94 of the 1,149 complaints filed about the BMW 3 Series are about the lighting — 8% of everything owners reported. The worst model year for it is 2004.
94
Complaints
8%
Share of all complaints
0
Crashes
4
Fires
EXTERIOR LIGHTING
REAR LIGHTS . CLIP CONTACTS MELTING GROUND WIRE . PURCHASED LIGHTS AND CLIPS 3 TIMES AND MELTED AGAIN. LIGHTS INOPERABLE AFTER 2 WEEKS OF LIFE HARNESS MELTED . RECEIVED MULTIPLE WARNINGS AND A TICKET I NOW HAVE TO PROVE REPAIR . RECALL FOUND FOR EVERY OTHER MODEL EXCEPT THE 323I 2000 . NOT SAFE TO HAVE NO TAIL LIGHTS AVAILABLE . CAN'T DRIVE CAR IN UNSAFE CONDITIONS. CAN'T SELL CAR IN UNSAFE CONDITION
NHTSA complaint #11386688 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
BRAKE LIGHTS ON BOTH SIDES GETS STUCK ON ONCE THE PEDAL IS PRESSED. THIS PRODUCES NO ERROR CODES. I WAS TOLD IT COULD BE THE BRAKE PEDAL PRESSURE SENSOR SWITCH. I CHANGED THIS AND IT DID NOTHING. THIS IS VERY DANGEROUS TO OTHER DRIVERS BECAUSE THEY ARE NOT SURE IF THE CAR IS BRAKING AS THE LIGHT IS ALWAYS ON AND WILL BURN OUT THE BULBS AND MELT THE HOUSING IF CONSTANTLY ON. THIS CAN BE REPRODUCED EITHER WHILE PARKED OR IN MOTION.
NHTSA complaint #11220395 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
HEADLAMP BULB OUT AND UPON REPLACEMENT IT WAS NOTED THE COATED WIRING TO THE XENON SYSTEM TO RIGHT AND LEFT HEADLIGHT IS BRITTLE (THE WIRES PLASTIC COATING IS FALLING OFF)AND IN SOME PLACES EXPOSED WIRING WAS FOUND. ELECTRICAL TAPE NEED TO WRAP THE WIRING TO AVOID POTENTIAL FIRE. LATE NOTICE TO THIS SITE I WAS UNAWARE TO FILE A REPORT. OTHERS ALSO HAVE COMPLAINED ABOUT THE SAME ISSUES.
NHTSA complaint #11190961 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
I WAS RECEIVING A IMAGINE ON THE ON BOARD COMPUTER SAYING THAT MY HEADLIGHTS WERE NOT WORKING. UPON INSPECTION INSIDE THE HEADLIGHT'S CASING, I SAW THAT ALL OF THE WIRING'S PROTECTION HAD COMPLETELY FELL OFF (PROBABLY DUE TO THE HUMID SOUTHERN CLIMATE OF NORTH TEXAS) LEAVING ALMOST ALL OF THE WIRING ON BOTH SIDES OF MY HEADLIGHTS (DRIVER AND PASSENGER SIDE) COMPLETELY EXPOSED. THE COPPER WIRING INSIDE IS ALMOST ALL EXPOSED. OBVIOUSLY THIS IS CAUSING THE HEADLIGHTS TO SHORT AND LEAVING ME WITH NO VISIBILITY WHILE DRIVING AT NIGHT. THIS IS A MODEL WITHOUT ANGEL EYES, SO MY DRL DO NOT WORK WHAT SO EVER. THESE HEADLIGHTS ARE COMPLETELY STOCK, SO THIS IS A FACTORY FAULT. VERY UNHAPPY WITH THIS. THANKS BMW FOR THE "FANTASTIC" ENGINEERING! SHOULD BE COVERED UNDER A RECALL.
NHTSA complaint #11175801 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
REPLACED BLOWER MOTOR TWICE 4 MONTHS 1ST ONE MADE NOISE AND STOP BLOWING AIR OUT VENTS NOW SECOND ONE IS MAKING LOUD RATTLING NOISE. CONSTANT TAIL LIGHT BULB ISSUES DISPLAY TAIL LIGHT MALFUNCTION.
