Owners have filed 115 complaints
about the 2012 Volkswagen Routan with NHTSA between 2013 and 2024.
The largest single group is the electrical system.
Across this model's run it ranks 4 of 4 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 19
Against the median year of the Volkswagen Routan. 50 means typical for this
model; 100 means roughly double.
Severity — 22
4.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 29
17% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2012 compares with every other Volkswagen Routan
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
56.2%
10,000 – 24,999 miles
911.1%
25,000 – 49,999 miles
44.9%
50,000 – 74,999 miles
1923.5%
75,000 – 99,999 miles
2024.7%
100,000 – 149,999 miles
1518.5%
150,000+ miles
911.1%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Configuration
Overall
Front
Side
Rollover
2012 Volkswagen Routan VAN FWD
—
—
—
16.4% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
May 2013peak 8Jul 2024
Recalls on the 2012 Volkswagen Routan
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
12V147000
SUSPENSION:REAR
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2012 ROUTAN VEHICLES, MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.
Risk: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
Reports where the owner recorded a crash, a fire, an injury or a death.
Blair, NE1 injured
AIR BAGS
Driver steering wheel airbag deployed while parking van at work. Nothing was hit just went off causing burns and wrist pain and swelling. Wife stated that the front windshield wipers started turning on randomly while driving to work and then airbag blew while parking.
NHTSA complaint #11600204 — an unverified report by a vehicle owner.
Mount Airy, MDCrash1 injured
AIR BAGS
I WAS IN A PRETTY BAD CAR ACCIDENT 4/5/2019 WITH 6 KIDS IN THE CAR AND NONE OF THE AIRBAGS DEPLOYED.. WE WERE I MOTION WHEN CAR INFRONT OF ME TRIED TO AVOID THE CAR IN FRONT OF HIM. I SAW HIM AND I TRIED TO AVOID HIM SO MY LEFT FRONT HIT HIS REAR RIGHT SIDE. NONE OF THE AIRBAGS DEPLOYED AND NOW I HAVE A HORRIBLE CONCUSSION IN THE HOSPITAL!
NHTSA complaint #11196628 — an unverified report by a vehicle owner.
Mount Airy, MDCrash1 injured
UNKNOWN OR OTHER
I WAS IN A PRETTY BAD CAR ACCIDENT 4/5/2019 WITH 6 KIDS IN THE CAR AND NONE OF THE AIRBAGS DEPLOYED.. WE WERE I MOTION WHEN CAR INFRONT OF ME TRIED TO AVOID THE CAR IN FRONT OF HIM. I SAW HIM AND I TRIED TO AVOID HIM SO MY LEFT FRONT HIT HIS REAR RIGHT SIDE. NONE OF THE AIRBAGS DEPLOYED AND NOW I HAVE A HORRIBLE CONCUSSION IN THE HOSPITAL!
NHTSA complaint #11196628 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Blair, NE1 injured
AIR BAGS
Driver steering wheel airbag deployed while parking van at work. Nothing was hit just went off causing burns and wrist pain and swelling. Wife stated that the front windshield wipers started turning on randomly while driving to work and then airbag blew while parking.
NHTSA complaint #11600204 — an unverified report by a vehicle owner.
Mableton, GA
ELECTRICAL SYSTEM
My vehicle is shutting off while driving. It randomly shuts off and I see there are other recalls associated with this issue for a different year but same vehicle/model. I am being quoted well over $2,000 in repairs. This vehicle only has 130,000 miles on it.
NHTSA complaint #11578885 — an unverified report by a vehicle owner.
Carson City, NV
ELECTRICAL SYSTEM
At first it starts off the vehicle will just shut off while you are driving which is very dangerous I have read many people complaining about this it needs to be recalled then the brakes go and then the transmission seal I have done all the maintenance up keep on my vehicle there is no reason for the vehicle did you shut off the way it keeps shutting off and dying for no reason the battery keeps dying by the next morning when nothing is left on in the vehicle it has caused me a great deal of grief and it is very scary when you have children in the car and your vehicle just shuts off on the freeway when everything is electric guess what no breaks
NHTSA complaint #11560584 — an unverified report by a vehicle owner.
Carson City, NV
SERVICE BRAKES
At first it starts off the vehicle will just shut off while you are driving which is very dangerous I have read many people complaining about this it needs to be recalled then the brakes go and then the transmission seal I have done all the maintenance up keep on my vehicle there is no reason for the vehicle did you shut off the way it keeps shutting off and dying for no reason the battery keeps dying by the next morning when nothing is left on in the vehicle it has caused me a great deal of grief and it is very scary when you have children in the car and your vehicle just shuts off on the freeway when everything is electric guess what no breaks
NHTSA complaint #11560584 — an unverified report by a vehicle owner.
