37 of the
552 complaints filed about the BMW M3
are about the electrical system —
7% of everything owners reported.
The worst model year for it is 2008.
Below is a partial email to a BMW Dealer that replaced an airbag 2 1/2 years ago per a recall. The airbag light, convertible top light were both illuminated when I left the dealer. I have sent emails and contacted BMW USA. A friend scanned the car with a Snap-On scanner that showed that the light has been illuminated because of the air bag that they replaced. They continue to avoid the issue and they made my car unsafe and allowed me to leave with it. What can be done to resolve this issue? From: [XXX] <[XXX]> Sent: Friday, May 10, 2024 10:06 AM To: '[XXX]' <[XXX]> Subject: Issues with service during an airbag replacement Good morning [XXX], I took my 2004 M3 to BMW of Fort Lauderdale in November 2023 for a passenger-airbag replacement. The airbag light on the dash was illuminated when I received the car. I notified the service manager who stated that the light was not on when he initially got in the car after my arrival. The car was returned to the garage to determine the issue. The car was returned 30 – 45 minutes later and the airbag light continued to illuminate. The service manage told me that the driver’s side airbag which was replaced at a different dealership was causing the issue. I got in the car and notice that an oil pressure and voltage gauge that I installed after rebuilding the engine were not working. Therefore, I notified the service manager of the issue. He asked another manager to talk to me. I asked how they replaced the airbag so I would know where to start troubleshooting the cause. He told me that they were NOT in the fuse box because they removed the airbag from the top of the dash. The airbag light has been constantly illuminated since the airbag was replaced at BMW of Fort Lauderdale. I attached an image that shows two passenger side airbag errors that were displayed on a Snap-on scanner on May 8, 2024. This was caused by work done at BMW of Fort Lauderdale. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11745653 — an unverified report by a vehicle owner.
During a regular fuel stop at a gas station, I noticed the central lock button nor the physical door hinge fail to operate to open the door for me to exit. The fuse for the central power door lock/unlock button blew out, completely disabling the interior door hinge mechanism. I got trapped inside but thankfully the power was still on and the rear doors remained unlocked. So, I lowered the driverside window and crawl outside. Then open the unlocked reer door to enter the vehicle from the back seat. Then located the fuse box, searched on the internet to itenfy the effected fuse, replaced damaged one to another fuse (dedicated to another function), temporarily replaced with the same ampage fuse. For my vehicle, there is no visible solution to enter the physical key to open the door from the outside that are typically found under the exterior door handle. If it wasn't for a combination of luck that the other door remained unlocked, had power to lower the window, have some knowledge of vehicle electrical system (fuse), and tolerable weather condition, I would've been stuck inside my car for indifinite time, or break the window to get to exit. I would testify that this is a serious safety concern the manufacturer should investigate and provide permanent resolution.
NHTSA complaint #11596458 — an unverified report by a vehicle owner.
When I put the battery terminals after swapping a new battery, my FRM got damaged. No brake or head lights are working, no turn signals, no windows moving etc. It's a safety issue on the road
NHTSA complaint #11489153 — an unverified report by a vehicle owner.
BMW M 3 parked in the driveway and had been turned off for several hours I was wax the car when I noticed a puff of smoke coming out of the air condition vent so I sat in the driver seat to investigate out of habit I close the door I planed to open the windows and the convertible top to take a look the car went into antitheft mode and locked me inside the smoke became thick quickly I tried to break the window with my elbow with no luck I was getting ready to try to kick the window if I could reach it with my foot I’m on most 70 years old so it was tough even moving I couldn’t get out ..my wife and daughter Who were in the backyard and saw what was happening they broke the window so that I could climb out of the car I sprayed the air conditioning vent with water which is also dangerous but I had to put it out I then disconnected the battery as quickly as I could I have called an insurance adjuster and had mechanics look at it apparently the LCM or the light control module for some reason caught fire I was lucky I had someone there to help me someone else might not be as lucky I did breathing a bit of the smoke and I’ve had cough but I don’t feel it’s severe I will have it looked out eventually would just like the car to be evaluated by BMW engineers to see if they can figure out why it caught on fire Before I pay money to have it repaired I’m not sure I can drive it again
NHTSA complaint #11486395 — an unverified report by a vehicle owner.
The contact owns a 2009 BMW M3. The contact stated while operating the vehicle, the driver’s and passenger’s side turn signal failed to illuminate. Additionally, the headlights and dashboard lights would flicker on and off. Upon inspection, it was discovered that the electrical wiring insulation was frayed and damaged. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was approximately 84,000.
NHTSA complaint #11427001 — an unverified report by a vehicle owner.
