146 of the 1,149 complaints filed about the BMW 3 Series are about the electrical system — 13% of everything owners reported. The worst model year for it is 2006.
146
Complaints
13%
Share of all complaints
4
Crashes
10
Fires
ELECTRICAL SYSTEM
REAR LIGHTS . CLIP CONTACTS MELTING GROUND WIRE . PURCHASED LIGHTS AND CLIPS 3 TIMES AND MELTED AGAIN. LIGHTS INOPERABLE AFTER 2 WEEKS OF LIFE HARNESS MELTED . RECEIVED MULTIPLE WARNINGS AND A TICKET I NOW HAVE TO PROVE REPAIR . RECALL FOUND FOR EVERY OTHER MODEL EXCEPT THE 323I 2000 . NOT SAFE TO HAVE NO TAIL LIGHTS AVAILABLE . CAN'T DRIVE CAR IN UNSAFE CONDITIONS. CAN'T SELL CAR IN UNSAFE CONDITION
NHTSA complaint #11386688 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
MY 2008 BMW 335XI WITH 42000 MILES WAS STORED IN MY HEATED SHOP. THE CAR STARTED ON FIRE AND DESTROYED THE CONTENTS OF MY SHOP AND THE CAR. BMW SENT AN INSPECTOR TO CHECK THE DAMAGE AND TOOK HUNDREDS OF PICTURES. CLEARLY THE FIRE STARTED UNDER THE GLOVE COMPARTMENT AREA AND CONTINUED TO BURN UNTIL THE FRONT OF THE CAR, WINDSHIELD AND INTERIOR WAS DESTROYED. CONTENTS IN MY SHOP WERE DESTROYED AND THE INTERIOR OF THE BUILDING HAD TO BE GUTTED TO THE STUDS. BMW OFFERED NOTHING. DAMAGES TOTALLED MORE THAN $150,000. I RECEIVED A RECALL LETTER FROM BMW 3 WEEKS AFTER THE FIRE. * (RECALL RELATED INCIDENT)
NHTSA complaint #11217626 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE DOOR LOCK ACTUATORS HAVE FAILED. THIS MAKES IT SO THAT THE DOORS DO NOT OPEN WHEN YOU ARE INSIDE THE VEHICLE ATTEMPTING TO GET OUT BY PULLING THE DOOR HANDLE. THIS IS A SAFETY ISSUE NOT ALLOWING ME TO GET OUT OF MY VEHICLE. IF THIS ISSUE IS NOT RESOLVED BY PAYING THE $1500 TO FIX THE ISSUE THE DOORS WILL STOP OPENING COMPLETELY MAKING THIS EVEN MORE OF A SAFETY ISSUE OVER TIME. THIS ISSUE ONLY GETS WORSE AND IS DIRECTLY RELATED TO THE FUNCTIONALITY OF THE CAR. THIS DOOR LOCK ACTUATOR SHOULD BE RECALLED ON ALL VEHICLES BMW MAKES THAT ARE HAVING THIS SAME ISSUE. THIS IS A KNOWN LONG-STANDING ISSUE WITH THESE VEHICLES AND HAS YET TO BE RECALLED EVEN THOUGH IT IS ABSOLUTELY A SAFETY ISSUE. BMW SHOULD NOT BE ABLE TO PROFIT OFF OF THEIR POOR SAFETY MANUFACTURING MISTAKES.
NHTSA complaint #11191736 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I WAS RECEIVING A IMAGINE ON THE ON BOARD COMPUTER SAYING THAT MY HEADLIGHTS WERE NOT WORKING. UPON INSPECTION INSIDE THE HEADLIGHT'S CASING, I SAW THAT ALL OF THE WIRING'S PROTECTION HAD COMPLETELY FELL OFF (PROBABLY DUE TO THE HUMID SOUTHERN CLIMATE OF NORTH TEXAS) LEAVING ALMOST ALL OF THE WIRING ON BOTH SIDES OF MY HEADLIGHTS (DRIVER AND PASSENGER SIDE) COMPLETELY EXPOSED. THE COPPER WIRING INSIDE IS ALMOST ALL EXPOSED. OBVIOUSLY THIS IS CAUSING THE HEADLIGHTS TO SHORT AND LEAVING ME WITH NO VISIBILITY WHILE DRIVING AT NIGHT. THIS IS A MODEL WITHOUT ANGEL EYES, SO MY DRL DO NOT WORK WHAT SO EVER. THESE HEADLIGHTS ARE COMPLETELY STOCK, SO THIS IS A FACTORY FAULT. VERY UNHAPPY WITH THIS. THANKS BMW FOR THE "FANTASTIC" ENGINEERING! SHOULD BE COVERED UNDER A RECALL.
