Owners have filed 86 complaints
about the 2012 BMW 535I with NHTSA between 2012 and 2025.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 7 of 9 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 56
Against the median year of the BMW 535I. 50 means typical for this
model; 100 means roughly double.
Severity — 18
3.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 37
22% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
34.7%
1,000 – 9,999 miles
57.8%
10,000 – 24,999 miles
11.6%
25,000 – 49,999 miles
1320.3%
50,000 – 74,999 miles
1117.2%
75,000 – 99,999 miles
1218.8%
100,000 – 149,999 miles
1625.0%
150,000+ miles
34.7%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jul 2012peak 6Oct 2025
NHTSA investigations into the 2012 BMW 535I
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
DP22005Opened 27 Jan 2023Closed 7 Aug 2023ELECTRICAL SYSTEM:PROPULSION SYSTEM
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc...
Complaints that involved harm
Reports where the owner recorded a crash, a fire, an injury or a death.
Belleville, NJFire
ELECTRICAL SYSTEM
The car was parked overnight. In the morning around dusk , it spontaneously caught fire.
NHTSA complaint #11649879 — an unverified report by a vehicle owner.
at 1,500 milesChatham, NJFire
WHEELS
I LEASED A 2012 NBMW 535I FROM PAUL MILLER BMW OF WAYNE, NJ. PAUL MILLER BMW IS A CERTIFIED AND AUTHORIZED BMW DEALER IN NJ, AND HANDLED ALL SERVICES FOR SEVERAL REPAIRS TO MY VEHICLE. I HAVE HAD TO REPLACE 19 TIRES FOR FLATS AND OTHER ISSUES IN A LITTLE OVER 2 YEARS SINCE LEASING MY VEHICLE. THIS CAR OBVIOUSLY HAS A TIGHT SUSPENSION WITH LOW PROFILE (40) TIRES AND THIS CAR IS PARTICULAR MAY BE MORE DEFECTIVE THAN OTHERS. SINCE THIS CAR?S RELEASE AND SOME PRIOR YEARS OF THE BMW 535I, I HAVE SEEN SEVERAL COMPLAINTS ONLINE ABOUT THE DANGER OF DRIVING THIS CAR AS IT FEELS LIKE GIANT BOULDER FALLS ONTO THE CAR WHEN IT HITS EVEN MODEST POTHOLES OR ROAD IMPERFECTIONS. BMW AS COMPANY SHOULD NOT MARKET THIS CAR TO ANY URBAN AREA CUSTOMERS, WHICH I HOPE THE FTC AND OTHER GOVERNMENT AGENCIES WOULD PLEASE ENFORCE BEFORE PEOPLE GET KILLED OR SERIOUSLY INJURED. I HAVE TRIED SEVERAL TIMES TO ASK BMW CORPORATION, FINANCIAL SERVICES, AND NJ PAUL MILLER BMW IN WAYNE NJ TO RESOLVE THIS ISSUE AND THEY ARE UNWILLING TO DO SO. ALSO BMW FINANCIAL SERVICES BREACHED WARRANTY AS THEY PROVIDED USED TIRES DURING FEBRUARY 2014 EVEN THOUGH I HAVE A TIRE REPLACEMENT CONTRACT THAT I PAID THEM $1813 FOR. PAUL MILLER BMW ALSO TRIED TO CHARGE ME FOR NEW TIRES BECAUSE 3 OF THEM NEEDED TO BE REPLACED DURING ONE EPISODE WHEN I HIT SOME HIGHWAY BUMPS. THEY ALSO SUGGESTED PUTTING LIQUID NITROGEN INTO THE TIRES AND BILLED ME FOR THIS. THE TIRES WENT FLAT IMMEDIATELY THEREAFTER. THIS WAS YET ANOTHER BREACH OF CONTRACT AS BMW'S TOWING SERVICE DID NOT PICK ME UP MULTIPLE TIMES WHEN FLATS OCCURRED. THEY ALSO SAID THE RUNFLAT TIRES CAN BE DRIVEN AT 50 MPH OR LESS FOR SEVERAL MILES AND THIS DID NOT WORK ON MULTIPLE OCCASIONS AS THE TIRES SHREDDED AND I WAS STRANDED - ONE TIME OF WHICH WAS WITH A CUSTOMER IN THE CAR!
