOW IT REPORTS 124, 685 MILES WHICH IS NOT AN ERROR BUT INTENTIONAL AND OBVIOUS ODOMETER FRAUD! I HAVE ATTACHED SEVERAL PHOTOS SHOWING THE DEALERSHIP WEBSITE'S LOG OF MILEAGE WHEN I BOUGHT IT, THE PICTURE OF MY ODOMETER AS OF OCTOBER 2015 (WHEN IT WAS NO LONGER ABLE TO DRIVE DUE TO OIL LEAK FROM VALVE COVER), AND THE EMAIL SCREENSHOT FROM CARFAX SHOWING THE ODOMETER FRAUD. THE NEW OWNERS OF THE VEHICLE ARE PETER LANDRY OF FOR FINANCIAL IN DONALDSONVILLE, LOUISIANA 225 473 7652

NHTSA complaint #10940189 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN BEETLE. WHILE DRIVING AT APPROXIMATELY 35 MPH, ALL THE GAUGES DROPPED TO ZERO AND FAILED TO FUNCTION. IN ADDITION, THE TEMPERATURE AND OIL WARNING LIGHTS ILLUMINATED. THE CONTACT MENTIONED THAT THE TEMPERATURE WARNING LIGHT REMAINED ILLUMINATED, BUT THE OIL WARNING LIGHT WAS NOT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

NHTSA complaint #10764279 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 55 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SPROCKET FRACTURED AND CAUSED THE TIMING BELT TO FRACTURE. IN ADDITION, THE WATER PUMP FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. IN ADDITION, WHILE DRIVING AT ANY SPEED, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE ALTERNATOR ASSEMBLY. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14E007000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS REPAIRED BY THE DEALER TWICE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

NHTSA complaint #10735160 — an unverified report by a vehicle owner.

ENGINE

I AM THE 2ND OR 3RD THIRD OWNER, AND I SHOULD HAVE CHECKED THIS CAR OUT FURTHER, SINCE WHOMEVER ('S) SOLD IT TO ME DIDN'T TELL ME A [XXX] THING WAS WRONG WITH THE CAR. I AM SO DISGUSTED ABOUT THIS INCIDENT OF BUYING BASICALLY A LEMON FROM DISHONEST CREEPS. I ONLY DROVE IT ONCE BEFORE I HANDED OVER EVERY HARD EARNED PENNY I HAD SAVED OVER SUCH A LENGTHY TIME DUE TO THE FACT I AM A STRUGGLING SINGLE MOTHER. I DON'T GET CHILD SUPPORT NOR WELFARE, THANK YOU! I PAID ALL I HAD LITERALLY EVER SAVED UP EVER IN MY WHOLE LIFE. (YES I AM THAT POOR TO BE QUITE FRANK) I PAID $4500 FOR A 2001 VW NEW BEETLE. I HAVE ALWAYS ONLY EVER HEARD EXCELLENT THINGS OF VW'S, THERE FOR I JUST PRAY AND WISH THAT VW WOULD HELP!!!!!!!!!!!! NOW I AM WITHOUT TRANSPORTATION TO GET TO AND FROM WORK, AS WELL AS MY CHILDREN TO AND FROM SCHOOL. I CAN'T EVEN DRIVE TO GET GROCERIES OR ANYTHING! HELP!! WHY CAN'T VW AT LEAST PAY TO HAVE IT FIXED? I AM JUST TO POOR. I AM LOOKING INTO A LAW SUIT. DISHONEST VW, WHY CAN'T YOU JUST BE HONEST AND FIX YOUR ERROR AND WRONG DOING? THEY SELL THESE BEETLES KNOWINGLY TO INNOCENT TRUSTING FAMILIES, SINGLE MOMS, ETC: ETC;, AND THAT ALONE I BELIEVE SHOULD BE GROUNDS ENOUGH FOR A HELL OF A LAW SUIT. THEY KNOWINGLY PUT WOMEN, CHILDREN, AND INNOCENT PEOPLE'S LIVES IN SERIOUS DANGER WITH NO CONSCIENCE WHAT SO EVER. BUYING A VW IS LIKE PLAYING RUSSIAN ROULETTE. FOR YOU, YOUR CHILDREN, YOUR FAMILY, LOVED ONES AND FRIENDS. [XXX] EVEN INNOCENT BY STANDERS AND PASSER BYES. FIX MY BEETLE EVIL CREEPS. MAY GOD DEAL WITH YOU EVENTUALLY EITHER WAY AMEN! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #10690293 — an unverified report by a vehicle owner.