NHTSA complaint #11175801 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
WHILE DRIVING THE VEHICLE THE GLOVE BOX DEPARTMENT CAUGHT ON FIRE.
NHTSA complaint #11175881 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
DRIVER AND PASSENGER TRAPPED IN CAR AFTER PARKING AT AS GAS PUMP. DOORS WOULD UNLOCK BUT NOT OPEN RESULTING IN THE POTENTIAL OF KILLING ITS PASSENGERS IN A CRASH. THERE IS A VIDEO ON YOUTUBE OF A SIMILAR INCIDENT.
NHTSA complaint #11169906 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I WAS GOING DOWN THE ROAD DOING ABOUT 45 MPH, AT NIGHT ON A BACK ROAD WHEN MY FRONT HEADLIGHT ON THE DRIVE SIDE WITHOUT. ON THE DISHBOARD OF THE CAR THE CHECK BULB LIGHT CAME ON. I GOT HOME THE NEXT DAY WHEN TK THE PART PLACE TO GET A BULB TO FIND OUT THE WIRES WHERE BARE THERE WAS ONLY METAL NO PLASTIC. THEG TOLD ME YOU HAD TO REPLACE THE HOLE THING WITCH COST OVER 1000 DOLLARS FOR. I WENT HOME RESEARCH IT ONLINE, AND FOUND OUT IT HAPPENS A LOT ON BMW, AND THEY NEVER RECALL THEM. THAT THEY HAVE EVEN BEEN ON FIRE DUE TO THIS. I CALLED BMW AND THEY TOLD ME THEY KNOW OF THE ISSUE, AND THEY HAVE YET TO RECALL THEN AND AFTER YOU FIT IT IT WILL HAPPEN AGAIN AND ABOUT FIVE YEARS DUE TO HEAT.
NHTSA complaint #11164047 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I WAS GOING BETWEEN 30 AND 35 MPH THROUGH CITY STREETS AT ROUGHLY 3AM ON MY WAY BACK FROM MY COMMUTE WHICH IS ROUGHLY 60 MILES. I NOTICED IT STARTED TO SMELL LIKE BURNING PLASTIC AND IMMEDIATELY AFTER SMOKE WAS VISIBLE COMING FROM HOOD VENTS, I PARKED THE CAR AS SOON AS I COULD AND POPPED THE HOOD AND THE HEAT COVER FOR THE HOOD WAS ON FIRE ALONG WITH MOST OTHER COMPONENTS IN THE ENGINE BAY. MY FRIEND IMMEDIATELY CALLED 911 FOR ASSISTANCE AS I RAN AND TRIED TO WARN NEIGHBORS , WITHIN 7 MINUTES THE CAR WAS COMPLETELY CHARD. NO MAITNANCE LIGHTS WERE ON AND NOTHING SEEMED TO BE A PROBLEM. THE TWO RECALLS I NEVER RECEIVED BOTH WOULD EXPLAN THIS INCEDENT NHTSA CAMPAIGN NUMBER: 17V683000 NHTSA CAMPAIGN NUMBER: 17V676000
NHTSA complaint #11162148 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I RECEIVED A RECALL LETTER TELLING ME TO STAND BY FOR ANOTHER RECALL LETTER TO THEN TELL ME TO HAVE THE CAR FIXED. THE CAR BLOWN UP PARKED OUTSIDE OF MY HOUSE IT HAS NOT BEEN USED FOR 24 HOURS PRIOR TO THE INCIDENT. I HAVE JUST NOW RECENTLY RECIEVED THE SECOND RECALL LETTER MONTHS LATER NO. 17V-676
NHTSA complaint #11161077 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
DEALER REFUSED TO MAKE THE REPAIRS ON MY ENGINE THAT WAS CAUSED BY THE RECALL PRODUCT THE PCV VALVE. DEALER SAYS THEIR NOT REQUIRED TO MAKE ANY REPAIRS, THEIR JOB IS TO REPLACE THE RECALL PART
NHTSA complaint #11154758 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
STATIONARY IN PARKING LOT. FRONT PASSENGER DOOR WILL NOT LOCK/UNLOCK WITH ANY METHOD ATTEMPTED. DRIVERS DOOR WILL ONLY UNLOCK USING EMERGENCY KEY FROM EXTERIOR.