THERE IS A BURNING SMELL WHEN I RUN MY A/C. I TOOK IT TO MECHANIC AND THEY STATED IT'S AN ISSUE WITH THE BLOWER MOTOR WIRING, WHICH IS COVERED UNDER RECALL. BUT I CHECKED THE RECALL NOTICE AND IT ONLY COVERS MY VEHICLE UP TO 2011, BUT MINE IS A 2013. HOWEVER, THE BLOWER MOTOR PARTS IN MY CAR ARE EXACTLY THE SAME AS THE 2011, SO I FEEL IT SHOULD BE A PART OF THE RECALL. I AM AFRAID TO DRIVE MY CAR WITH A/C BECAUSE SOMETHING IS GOING TO CATCH FIRE AND I HAVE NO IDEA WHAT HAS ALREADY BURNED SO FAR.
NHTSA complaint #11416316 — an unverified report by a vehicle owner.
I WAS DRIVING ON THE FREEWAY ACCELERATING WHEN I HIT APPROXIMATELY 75 MPH MY CAR WAS MAKING A LOUD REVVING SOUND AND METAL CLANKING SOUND IN MIDDLE AND SMOKE WAS COMING FROM THE FRONT AND BACK OF THE VEHICLE VERY THICK WHITE SMOKE ALL OF A SUDDEN MY CAR SLOWED DOWN AND ALL THE LIGHTS WERE BLINKING ON THE DASH ALMOST GOT INTO ACCIDENTS WHILE CARS AVOID HITTING! MY CAR WASN'T GOING OVER 5 10 MPH THERE WAS SO MUCH SMOKE WAS GETTING WORRIED,SOME HOW I MANAGED TO EXIT THE FREEWAY AND PARKED I WAS TOLD MY ENGLISH WAS BLOWN! MAINTENANCE WAS UP-TO-DATE ONLY DROVE IT ON THE WEEKENDS ONLY HAD 52,000 MILES NIGHTMARE 2011 BMW M3
NHTSA complaint #11390611 — an unverified report by a vehicle owner.
THE DOOR CENTRAL LOCK CONTROL MODULE FAILS ON ALL OF THE E46 BMW MODELS WHERE THE PASSENGER AND DRIVER CAN BECOME TRAPPED IN THE VEHICLE BECAUSE THE DOOR LOCKS CANNOT BE UNLOCKED IN ANY WAY BECAUSE OF THE FAULTY GM5 CENTRAL LOCKING MODULE
NHTSA complaint #11339459 — an unverified report by a vehicle owner.
VEHICLE IS A 2017 BMW M3 WITH 6352 MILES. IN THIS PARTICULAR CASE THE VEHICLE HAD STARTED AND HAD BEEN OPERATING NORMALLY THE DAY PRIOR. THE FOLLOWING DAY THE CAR WAS STATIONARY AND WOULD NOT START.IT WAS CLEAR THERE WAS NO POWER GETTING TO THE ELECTRONICS EVEN THOUGH THE BATTERY WAS FULLY CHARGED. THE VEHICLE WAS TRANSPORTED BY FLATBED TRUCK TO THE LOCAL DEALERSHIP TO DIAGNOSE THE ISSUE. THE DEALERSHIP INVESTIGATED THE ROOT CAUSE AND FOUND THE PRIMARY BATTERY CABLE CONNECTOR TO THE ELECTRICAL DISTRIBUTION BOX HAD FAILED WHERE THERE WAS NO LONGER ELECTRICAL CONTACT BETWEEN THE CABLE END AND THE DISTRIBUTION BOX TERMINAL. THE DEALERSHIP HAD NOT INITIALLY DISCLOSED THAT THEY HAD DONE REPAIR WORK ON OTHER MODELS FOR THE SIMILAR TYPE ELECTRICAL FAILURE. UPON FURTHER RESEARCH IT WAS FOUND THAT THERE HAVE BEEN NUMEROUS RECALLS FOR MANY DIFFERENT MODELS OF BMW INCLUDING 1 SERIES, 3 SERIES AND Z SERIES FOR THE SIMILAR FAILURE MODE OF ELECTRICAL CONNECTION FAILURE AT THE BATTERY CABLE/ DISTRIBUTION BOX CONNECTION. THE FOLLOWING ARE SO FAR THE KNOWN RECALLS RELATED TO THE BATTERY CABLE CONNECTOR FAILURE: 18V-314 FOR MODEL YEARS 2010-2011. OVER 7000 VEHICLES AFFECTED 19V-472 FOR MODEL YEARS 2008-2012 13V-044 FOR MODEL YEARS 2008-2012 OVER 500,000 VEHICLES AFFECTED IT WAS EVENTUALLY CONFIRMED BY THE MECHANICS AT THE DEALERSHIP THAT THIS WAS A SIMILAR FAILURE MODE OF THE CONNECTOR THAT THEY HAD SEEN IN THE PAST HOWEVER THEY COMMENTED THAT THIS WAS THE FIRST 2017 MODEL THAT THEY HAD SEEN WITH THIS FAILURE. THE CONCLUSION CAN BE DRAWN ON THAT THE BATTERY CABLE/ELECTRICAL DISTRIBUTION BOX CONNECTOR DESIGN IS SIMILAR TO THAT USED IN PREVIOUS MODEL YEARS AND THEREFORE WILL FAIL IN A SIMILAR MANNER AND THAT ADDITIONAL MODEL YEARS SHOULD BE ADDED TO THE RECALL SO THAT THE DEFECT CAN BE IDENTIFIED AND REMEDIED AS SOON AS POSSIBLE.
