Owners have filed 33 complaints
about the 2004 Audi TT with NHTSA between 2005 and 2019.
The largest single group is the transmission & drivetrain.
Across this model's run it ranks 7 of 8 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 33
Against the median year of the Audi TT. 50 means typical for this
model; 100 means roughly double.
Severity — 0
0% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 40
23% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
26.7%
25,000 – 49,999 miles
1033.3%
50,000 – 74,999 miles
516.7%
75,000 – 99,999 miles
723.3%
100,000 – 149,999 miles
620.0%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Side barrier crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2004 Audi TT 2-DR. Convertible w/SAB
—
—
—
—
2004 Audi TT Coupe 2-DR. w/SAB
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2005peak 6Jul 2019
Recalls on the 2004 Audi TT
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
14E007000
ENGINE AND ENGINE COOLING:ENGINE
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Risk: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
04V007000
POWER TRAIN:CLUTCH ASSEMBLY
ON CERTAIN PASSENGER VEHICLES WITH DIRECT SHIFT GEARBOX, DURING THE PRODUCTION OF THE GEARBOX, A SEAM AT THE CLUTCH WAS NOT WELDED TO SPECIFICATIONS. THIS COULD LEAD TO DEGRADED PERFORMANCE OF THE CLUTCH INSIDE THE GEARBOX.
Risk: THE CLUTCH COULD LOSE ITS ABILITY TO PROVIDE INPUT TORQUE TO THE TRANSMISSION WITHOUT PRIOR WARNING, WHICH COULD ALLOW THE VEHICLE TO ROLL, INCREASING THE RISK OF A CRASH.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 200334315 units in Canada
Powertrain
On certain vehicles equipped with a Direct Shift Gearbox, a seam at the clutch was not welded to specification. This could lead to degraded performance of the clutch after an indefinite period of use. The clutch could lose its ability to provide input torque to the transmission without prior warning, which could allow the vehicle to roll. Correction: Dealer will replace the clutch.
In the owners' own words, exactly as filed with NHTSA.
at 110,000 milesLeawood, KS
POWER TRAIN
CAR JERKS VIOLENTLY AUDI DEALERSHIP STATE THEY WILL NOT FIX THIS ISSUE ALTHOUGH MY CAR FALLS UNDER THIS CAMPAIGN HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2004/RCRIT-04V007-5629.PDF AUDI CAMPAIGN JA (04V-007) DIRECT SHIFT AUTOMATIC TRANSMISSION REPLACE DUAL CLUTCH
NHTSA complaint #11230513 — an unverified report by a vehicle owner.
at 110,000 milesLeawood, KS
UNKNOWN OR OTHER
CAR JERKS VIOLENTLY AUDI DEALERSHIP STATE THEY WILL NOT FIX THIS ISSUE ALTHOUGH MY CAR FALLS UNDER THIS CAMPAIGN HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2004/RCRIT-04V007-5629.PDF AUDI CAMPAIGN JA (04V-007) DIRECT SHIFT AUTOMATIC TRANSMISSION REPLACE DUAL CLUTCH
NHTSA complaint #11230513 — an unverified report by a vehicle owner.
at 96,250 milesSacramento, CA
AIR BAGS
AIRBAGS NOT WORKING DUE CAR SITTING AND BATTERY RUNNING LOW. LOW BATTERY TRIGGERED CODE 65535 WHICH MAKES ALL THE AIRBAGS IN THE VEHICLE INOPERATIVE.
NHTSA complaint #11131158 — an unverified report by a vehicle owner.
at 95,000 milesTacoma, WA
POWER TRAIN
FUEL SENSOR NOT WORKING PROPERLY; WHILE HAVING GAS, ONCE TANK METER READS 1/2, THE ENGINE SHOT-DOWN, INCORRECTLY TELLING THAT THE TANK IS EMPTY. SAME ISSUES WITH THE CATHALYTIC CONVERTER SYSTEM. ENGINE'S TRANSMISSION WEARING FAST; PUSHING BACK AND FORT WHILE ACCELERATING.