NHTSA complaint #11150825 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
DESPITE REPEATED PHONE CALLS TO BMW CUSTOMER SERVICE, AND STOPPING AT THE LOCAL DEALERSHIP, NO ACTION HAS BEEN TAKEN BY BMW FOR A RECALL REGARDING A SPONTANEOUS FIRE THAT CAN OCCUR WITH MY VEHICLE DUE TO AN ELECTRICAL ISSUE, EVEN WHEN THE CAR IS GARAGED AND NOT IN USE. CUSTOMER SERVICE REPEATEDLY TELLS ME THEY DON'T HAVE THE PARTS TO FIX THE ISSUE. I LEARNED ABOUT THIS PROBLEM A YEAR AND A HALF AGO FROM THE NEWS. I HAVE NEVER RECEIVED A RECALL LETTER FROM BMW, ALTHOUGH I VERIFIED WITH THEM THEY HAVE MY VIN NUMBER AND MY CAR IS PART OF THE RECALL. I HESITATE TO EVEN DRIVE MY CAR AND HAVE SERIOUS CONCERNS ABOUT A SPONTANEOUS FIRE SPARKED BY AN ELECTRICAL ISSUE. IT SEEMS UNACCEPTABLE AS A CONSUMER NO ACTION HAS BEEN TAKEN TO REMEDY WHAT COULD BE A VERY SERIOUS ISSUE (MY HOUSE BURNING DOWN FOR ONE). I AM GETTING NOWHERE WHEN I CONTACT BMW.
NHTSA complaint #11149689 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
RECALL 17V-676: BLOWER MOTOR WIRING BURNING HOT AIR FROM THE VENT IS IN WITH OR WITHOUT FAN ON (MOTION OR PARKING). IT IS OVERDUE AND NO RESPONSE FROM BMW OF AMERICA, LLC AS I KEPT ON CALLING THE OFFICE MANY TIMES SINCE 12/16/2017 LETTER RECEIVED. 1/19/2018 6/5/2018 8/20/2018 10/12/2018 TO NHTSA 11/5/2018
NHTSA complaint #11149509 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE WIRES ON THE INSIDE OF MY HEADLIGHTS ARE CRACKED, AND HAVE A LOT OF BARE COPPER SHOWING. THE PLASTIC SHEATHING (CABLE JACKET) HAS BECOME BRITTLE FROM THE HEAT, AND IS FALLING APART, EXPOSING THE CONDUCTOR. THIS IS CREATING THE RISK OF AN ELECTRICAL FIRE OR DAMAGE TO THE ELECTRICAL SYSTEM. THE RIGHT HEADLIGHT AND THE ANGEL LIGHTS OF MY CAR IS NOT WORKING IT WHEN OFF WHILE THE CAR WAS IN MOTION - ALL IT TAKES IS TO TOUCH A CABLE WITH YOUR FINGERS AND THE COOPER WILL BE EXPOSE. I'M REQUESTING IMMEDIATE RECALL FROM BMW - SEVERAL CARS ARE HAVING THE SAME ELECTRICAL AND FIRE HAZARD ISSUES. PLEASE FIX THIS PROBLEM BEFORE SOMEBODY GET'S HURT.
NHTSA complaint #11139363 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
A RECALL WAS ISSUE FOR BLOWER MOTOR WIRING. IT HAS ALMOST BEEN A YEAR AND EVERY TIME I INQUIRE WITH THE DEALER THEY SAY THEY DON'T HAVE THE REMEDY AVAILABLE. SHOULD I BE CONCERNED ABOUT THE VEHICLE CATCHING FLAMES WHILE IN MY GARAGE?