NHTSA complaint #10644000 — an unverified report by a vehicle owner.
at 1,500 milesChatham, NJFire
TIRES
I LEASED A 2012 NBMW 535I FROM PAUL MILLER BMW OF WAYNE, NJ. PAUL MILLER BMW IS A CERTIFIED AND AUTHORIZED BMW DEALER IN NJ, AND HANDLED ALL SERVICES FOR SEVERAL REPAIRS TO MY VEHICLE. I HAVE HAD TO REPLACE 19 TIRES FOR FLATS AND OTHER ISSUES IN A LITTLE OVER 2 YEARS SINCE LEASING MY VEHICLE. THIS CAR OBVIOUSLY HAS A TIGHT SUSPENSION WITH LOW PROFILE (40) TIRES AND THIS CAR IS PARTICULAR MAY BE MORE DEFECTIVE THAN OTHERS. SINCE THIS CAR?S RELEASE AND SOME PRIOR YEARS OF THE BMW 535I, I HAVE SEEN SEVERAL COMPLAINTS ONLINE ABOUT THE DANGER OF DRIVING THIS CAR AS IT FEELS LIKE GIANT BOULDER FALLS ONTO THE CAR WHEN IT HITS EVEN MODEST POTHOLES OR ROAD IMPERFECTIONS. BMW AS COMPANY SHOULD NOT MARKET THIS CAR TO ANY URBAN AREA CUSTOMERS, WHICH I HOPE THE FTC AND OTHER GOVERNMENT AGENCIES WOULD PLEASE ENFORCE BEFORE PEOPLE GET KILLED OR SERIOUSLY INJURED. I HAVE TRIED SEVERAL TIMES TO ASK BMW CORPORATION, FINANCIAL SERVICES, AND NJ PAUL MILLER BMW IN WAYNE NJ TO RESOLVE THIS ISSUE AND THEY ARE UNWILLING TO DO SO. ALSO BMW FINANCIAL SERVICES BREACHED WARRANTY AS THEY PROVIDED USED TIRES DURING FEBRUARY 2014 EVEN THOUGH I HAVE A TIRE REPLACEMENT CONTRACT THAT I PAID THEM $1813 FOR. PAUL MILLER BMW ALSO TRIED TO CHARGE ME FOR NEW TIRES BECAUSE 3 OF THEM NEEDED TO BE REPLACED DURING ONE EPISODE WHEN I HIT SOME HIGHWAY BUMPS. THEY ALSO SUGGESTED PUTTING LIQUID NITROGEN INTO THE TIRES AND BILLED ME FOR THIS. THE TIRES WENT FLAT IMMEDIATELY THEREAFTER. THIS WAS YET ANOTHER BREACH OF CONTRACT AS BMW'S TOWING SERVICE DID NOT PICK ME UP MULTIPLE TIMES WHEN FLATS OCCURRED. THEY ALSO SAID THE RUNFLAT TIRES CAN BE DRIVEN AT 50 MPH OR LESS FOR SEVERAL MILES AND THIS DID NOT WORK ON MULTIPLE OCCASIONS AS THE TIRES SHREDDED AND I WAS STRANDED - ONE TIME OF WHICH WAS WITH A CUSTOMER IN THE CAR!