NHTSA complaint #11097849 — an unverified report by a vehicle owner.
at 95,000 milesTacoma, WA
ELECTRONIC STABILITY CONTROL (ESC)
FUEL SENSOR NOT WORKING PROPERLY; WHILE HAVING GAS, ONCE TANK METER READS 1/2, THE ENGINE SHOT-DOWN, INCORRECTLY TELLING THAT THE TANK IS EMPTY. SAME ISSUES WITH THE CATHALYTIC CONVERTER SYSTEM. ENGINE'S TRANSMISSION WEARING FAST; PUSHING BACK AND FORT WHILE ACCELERATING.
NHTSA complaint #11097849 — an unverified report by a vehicle owner.
at 95,000 milesTacoma, WA
FUEL/PROPULSION SYSTEM
FUEL SENSOR NOT WORKING PROPERLY; WHILE HAVING GAS, ONCE TANK METER READS 1/2, THE ENGINE SHOT-DOWN, INCORRECTLY TELLING THAT THE TANK IS EMPTY. SAME ISSUES WITH THE CATHALYTIC CONVERTER SYSTEM. ENGINE'S TRANSMISSION WEARING FAST; PUSHING BACK AND FORT WHILE ACCELERATING.
NHTSA complaint #11097849 — an unverified report by a vehicle owner.
at 125,000 milesTacoma, WA
UNKNOWN OR OTHER
GAS SENSOR AND WATER / COOLANT PUMPS/ EXAUST SYS..: CAR WAS IN MOTION...; TAKEN TO REPAIR-SHOP... HIFGH COST.
NHTSA complaint #11091952 — an unverified report by a vehicle owner.
at 125,000 milesTacoma, WA
ELECTRICAL SYSTEM
GAS SENSOR AND WATER / COOLANT PUMPS/ EXAUST SYS..: CAR WAS IN MOTION...; TAKEN TO REPAIR-SHOP... HIFGH COST.
NHTSA complaint #11091952 — an unverified report by a vehicle owner.
at 125,000 milesTacoma, WA
FUEL/PROPULSION SYSTEM
GAS SENSOR AND WATER / COOLANT PUMPS/ EXAUST SYS..: CAR WAS IN MOTION...; TAKEN TO REPAIR-SHOP... HIFGH COST.
NHTSA complaint #11091952 — an unverified report by a vehicle owner.
Allendale, MI
POWER TRAIN
MECHATRONIC FAILURE, TAKING A MICHIGAN UTURN CAR WENT INTO LIMP MODE CROSSIMG THE STREET ,ALMOST T BONED BY 2 DIFFERENT CARS, CALLED AUDI THEY WANT ME TO BUY A NEW UNIT FOR A CRAZY AMOUNT OF MONEY AND A LONG WAITING PERIOD, CALLED EVERYONE I COULD FOR HELP BUT SEEMS THERE IA SOME SORT OF COVER UP OR NEGLECT WHEN IT COMES TO THIS SPECIFIC CAR AND PROBLEM, SOMEBODY IS GOING TO GET SERIOUSLY HURT IF THERE ISNT A RECALL SOON, IM ONE OF HUNDEREDS THAT HAVE RAN INTO THIS SAME PROBLEM, BOUGHT THE CAR STILL MAKING PAYMENTS AT 61007 MILES AND THIS HAPPEND AT 72361 MILES.
NHTSA complaint #10984780 — an unverified report by a vehicle owner.