Las Vegas, NV
UNKNOWN OR OTHER
NHTSA Recall 14v396 is probably the best correction to this issue. My van has shut off mid-driving while my children are in the car with me. It is so dangerous in the road. I can't move the steering wheel. Mechanics can't seem to diagnose the problem because the van doesn't give any computer codes when it would shut down. There are similar complaints and I wonder how Volkswagen knows of this issue and has failed to inform the owners of these vehicles. Chrysler had a similar issue and did a recall. I hope Volkswagen would acknowledge this issue.
NHTSA complaint #11528397 — an unverified report by a vehicle owner.
Las Vegas, NV
ELECTRICAL SYSTEM
NHTSA Recall 14v396 is probably the best correction to this issue. My van has shut off mid-driving while my children are in the car with me. It is so dangerous in the road. I can't move the steering wheel. Mechanics can't seem to diagnose the problem because the van doesn't give any computer codes when it would shut down. There are similar complaints and I wonder how Volkswagen knows of this issue and has failed to inform the owners of these vehicles. Chrysler had a similar issue and did a recall. I hope Volkswagen would acknowledge this issue.
NHTSA complaint #11528397 — an unverified report by a vehicle owner.
Las Vegas, NV
ENGINE
NHTSA Recall 14v396 is probably the best correction to this issue. My van has shut off mid-driving while my children are in the car with me. It is so dangerous in the road. I can't move the steering wheel. Mechanics can't seem to diagnose the problem because the van doesn't give any computer codes when it would shut down. There are similar complaints and I wonder how Volkswagen knows of this issue and has failed to inform the owners of these vehicles. Chrysler had a similar issue and did a recall. I hope Volkswagen would acknowledge this issue.
NHTSA complaint #11528397 — an unverified report by a vehicle owner.
Sussex, WI
POWER TRAIN
Several times in the last month the car has stopped running without warning. It just shuts off. This has happened in our subdivision travelling at 20mph and most recently on the highway travelling 65mph. The power steering, brakes, everything go dead when the car just turns off and this could cause a serious accident.
NHTSA complaint #11487850 — an unverified report by a vehicle owner.
Sussex, WI
ELECTRICAL SYSTEM
Several times in the last month the car has stopped running without warning. It just shuts off. This has happened in our subdivision travelling at 20mph and most recently on the highway travelling 65mph. The power steering, brakes, everything go dead when the car just turns off and this could cause a serious accident.
NHTSA complaint #11487850 — an unverified report by a vehicle owner.
Monterey, CA
POWER TRAIN
On Thursday January 6, 2022, I took my car Volkswagen Routan 2012 to the service center because the check engine light went on and the engine revving. The service center took a week for diagnostic it, then they informed me on January 13, after charging me $180 that it needs a new transmission because it stuck in limp mode (see attached report). I asked the customer service to contact Volkswagen representative because this problem seems to be a manufacture problem, especially the car run less than 85000 miles and all maintenance service done on time with Volkswagen dealership. This mileages are considered very low to have a transmission problem with well maintained car. They took another three weeks to report me by phone that Volkswagen refused completely to take care or to share responsibility for this problem and they rejected my claim. Because the claim runs by the dealership “service center” on behalf of me, I asked their customer service representative to email me what is Volkswagen final decision and why? Three days later, the customer service told me by phone “it’s confidential” and they can not email me.
NHTSA complaint #11451803 — an unverified report by a vehicle owner.
Monterey, CA
UNKNOWN OR OTHER
On Thursday January 6, 2022, I took my car Volkswagen Routan 2012 to the service center because the check engine light went on and the engine revving. The service center took a week for diagnostic it, then they informed me on January 13, after charging me $180 that it needs a new transmission because it stuck in limp mode (see attached report). I asked the customer service to contact Volkswagen representative because this problem seems to be a manufacture problem, especially the car run less than 85000 miles and all maintenance service done on time with Volkswagen dealership. This mileages are considered very low to have a transmission problem with well maintained car. They took another three weeks to report me by phone that Volkswagen refused completely to take care or to share responsibility for this problem and they rejected my claim. Because the claim runs by the dealership “service center” on behalf of me, I asked their customer service representative to email me what is Volkswagen final decision and why? Three days later, the customer service told me by phone “it’s confidential” and they can not email me.
NHTSA complaint #11451803 — an unverified report by a vehicle owner.