NHTSA complaint #11301469 — an unverified report by a vehicle owner.
I DID SOME RESEARCH IT LOOKS MY CAR HAS THE POSITIVE BATTERY CABLE RECALL NOT DONE IT'S MAJOR SAFETY ISSUE!! UP ON FURTHER INFORMATION CARS BUILD FROM DATE 2008-2012 MY VEHICLE PRODUCTION DATE IS FROM SEPTEMBER 2010. I STILL HAVEN'T RECEIVED MY RECALL LATER PLEASE SOLVE ISSUE AS SOON AS POSSIBLE THANKS.
NHTSA complaint #11269801 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2008 BMW M3. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN REVERSE ON A HILL. THE EMERGENCY BRAKE WAS NOT APPLIED PROPERLY AND THE VEHICLE ROLLED DOWN THE HILL AND CRASHED INTO ANOTHER VEHICLE. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S VEHICLE SUSTAINED DAMAGES TO THE HOOD, BUMPER, AND FENDER. THE VEHICLE WAS TOWED BY AAA TO AUTOMASTER BMW (3328 SHELBURNE RD, #3, SHELBURNE, VT 05482, (802) 985-1850) WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL SYSTEM NEEDED TO BE REPLACED. THE ELECTRICAL SYSTEM WAS REPLACED; HOWEVER, THE BODY DAMAGE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 19V472000 (ELECTRICAL SYSTEM) AS A POTENTIAL CAUSE OF THE FAILURE, BUT HE HAD NOT RECEIVED A RECALL NOTICE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ASSISTED WITH THE REPAIR COST. THE VEHICLE WAS CURRENTLY AT AN INDEPENDENT MECHANIC TO HAVE THE BODY DAMAGE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. *TR
NHTSA complaint #11253458 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2003 BMW M3. THE CONTACT STATED THAT THE ELECTRICAL SYSTEM SHORTED OUT AND ALL THE ELECTRICAL DEVICES FAILED TO WORK. THE VEHICLE DECELERATED WITHOUT WARNING AND THE ENGINE WENT INTO LIMP MODE AND LOST POWER. ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A NEW BATTERY WAS NEEDED AND A PART ON THE FUSE BOX NEEDED TO BE REPLACED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000. THE VIN WAS UNKNOWN.
NHTSA complaint #11246068 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2011 BMW M3. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 17V676000 (ELECTRICAL SYSTEM) WAS RECEIVED IN NOVEMBER OF 2017. AFTER CONTACTING THE DEALER (BMW OF HUDSON VALLEY, 2068 SOUTH RD, POUGHKEEPSIE, NY) AND THE MANUFACTURER, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REMEDY THE DEFECT WOULD NOT BE AVAILABLE UNTIL APRIL OF 2019. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA complaint #11155842 — an unverified report by a vehicle owner.
NHTSA RECALL NUMBER: 17V676 THIS RECALL WAS ISSUED OVER A YEAR AGO AND STILL HAVE YET TO BE CONTACTED BY BMW TO RESOLVE THE RECALL OR PROVIDE ANY RECOURSE. WHAT IS THE TYPICAL RESPONSE TIME?
NHTSA complaint #11144882 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2008 BMW M3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V676000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (BASNEY BMW MAZDA, 52203 IN-933, SOUTH BEND, IN 46637, (574) 272-8504) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA complaint #11098485 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2011 BMW M3. WHILE DRIVING AT 55 MPH, THE AIR CONDITIONER STOPPED FUNCTIONING AND THE ODOR OF BURNING PLASTIC ENTERED THE CABIN. THE CONTACT DISCONNECTED THE FUSES TO THE AIR CONDITIONER TO CORRECT THE FAILURE. REEVES IMPORT MOTORCARS DEALER LOCATED IN TAMPA, FLORIDA WAS MADE AWARE OF THE FAILURE, BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V676000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. *TT
NHTSA complaint #11073899 — an unverified report by a vehicle owner.