at 49,000 milesLA Grange, IL
POWER TRAIN
THE FIRST WEEK OF DEC 2014, I HAD BEEN HEARING A SPORADIC, WHOOTING NOISE FROM THE FLOOR OF MY AUDI TT 2004 (49,000 MILES). I BROUGHT MY VEHICLE INTO THE DEALERSHIP ON 12/05/14. ASIDE FROM SOME OTHER NON-CRITICAL REPAIRS, THE DEALERSHIP COULD NOT FIND A CAUSE FOR THE NOISE AND IT WAS RELEASED. AS I WAS DRIVING THE VEHICLE BACK TO THE DEALERSHIP ON 12/12/14 TO PICK UP MY OTHER VEHICLE, I HAD SIGNIFICANT ISSUES. I WAS DRIVING ALONG NORTH AVE AT 35 - 40 MPH IN RUSH-HOUR TRAFFIC. AS I WAS DRIVING, THE VEHICLE SUDDENLY SHIFTED INTO NEUTRAL AND BEGAN TO RAPIDLY SLOW. IN AN EFFORT TO AVOID A SERIOUS REAR-END COLLISION, I QUICKLY ENGAGED THE HAZARD LIGHTS AND SLOWED TO A STOP. ONCE STOPPED, I SHIFTED INTO PARK (NOT CERTAIN IF IT ACTUALLY SHIFTED TO PARK AT THIS POINT), SHUT OF THE ENGINE, AND RE-STARTED. FORTUNATELY, THE VEHICLE MADE IT SAFELY TO THE DEALERSHIP WITHOUT ANOTHER INCIDENT THAT DAY. THE FOLLOWING WEEK ON 12/15/14, THE DEALER RAN DIAGNOSTICS ON THE VEHICLE. THEY NOTED A FAULT IN THE TRANSMISSION, BUT COULD NOT DETERMINE THE CAUSE AND AFTER RUNNING 10 MILES, NOTED THAT IT WAS RUNNING WELL. IN AN EFFORT TO CONTINUE TROUBLESHOOTING, THE DEALER USED MY VEHICLE TO RUN ERRANDS. AS THEY TURNED ONTO OGDEN AVE (WESTMONT, IL), THEY HAD THE SAME PROBLEM WITH THE VEHICLE SHIFTING SPONTANEOUSLY INTO NEUTRAL. I DO NOT KNOW THE FULL DETAILS OF THAT INCIDENT, BUT CAN IMAGINE IT WAS ALSO A CLOSE CALL AS OGDEN AVE IS A BUSY, FOUR-LANE ROAD. THE OFFICIAL DIAGNOSIS WAS THAT IT NEEDS A MECHATRONICS UNIT REPLACEMENT. I AM GRATEFUL THAT THIS INCIDENT DID NOT HAPPEN ON THE HIGHWAY AND THAT I WAS NOT DRIVING IN FRONT OF A MORE AGGRESSIVE DRIVER (WHO MAY HAVE OTHERWISE COLLIDED WITH MY VEHICLE). I BELIEVE THIS IS A SERIOUS SAFETY CONCERN AS IT OCCURS WHILE THE VEHICLE IS IN MOTION, IT OCCURS ON A SPORADIC BASIS, AND IT IS EVIDENTLY UNDETECTABLE AT THE DEALERSHIP.
NHTSA complaint #10668033 — an unverified report by a vehicle owner.
Carmel, CA
POWER TRAIN
THE TRANSMISSION SLIPS VIOLENTLY BETWEEN 2 ND AND 3 RD GEAR. THERE WAS A COMPLETE LOSS OF POWER WITH THE PEDAL DOWN COMPLETELY. AFTER RESEARCH HAVE DISCOVERED THAT THE DESIGN OF THESE TRIPTONIC TRANSMISSIONS WHICH CAN BE SWITCHED FROM MANUAL TO AUTOMATIC ARE FAULTY AND COSTLY TO REPAIR. I AM CONSIDERING A VALVE BODY REPLACEMENT WHICH MAY OR MAY NOT FIX THE PROBLEM. AUDI DOES NOT STAND BEHIND THEIR PRODUCT. THIS IS A COMMON PROBLEM AMONG AUDI OWNERS.
NHTSA complaint #10487274 — an unverified report by a vehicle owner.
Carmel, CA
ENGINE
THE TRANSMISSION SLIPS VIOLENTLY BETWEEN 2 ND AND 3 RD GEAR. THERE WAS A COMPLETE LOSS OF POWER WITH THE PEDAL DOWN COMPLETELY. AFTER RESEARCH HAVE DISCOVERED THAT THE DESIGN OF THESE TRIPTONIC TRANSMISSIONS WHICH CAN BE SWITCHED FROM MANUAL TO AUTOMATIC ARE FAULTY AND COSTLY TO REPAIR. I AM CONSIDERING A VALVE BODY REPLACEMENT WHICH MAY OR MAY NOT FIX THE PROBLEM. AUDI DOES NOT STAND BEHIND THEIR PRODUCT. THIS IS A COMMON PROBLEM AMONG AUDI OWNERS.