NHTSA complaint #11132372 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TAKATA RECALL - I THINK AIR BAG AND SEAT BELT WARNING LIGHTS ARE ON ALL THE TIME. BMW SAYS THERE IS NO RECALL AFFECTING THIS. BOTH STATIONARY AND MOVING.
NHTSA complaint #11132144 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
RECALL # 17V676, 17V683 IT HAS BEEN NEARLY A YEAR AND I'M STILL UNABLE TO MAKE REPAIR APPOINTMENT WITH BMW DEALER FOR REASON OF PARTS UNAVAILABLE. MY AIR CONDITIONING SYSTEM COULDN'T KEEP CAR COOL ENOUGH AS HEAT FROM THE ENGINE IS HIGH.
NHTSA complaint #11131585 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
REPLACED BLOWER MOTOR TWICE 4 MONTHS 1ST ONE MADE NOISE AND STOP BLOWING AIR OUT VENTS NOW SECOND ONE IS MAKING LOUD RATTLING NOISE. CONSTANT TAIL LIGHT BULB ISSUES DISPLAY TAIL LIGHT MALFUNCTION.
NHTSA complaint #11128187 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
MANUFACTURER HAS NOT REMEDY THE SAFETY RECALLS IN A TIMELY MANNER AS IT'S BEEN ALMOST A YEAR SINCE THE RECALLS AND THERE ARE STILL NO PARTS/FIXES AVAILABLE. THERE ARE 2 RECALLS FROM OCT 2017 AND AS OF TODAY AUG 2018 THERE ARE NO PARTS AVAILABLE TO FIX THE ISSUES: POSITIVE CRANKCASE VENTILATION (PCV) VALVE HEATER AND BLOWER MOTOR WIRING. SAFETY RISKS: OVER TIME, IT COULD DETERIORATE AND, IN RARE CASES, COULD LEAD TO OVERHEATING. AND CONNECTION BETWEEN THE WIRING AND THIS SYSTEM COULD DETERIORATE AND, IN RARE CASES, COULD LEAD TO OVERHEATING.
NHTSA complaint #11122901 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
PASSENGER AIRBAG RESTRAINT FAILURE - BMW'S, IN PARTICULAR 3 SERIES AND E90 MODELS, HAVE A KNOWN AND COMMON FAILURE WHERE THE SEAT BASED ELECTRICAL MAT FAILS IN THE PASSENGER SEATS. THIS IS NOT RELATED TO WEAR AND TEAR AS THE SEATS OFTEN GO UNUSED BUT SIMPLY FAIL AFTER A CERTAIN PERIOD OF TIME. THE ERROR CAUSES THE PASSENGER SIDE AIRBAG TO DEFAULT TO ALWAYS ON, WHICH CAN CAUSE INJURY OR DEATH TO CHILDREN OR SMALL PASSENGERS IN THAT SEAT. THE COST TO REPAIR THIS IS USUALLY $200 FOR PARTS AND $400 FOR LABOR WHICH MEANS MANY DRIVERS SIMPLY DON'T FIX IT CREATING A VULNERABILITY. THE ISSUE HAS BEEN RECURRING WITH BMWS FOR SEVERAL GENERATIONS AND ACROSS MODEL TYPES AND SHOULD BE ADDRESSED BY THE MANUFACTURER AS ITS A POORLY MADE PART AND SET UP. THERE ARE NUMEROUS DOCUMENTED CASES ON BMW FORUMS AND A PARTIAL RECALL FOR SOME MODELS WAS IMPLEMENTED. A FULL RECALL IS NEEDED ON ALL CARS AFFECTED, INCLUDING 2007 3 SERIES MODELS. THE ISSUE DOES NOT APPEAR FIXED UNTIL THE F MODEL 3 SERIES CAME OUT. HTTPS://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?P=4746508#POST4746508 HTTPS://WWW.BIMMERFEST.COM/FORUMS/ARCHIVE/INDEX.PHP/T-496444.HTML
NHTSA complaint #11121592 — an unverified report by a vehicle owner.