THE OEM WIRING INSULATION IN THE HEADLIGHT HOUSING HAS FLAKED OFF. THE BARE WIRES CAUSED AN ELECTRICAL SHORT WHEN I REPLACED A LIGHT BULB. BMW SAYS THAT THE ONLY REPAIR IS TO REPLACE THE ENTIRE HOUSING FOR $2100. THIS WILL NEED TO BE DONE ON THE OTHER SIDE EVENTUALLY, AS THE INSULATION IS DETERIORATING IN THAT HOUSING AS WELL. I HAVE READ ONLINE THAT THIS IS A COMMON PROBLEM IN MANY DIFFERENT MODELS BECAUSE OF THE TYPE OF WIRING THAT WAS SPECIFIED BY BMW JUST DOES NOT HOLD UP UNDER HIGHER TEMPERATURES. KNOWING THAT IT WILL BE SUBJECT TO HIGHER TEMPERATURES IN THE ENGINE COMPARTMENT IS A DESIGN OVERSIGHT AND WILL LEAD TO DANGEROUS MALFUNCTIONS WHEN OPERATING THE VEHICLE. IT IS JUST A MATTER OF TIME.
NHTSA complaint #11000488 — an unverified report by a vehicle owner.
VEHICLE WOULD NOT START AND ALL ELECTRICAL SYSTEMS WERE DEAD DESPITE A GOOD BATTERY. WAS SOLVED BY REMOVING GLOVE BOX AND FUS BOX AND PUSHING ON THE BATTERY CABLE THAT GOES INTO THE FUSE BOX TO GET A CONNECTION. THIS IS A KNOW ISSUE FOR BMW AND A RECALL WAS ISSUED ON OTHER 3-SERIES VEHICLES (2007 - 2011) WITH THE SAME PART NUMBERS, BUT WILL NOT COVER M3. THIS IS A SAFETY ISSUE AS LOSS OF POWER TO FUSE BOX WHILE DRIVING CAN SHUT DOWN THE CAR.
NHTSA complaint #10991274 — an unverified report by a vehicle owner.
THE CAR WAS PARKED AT A FLAT SPACE PARKING LOT. WHEN I TRIED TO OPEN THE VEHICLE USING A FOB KEY, THE ALARM STARTED TO GO OFF. I WAS NOT ABLE TO ACCESS THE VEHICLE OTHER THAN USING A KEY BLADE TO OPEN THE DOOR MANUALLY, HOWEVER ALL SYSTEM WAS DEAD. I HAVE REPLACED THE FOB KEY BATTERY, CHECKED THE BATTERY STATUS, AND RAN THE ERROR CODE SYSTEM, BUT EVERYTHING WAS FINE. AFTER SOME RESEARCH, I'VE FOUND OUT THAT THERE IS A RECALL ON THE SIMILAR MODELS (BMW 3 SERIES) FOR A FUSE BOX - BATTERY CONNECTION ISSUE. AND GIVING A GOOD PRESS TOWARDS THE FUSE BOX LOCATED IN THE GLOVE-BOX DID FIX THE PROBLEM TEMPORARILY, HOWEVER THE ISSUE HAS KEPT HAPPENING SINCE THEN. 3 SERIES MANUFACTURED MARCH 2007 THROUGH JULY 2011 HAVE BEEN RECALLED DURING THE NHTSA CAMPAIGN ID NUMBER: 13V044000. MY MODEL, M3, USES THE SAME DESIGN AND SAME PARTS AS 328I AND 335I FOR THE FUSE BOX AND BATTERY CONNECTION, AND THE SAME ISSUE HAS BEEN OCCURRED SEVERAL TIMES NOT JUST TO ME BUT TO OTHER M3 MODELS, BUT THIS MODEL FOR SOME REASON HAS NOT BEEN INCLUDED THE PREVIOUS RECALL CAMPAIGN.
NHTSA complaint #10955248 — an unverified report by a vehicle owner.
WHEN I ACCELERATE QUICKLY AT AN INTERSECTION WHEN I GET A GREEN LIGHT, THE ENGINE LOOSES ALL POWER BUT KEEPS RUNNING. BMW HAS NO IDEA AS NO CODES ARE BEING SAVED WHEN THIS HAPPENS. THE GENERAL MANAGER SAID IT PROBABLY COMPUTER PART BUT WE MAY NEVER KNOW.
NHTSA complaint #10910460 — an unverified report by a vehicle owner.