ENGINE

CONTINUE OVER HEATING BLOWING HEAD TWICE ENGINE LIGHT STAY ON BRAKE LIGHTS ON LEFT SIDE DON'T WORK ALARM WONT LOCK LEFT SIDE DOESN'T WORK AND BACK SEAT IS TOTALLY UNSAFE FOR KIDS. FRONT IS VARY UNSTABLE IT FEEL LIKE IT GOING TO FALL OFF TO LOW TO THE GROUND , ETC......IT GOES ON AND ON.

NHTSA complaint #10549694 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

AUTOMATIC TRANSMISSION HAS PROBLEM AND SOMETIMES WHILE DRIVING DOES NOT ADVANCES, THIS COULD BE A SAFETY ISSUE.

NHTSA complaint #10456377 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

THROTTLE BODY GOES OUT (02-03-2009) CV AXEL GOES OUT (03-31-2009 BRAKE LIGHTS GO OUT (02-18-2010) CV AXEL GOES OUT AGAIN (4-31-2010) ALTERNATOR GOES OUT (06-21-2010) IGNITION COILS FAIL (09-13-2010) IGNITION COILS FAIL AGAIN(01-21-2011) BRAKE SWITCH REPLACED AGAIN (01-21-2011) AIR FLOW SENSOR FAILS (01-21-2011) AIR FLOW SENSOR FAILS AGAIN (07-26-2011) TIMING BELT REPLACED (06-15-2011) THERMOSTAT REPLACED (06-15-2011) WATER PUMP REPLACED (06-15-2011) NOW HAVING PROBLEMS WITH THROTTLE BODY/ THROTTLE BODY SENSOR/ ELECTRICAL ISSUE. DEALER IS NOT SURE WHAT THE PROBLEMS IS AND WANTS TO THROW MONEY AT IT TO SEE WHAT THE PROBLEMS IS. THIS CAR IS JUST ONE PROBLEM AFTER ANOTHER AFTER ANOTHER.

