2020 BMW X7 problems

UNKNOWN OR OTHER

We came from [XXX] to [XXX] at night. It was rainy in [XXX]. We parked the vehicle in the front of the garage door of the house and went to sleep. Around 8:00-9:00AM two police cars from [XXX] PD came to our house. The officer said that the vehicle calls to BMW or 911 as an emergency and they forwarder that call to FPD. The officers checked the vehicle and they figured that the vehicle did the emergency call when was parked. Now, the emergency call system is not working, because of the bad factory sealant in the top of the roof and the water leaks exactly to the Telecomunication module (TCM). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11749192 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

We came from [XXX] to [XXX] at night. It was rainy in [XXX]. We parked the vehicle in the front of the garage door of the house and went to sleep. Around 8:00-9:00AM two police cars from [XXX] PD came to our house. The officer said that the vehicle calls to BMW or 911 as an emergency and they forwarder that call to FPD. The officers checked the vehicle and they figured that the vehicle did the emergency call when was parked. Now, the emergency call system is not working, because of the bad factory sealant in the top of the roof and the water leaks exactly to the Telecomunication module (TCM). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11749192 — an unverified report by a vehicle owner.

ENGINE

Low oil sensor continues to light up and says i am low on oil. Found out that my oil pump was the main cause of the issue. At this time I have to have the oil pump replaced. It was also determined there have been numerous reports regarding oil pump failure in the 2020 BMW x7 due to an internal plastic part.

NHTSA complaint #11745685 — an unverified report by a vehicle owner.

SUSPENSION

The front thrust arm bushing was previously replaced on December 19, 2023, at 34,750 miles (after three years of ownership). It has now failed again at 57,203 miles, lasting only about 22,500 miles. This repeat failure within a relatively short timeframe and mileage interval suggests an underlying issue or defective part. The dealer wants me to replace both Front Thrust Arm bushings again.

NHTSA complaint #11744300 — an unverified report by a vehicle owner.

POWER TRAIN

My X7’s front differential went bad at 50k miles. I paid over 100k for a vehicle of this caliber to have something like this fail and have to pay 8k with no help from BMWNA. I’ve been a loyal customer with bmw having owned over 5 bmw vehicles in the past. And for me to get treated like this is unacceptable. I hope we can have a law suit against bmw for this.

NHTSA complaint #11744077 — an unverified report by a vehicle owner.

ENGINE

While driving the vehicle sensor lights began to come on. I assumed it was a dirty outside sensor. Not long after the ABS system lit up and my car said traction even though I was just pulling into my driveway. I quickly turned around and drove to my mechanic. Showed him all the lights and he connected the computer to read the error codes. Found out that my oil pump was the main cause of the issue. Double checked to make sure it wasn't a battery failure causing incorrect error codes and the battery was in good condition. At this time I have to have the oil pump replaced. It was also determined there have been numerous reports regarding oil pump failure in the 2020 BMW x7 due to an internal plastic part.

NHTSA complaint #11742175 — an unverified report by a vehicle owner.

ENGINE

I am writing to formally report a potential safety-related defect involving BMW vehicles equipped with the B58TU engine, primarily affecting model years 2019 through 2021. My vehicle experienced a sudden loss of engine oil pressure that resulted in catastrophic engine failure. This condition occurred with little to no warning and led to immediate vehicle disablement. The failure created a hazardous situation, as the vehicle was no longer able to maintain propulsion and could have placed occupants at risk because it occurred in active traffic or unsafe conditions. Based on my experience and additional research, the issue appears to originate from the engine’s oil pump design. Specifically, the oil pump contains an internal pressure-regulating component originally manufactured from plastic. This component is prone to fracturing, particularly during cold starts or low ambient temperatures. When this failure occurs, oil pressure becomes erratic or is lost entirely, often without sufficient warning to prevent engine damage or vehicle shutdown. My vehicle had this occur on January 20th 2026, as it was 5 Degrees outside. I suddenly lost oil pressure and had my vehicle’s engine catastrophically fail on a highway with my two small children ages (3) and (7 months) in the vehicle. In some cases, drivers may observe warning signs such as inability to measure oil level electronically, abnormal oil pressure readings, or drivetrain malfunction warnings. However, these indicators are inconsistent and often appear only moments before complete failure, leaving insufficient time for corrective action. This issue represents a significant safety concern for the following reasons: * Sudden loss of oil pressure can result in immediate engine shutdown or loss of propulsion while driving * Failures frequently occur under predictable conditions (cold starts in low temperatures), indicating a repeatable defect * Drivers are not provided with adequate warning to safely respond before damage.

