Owners have filed 152 complaints
about the 2008 BMW 328XI with NHTSA between 2009 and 2025.
The largest single group is the electrical system.
Across this model's run it ranks 1 of 8 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 92
Against the median year of the BMW 328XI. 50 means typical for this
model; 100 means roughly double.
Severity — 100
23% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 27
16% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
66.8%
10,000 – 24,999 miles
44.5%
25,000 – 49,999 miles
1213.6%
50,000 – 74,999 miles
2528.4%
75,000 – 99,999 miles
1517.0%
100,000 – 149,999 miles
2022.7%
150,000+ miles
66.8%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jul 2009peak 10Apr 2025
Recalls on the 2008 BMW 328XI
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
24V513000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
20V017000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
17V676000
ELECTRICAL SYSTEM:WIRING
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Risk: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 70,000 milesBloomfield, CTFire
ENGINE AND ENGINE COOLING
The contact owned a 2008 BMW 328xi. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the repair was unavailable. The contact's son was driving approximately 30 MPH when the son noticed that smoke had begun to issue from the dashboard vents. The son pulled over and stopped the vehicle and exited when the vehicle dashboard burst into flames. The fire department was called and extinguished the flames with water. The vehicle was towed to the contact's residence. The contact's insurance provider declared the vehicle a total loss. The failure mileage was approximately 70,000. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. Parts distribution disconnect.
NHTSA complaint #11492266 — an unverified report by a vehicle owner.
at 131,000 milesKingston, NYFire
ENGINE
The contact owned a 2008 BMW 328xi. The contact stated while driving 35 mph, she saw smoke exiting the front passenger side of the vehicle. The contact stated that there was no warning light illuminated. The contact parked and exited the vehicle safely and called 911. The contact stated 25 seconds after exiting the vehicle, the vehicle exploded and caught on fire. The fire department arrived and extinguished the fire. A fire report was filed. The contact stated that there was no injury. A police report was not filed. The vehicle was towed to a towing lot. The vehicle was not diagnosed nor repaired. A dealer was not contacted. The manufacturer was not informed of the failure. The failure mileage was approximately 131,000.
NHTSA complaint #11419176 — an unverified report by a vehicle owner.
at 250,000 milesBrooklyn, NYFire
AIR BAGS
CAR CAUGHT ON FIRE FOR UNKNOWN REASONS. WHEN THE CAR WAS TURNED ON SMOKE CAME OUT FROM THE AIR CONDITIONING VENTS AND ALL DOORS LOCKED FROM INSIDE. THERE WERE 2 OCCUPANTS INSIDE THAT NEEDED ASSISTANCE TO GET OUT WHILE THE CAR WAS CATCHING FIRE. THE VEHICLE WAS PARKED.
NHTSA complaint #11337419 — an unverified report by a vehicle owner.
at 250,000 milesBrooklyn, NYFire
UNKNOWN OR OTHER
CAR CAUGHT ON FIRE FOR UNKNOWN REASONS. WHEN THE CAR WAS TURNED ON SMOKE CAME OUT FROM THE AIR CONDITIONING VENTS AND ALL DOORS LOCKED FROM INSIDE. THERE WERE 2 OCCUPANTS INSIDE THAT NEEDED ASSISTANCE TO GET OUT WHILE THE CAR WAS CATCHING FIRE. THE VEHICLE WAS PARKED.
NHTSA complaint #11337419 — an unverified report by a vehicle owner.
at 250,000 milesBrooklyn, NYFire
ELECTRICAL SYSTEM
CAR CAUGHT ON FIRE FOR UNKNOWN REASONS. WHEN THE CAR WAS TURNED ON SMOKE CAME OUT FROM THE AIR CONDITIONING VENTS AND ALL DOORS LOCKED FROM INSIDE. THERE WERE 2 OCCUPANTS INSIDE THAT NEEDED ASSISTANCE TO GET OUT WHILE THE CAR WAS CATCHING FIRE. THE VEHICLE WAS PARKED.
NHTSA complaint #11337419 — an unverified report by a vehicle owner.