NHTSA complaint #10644000 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Peachtree City, GA
POWER TRAIN
BMW N63 Engine Powertrain Issues 2012 535i The N63 engine, utilized in various BMW models including the 2012 535i, has been subject to multiple customer complaints regarding premature timing chain wear and other powertrain-related issues. This led BMW to introduce a "Customer Care Package," detailed in Technical Service Bulletin (TSB) B110614, to address the concerns reported by multiple owners and noted by the National Highway Traffic Safety Administration (NHTSA) under ID Number 11016414. A primary cause of the issue is accelerated timing chain wear. The N63 engine's design features timing chains that are prone to stretching prematurely. This stretching can disrupt the precise timing of the engine's valves, leading to a cascade of problems. As a consequence, owners have reported a variety of symptoms, including the illumination of the "drivetrain malfunction" warning light, noticeable engine noise, excessive vibration, and potentially catastrophic engine failure. The "drivetrain malfunction" message, in particular, is a frequently cited indicator of this underlying powertrain problem. To address these widely reported issues, the N63 Customer Care Package was implemented. This service bulletin instructs authorized BMW technicians to perform a series of diagnostic tests. The main objective is to detect if the timing chains have stretched beyond acceptable tolerances. If excessive wear is confirmed, the TSB provides a detailed procedure for the necessary repairs. This often involves replacing the timing chains and related components to restore proper engine function. Beyond the core timing chain replacement, the Customer Care Package also includes several proactive and preventative measures. Technicians are instructed to check and potentially replace other components, such as fuel injectors and boost solenoids, which may have been impacted or contributed to the engine's performance issues. Furthermore, the service includes reprogramming the vehicle's software
NHTSA complaint #11696232 — an unverified report by a vehicle owner.
Peachtree City, GA
ENGINE
BMW N63 Engine Powertrain Issues 2012 535i The N63 engine, utilized in various BMW models including the 2012 535i, has been subject to multiple customer complaints regarding premature timing chain wear and other powertrain-related issues. This led BMW to introduce a "Customer Care Package," detailed in Technical Service Bulletin (TSB) B110614, to address the concerns reported by multiple owners and noted by the National Highway Traffic Safety Administration (NHTSA) under ID Number 11016414. A primary cause of the issue is accelerated timing chain wear. The N63 engine's design features timing chains that are prone to stretching prematurely. This stretching can disrupt the precise timing of the engine's valves, leading to a cascade of problems. As a consequence, owners have reported a variety of symptoms, including the illumination of the "drivetrain malfunction" warning light, noticeable engine noise, excessive vibration, and potentially catastrophic engine failure. The "drivetrain malfunction" message, in particular, is a frequently cited indicator of this underlying powertrain problem. To address these widely reported issues, the N63 Customer Care Package was implemented. This service bulletin instructs authorized BMW technicians to perform a series of diagnostic tests. The main objective is to detect if the timing chains have stretched beyond acceptable tolerances. If excessive wear is confirmed, the TSB provides a detailed procedure for the necessary repairs. This often involves replacing the timing chains and related components to restore proper engine function. Beyond the core timing chain replacement, the Customer Care Package also includes several proactive and preventative measures. Technicians are instructed to check and potentially replace other components, such as fuel injectors and boost solenoids, which may have been impacted or contributed to the engine's performance issues. Furthermore, the service includes reprogramming the vehicle's software
NHTSA complaint #11696232 — an unverified report by a vehicle owner.
Peachtree City, GA
FUEL/PROPULSION SYSTEM
BMW N63 Engine Powertrain Issues 2012 535i The N63 engine, utilized in various BMW models including the 2012 535i, has been subject to multiple customer complaints regarding premature timing chain wear and other powertrain-related issues. This led BMW to introduce a "Customer Care Package," detailed in Technical Service Bulletin (TSB) B110614, to address the concerns reported by multiple owners and noted by the National Highway Traffic Safety Administration (NHTSA) under ID Number 11016414. A primary cause of the issue is accelerated timing chain wear. The N63 engine's design features timing chains that are prone to stretching prematurely. This stretching can disrupt the precise timing of the engine's valves, leading to a cascade of problems. As a consequence, owners have reported a variety of symptoms, including the illumination of the "drivetrain malfunction" warning light, noticeable engine noise, excessive vibration, and potentially catastrophic engine failure. The "drivetrain malfunction" message, in particular, is a frequently cited indicator of this underlying powertrain problem. To address these widely reported issues, the N63 Customer Care Package was implemented. This service bulletin instructs authorized BMW technicians to perform a series of diagnostic tests. The main objective is to detect if the timing chains have stretched beyond acceptable tolerances. If excessive wear is confirmed, the TSB provides a detailed procedure for the necessary repairs. This often involves replacing the timing chains and related components to restore proper engine function. Beyond the core timing chain replacement, the Customer Care Package also includes several proactive and preventative measures. Technicians are instructed to check and potentially replace other components, such as fuel injectors and boost solenoids, which may have been impacted or contributed to the engine's performance issues. Furthermore, the service includes reprogramming the vehicle's software
NHTSA complaint #11696232 — an unverified report by a vehicle owner.