NHTSA complaint #10435729 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

2001 VW BEETLE. FROM THE VERY BEGINNING, IT HAS BEEN NOTHING BUT PROBLEMS. FOR THE FIRST FEW YEARS IT WAS COVERED UNDER THE WARRANTY, FREE OF CHARGE REPAIRS. I HAVE LOW MILEAGE SO I THOUGHT THAT BY THE TIME THESE ITEMS WERE REPAIRED IT WOULD BE FINE WHEN THE WARRANTY EXPIRED. THERE IS ALWAYS SOMETHING WRONG WITH THE CAR AND IN PARTICULAR THE ELECTRICAL SYSTEM. THE CHECK ENGINE LIGHT IS ALWAYS GOING OFF. THE SAFETY ISSUE COMES IN WITH ITS CURRENT PROBLEM. I HAD A FUEL INJECTION FLUSH WHICH INCLUDED THE CARBON DEPOSITS REMOVAL KNOWN AS INDUCTION, AIR FILTER REPLACED, ENGINE FUEL FILTER REPLACED, AND A BRAKE FLUID FLUSH PLUS 4 NEW SPARK PLUGS. PRIOR TO THIS SERVICE, MY CAR WAS HAVING DIFFICULTY STARTING WITH MAJOR SHAKING. I HAD TO PUT MY FOOT ON THE ACCELERATOR TO GET IT GOING WHILE STARTING. NOW AFTER THE SERVICE IT RUNS MUCH BETTER BUT THE PROBLEM IS THAT NOW STALLS WHEN I COME TO A TRAFFIC LIGHT AND STOP FOR A PERIOD OF TIME. THIS IS EXTREMELY DANGEROUS. THE OTHER MALFUNCTIONS THAT HAVE HAPPENED OVER THE YEARS ARE AN EXPENSE BUT IT WAS SOMETHING THAT I COULD SOMEHOW MANAGE. THIS IS INCREDIBLY DANGEROUS. I HAVE NO CONTROL OVER TRAFFIC LIGHTS AND THE GENERATOR COMES ON WHEN I STOP, IT IS WORSE WHEN THE LIGHT CHANGES FAST AND THEN I HAVE TO STOP EVEN MORE SUDDENLY. IMAGINE IF I AM ON THE HIGHWAY AND IT STOPS. THIS HAS HAPPENED ONCE, A FEW WEEKS PRIOR TO THE CLEANING SERVICE. NOW, I AM AFRAID TO DRIVE THAT VEHICLE. I HAVE LOOKED ONLINE AT MESSAGE BOARDS FROM OTHER VW BEETLE OWNERS AND HAD READ SIMILAR STORIES OF SUCH DISSATISFACTION, INCREDIBLE FINANCIAL EXPENSE WITH THE ELECTRICAL SYSTEM AND OTHER COMPONENTS OF CARS. I HAVE EVEN READ THAT THESE CARS CAN BECOME INFLAMED , NECESSITATING THE FIRE DEPT. TO PUT IT OUT. THIS IS A LEMON AND SO MANY OTHER VW OWNERS HAVE WRITTEN SIMILAR ACCOUNT MESSAGE BOARDS. THE CONSUMER STATED THE OXYGEN SENSOR AND MASS AIR FLOW SENSOR HAD TO BE REPLACED. ALSO, THE EPC LIGHT ILLUMINATED. UPDATED IVOQ 07/07/11. *JB

NHTSA complaint #10410335 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

2001 VW BEETLE. FROM THE VERY BEGINNING, IT HAS BEEN NOTHING BUT PROBLEMS. FOR THE FIRST FEW YEARS IT WAS COVERED UNDER THE WARRANTY, FREE OF CHARGE REPAIRS. I HAVE LOW MILEAGE SO I THOUGHT THAT BY THE TIME THESE ITEMS WERE REPAIRED IT WOULD BE FINE WHEN THE WARRANTY EXPIRED. THERE IS ALWAYS SOMETHING WRONG WITH THE CAR AND IN PARTICULAR THE ELECTRICAL SYSTEM. THE CHECK ENGINE LIGHT IS ALWAYS GOING OFF. THE SAFETY ISSUE COMES IN WITH ITS CURRENT PROBLEM. I HAD A FUEL INJECTION FLUSH WHICH INCLUDED THE CARBON DEPOSITS REMOVAL KNOWN AS INDUCTION, AIR FILTER REPLACED, ENGINE FUEL FILTER REPLACED, AND A BRAKE FLUID FLUSH PLUS 4 NEW SPARK PLUGS. PRIOR TO THIS SERVICE, MY CAR WAS HAVING DIFFICULTY STARTING WITH MAJOR SHAKING. I HAD TO PUT MY FOOT ON THE ACCELERATOR TO GET IT GOING WHILE STARTING. NOW AFTER THE SERVICE IT RUNS MUCH BETTER BUT THE PROBLEM IS THAT NOW STALLS WHEN I COME TO A TRAFFIC LIGHT AND STOP FOR A PERIOD OF TIME. THIS IS EXTREMELY DANGEROUS. THE OTHER MALFUNCTIONS THAT HAVE HAPPENED OVER THE YEARS ARE AN EXPENSE BUT IT WAS SOMETHING THAT I COULD SOMEHOW MANAGE. THIS IS INCREDIBLY DANGEROUS. I HAVE NO CONTROL OVER TRAFFIC LIGHTS AND THE GENERATOR COMES ON WHEN I STOP, IT IS WORSE WHEN THE LIGHT CHANGES FAST AND THEN I HAVE TO STOP EVEN MORE SUDDENLY. IMAGINE IF I AM ON THE HIGHWAY AND IT STOPS. THIS HAS HAPPENED ONCE, A FEW WEEKS PRIOR TO THE CLEANING SERVICE. NOW, I AM AFRAID TO DRIVE THAT VEHICLE. I HAVE LOOKED ONLINE AT MESSAGE BOARDS FROM OTHER VW BEETLE OWNERS AND HAD READ SIMILAR STORIES OF SUCH DISSATISFACTION, INCREDIBLE FINANCIAL EXPENSE WITH THE ELECTRICAL SYSTEM AND OTHER COMPONENTS OF CARS. I HAVE EVEN READ THAT THESE CARS CAN BECOME INFLAMED , NECESSITATING THE FIRE DEPT. TO PUT IT OUT. THIS IS A LEMON AND SO MANY OTHER VW OWNERS HAVE WRITTEN SIMILAR ACCOUNT MESSAGE BOARDS. THE CONSUMER STATED THE OXYGEN SENSOR AND MASS AIR FLOW SENSOR HAD TO BE REPLACED. ALSO, THE EPC LIGHT ILLUMINATED. UPDATED IVOQ 07/07/11. *JB