Bellerose, NYFire
UNKNOWN OR OTHER
VEHICLE WAS PARKED OVERNIGHT AND A FIRE STARTED UNDER THE DASHBOARD
NHTSA complaint #11301519 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Norwalk, CT
TIRES
225/40R18 the stoplight right down route 7 by stop and shop there is a rectangular hole in the street. I could not avoid it when driving Friday morning 4/25/25 and the dip in the ground blew my driver side front and rear tires and scratched the rims. I had to spend my day Friday getting my tires replaced and now I have scratches on my rims which are fairly new
NHTSA complaint #11657027 — an unverified report by a vehicle owner.
at 162,000 milesPortage, IN
AIR BAGS
The contact owns a 2008 BMW 328XI. The contact stated that while the vehicle was parked, the air bag deployed unintendedly. The contact stated there was no warning light illuminated prior to the air bag deployment. The air bag deployed, and there was no occupant inside the vehicle. The contact stated that after the air bag had deployed, the air bag warning light was illuminated after the air bag had deployed. The vehicle was recently taken to the dealer and the vehicle was taken to the dealer, and the dealer informed the contact that the VIN was not under recall. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 162,000.
NHTSA complaint #11655170 — an unverified report by a vehicle owner.
Reading, PA
FUEL/PROPULSION SYSTEM
Unknown
NHTSA complaint #11635483 — an unverified report by a vehicle owner.
Deltona, FL
EXTERIOR LIGHTING
Wiring inside headlamp is not up to Standards. For the cost the replace the headlight the wiring should not be falling apart causing shorts. One night I was driving and got a warning on my dash for my headlights and noticed it was a bit harder to see. Pulled over and noticed the headlight was out. Went to replace the bulb and noticed the wires have zero protection on them and are all touching.. this is not safe as wire shorts can cause a fire and not to mention the visibility issues. The driver side is not the bright at all and flickers while I’m driving. Both sides are having this issue and that’s unacceptable saying the headlights are over 800 dollars EACH and that’s used.. I do not feel safe driving this vehicle knowing that the wire short can cause a fire while I’m driving.
NHTSA complaint #11603501 — an unverified report by a vehicle owner.
Deltona, FL
ELECTRICAL SYSTEM
Wiring inside headlamp is not up to Standards. For the cost the replace the headlight the wiring should not be falling apart causing shorts. One night I was driving and got a warning on my dash for my headlights and noticed it was a bit harder to see. Pulled over and noticed the headlight was out. Went to replace the bulb and noticed the wires have zero protection on them and are all touching.. this is not safe as wire shorts can cause a fire and not to mention the visibility issues. The driver side is not the bright at all and flickers while I’m driving. Both sides are having this issue and that’s unacceptable saying the headlights are over 800 dollars EACH and that’s used.. I do not feel safe driving this vehicle knowing that the wire short can cause a fire while I’m driving.
NHTSA complaint #11603501 — an unverified report by a vehicle owner.
Deltona, FL
VISIBILITY/WIPER
Wiring inside headlamp is not up to Standards. For the cost the replace the headlight the wiring should not be falling apart causing shorts. One night I was driving and got a warning on my dash for my headlights and noticed it was a bit harder to see. Pulled over and noticed the headlight was out. Went to replace the bulb and noticed the wires have zero protection on them and are all touching.. this is not safe as wire shorts can cause a fire and not to mention the visibility issues. The driver side is not the bright at all and flickers while I’m driving. Both sides are having this issue and that’s unacceptable saying the headlights are over 800 dollars EACH and that’s used.. I do not feel safe driving this vehicle knowing that the wire short can cause a fire while I’m driving.
NHTSA complaint #11603501 — an unverified report by a vehicle owner.
Guttenberg, NJ
EXTERIOR LIGHTING
BMW Bi Xenon Headlights wires harness. Insulation on wires peels off and start touching each other. Malfunction high beam, low beam, turning light.
NHTSA complaint #11504077 — an unverified report by a vehicle owner.