North Canton, OH
ELECTRICAL SYSTEM
Car is stalling out while driving with no warning. Doesn't matter the rate of speed I'm going it just cuts out. Can't turn steering wheel. No codes pop up. No mechanics can pinpoint issue. I have seen quite a few thousand people complaining of the same issue and reported it to vw as well as nhtsa and NO ONE will do a recall. Chrysler did a recall for this same issue but NOT vw. This is a safety issue for not only the owner but other drivers on the road. If I get into an accident or cause one I WILL BE suing nhtsa as well as vw for no recall being done. I have printed out over 100 pages of complaints from others for evidence of complaints. I have already entered the class action lawsuit with others having the same issue. RECALL THE ISSUE OR FACE LAWSUITS.
NHTSA complaint #11446236 — an unverified report by a vehicle owner.
North Canton, OH
ENGINE
Car is stalling out while driving with no warning. Doesn't matter the rate of speed I'm going it just cuts out. Can't turn steering wheel. No codes pop up. No mechanics can pinpoint issue. I have seen quite a few thousand people complaining of the same issue and reported it to vw as well as nhtsa and NO ONE will do a recall. Chrysler did a recall for this same issue but NOT vw. This is a safety issue for not only the owner but other drivers on the road. If I get into an accident or cause one I WILL BE suing nhtsa as well as vw for no recall being done. I have printed out over 100 pages of complaints from others for evidence of complaints. I have already entered the class action lawsuit with others having the same issue. RECALL THE ISSUE OR FACE LAWSUITS.
NHTSA complaint #11446236 — an unverified report by a vehicle owner.
North Canton, OH
FUEL/PROPULSION SYSTEM
Car is stalling out while driving with no warning. Doesn't matter the rate of speed I'm going it just cuts out. Can't turn steering wheel. No codes pop up. No mechanics can pinpoint issue. I have seen quite a few thousand people complaining of the same issue and reported it to vw as well as nhtsa and NO ONE will do a recall. Chrysler did a recall for this same issue but NOT vw. This is a safety issue for not only the owner but other drivers on the road. If I get into an accident or cause one I WILL BE suing nhtsa as well as vw for no recall being done. I have printed out over 100 pages of complaints from others for evidence of complaints. I have already entered the class action lawsuit with others having the same issue. RECALL THE ISSUE OR FACE LAWSUITS.
NHTSA complaint #11446236 — an unverified report by a vehicle owner.
El Cajon, CA
POWER TRAIN
The transmission on our 2012 VW Routan has completely failed. The car will not go into gear and left my wife in a position where she was stranded in traffic. We are the original owners of this vehicle and have followed the recommended maintenance schedule. The engine in this vehicle is a Chrysler Pentastar V6. (The vehicle was built as a joint venture between VW and Chrysler) According to online research Chrysler has recognized a “fatal flaw” in this engine and has extended warranty to customers in order to cover repairs beyond 100,000 miles. We only have 72,000 on our vehicle. I have spoken with VW North America, they told me to plead my case with Chrysler. I spoke with Chrysler and they told me to plead my case with VW. Neither company is willing to recognize that a total transmission failure at 72k miles is [their] responsibility. I am asking for the drivetrain warranty on our vehicle to be extended, due to the “fatal flaw” which has already been identified by Chrysler on the Pentastar V6. VW service is asking me to pay more than $6,000 to repair the vehicle.
NHTSA complaint #11445020 — an unverified report by a vehicle owner.
El Cajon, CA
ENGINE
The transmission on our 2012 VW Routan has completely failed. The car will not go into gear and left my wife in a position where she was stranded in traffic. We are the original owners of this vehicle and have followed the recommended maintenance schedule. The engine in this vehicle is a Chrysler Pentastar V6. (The vehicle was built as a joint venture between VW and Chrysler) According to online research Chrysler has recognized a “fatal flaw” in this engine and has extended warranty to customers in order to cover repairs beyond 100,000 miles. We only have 72,000 on our vehicle. I have spoken with VW North America, they told me to plead my case with Chrysler. I spoke with Chrysler and they told me to plead my case with VW. Neither company is willing to recognize that a total transmission failure at 72k miles is [their] responsibility. I am asking for the drivetrain warranty on our vehicle to be extended, due to the “fatal flaw” which has already been identified by Chrysler on the Pentastar V6. VW service is asking me to pay more than $6,000 to repair the vehicle.
NHTSA complaint #11445020 — an unverified report by a vehicle owner.
Andalusia, IL
AIR BAGS
The ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which then depowers various key safety systems including, but not limited to, air bags, power steering, and power braking. This has happened to me several times including while driving on the interstate and in traffic. I was able to pull over but it is very difficult when power steering and power breaking goes out. I had children in the vehicle several times when this has happened. Per Volkswagon website, I removed all keychains or anything that would cause the key fob to be weighed down. When I contacted them, they said my van is not under recall even though it is the same exact issue previous models had been recalled for. The only symptom prior was the check engine light was on.
NHTSA complaint #11439049 — an unverified report by a vehicle owner.