NHTSA complaint #10410335 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

WHILE BEETLE DRIVEN BY MY WIFE IT WILL JUST SHUT DOWN!!! IT WILL ONLY CRANK BACK ON ABOUT 30 MINUTES LATER! THIS IS VERY DANGEROUS BECAUSE IT WILL SHUT DOWN WHEREVER!!! I ALREADY SPEND 1350.00 DOLLARS. AND NOT YET FIXED! THE CAR HAS BEING PARK OUTSIDE OF MY HOUSE FOR LAS YEAR! AND STILL MAKING PAYMENTS ON IT!!!! DEALER WILL NOT DO ANYTHING!

NHTSA complaint #10361444 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

WHY DON'T YOU HAVE A CATALYTIC CONVERTER PROBLEM FOR THE 2001 VOLKSWAGEN BEETLE. THE COMPANY IS REPLACING THEM. I JUST HAD ONE INSTALLED AFTER HAVING THE ENGINE LIGHT INDICATE I HAD A PROBLEM.

NHTSA complaint #10342095 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

ENGINE AND TRANSMISSION OVERHEATING JUST A TERRIBLE CAR. WAX MATERIAL INTERIOR REMOVES EASILY WITH NAILS CHILDREN CAN EAT IT HAS CRAYOLA SMELL.SHOULD HAVE BEEN MADE OF PLASTIC OR VINYL. THIS WHOLE CAR SHOULD BE RECALL. EPC BRAKE SWITCH ALWAYS ON HAD IT REPAIRED 3 TIMES ENGINE LIGHT IS ALWAYS ON. BAD ELECTRICAL. INTERIOR AC LIGHT IS ALWAYS OFF. IN AND OUT OF MECHANIC.

NHTSA complaint #10307345 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

1. NORMAL DRIVING. 2. EXHAUST GAS RECIRCULATING (EGR) COOLER CONNECTING PIPE FRACTURES. THIS CAN OCCUR ANYWHERE BETWEEN 30,000 AND 120,000 MILES. THIS FRACTURE ALLOWS EXHAUST FUMES TO ENTER THE PASSENGER CABIN. AS OF NOW THE PART HAS NOT BEEN REPLACED, $178 DEALER ITEM. OLD PART WILL BE AVAILABLE UPON REQUEST.