Guttenberg, NJ
ELECTRICAL SYSTEM
BMW Bi Xenon Headlights wires harness. Insulation on wires peels off and start touching each other. Malfunction high beam, low beam, turning light.
NHTSA complaint #11504077 — an unverified report by a vehicle owner.
at 70,000 milesBloomfield, CTFire
ENGINE AND ENGINE COOLING
The contact owned a 2008 BMW 328xi. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the repair was unavailable. The contact's son was driving approximately 30 MPH when the son noticed that smoke had begun to issue from the dashboard vents. The son pulled over and stopped the vehicle and exited when the vehicle dashboard burst into flames. The fire department was called and extinguished the flames with water. The vehicle was towed to the contact's residence. The contact's insurance provider declared the vehicle a total loss. The failure mileage was approximately 70,000. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. Parts distribution disconnect.
NHTSA complaint #11492266 — an unverified report by a vehicle owner.
Stanardsville, VA
EXTERIOR LIGHTING
The positive battery fuse cable under the glovebox is placed into a plastic space causing melting. This leads to the vehicle going dead and not even emergency lights will work. This recall has been placed on very few BMWs however it is affecting way more then they are saying. You can see in UK where a man was killed for the vehicle going dead in the middle of the road and emergency lights cannot be used to warn other drivers. How has their not been taken car of already. I am extremely disappointed in our system, and in BMW. My mind is completely blown that this is not cared about.
NHTSA complaint #11487711 — an unverified report by a vehicle owner.
Stanardsville, VA
ELECTRICAL SYSTEM
The positive battery fuse cable under the glovebox is placed into a plastic space causing melting. This leads to the vehicle going dead and not even emergency lights will work. This recall has been placed on very few BMWs however it is affecting way more then they are saying. You can see in UK where a man was killed for the vehicle going dead in the middle of the road and emergency lights cannot be used to warn other drivers. How has their not been taken car of already. I am extremely disappointed in our system, and in BMW. My mind is completely blown that this is not cared about.
NHTSA complaint #11487711 — an unverified report by a vehicle owner.
Stanardsville, VA
ENGINE
The positive battery fuse cable under the glovebox is placed into a plastic space causing melting. This leads to the vehicle going dead and not even emergency lights will work. This recall has been placed on very few BMWs however it is affecting way more then they are saying. You can see in UK where a man was killed for the vehicle going dead in the middle of the road and emergency lights cannot be used to warn other drivers. How has their not been taken car of already. I am extremely disappointed in our system, and in BMW. My mind is completely blown that this is not cared about.
NHTSA complaint #11487711 — an unverified report by a vehicle owner.
Pittsburgh, PA
ENGINE AND ENGINE COOLING
The contact owns a 2008 BMW 328XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11471998 — an unverified report by a vehicle owner.
Fort Wayne, IN
UNKNOWN OR OTHER
The car was over heating and not starting as well as fuel pump error on my dash. There is an open recall on my vehicle starting March of 2022 it is now June and BMW says they don’t know when they will have a remedy for this and it could be months but I need my car.
NHTSA complaint #11470189 — an unverified report by a vehicle owner.
Fort Wayne, IN
ENGINE
The car was over heating and not starting as well as fuel pump error on my dash. There is an open recall on my vehicle starting March of 2022 it is now June and BMW says they don’t know when they will have a remedy for this and it could be months but I need my car.
NHTSA complaint #11470189 — an unverified report by a vehicle owner.
Fort Wayne, IN
FUEL/PROPULSION SYSTEM
The car was over heating and not starting as well as fuel pump error on my dash. There is an open recall on my vehicle starting March of 2022 it is now June and BMW says they don’t know when they will have a remedy for this and it could be months but I need my car.
NHTSA complaint #11470189 — an unverified report by a vehicle owner.
Newark, NJ
ENGINE AND ENGINE COOLING
The contact owns a 2008 BMW 328XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer and BMW of Springfield Parts & Accessories (391 US-22, Springfield, NJ 07081: (908) 232-1466) were contacted and made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. VIN tool confirms parts not available.
NHTSA complaint #11457954 — an unverified report by a vehicle owner.