Belleville, NJFire
ELECTRICAL SYSTEM
The car was parked overnight. In the morning around dusk , it spontaneously caught fire.
NHTSA complaint #11649879 — an unverified report by a vehicle owner.
Bellevue, WA
AIR BAGS
UNKNOWN passenger restraint system malfunction message started coming.
NHTSA complaint #11637534 — an unverified report by a vehicle owner.
at 127,000 milesHouston, TX
ELECTRICAL SYSTEM
The contact owns a 2012 BMW 535I. The contact stated while driving at approximately 65 MPH, the engine temperature and "Pull Over - Stop Vehicle" warning lights were illuminated. The contact pulled over and let the vehicle cool down and drove to an independent mechanic. The vehicle was diagnosed, and it was determined that the water pump needed to be replaced. The mechanic advised the contact that there was an active recall, NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 127,000.
NHTSA complaint #11621488 — an unverified report by a vehicle owner.
at 127,000 milesHouston, TX
ENGINE AND ENGINE COOLING
The contact owns a 2012 BMW 535I. The contact stated while driving at approximately 65 MPH, the engine temperature and "Pull Over - Stop Vehicle" warning lights were illuminated. The contact pulled over and let the vehicle cool down and drove to an independent mechanic. The vehicle was diagnosed, and it was determined that the water pump needed to be replaced. The mechanic advised the contact that there was an active recall, NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 127,000.
NHTSA complaint #11621488 — an unverified report by a vehicle owner.
at 119,000 milesBlythewood, SC
FUEL SYSTEM, GASOLINE
The contact owns a 2012 BMW 535I. The contact stated while driving approximately 50–55 MPH, the engine overheated and the vehicle shutoff. The engine warning light was illuminated. The vehicle was restarted. The contact continued to drive to her residence. The contact stated that the failure was related to NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, who determined that the failure was due to the fuel pump and the water pump. The water pump and fuel pump were replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 119,000. The VIN was not available.
NHTSA complaint #11609875 — an unverified report by a vehicle owner.
at 119,000 milesBlythewood, SC
ENGINE AND ENGINE COOLING
The contact owns a 2012 BMW 535I. The contact stated while driving approximately 50–55 MPH, the engine overheated and the vehicle shutoff. The engine warning light was illuminated. The vehicle was restarted. The contact continued to drive to her residence. The contact stated that the failure was related to NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, who determined that the failure was due to the fuel pump and the water pump. The water pump and fuel pump were replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 119,000. The VIN was not available.
NHTSA complaint #11609875 — an unverified report by a vehicle owner.
Birmingham, AL
ENGINE
Confirmed by a Certified BMW repair center. Failure of Vanos Camshaft Gear Bolts. Recall has been issued for all 5 series models (and beyond) up to 2011, but does not include 2012 (5 series,) as it should. The Recall needs to be extended to include 2012 - 5 series models as failure of these bolts will cause immediate engine failure and could result in catastrophic crash, especially if driving at high speeds. I have contacted BMW of North America and they will not extend the recall until formal complaints, such as this, are received. My Issue with the Vanos Camshaft Bolts is currently being repaired (out of pocket) and I will share my invoice once received.