NHTSA complaint #10299637 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN BEETLE. EVER SINCE THE VEHICLE WAS PURCHASED, THE MASS AIR FLOW SENSOR HAS BEEN REPAIRED 4 TIMES. WHEN THE VEHICLE WAS STARTED AND PLACED INTO FIRST GEAR, THE VEHICLE WOULD SHUTTER, STALL, AND THEN FAIL. A LOCAL TECHNICIAN STATED THAT THE MASS AIR FLOW SENSOR WAS FAILING AND THE VEHICLE WAS REPAIRED AT THE COST OF $350. THE MASS AIR FLOW SENSOR HAS BEEN REPLACED FOUR TIMES SINCE THE VEHICLE WAS PURCHASED. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 68,000 AND CURRENT MILEAGE WAS 69,900. UPDATED 02/05/09 *BF UPDATED 02/06/09.

NHTSA complaint #10253247 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE DRAIN PLUG IN THE OIL PAN LEAKS OIL. THE FAILURE OCCURRED BECAUSE THE PLUG IS HARD STEEL AND THE PAN THAT HOLDS THE OIL IS ALUMINUM. IF THE TECHNICIAN TIGHTENS THE NUTS TOO TIGHTLY ON THE DRAIN PAN, ALL OF THE OIL WILL LEAK OUT. THE DEALER PERFORMED A TEMPORARY REPAIR, BUT IT DID NOT WORK. THEY HAD TO REPLACE THE ENTIRE OIL PAN AND PLUG AT THE COST OF $360.78; THE FAILURE MILEAGE WAS 76,049. UPDATED 11-19-08 *BF UPDATED 11/20/08.

NHTSA complaint #10247560 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

DEFECTIVE PART. CATALYST FAILED ON OUR 2001 NEW BEETLE TURBO. THIS VEHICLE, FOR SOME REASON, WAS NOT OF WARRANTY EXTENSION FOR THIS ISSUE FROM 80,000 TO 120,000. WE DID NOT GET ANY NOTICE, AND, AS A RESULT, VW REFUSES TO REPLACE OUR CATALYST AS WE HAVE 85,000 MILES ON THE VEHICLE.

NHTSA complaint #10237207 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

THIS PROBLEM HAS BEEN A ON GOING PROBLEM FOR ABOUT 2 YEARS NOW, EACH TIME THIS HAPPENS YOU HAVE TO TAKE THE CAR TO THE VW DEALER ONLY TO GET SCREWED ,CHECK ENGINE LIGHT COMES ON CAR STARTS MISFIRING HAS NO POWER USES LOTS OF GAS STALLS RUNS RUFF . I AM AFRAID TO DRIVE THIS CAR ON THE FREEWAY IN HEAVY TRAFFIC FOR FEAR OF IT STALLING AND GETTING RAN INTO BY ANOTHER CAR ITS A PUBLIC ENDANGERMENT THESE CARS ARE. IN APRIL OF 2007 I HAD TO TAKE IT TO THE DEALER THEY GAVE IT A QUICK FIX COSTING 450.00 THE LAST TIME THEY TOLD ME I HAD A BAD FUEL INJECTOR THEY REPLACE IT . IT RAN FINE FOR A COUPLE OF MONTHS THEN IN NOV 15 2007 THE CAR STALLED AGAIN DAUGHTER LIMPED IT HOME THE CHECK ENGINE LIGHT WAS ON THE CAR WAS MISSING BAD IT WAS NIGHT AND GETTING CLOSE TO ZERO OUTSIDE . WE PARKED IT THIS TIME BECAUSE WE DID NOT HAVE THE MONEY TO FIX THE CAR IT HAS 53,000 MILES ON IT. I REFUSE TO TAKE IT TO ANOTHER VW DEALER , AND ALL VW OF AMERICA WILL SAY IS WE ARE SORRY FOR YOU TROUBLE BUT BECAUSE YOU ARE NOT THE FIRST BUYER OF THE CAR AND ARE THE SECOND BUYER OF THIS CAR THAT WAS A LEASE RETURN YOU ARE NOT ENTITLE TO THE 10 YEARS 100.000 MILE POWERTRAIN WARRANTY THAT COME WITH THE CAR. IF YOU ARE THE FIRST BUYER OF THE CAR. THEN THESE REPAIR WOULD BE COVERED . THE WEEK OF JAN 15 2008 WE TOOK THE CAR TO AN INDEPENDENT AUTO MECHANIC SHOP . I TOOK THEM 2 DAYS TO FIND THE PROBLEM THE MASS AIRFLOW SENSOR WAS BAD AND THE TPS SENSOR IS BAD IN ALL IT WILL TAKE 1,400.00 DOLLARS TO FIX THIS CAR. WE PAID FOR THE MASS AIRFLOW SENSOR TO BE REPLACED AND THE COST TO FIND THE PROBLEMS. THEN WE TOOK THE CAR HOME AND PARKED IT . IT STILL NEEDS THE TPS SENSOR REPLACED THAT WILL COST 1,000.00 AND THE CAR WILL BE DRIVABLE .