NHTSA complaint #11128187 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
INTERMITTENT SIDE LIGHT, BRAKE LIGHT PROBLEM
NHTSA complaint #11013524 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
PASSENGER TURN SIGNAL BULB WAS THOUGHT TO BE OUT. BROUGHT TO LOCAL BMW DEALER AND HAD THEM TELL ME I NEED A WHOLE HEADLIGHT SINCE THE TURN SIGNAL BURNED INSIDE.
NHTSA complaint #10971454 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
PASSENGER HEADLIGHT LOW BEAM REFLECTOR IS BURNT OUT DUE TO FAULTY MATERIAL BEING USED. REFLECTOR IS MADE OUT OF PLASTIC AND NORMAL HEAT FROM BULB MELTS THE PLASTIC. THIS MAKES IT VERY UNSAFE AND DIFFICULT TO SEE AT NIGHT. THIS SEEMS TO BE EXTREMELY COMMON ON THE INTERNET. THE SOLUTION IS VERY EXPENSIVE AND DUE TO THIS COST,MOST PEOPLE WILL NOT FIX AND DRIVE UNDER THIS UNSAFE SITUATION. PLEASE LOOK INTO THIS AND HOLD BMW RESPONSIBLE.
NHTSA complaint #10971468 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
WIRING INSULATION CRACKING DEGRADING LEAVING EXPOSED BARE WIRING CAUSING SHORTS AND POSSIBLE FIRE IN HEADLIGHT WIRING HARNESSES, WIRES ARE STATIONARY DO NOT MOVE. INSULATION IS CRAKED AND FALLING OFF WIRES. NOTICED FAILURE DURING BULB REPLACEMENT. MADE THIS COMPLAINT AFTER READING ABOUT NUMEROUS OTHER BMW OWNERS NOTICING SAME FAULT
NHTSA complaint #10969189 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
INSULATION FAILED ON WIRING INSIDE HEADLAMP ASSEMBLY, CRUMBLING OFF AND CREATING MULTIPLE EXPOSED BARE COPPER WIRING. DISCOVERED DURING LAMP REPLACEMENT PROCEDURE NOV 21, 2015. I OVERLAID ALL ACCESSIBLE WIRES WITH ELECTRICAL TAPE IN HOPES TO PREVENT A SHORT AND FIRE. SINCE THEN I'VE READ OF SIMILAR PROBLEMS REPORTED BY SEVERAL BMW OWNERS ON BIMMERFORUMS.COM, WITH ATTACHED CORRESPONDENCES FROM BMW DENYING ANY PROBLEM. DEALERS AND REPUTABLE INDEPENDENT REPAIR SHOPS ARE VERY AWARE OF THIS ISSUE.
NHTSA complaint #10960264 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
HEADLIGHTS PROJECT ALMOST NO LIGHT. JUST PAID $130 TO HAVE LENSES CLEANED, NO IMPROVMENT. I THOUGHT IT WAS MY EYES AND COMPLAINED TO OPTHAMOLOGIST TWICE BUT MY EYES ARE OK. I'VE READ THT THE REFLECTOR BOWLS IN THIS MODEL MELT FROM THE HEAT OF THE BULB. I NEED TO REMEDY THIS SITUATION ASAP SO I WILL NOT BE ABLE TO WAIT FOR AN INVESTIGATION.
NHTSA complaint #10939058 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
THE ZKW XENON HEADLIGHTS HAVE A FLAW IN THE PLASTIC PROJECTOR HOUSING. THE HOUSING GETS TOO HOT AND MELTS AND THE LIGHT OUTPUT IS SEVERELY RESTRICTED. THIS HAPPENS TO 100% OF THE HEADLIGHTS MADE BY THIS MANUFACTURER AND IS A SAFETY ISSUE. THE REFLECTIVE COATING ON THE HEADLIGHTS MELTS AND THE LIGHT CAN NO LONGER BE PROJECTED OUT CORRECTLY. THE FOG LIGHTS ARE NOW BRIGHTER THEN THE HEADLIGHTS. THE VEHICLE CAN NO LONGER BE SAFELY DRIVEN AT NIGHT. SPARE PARTS ARE NOT AVAILABLE AND THE ONLY FIX IS TO REPLACE THE ENTIRE HEADLIGHTS AT A COST OF OVER $2000. THERE SHOULD BE A RECALL TO REPLACE THE HEADLIGHTS AS THIS IS A SAFETY ISSUE OF NOT BEING ABLE TO SEE.