Andalusia, IL
ENGINE
The ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which then depowers various key safety systems including, but not limited to, air bags, power steering, and power braking. This has happened to me several times including while driving on the interstate and in traffic. I was able to pull over but it is very difficult when power steering and power breaking goes out. I had children in the vehicle several times when this has happened. Per Volkswagon website, I removed all keychains or anything that would cause the key fob to be weighed down. When I contacted them, they said my van is not under recall even though it is the same exact issue previous models had been recalled for. The only symptom prior was the check engine light was on.
NHTSA complaint #11439049 — an unverified report by a vehicle owner.
Andalusia, IL
SERVICE BRAKES
The ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which then depowers various key safety systems including, but not limited to, air bags, power steering, and power braking. This has happened to me several times including while driving on the interstate and in traffic. I was able to pull over but it is very difficult when power steering and power breaking goes out. I had children in the vehicle several times when this has happened. Per Volkswagon website, I removed all keychains or anything that would cause the key fob to be weighed down. When I contacted them, they said my van is not under recall even though it is the same exact issue previous models had been recalled for. The only symptom prior was the check engine light was on.
NHTSA complaint #11439049 — an unverified report by a vehicle owner.
rio Vista, CA
STEERING
referenced to recall nhsta Id no:11v-151 same issue happens on newer models, the car key ignition switch does not secure the key and that causes the car shut-down in tje middle of highway or road intermittently! ıt does not give any dashboard warning and no codes! all the lights are being gone and even ac shuts off! when ı push the key the lights come back on and the car can be turned on again. similiar problems are poster on youtube: https://youtu.be/ZESy-MnVPZs
NHTSA complaint #11427268 — an unverified report by a vehicle owner.
rio Vista, CA
UNKNOWN OR OTHER
referenced to recall nhsta Id no:11v-151 same issue happens on newer models, the car key ignition switch does not secure the key and that causes the car shut-down in tje middle of highway or road intermittently! ıt does not give any dashboard warning and no codes! all the lights are being gone and even ac shuts off! when ı push the key the lights come back on and the car can be turned on again. similiar problems are poster on youtube: https://youtu.be/ZESy-MnVPZs
NHTSA complaint #11427268 — an unverified report by a vehicle owner.
rio Vista, CA
ELECTRICAL SYSTEM
referenced to recall nhsta Id no:11v-151 same issue happens on newer models, the car key ignition switch does not secure the key and that causes the car shut-down in tje middle of highway or road intermittently! ıt does not give any dashboard warning and no codes! all the lights are being gone and even ac shuts off! when ı push the key the lights come back on and the car can be turned on again. similiar problems are poster on youtube: https://youtu.be/ZESy-MnVPZs
NHTSA complaint #11427268 — an unverified report by a vehicle owner.
Jacksonville, FL
ELECTRICAL SYSTEM
The battery started dying randomly several months ago. I have called multiple dealerships and had diagnostics ran twice on the car. Initially I was told there is no draw on the battery. Then it was discovered that the TIPM module needs to be replaced. I then started researching this problem with this vehicle only to find multiple forums full of people having the same exact issue or worse! As in, their car stalls on the highway randomly while driving!! Someone could die! This module fails and in my case causes the fuel pump to continue running even when the car is off which completely drains the battery overnight! Chrysler (same manufacturer of this TIPM) already lost a class action lawsuit and recalled this TIPM but the Volkswagens affected by this same issue were not included leaving those of us now experiencing the same problem in a scary position because we can’t afford to get this fixed as it is very expensive let alone get a new car! It baffles me how well known it is that this part is the same part that’s been recalled but it doesn’t apply to this vehicle. On top of that, I called 3 Chrysler dealerships to explain the problem and was told they don’t work on this vehicle! This is unacceptable! I don’t know how the NHTSA has not done something about this! It seems several class action lawsuits need to filed! Hopefully before someone loses their life!
NHTSA complaint #11425764 — an unverified report by a vehicle owner.
Shelby, NC
POWER TRAIN
While driving along my vehicle will shut completely off. This happens especially on bumpy roads. Sometime the vehicle will shut off right after starting the engine. The only way I can duplicate the problem is to turn the key completely off and restart the vehicle. This problem is very similar to the recall with the 2010 Volkswagens.
NHTSA complaint #11423852 — an unverified report by a vehicle owner.
Shelby, NC
AIR BAGS
While driving along my vehicle will shut completely off. This happens especially on bumpy roads. Sometime the vehicle will shut off right after starting the engine. The only way I can duplicate the problem is to turn the key completely off and restart the vehicle. This problem is very similar to the recall with the 2010 Volkswagens.
NHTSA complaint #11423852 — an unverified report by a vehicle owner.