NHTSA complaint #10223100 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

THE CAR'S CHECK ENGINE LIGHT COMES ON VARIABLY, LOCAL MECHANIC CLAIMS AN OXYGEN SENSOR IS MALFUNCTIONING, AND ABLE TO CLEAR THE COMPUTER WARNING CHECK ENGINE LIGHT. VW SERVICE STATION CLAIMS CAN'T DIAGNOSE PROBLEM IF LIGHT IS OUT, HAVE TO WAIT TIL LIGHT IS ON AGAIN.

NHTSA complaint #10219372 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 70 MPH IN DRY CONDITIONS, THE TIMING BELT FAILED. THE CONTACT PULLED OFF THE ROAD AND HAD THE VEHICLE TOWED TO THE DEALER. THE OWNER'S MANUAL ADVISES THAT THE TIMING BELT SHOULD BE REPLACED AT 105,000 MILES. THE MANUFACTURER WOULD NOT REPLACE THE TIMING BELT BECAUSE THE VEHICLE WAS 500 MILES OUTSIDE OF THE WARRANTY. THE CONTACT STATED THAT THE VEHICLE HAS BEEN WELL MAINTAINED AND IS BELOW THE REPLACEMENT MILEAGE. THE CURRENT AND FAILURE MILEAGES WERE 100,575.