NHTSA complaint #10928130 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
MY HEADLIGHTS ARE SO DIM AT NIGHT IT IS IMPOSSIBLE TO SEE WITHOUT HIGH BEAMS ON AT ALL TIMES. THE FOG LIGHTS ARE BRIGHTER THAN MY NEW HEADLIGHT BULBS. ONLY SOLUTION SEEMS TO REPLACE THE WHOLE ASSEMBLY BUT AFTER RESEARCHING THIS SEEMS TO BE AN ONGOING ISSUE WITH BMW SO WHY SHOULD I HAVE TO SPEND OVER 1500.00 WHEN THEY SHOULD HAVE TO REPLACE THEM WITH A RECALL.
NHTSA complaint #10915585 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
THE BRAKE LIGHTS AND TURN SIGNALS DON'T WORK... THE TRANSMISSION- REVERSE HAS GONE OUT... AND THE RADIATOR HAS A SERIOUS LEAK... MAKES THE CAR RUN HOT!
NHTSA complaint #10887482 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
I OWN A 2006 BMW 325I. ABOUT A YEAR OR TWO AGO, THE REVERSE LIGHTS WILL NOT ILLUMINATE WHILE REVERSING. I TOOK THE VEHICLE TO THE DEALERSHIP, EXPLAINED THE PROBLEM, AND MENTIONED MULTIPLE ONLINE ACCOUNTS OF THIS PROBLEM EXTENDING AT LEAST FROM 2003 THROUGH 2008. IT COULD HAVE BEEN LONGER. I ALSO REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TURN SIGNAL) AND NHTSA ID NUMBER: 10443539 (TAIL LIGHT FAILURE). THE DEALER ADVISED ME THAT THIS VEHICLE YEAR WAS NOT INCLUDED IN ANY RECALL CAMPAIGN FOR THIS PROBLEM. IN ADDITION, THE DEALER ADVISED THAT THE FRM MODULE NEEDED TO BE REPLACED DUE TO A WIRING MALFUNCTION. FROM ONLINE REPORTS AND PICTURES, I CONFIRMED MY REVERSE LIGHT FAILURE WAS ALSO A WIRING ISSUE CAUSED FROM A VERY POOR WIRE ROUTING DESIGN BY BMW. THE FAILURE MILEAGE WAS AT APPROXIMATELY 110,000 AND THE COST TO REPAIR WAS OUTRAGEOUS! SINCE THAT TIME EVEN WITH MULTIPLE DOCUMENTED CASES, BMW HAS BEEN UNWILLING TO ADMIT THIS IS THEIR DESIGN FAILURE AND TO SHARE IN ANY OF THE REPAIR COSTS.
NHTSA complaint #10861603 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
THE RIGHT TAIL LIGHTS' TURN SIGNAL START FLICKERING WITH THE LIGHT ERROR SIGNAL IN THE DASH, I RESEARCHED IT TO FIND OUT THAT THEY HAVE BEEN SEVERAL SERVICE BULLETINS OUT ABOUT THE REAR TURN SIGNALS GETTING CORROSION. I CALLED THE DEALER AND THEY STATED IT WAS OUT OF WARRANTY AND THEY WOULD NOT PAY TO FIX IT. THEY STATED THEY KNEW THE SERVICE BULLETINS WERE OUT BUT IT WAS NOT A RECALL. AFTER FURTHER SEARCHING I FOUND OUT THE OLDER MODELS HAD A RECALL TO FIX THIS ISSUE. IF THEY KNOW THEY HAVE AN ISSUE THEN WHY DON'T THEY FIX IT.
NHTSA complaint #10854350 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
SIDE MIRRORS FADING INTO A BROWN COLOR. MAKING THE VISIBILITY THROUGH THEM IMPOSSIBLE. MANY TIMES I HAVE ALMOST SIDE SWIPED CARS THAT ARE ON THE SIDE OF ME DUE TO MY NOT BEING ABLE TO SEE OUR OF MY SIDE MIRRORS. ALSO FRONT LIGHT KEEPS GOING OUT. I HAVE CHANGED IT 3 TIMES IN TWO MONTHS AND IT KEEPS EITHER GOING OUT OR FALLING OUT OF THE HOLE MAKING THE INDICATOR LIGHT COME ON.