NHTSA complaint #11568781 — an unverified report by a vehicle owner.
Charlottesville, VA
EXTERIOR LIGHTING
The headlights on the BMW 535 collect excessive amounts of condensation. If the condensation builds up, then the light does not function properly. The main safety concern is the malfunction of the turn signal. It will function in the rear of the vehicle but does not light up on the front in the affected headlight housing. Review of this problem on-line shows that this has occurred in many BMW vehicles and BMW also has issued a service bulletin for this problem (SI B63 05 16). As widespread as this problem is, I would think there would be a required recall for this service.
NHTSA complaint #11506957 — an unverified report by a vehicle owner.
Princeton, NJ
EXTERIOR LIGHTING
The front lights - water gets in impact visibility. The only repair is to replace the entire unit which is $2k per light. There is not other options. The adaptive warning sign does not go away due to this water.
NHTSA complaint #11473074 — an unverified report by a vehicle owner.
Lithonia, GA
POWER TRAIN
While driving heard a loud noise and oil start pouring out the bottom of the car.. After getting my Vehicle looked at BMW dealership informed me that the drive shaft had broken and fell in the engine and caused a hole in the engine and damaging the oil pan also
NHTSA complaint #11465609 — an unverified report by a vehicle owner.
Lithonia, GA
ENGINE
While driving heard a loud noise and oil start pouring out the bottom of the car.. After getting my Vehicle looked at BMW dealership informed me that the drive shaft had broken and fell in the engine and caused a hole in the engine and damaging the oil pan also
NHTSA complaint #11465609 — an unverified report by a vehicle owner.
West Chester, OH
SEAT BELTS
Driver seatbelt fails to engage with latch. Latch does not positively lock when inserted. Safety risk is obvious and has rendered the car undrivable. This just happened and has not been inspected by dealer. I personally looked at it and compared with other belt points. to me, it looks like the small metal clip failed.
NHTSA complaint #11461597 — an unverified report by a vehicle owner.
at 90,000 milesBakersfield, CA
POWER TRAIN
The contact owns a 2012 BMW 535I. The contact stated that while driving at 20 MPH, the vehicle stalled as the drivetrain malfunction warning message flashed on the instrument panel. The contact stated that the vehicle failed to start up after multiple attempts. The contact had a friend replace the battery; however, the failure persisted. The contact then had the vehicle towed to a dealer where they diagnosed the vehicle with a defective fuel pump. Upon investigation, the contact discovered NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline) which she linked to the failure. The manufacturer was notified and informed her that there were no recalls on the vehicle. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 90,000.
NHTSA complaint #11442812 — an unverified report by a vehicle owner.
at 90,000 milesBakersfield, CA
FUEL SYSTEM, GASOLINE
The contact owns a 2012 BMW 535I. The contact stated that while driving at 20 MPH, the vehicle stalled as the drivetrain malfunction warning message flashed on the instrument panel. The contact stated that the vehicle failed to start up after multiple attempts. The contact had a friend replace the battery; however, the failure persisted. The contact then had the vehicle towed to a dealer where they diagnosed the vehicle with a defective fuel pump. Upon investigation, the contact discovered NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline) which she linked to the failure. The manufacturer was notified and informed her that there were no recalls on the vehicle. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 90,000.
NHTSA complaint #11442812 — an unverified report by a vehicle owner.
Milton, GA
SEATS
Based on research it appears BMW has a long history of issues and even a recall on select years around the passenger seat sensor detector becoming faulty and impacting the ability of the air bags to deploy in a collision. This seems to a critical issue since it could result in serious injury to the passenger in the event of a collision.
NHTSA complaint #11438883 — an unverified report by a vehicle owner.
Milton, GA
AIR BAGS
Based on research it appears BMW has a long history of issues and even a recall on select years around the passenger seat sensor detector becoming faulty and impacting the ability of the air bags to deploy in a collision. This seems to a critical issue since it could result in serious injury to the passenger in the event of a collision.