NHTSA complaint #11733459 — an unverified report by a vehicle owner.

ENGINE

I'm reporting a safety issue with BMW vehicles equipped with the B58TU engine, primarily 2019-2021 models. These vehicles have an oil pump with an internal plastic component that regulates oil pressure, and this part is fracturing in the field, causing sudden loss of oil pressure. The failure typically occurs during cold starts in low temperatures. When it fails, oil pressure becomes erratic or is lost entirely, often with little to no warning before engine damage or vehicle disablement. Warning signs, when present, include inability to measure oil level electronically, abnormal oil pressure, or sudden drivetrain malfunction warnings. These can rapidly progress to engine shutdown or severe damage from oil starvation. This creates a dangerous situation because the vehicle can become disabled without warning while driving or after startup. This is especially hazardous when cars become immobilized in traffic or during winter conditions when failures occur most frequently, leaving occupants exposed to freezing temperatures while awaiting assistance. Pump replacement requires extensive disassembly and commonly costs $6,000-$8,000, assuming no engine damage. A critical concern: owners cannot determine if their vehicle has the original plastic pump or the later metal revision. BMW's VIN-based parts lookup now shows updated components even when original plastic parts remain installed, and BMW has removed the original plastic part number from dealer networks entirely. Failures are reported across multiple production years, and the scope of affected vehicles remains unclear. Because this condition causes sudden vehicle disablement without adequate warning, especially in cold weather, I believe this warrants investigation as a potential safety-related defect.

NHTSA complaint #11731322 — an unverified report by a vehicle owner.

POWER TRAIN

The transfer case on my 2020 BMW X7 failed and had to be replaced. Turning the vehicle became unstable as the vehicle shuttered badly. BMW confirmed the shuttering and first changed the transfer case fluid. However, it only slightly helped at first but the shuttering came fully back shortly thereafter. The vehicle was inspected by BMW twice. I don’t remember any warning lights on the dash. The shuttering first occurred in 2024.

NHTSA complaint #11721850 — an unverified report by a vehicle owner.

ENGINE

Oil pum with plastic internals. Repeat hot and cold cycles cause premature failure of the plastic components and cause loss of oil pressure along with the pump grenading itself.

NHTSA complaint #11721065 — an unverified report by a vehicle owner.

POWER TRAIN

Transfer case broke and struck the engine while driving.

NHTSA complaint #11717153 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

My vehicle is included in BMW Recall Campaign No. 25V 644 – Engine Starter. It has repeatedly failed to start, and on two separate occasions the engine completely stalled while I was stopped at a traffic light. Each time, it took multiple attempts before the car would restart. I have also been stranded in numerous parking lots—during both extreme heat and freezing temperatures—with my children because the vehicle would not start. These incidents were unexpected, unsafe, and entirely consistent with the symptoms described in the recall. We have experienced these problems since purchasing the vehicle, but at the time we had no reason to believe we needed to document every occurrence. Now that BMW has acknowledged a fire risk defect and still has no available remedy, I do not feel safe continuing to operate this car. BMW has even advised owners not to park in a garage due to the potential fire hazard. The first recall was issued in 2024 and did not resolve the issue. The subsequent recall in August 2025 still has no fix. This ongoing situation presents a serious safety risk, and it is unacceptable that it remains unresolved. BMW should be buying these vehicles back and compensating owners for the significant inconvenience and danger this defect has caused.