NHTSA complaint #10487274 — an unverified report by a vehicle owner.
at 65,232 milesHouston, TX
POWER TRAIN
WHILE DRIVING ON THE FREEWAY, THE TRANSMISSION SUDDENLY WENT TO NEUTRAL. WITH NO POWER AND AT 70MPH, I WAS FORCED INTO AN UNSAFE MANEUVER, CUTTING DRIVERS OFF IN ORDER TO GET ONTO THE SHOULDER LANE. I WAS TOWED TO A NEARBY AUDI DEALERSHIP AROUND 11:00PM. 3 BUSINESS DAYS LATER, THEY CALLED ME WITH THE RESULTS; THE MECHATRONICS (TRANSMISSION COMPUTER) WAS FAULTY AND WAS ESTIMATED TO COST $2800 FOR THE REPAIR. THIS ISSUE WITH VW'S DSG TRANSMISSION IS WIDESPREAD AS OWNERS AT VARIOUS MILEAGES HAVE REPORTED BROKEN MECHATRONICS UNITS. MY VEHICLE HAS 65K MILES AND REPLACING A TRANSMISSION AT THAT MILEAGE IS ABSURD.
NHTSA complaint #10468347 — an unverified report by a vehicle owner.
at 70,000 milesPalisade, CO
POWER TRAIN
TL* THE CONTACT OWNS A 2004 AUDI TT1.8 COUPE. THE CONTACT STATED WHILE DRIVING 45 MPH, THE VEHICLE WOULD JERK IN BETWEEN GEARS AND STALL. AFTER THE FAILURE, THE VEHICLE COULD NOT BE SHIFTED IN OR OUT OF ANY GEAR. BY TURNING THE ENGINE OFF AND THEN RESTARTING, THE FAILURE WOULD CORRECT ITSELF BUT WOULD RECUR AFTER SEVERAL MINUTES. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THEY NEEDED TO REPLACE THE TRANSMISSION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO OFFERED TO BUY THE VEHICLE BACK BUT THE CONTACT REFUSED. THE FAILURE MILEAGE WAS 70,000.
NHTSA complaint #10459864 — an unverified report by a vehicle owner.
at 55,501 milesWilton, CT
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
FAILED ENGINE TEMPERATURE GAUGE DIAGNOSED BY AUDI TECHNICIAN AS A FAILED INSTRUMENT CLUSTER; THE CLUSTER HAS TO BE REPLACED OR ALL GAUGES MAY FAIL WITHOUT WARNING.
NHTSA complaint #10455918 — an unverified report by a vehicle owner.
at 81,000 milesSuffield, CT
POWER TRAIN
MECHATRONIC VALVE CONTROL MODULE FAILURE GOING INTO NEUTRAL OR CHANGING DOWN AT HIGHWAY CRUISE. MOST DANGEROUS OCCURRENCE: SLIPPING CLUTCH AND NOT ENGAGING FIRST GEAR PROPERLY. I WAS NEARLY HIT BY A CAR TRAVELING AT 60MPH WHILE LIMPING ACROSS AN INTERSECTION. COULD HAVE BEEN FATAL.
NHTSA complaint #10449261 — an unverified report by a vehicle owner.
at 106,000 milesCoral Springs, FL
POWER TRAIN:AUTOMATIC TRANSMISSION
I HAVE A 2004 AUDI TT 3.2 DSG WITH ABOUT 106,000 MILES ON IT, WHEN EVER I TURN THE CAR ON AND SHIFT INTO GEAR THE CAR WILL JUST SIT THERE WITH THE GEAR LIGHTS ON THE INSTRUMENT CLUSTER BLINKING. I HAVE NO REVERSE GEAR, THE CAR CAN MOVE IN DRIVE BUT MAKES A GRINDING NOISE, I MIGHT HAVE TO RESTART THE CAR 20 TIMES BEFORE THE CAR DECIDES TO WORK RIGHT AND GO INTO REVERSE AND DRIVE NORMALLY... ALSO THERE IS A STRONG OILY SMELL COMING FROM THE ENGINE COMPARTMENT. THE CAR GETS SERVICED AND CHECKED NORMALLY AND THIS JUST STARTED ALL OF A SUDDEN.