Minneapolis, MN
ENGINE AND ENGINE COOLING
The contact owns a 2008 BMW 328XI. The contact received a notification for NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The dealer was notified about the issue and confirmed that parts were not yet available. The contact was also informed that the vehicle was still safe to drive despite the parts for the recall not being available. The manufacturer was also notified of the issue and informed him that the vehicle was not safe to drive; he was instructed to leave the vehicle parked until parts for the recall were available. The contact was referred back to the dealer for a loaner vehicle; however, the dealer stated that there were no loaner vehicles available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11456771 — an unverified report by a vehicle owner.
at 147,675 milesChico, CA
ENGINE
The contact owns a 2008 BMW 328XI. The contact stated that while driving at 60 MPH on the highway, the engine failed. The contact pulled over to the emergency lane. There were no warning lights illuminated. The contact restarted the vehicle and drove home safely. The vehicle was taken to a dealer where the failure code was not able to be generated and another appointment was made for further testing. The vehicle was not repaired. The contact was also informed that his vehicle could be related to a fuel injection issue. No further information was available. The approximate failure mileage was 147,675.
NHTSA complaint #11453475 — an unverified report by a vehicle owner.
Jackson, NJ
SUSPENSION
Mileage Rollback
NHTSA complaint #11437624 — an unverified report by a vehicle owner.
Jackson, NJ
ENGINE
Mileage Rollback
NHTSA complaint #11437624 — an unverified report by a vehicle owner.
Jackson, NJ
FUEL/PROPULSION SYSTEM
Mileage Rollback
NHTSA complaint #11437624 — an unverified report by a vehicle owner.
at 131,000 milesKingston, NYFire
ENGINE
The contact owned a 2008 BMW 328xi. The contact stated while driving 35 mph, she saw smoke exiting the front passenger side of the vehicle. The contact stated that there was no warning light illuminated. The contact parked and exited the vehicle safely and called 911. The contact stated 25 seconds after exiting the vehicle, the vehicle exploded and caught on fire. The fire department arrived and extinguished the fire. A fire report was filed. The contact stated that there was no injury. A police report was not filed. The vehicle was towed to a towing lot. The vehicle was not diagnosed nor repaired. A dealer was not contacted. The manufacturer was not informed of the failure. The failure mileage was approximately 131,000.
NHTSA complaint #11419176 — an unverified report by a vehicle owner.
at 120,000 milesBristol, CT
UNKNOWN OR OTHER
WHILE COMING TO A STOP OR TAKING A TURN THE CAR WILL RANDOMLY SHUT OFF AT WHICH POINT I LOSE TOTAL CONTROL OVER THE CAR. AT THIS POINT I HAVE TO DO MY BEST TO COME TO A STOP SAFELY AND AVOID ANY POTENTIAL ACCIDENT. THE CHECK ENGINE LIGHT WILL COME ON ONCE THE CAR SHUTS DOWN, BUT THE CAR WILL START RIGHT BACK UP AFTERWARDS AND THE CHECK ENGINE LIGHT GOES AWAY. THE CAR WILL DRIVE NORMAL, BUT THIS HAPPENS OFTEN AND SCARED AS THERE IS NO WARNING SIGN OF WHEN THIS IS GOING TO HAPPEN TO ME; I HAVE BEEN LUCKY SO FAR NOT TO GET INTO A MAJOR ACCIDENT.
NHTSA complaint #11354816 — an unverified report by a vehicle owner.
at 250,000 milesBrooklyn, NYFire
AIR BAGS
CAR CAUGHT ON FIRE FOR UNKNOWN REASONS. WHEN THE CAR WAS TURNED ON SMOKE CAME OUT FROM THE AIR CONDITIONING VENTS AND ALL DOORS LOCKED FROM INSIDE. THERE WERE 2 OCCUPANTS INSIDE THAT NEEDED ASSISTANCE TO GET OUT WHILE THE CAR WAS CATCHING FIRE. THE VEHICLE WAS PARKED.
NHTSA complaint #11337419 — an unverified report by a vehicle owner.