NHTSA complaint #11715264 — an unverified report by a vehicle owner.

ENGINE

My vehicle is included in BMW Recall Campaign No. 25V 644 – Engine Starter. It has repeatedly failed to start, and on two separate occasions the engine completely stalled while I was stopped at a traffic light. Each time, it took multiple attempts before the car would restart. I have also been stranded in numerous parking lots—during both extreme heat and freezing temperatures—with my children because the vehicle would not start. These incidents were unexpected, unsafe, and entirely consistent with the symptoms described in the recall. We have experienced these problems since purchasing the vehicle, but at the time we had no reason to believe we needed to document every occurrence. Now that BMW has acknowledged a fire risk defect and still has no available remedy, I do not feel safe continuing to operate this car. BMW has even advised owners not to park in a garage due to the potential fire hazard. The first recall was issued in 2024 and did not resolve the issue. The subsequent recall in August 2025 still has no fix. This ongoing situation presents a serious safety risk, and it is unacceptable that it remains unresolved. BMW should be buying these vehicles back and compensating owners for the significant inconvenience and danger this defect has caused.

NHTSA complaint #11715264 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The check engine light on my 2020 BMW X7 intermittently illuminates and then clears without warning. A BMW technician diagnosed the cause as a malfunctioning active grille shutter assembly at the front of the vehicle. Research shows this is a widespread issue among BMW X5 and X7 models of similar years, with many owners reporting the same failure and expensive repairs. This appears to be a systemic defect, not an isolated incident. Because the grille shutter directly affects engine airflow and cooling, this issue raises reliability and potential safety concerns and should be reviewed for a possible recall.

NHTSA complaint #11715043 — an unverified report by a vehicle owner.

ENGINE

The check engine light on my 2020 BMW X7 intermittently illuminates and then clears without warning. A BMW technician diagnosed the cause as a malfunctioning active grille shutter assembly at the front of the vehicle. Research shows this is a widespread issue among BMW X5 and X7 models of similar years, with many owners reporting the same failure and expensive repairs. This appears to be a systemic defect, not an isolated incident. Because the grille shutter directly affects engine airflow and cooling, this issue raises reliability and potential safety concerns and should be reviewed for a possible recall.

NHTSA complaint #11715043 — an unverified report by a vehicle owner.

ENGINE

Low oil pressure warning. Oil pump replacement

NHTSA complaint #11709010 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2020 BMW X7. The contact received notification of NHTSA Campaign Number: 25V644000 (Electrical System). The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle stalled in the middle of traffic. The contact immediately depressed the brake and attempted to shift into park(P), but the transmission failed to respond as needed. The contact remained in the vehicle with the brake pedal depressed until Roadside Assistance arrived. The contact stated that the Roadside Assistance team held the start button down and the gear selector was shifted into neutral(N) for a second and continued to inadvertently shift back to park(P). The vehicle was towed to an independent mechanic who was unable to properly diagnose the vehicle and referred the contact to the dealer. The vehicle was then towed to the dealer, where it was diagnosed and determined that the starter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 85,600.

NHTSA complaint #11704522 — an unverified report by a vehicle owner.

POWER TRAIN

Hello , I would like to report a failed front differential on my vehicle. This issue was diagnosed by an independent BMW shop and is currently being repaired. Mine made it to 69k miles but many others have had theirs failed before 50k miles. My main goal is to bring light to this issue since it seems to be a design flaw. There's also numerous reports for failed transfer cases since they aren't normally serviced by BMW dealers. I've attached both repair invoices.

NHTSA complaint #11702895 — an unverified report by a vehicle owner.

STEERING

Hello , I would like to report a failed front differential on my vehicle. This issue was diagnosed by an independent BMW shop and is currently being repaired. Mine made it to 69k miles but many others have had theirs failed before 50k miles. My main goal is to bring light to this issue since it seems to be a design flaw. There's also numerous reports for failed transfer cases since they aren't normally serviced by BMW dealers. I've attached both repair invoices.

NHTSA complaint #11702895 — an unverified report by a vehicle owner.