NHTSA complaint #10216286 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

2001 BRAND NEW BEETLE STARTED DEVELOPING STAINS ON THE SEAT FROM DAY ONE. BLUE JEANS AND DARK SWEATERS STAIN THE INTERIORS TO THAT COLOR EVERYTIME SOMEONE SITS DOWN IN THE CAR. THE THROTTLE BODY HAS GONE OUT THREE TIMES, COSTING ME OVER COUNTLESS DOLLARS IN REPAIR FEES AND IS NOW OUT FOR THE FOURTH TIME. CROWN VOLKSWAGEN IN TYLER, TX HAS REPAIRED IT EACH TIME, THE LONGEST REPAIR LASTING ABOUT FOUR MONTHS. THEY'VE PAID FOR THE REPAIR ONCE, BUT DO NOT PROVIDE ME WITH A REPLACEMENT RENTAL VEHICLE, REFUSE TO PICK UP THE PHONE DURING THE DAY OR RETURN PHONE CALLS, AND HAS COST ME TONS OF TIME AND MONEY TRAVELING FROM DALLAS TO TYLER TO CHECK ON THE CAR AND PICK IT UP. ONCE, I DROVE TWO HOURS FROM NACOGDOCHES, TX TO TYLER, TX ON THE SCHEDULED PICK UP DAY, HAVING TRIED TO CALL BEFORE LEAVING TOWN TO MAKE SURE IT WAS READY, ONLY TO FIND THAT THEY HADN'T GOTTEN TO THE CAR WHEN I ARRIVED. THIS HAPPENED TWICE DURING THE SAME REPAIR WHICH LASTED A COUPLE OF WEEKS. THEY HAVE BEEN UNCOOPERATIVE, AND THE CAR IS HORRIBLE. THE ARM REST BROKE ONE DAY AS I LIFTED IT, IT JUST FELL APART IN MY HANDS, THE INTERIOR COVERING ON THE DOORS AND DASHBOARD FLAKES OFF, THE SUNROOF BROKE NUMEROUS TIMES WHILE DRIVING OVER A RAILROAD TRACK TO GET TO WORK EVERYDAY. IT FINALLY JAMMED THE VISOR SO THAT IT NO LONGER WORKS. THE SEAT MOVING MECHANISMS NO LONGER WORK. THE AIRBAG IS IN CONSTANT MALFUNCTION, THE CHECK ENGINE AND EPS LIGHTS ARE ALWAYS ON. I CONSTANTLY HAVE TO PULL MY CAR OVER ONTO THE SIDE OF THE ROAD BECAUSE IT LOSES POWER AND I HAVE TO RESTART IT TO GET IT TO WORK AGAIN, ALTHOUGH IT NEVER HAS A LOT OF POWER. THIS PARTICULAR ISSUE HAS NEARLY CAUSED SEVERAL WRECKS. I AM INCREDIBLY LUCKY. THE CRUISE CONTROL NO LONGER WORKS, AND IT TAKES ABOUT 200 DOLLARS A MONTH TO FILL IT UP WITH GAS BECAUSE THE ENGINE PROBLEMS EFFECT THE FUEL EFFICIENCY.

NHTSA complaint #10208211 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

THE TOP OF THE OIL DIPSTICK ON MY 2001 VW BEETLE IS APPARENTLY VERY FRAGILE AND COULD COME OFF BY ITSELF, POSSIBLY LODGING ITSELF INTO ANOTHER PART OF THE MOTOR AND CAUSING A DANGEROUS SITUATION. IT DISAPPEARED DURING PREVENTIVE MAINTENANCE AT DOVER VOLKSWAGEN, INC. IN DOVER, DELAWARE. THEY CLAIMED THEY DID NOT BREAK IT.

NHTSA complaint #10207377 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

EPC LIGHT CAME ON NUMEROUS TIMES, CAUSING THE ENGINE POWER TO BE REDUCED GREATLY. THE LIGHT WAS NEVER CONSTANT IT WOULD COME ON AT RANDOM TIMES. BROUGHT TO DEALER 6/13-6/15. ENGINE FAILED ON 6/16 DUE TO A COOLANT COMPONENT FAILURE. NEW ENGINE PUT IN, I HAD TO PAY $1,360 EVEN THOUGHT STILL UNDER WARRANTY. VEHICLE WAS PICKED UP 7/9. EPC LIGHT ON AGAIN THE NEXT WEEK, BROUGHT BACK TO DEALER, WHEN I WENT TO PICK IT UP THE LIGHT WAS STILL ON ACCOMPANIED BY THE CHECK ENGINE LIGHT AND THE CAR WAS BARELY RUNNING, IT SOUNDED LIKE IT WOULD STALL OUT AT ANY MINUTE. CAR WAS PICKED UP A FEW DAYS LATER. EPC AND CHECK ENGINE LIGHT ON AGAIN ON 9/11 BEFORE BRINGING IT TO THE DEALER I HAD MY BROTHER LOOK AT IT, HE STATES ITS A PROBLEM WITH THE THROTTLE, THE SAME PROBLEM AS ALL THE OTHER TIMES. I BROUGHT THE CAR TO DEALER ON 9/13 AND STILL WAITING FOR REPAIRS.

NHTSA complaint #10203398 — an unverified report by a vehicle owner.