NHTSA complaint #10393925 — an unverified report by a vehicle owner.
at 32,000 milesEast Windsor, NJ
ELECTRICAL SYSTEM
IN NOVEMBER OF 2010, I WAS DRIVING IN MY 2004 1.8 AUDI TT AT APPROXIMATELY 45 MILES PER HOUR. WITHOUT WARNING, THE CAR LOST ALL POWER IN THE MIDDLE OF THE ROAD. FORTUNATELY, THE CAR LOST POWER AT 1:00 AM OR I MAY HAVE BEEN EASILY HIT/KILLED BY THE HEAVY FLOW OF DAYTIME TRAFFIC. AS IT TURNS OUT, THERE WAS AN IGNITION COIL RECALL ON MY VEHICLE. I NEVER RECEIVED NOTICE OF SUCH RECALL AND AS A RESULT, WAS PUT IN DANGER BY OPERATING A VEHICLE WITH A KNOWN DEFECT AND SUFFERED OVER TWO THOUSAND DOLLARS IN RELATED REPAIR EXPENSE. THE MECHANIC AT AUDI TOLD ME MY FUEL PUMP, COLLANT TEMP SENSOR, CRANK SENSOR AND IGNITION COIL NEEDED TO BE REPLACED. HE WAS QUITE SURPRISED THE THE PREVIOUS AUDI DEALERSHIP DID NOT CORRECT THE RECALL DURING ROUTINE SERVICE. MY VEHICLE WAS PERFECTLY MAINTAINED, SERVICED BY AN AUDI DEALERSHIP AND HAD APPROXIMATELY 32,000 MILES. FAILURE OF AUDI TO NOTIFY ME OF THE RECALL AND FAILURE OF THE AUDI DEALERSHIP TO CORRECT THE IGNITION COIL DURING ROUTINE SERVICE COULD HAVE RESULTED IN GRAVE INJURY. BOTH AUDI CORP AND THE INDIVIDUAL AUDI DEALERSHIP DISPLAYED A CARELESS DISREGARD FOR MY SAFETY AND ANY OTHERS WHO MAY HAVE BEEN IMPACTED BY MY VEHICLE FAILURE.
NHTSA complaint #10384683 — an unverified report by a vehicle owner.
at 32,000 milesEast Windsor, NJ
ELECTRICAL SYSTEM
IN NOVEMBER OF 2010, I WAS DRIVING IN MY 2004 1.8 AUDI TT AT APPROXIMATELY 45 MILES PER HOUR. WITHOUT WARNING, THE CAR LOST ALL POWER IN THE MIDDLE OF THE ROAD. FORTUNATELY, THE CAR LOST POWER AT 1:00 AM OR I MAY HAVE BEEN EASILY HIT/KILLED BY THE HEAVY FLOW OF DAYTIME TRAFFIC. AS IT TURNS OUT, THERE WAS AN IGNITION COIL RECALL ON MY VEHICLE. I NEVER RECEIVED NOTICE OF SUCH RECALL AND AS A RESULT, WAS PUT IN DANGER BY OPERATING A VEHICLE WITH A KNOWN DEFECT AND SUFFERED OVER TWO THOUSAND DOLLARS IN RELATED REPAIR EXPENSE. THE MECHANIC AT AUDI TOLD ME MY FUEL PUMP, COOLANT TEMP SENSOR, CRANK SENSOR AND IGNITION COIL NEEDED TO BE REPLACED. HE WAS QUITE SURPRISED THAT THE PREVIOUS AUDI DEALERSHIP DID NOT CORRECT THE RECALL DURING ROUTINE SERVICE. MY VEHICLE WAS PERFECTLY MAINTAINED, SERVICED BY AN AUDI DEALERSHIP AND HAD APPROXIMATELY 32,000 MILES. FAILURE OF AUDI TO NOTIFY ME OF THE RECALL AND FAILURE OF THE AUDI DEALERSHIP TO CORRECT THE IGNITION COIL DURING ROUTINE SERVICE COULD HAVE RESULTED IN GRAVE INJURY. BOTH AUDI CORP AND THE INDIVIDUAL AUDI DEALERSHIP DISPLAYED A CARELESS DISREGARD FOR MY SAFETY AND ANY OTHERS WHO MAY HAVE BEEN IMPACTED BY MY VEHICLE FAILURE.
