2025 Volkswagen Tiguan other reported problems

UNKNOWN OR OTHER

I brought my vehicle to the dealership because it was shifting itself into Park while I was driving. I have brought the car in four times. During the last two visits, the dealership performed a system update called **VW 47DM Collision Vehicle Software Update for Travel Assist/Emergency Assist**. Immediately after leaving the dealership following these updates, my vehicle developed additional and more serious problems. The infotainment system stops working for several minutes at a time before turning back on. The vehicle is also now displaying a “Front Assist Not Available” warning. In addition, the vehicle jerks violently while driving forward or accelerating, and the front end is making a grinding noise. This software update has made my vehicle worse than it was before. I have contacted Volkswagen Customer Care multiple times, but I have been denied assistance because there is reportedly no diagnostic code in the system. However, I have video evidence of these issues occurring while driving. Volkswagen has refused to repair the vehicle or take it back despite these ongoing problems. A vehicle shifting into Park while driving, jerking during acceleration, displaying a Front Assist warning, and experiencing other system failures presents a serious safety hazard to me, my passengers, and others on the road.

NHTSA complaint #11758908 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

When I am backing , my card comes to a complete stop, like I hit wall . There is nothing behind my car. It like you ran into a brick wall. This has happened several times

NHTSA complaint #11745619 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

EVAP warning light sporadically displays and the odor of fuel emits from vehicle - both inside and outside. Occured approximately seven times since purchase. Driver door is not operational, sporadically. Will not respond to key fob, windows will not roll down or up, cannot lock or unlock, and displaying a flashing red light with a loud noise emitting every three seconds. Occured approximately five times since purhcase. Mirrors will sporadically not fold outwards and remain in a stuck inward position. Travel assist, side assist, and start / stop has malfunctioned approximately seven times. Dynamic cornering light malfunction approximately three times. Vehicle was not configured when purchased. SOS was not operational.

NHTSA complaint #11745737 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Moonroof spontaneously exploded while driving; shards of glass fell all over me (head, face, arms, back, legs), and throughout the vehicle. Nothing hit my vehicle, no road debris.

NHTSA complaint #11742427 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The moonroof exploded, shattered glass, shards, and glass dust fell all over me (head, face, arms, chest, back, legs) and throughout my car. There was no road debris, nor did anything hit my vehicle to cause the moonroof to shatter. Temperature outside was mid 70’s, I was driving in a predominately shaded area when the incident happened around 7:50am.

NHTSA complaint #11742446 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The vehicle is experiencing a persistent and severe manufacturing defect regarding its steering wheel geometry and vehicle alignment. While operating the vehicle under normal driving conditions, the steering wheel alignment is visibly off-center, failing to achieve proper tracking geometry. There is comprehensive photographic and video evidence documenting that the steering wheel and tracking alignment are fundamentally incorrect. To date, this vehicle has been brought to an authorized Volkswagen dealership service department for a total of eleven (11) separate service visits specifically targeting this exact defect. The dealership service department refuses to perform further corrective actions, insisting that the off-center geometry is "normal and within factory specifications" after test-driving two other lot vehicles. The dealership has explicitly stated they will not correct this defect without direct corporate intervention. Safety Risk Assessment: The manufacturer and dealership's failure to remedy the off-center steering wheel geometry and tracking alignment presents an ongoing safety hazard. Operating a vehicle with compromised steering geometry introduces unpredictable handling characteristics, accelerated or uneven tire wear, and an elevated risk of sudden component fatigue. The persistent alignment deviation forces the driver to constantly compensate to maintain a straight line of travel, increasing the risk of driver fatigue and unpredicted lane drifting at highway speeds. A vehicle that cannot maintain proper tracking geometry poses a clear and present danger to its occupants and surrounding traffic. Timeline of Events & Notice to Manufacturer: Both the local franchised dealership management and Volkswagen of America corporate regional management have been formally notified of this recurring defect through 11 documented service attempts. Following initial acknowledgments, the Volkswagen corporate regional representative has ceased all communications

NHTSA complaint #11741598 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Snow sticks between the rim and brake when I am driving causing vehicle to majorly shake. I can not manually reach in this area to remove the snow This is a hazard when I am driving on a thruway or country roads. The dealer does not know why this is sticking so badly.

NHTSA complaint #11714251 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I purchased a new 2025 Volkswagen Tiguan (VIN [XXX] ) on December 9, 2025. On January 18, 2026, with 1,243 miles, the closed sunroof suddenly shattered as I slowly backed out of my indoor garage. There was no debris, no storm, and no outside impact. I took photos immediately, including wide and close‑up shots; none show any impact point. I reported the incident to Brookdale Volkswagen the same day and sent my photos. The dealership submitted a warranty request, but Volkswagen denied it as “outside influence,” without identifying an impact point or providing written inspection notes. I requested evidence supporting that conclusion, the VW case details, and a physical inspection with written findings. After the car was towed to the dealer, the service manager sent a new photo labeled a “rock chip.” This mark does not appear in any of my original photos taken immediately after the shattering, before towing. The dealer referenced VW Tracking [XXX] and repeated the denial. Volkswagen Customer CARE later issued a formal denial and directed me to BBB AUTO LINE for dispute resolution. No external cause was present; the vehicle was indoors and stationary. No impact point appears in my original photos, and the later “chip” only appeared after the vehicle left my possession, so it is not reliable evidence of pre‑existing damage. Tempered roof glass can fail spontaneously due to manufacturing or installation stress, making this a warranty‑covered defect absent proof of impact. I am requesting warranty coverage for replacement of the panoramic sunroof assembly and related interior cleanup or repairs, written inspection findings and all photos used to support any continued impact claim, and reimbursement or coverage of reasonable costs tied to the failure. I am filing this claim through BBB AUTO LINE, and a related NHTSA complaint is being filed to document the safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11712553 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Spontaneous Panoramic Sunroof Shattering on 2025 VW Tiguan

NHTSA complaint #11712038 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

When placing the vehicle on reverse the rear back up camera screen goes dark, preventing to see anything when backing up. I’ve cleaned the back up camera and there is nothing obstructing the lens.

NHTSA complaint #11684850 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Sunroofs suddenly exploding

NHTSA complaint #11674529 — an unverified report by a vehicle owner.