NHTSA complaint #11438883 — an unverified report by a vehicle owner.
Townsend, DE
EXTERIOR LIGHTING
While driving car stalled, dropped speed and engine warning light came on. Fuel pump was needed. Had to have car towed obtained a rental for 11 days. Fuel pump out of stock. Immediately after fuel pump was replaced less than two weeks the thermostat had to be replaced. Another tow and another rental. I need to be compensated for stress aggravation and loss of use. Repairs and car rental and tow cost over $3500
NHTSA complaint #11432548 — an unverified report by a vehicle owner.
Townsend, DE
ENGINE
While driving car stalled, dropped speed and engine warning light came on. Fuel pump was needed. Had to have car towed obtained a rental for 11 days. Fuel pump out of stock. Immediately after fuel pump was replaced less than two weeks the thermostat had to be replaced. Another tow and another rental. I need to be compensated for stress aggravation and loss of use. Repairs and car rental and tow cost over $3500
NHTSA complaint #11432548 — an unverified report by a vehicle owner.
Townsend, DE
FUEL/PROPULSION SYSTEM
While driving car stalled, dropped speed and engine warning light came on. Fuel pump was needed. Had to have car towed obtained a rental for 11 days. Fuel pump out of stock. Immediately after fuel pump was replaced less than two weeks the thermostat had to be replaced. Another tow and another rental. I need to be compensated for stress aggravation and loss of use. Repairs and car rental and tow cost over $3500
NHTSA complaint #11432548 — an unverified report by a vehicle owner.
at 97,000 milesRedding, CA
FUEL SYSTEM, GASOLINE
The contact owns a 2012 BMW 535i. The contact stated while driving 70 MPH, the vehicle stalled without warning. The contact waited approximately 5-10 minutes before restarting the vehicle. The contact stated that the failure persisted soon after the initial failure. The contact had not taken the vehicle to a dealer for assistance. The manufacturer had yet to be notified of the failure. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 16V746000 (Fuel System, Gasoline) however, the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 97,000.
NHTSA complaint #11430482 — an unverified report by a vehicle owner.
at 70,000 milesMiami, FL
POWER TRAIN
The contact owns a 2012 BMW 535i. The contact stated that the power train warning message was displayed. The vehicle was diagnosed but not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.
NHTSA complaint #11420906 — an unverified report by a vehicle owner.
at 116,526 milesLittle Canada, MN
SUSPENSION
3/23/2021 DRIVING ON I-94 IN MORNING RUSH HOUR WHEN ENGINE KILLED. WAS ABLE TO ROLL OVER TO THE MEDIAN BETWEEN AN ON-RAMP AND THE HIGHWAY BEFORE CAR STOPPED MOVING. CHARGE BATTERY LIGHT ON ON THE DASH AS WELL AS CHECK STABILIZATION WARNING. WOULD NOT TURN OVER AT ALL BUT DASH LIGHTS/WIPERS WERE ON (RAINING). TOWED TO MECHANIC I'VE TAKEN VEHICLES TO FOR PAST 4-5 CARS/TRUCKS. IT WAS FOUND THAT THE #2 PISTON RING CAME OFF AND JAMMED BETWEEN THE CYLINDER WALL AND PISTON CAUSING THE ENGINE TO SEIZE/NEED TO BE REPLACED. ONCE IT WAS REPLACED AND WHILE DOING A TEST DRIVE, THE MECHANIC FELT A VIBRATION AND THEY FOUND THAT THERE WAS MOVEMENT ON THE PASSENGER SIDE AXLE SO THEY REPLACED THAT AS WELL. THE CAR HAD 116.5K ON IT WHEN I PURCHASED ABOUT 2 WEEKS PRIOR TO THE ENGINE AND CV ASSEMBLY NEEDING TO BE REPLACED. JUST GOT CAR BACK YESTERDAY, JUST OVER A MONTH AND A HALF TO REPAIR.
NHTSA complaint #11416491 — an unverified report by a vehicle owner.