NHTSA complaint #10384684 — an unverified report by a vehicle owner.
at 45,000 milesPortland, OR
POWER TRAIN:AUTOMATIC TRANSMISSION
THE CAR WAS HAVING ELECTRICAL PROBLEMS, APPEAR RELATED TO INSTRUMENT CLUSTER FAILURE. I SCHEDULED WITH AUDI TO EVALUATE FAULTY GAS GAUGE AND RADIO STAYING ON AFTER KEY REMOVED. ANYHOW, BEFORE I COULD GET IT INTO AUDI, THE CAR WHILE DRIVING JERKED VIOLENTLY AND THEN WOULD NOT SHIFT GEARS. IT WAS LUCKY I WAS NOT GOING VERY FAST AS I WAS ON WINDY ROADS WITH CLIFFS. I COULD HAVE BEEN SERIOUSLY INJURED OR DEAD HAD THE CAR LOST CONTROL. THERE HAVE BEEN RECALLS ON THE DSG AND CLUTCH ASSEMBLY FOR MY MODEL CAR, BUT THEY DON'T SHOW UP ON MY RECORD WITH AUDI. THE CAR THEN WOULD NOT ENGAGE GEARS FOR A FEW RESTARTS, SUDDENLY IT WAS FINE AND WOULD DRIVE BUT I HAD IT TOWED DUE TO RISK FACTORS AND UNCERTAINTY. I BELIEVE THESE ARE RELATED EVENTS AND THEY TELL ME I NEED A NEW TRANSMISSION. THIS CAR HAS ONLY 45K MILES AND I'M NOT SURE IT IS A MECHANICAL FAILURE AT TALL. IT IS STRANGE THAT ALL OF THESE EVENTS COINCIDED AND SUSPECT PROBLEMS WITH COMPUTER COMMUNICATION BETWEEN TRANNY AND INSTRUMENT CLUSTER. THEY ARE NOT HELPING ME RESOLVE THIS AND DENYING INSTRUMENT CLUSTER PROBLEM. SAYING THERE IS NOTHING WRONG BUT THE GAS GAUGE IS NOT WORKING AND THIS IS A CLASSIC SIGN OF INSTRUMENT CLUSTER FAILURE WHICH LED TO THE LAWSUIT.
NHTSA complaint #10369978 — an unverified report by a vehicle owner.
at 45,000 milesPortland, OR
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
THE CAR WAS HAVING ELECTRICAL PROBLEMS, APPEAR RELATED TO INSTRUMENT CLUSTER FAILURE. I SCHEDULED WITH AUDI TO EVALUATE FAULTY GAS GAUGE AND RADIO STAYING ON AFTER KEY REMOVED. ANYHOW, BEFORE I COULD GET IT INTO AUDI, THE CAR WHILE DRIVING JERKED VIOLENTLY AND THEN WOULD NOT SHIFT GEARS. IT WAS LUCKY I WAS NOT GOING VERY FAST AS I WAS ON WINDY ROADS WITH CLIFFS. I COULD HAVE BEEN SERIOUSLY INJURED OR DEAD HAD THE CAR LOST CONTROL. THERE HAVE BEEN RECALLS ON THE DSG AND CLUTCH ASSEMBLY FOR MY MODEL CAR, BUT THEY DON'T SHOW UP ON MY RECORD WITH AUDI. THE CAR THEN WOULD NOT ENGAGE GEARS FOR A FEW RESTARTS, SUDDENLY IT WAS FINE AND WOULD DRIVE BUT I HAD IT TOWED DUE TO RISK FACTORS AND UNCERTAINTY. I BELIEVE THESE ARE RELATED EVENTS AND THEY TELL ME I NEED A NEW TRANSMISSION. THIS CAR HAS ONLY 45K MILES AND I'M NOT SURE IT IS A MECHANICAL FAILURE AT TALL. IT IS STRANGE THAT ALL OF THESE EVENTS COINCIDED AND SUSPECT PROBLEMS WITH COMPUTER COMMUNICATION BETWEEN TRANNY AND INSTRUMENT CLUSTER. THEY ARE NOT HELPING ME RESOLVE THIS AND DENYING INSTRUMENT CLUSTER PROBLEM. SAYING THERE IS NOTHING WRONG BUT THE GAS GAUGE IS NOT WORKING AND THIS IS A CLASSIC SIGN OF INSTRUMENT CLUSTER FAILURE WHICH LED TO THE LAWSUIT.