NHTSA complaint #10839998 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
XENON ADAPTIVE HEADLIGHTS - THE WIRE INSIDE MY XENON ADAPTIVE HEADLIGHTS IS BRITTLE AND THE INSULATION IS FLAKING OFF. I DISCOVERED THE PROBLEM WHEN I OPENED ONE OF MY HEADLIGHT ASSEMBLIES TO REPLACE A BULB. SIGNIFICANT AMOUNTS OF WIRE INSULATION HAVE FLAKED OFF AND EXPOSED COPPER WIRING. I HAVE LOTS OF PICTURES. I AM FORTUNATE THAT I DID NOT HAVE A SHORT OR A FIRE. THIS IS A SAFETY ISSUE AND COMPLETELY UNACCEPTABLE. BMW MUST ALREADY KNOW THAT THEY HAVE A WIRING DEFECT IN THEIR CARS. BMW REPLACEMENT HEADLIGHT ASSEMBLIES ARE $2600 PLUS LABOR. I AM THE SECOND OWNER OF THIS 2007 BMW 328I E92 WITH 48,000 MILES. BMW WOULD NOT STAND BEHIND THEIR PRODUCT AND REPLACE THE HEADLIGHT ASSEMBLIES.
NHTSA complaint #10809811 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
THE REAR PARKING LIGHT WENT OUT IN MY CAR, SO I PURCHASED MORE BULBS, BUT THE BULB NEVER WORKED. I TOOK MY CAR TO MY BMW DEALERSHIP FOR THE TAKATA RECALL, THEY CHECKED THE LIGHT TOO AND SAID THAT A PART IN THE HOUSING HAD BURNED ALL THE WAY DOWN . I RECENTLY CHECKED ON RECALLS, AND FOUND THAT THERE WERE PROBLEMS WITH THE HOUSING THAT HOUSES THE BRAKE AND SIGNAL LIGHTS, BEGINNING WITH 2002 MODELS. MY CAR IS A 325I 2001, I FEEL THAT THIS YEAR SHOULD BE INCLUDED IN A RECENT RECALL, I RESEARCHED ONLINE, AND FOUND THAT THERE ARE MANY 2001 BMW 325IS WITH THE SAME PROBLEM AS THE THAT RECALL. THIS COULD POSSIBLY CAUSE AN ACCIDENT. I REALLY THINK THIS SHOULD BE INCLUDED IMMEDIATELY.
NHTSA complaint #10795195 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
CAR WAS PARKED IN THE DRIVEWAY, DROVE IT EARLIER THAT DAY FOR ABOUT AN HOUR, PARKED IT 3PM AND 2 HOURS LATER NEIGHBOR CAME KNOCKING SAYING CAR WAS SMOKING. RAN OUTSIDE AND CAR WAS ON FIRE. INTERIOR WAS SMOKED OUT. KEYLESS ENTRY WAS DEAD. BROKE THE WINDOW TO GET THE CAR OPEN, TURNED THE GARDEN HOSE ON TO TRY AND STOP THE CAR FROM BURNING. CALLED 911 FIRE DEPT ARRIVED AND HAD TO PRY THE TRUCK OPEN BECAUSE IT WAS STILL SIZZLING. FIRE DEPT CUT THE BATTERY CABLES AND SAID IT LOOKED LIKE AN ELECTRICAL FIRE UNDER THE DASH. GLOVE BOX AND PASSENGER SIDE FRONT SEAT WAS COMPLETELY CHARRED. AFTER 22 DAYS, A BMW ENGINEER AND ALLSTATE INS CALLED IT A TOTAL LOSS. BMW ENGINEERS REPORT STILL HAS NOT BEEN PUBLISHED. TOTAL LOSS ON A PARKED VEHICLE; CLEARLY THIS VEHICLE WAS UNSAFE AND A DESIGN FAULT. MANUFACTURERS ARE SUPPOSE TO ENGINEER CARS TO WITHSTAND FIRES.
NHTSA complaint #10758905 — an unverified report by a vehicle owner.