NHTSA complaint #10369978 — an unverified report by a vehicle owner.
at 75,423 milesFort Myers, FL
POWER TRAIN:AUTOMATIC TRANSMISSION
2004 AUDI TT 3.2 DSG TRANSMISSION, 75823 MILES. 2ND TIME THAT THE TRANSMISSION HAS DISENGAGED FROM THE ENGINE IN THE PASS SEVERAL MONTHS.THE BOTH TIMES THAT IT HAS HAPPENED IS WHEN INITIALLY THE CAR IS FIRST STARTED UP. I DRIVE SEVERAL FEET, STOP AND THEN ACCELERATE AGAIN AND THE CAR DOES NOT MOVE. WHEN ACCELERATING BY USING THE GAS PEDAL, THE ENGINE REVS TO HIGHER RPMS BUT DOES NOT MOVE OR THE TRANSMISSION DOES NOT ENGAGE. I TURN THE IGNITION OFF AND THEN RESTART THE CAR AGAIN AND CAR OPERATES NORMALLY WITH NO PROBLEMS. NO ENGINE MANAGEMENT LIGHT COMES ON TO INDICATE A PROBLEM. I CALLED THE DEALERSHIP THE FIRST TIME AND IT WAS INDICATED THAT THE CAR SOFTWARE SYSTEM WILL GET A HICCUP ON OCCASION AND THIS WAS NORMAL. I HAVE NEVER EXPERIENCE THIS PROBLEM (OR THE OCCASIONAL HICCUP) SINCE OWNING THE CAR WITH 5,500 MILES ON THE ODOMETER UNTIL RECENTLY.
NHTSA complaint #10365669 — an unverified report by a vehicle owner.
at 47,500 milesPhelan, CA
POWER TRAIN
OPERATING VEHICLE AT NORMAL SURFACE STREET AND HIGHWAY CONDITIONS - DSG TRANSMISSION DISENGAGES PUTTING VEHICLE INTO NEUTRAL AND ELIMINATING ALL POWER TRAIN RESPONSE. THIS FAILURE HAS OCCURRED TWICE WITHIN THE FIRST FIVE DAYS OF OPERATION - 1 @ SURFACE COASTING AS APPROACH TO INTERSECTION - THEN ACCELERATE - SYSTEM INITIATED A AUTO SHIFT SEQUENCE THAT RESULTED IN NEUTRAL, AND REQUIRED SYSTEM (IGNITION ) RESTART. 2@ FREEWAY COASTING AS APPROACHING SLOWER VEHICLE - THEN ACCELERATE - SYSTEM INITIATED A AUTO SHIFT SEQUENCE THAT RESULTED IN NEUTRAL, AND REQUIRED SYSTEM (IGNITION ) RESTART. NO REPAIR HAS BEEN DONE TO CORRECT ISSUE - STILL WORKING WITH DEALER.
NHTSA complaint #10365797 — an unverified report by a vehicle owner.
at 32,350 milesPalo Alto, CA
POWER TRAIN:AUTOMATIC TRANSMISSION
2004 AUDI TT 3.2 LITER, DSG TRANSMISSION, 32,000 MILES. AT RANDOM TIMES, THE ENGINE WOULD SUDDENLY DISCONNECT FROM THE DRIVETRAIN FOR A FEW SECONDS, A SERIOUS SAFETY ISSUE WHEN MERGING ONTO A FREEWAY, OR CROSSING A BUSY STREET. THIS OCCURRED MANY TIMES OVER A PERIOD OF WEEKS, UNTIL I STOPPED DRIVING THE CAR BECAUSE OF SAFETY CONCERNS. AN ERROR CODE SHOWED A SPEED SENSOR FAILURE, BUT REPLACING THE SENSOR DID NOT FIX THE PROBLEM. ULTIMATELY I HAD TO HAVE THE MECHATRONIC UNIT IN THE TRANSMISSION REPLACED TO FIX THE PROBLEM, AT A COST OF ABOUT 3,200 DOLLARS. I HAVE THE DEFECTIVE MECHATRONIC UNIT IN MY POSSESSION.
NHTSA complaint #10363934 — an unverified report by a vehicle owner.
