2016 Buick Encore problems

STRUCTURE:BODY

We noticed the paint bubbling on one of her doors on the car and took it to the dealership who took no accountability. Now the car is peeling in the back and we’ve also noticed the same car, same model and make on the road with the same paint peeling issues that there’s no formal recall as of yet and we are not getting any resolution with GM.

NHTSA complaint #11753920 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Ignition switch getting very hot

NHTSA complaint #11750168 — an unverified report by a vehicle owner.

SUSPENSION

power steering failure while driving at highway speeds. In traffic had a warning come on power steering fault. Then wheel was hard to turn. Had to use strength to steer car home approx. 25 miles. Took to dealer they had car for 3 days before repair done. For $1800 repair bill. Said it was a circuit card in the steering system that was the problem. 2015 years had a recall but not 2016 . But the failure from the 2015 is the same with the 2016 year. GM contacted and they deny claim to get repair cost refunded.

NHTSA complaint #11719555 — an unverified report by a vehicle owner.

ENGINE

power steering failure while driving at highway speeds. In traffic had a warning come on power steering fault. Then wheel was hard to turn. Had to use strength to steer car home approx. 25 miles. Took to dealer they had car for 3 days before repair done. For $1800 repair bill. Said it was a circuit card in the steering system that was the problem. 2015 years had a recall but not 2016 . But the failure from the 2015 is the same with the 2016 year. GM contacted and they deny claim to get repair cost refunded.

NHTSA complaint #11719555 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Turbo exhibits exact same symptoms of 17-18 encore recall for the turbo. I frequently get the p0299 code the car becomes sluggish and hesitates to take off from a stop when this code comes on making this car dangerous to drive. This issue has almost caused multiple accidents because the car is so under powered that its hard to get the car across traffic without being hit. I have been having this issue for several years and no one has been able to tell me why the car does this.

NHTSA complaint #11715060 — an unverified report by a vehicle owner.

POWER TRAIN

On my way home in December 2025, my car started to sputter and make noises. All of a sudden the car started going about 10-15 miles. I almost go hit by several vehicles, because they had to put on brakes, I was trying to go up then down a hilly road. I finally was able to get to an Auto Advance Shop, I had to tow the car to Honda then to Buick for a diagnostic test. It had been over a month and I can’t get information in writing what the diagnostic test results are. I’ve had to rent a vehicle for over a month, even though I have a Lifetime Warranty on my power train and motor. I have submitted all my service and repair paperwork to John Miles Buick Conyers Georgia, the GM and Service Department, also I contacted GMC Corporate Office. I have been in a rental car for over a month that I can no longer afford. I don’t know where else to get results for my issue. Thank you, XXX. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11711624 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

On my way home in December 2025, my car started to sputter and make noises. All of a sudden the car started going about 10-15 miles. I almost go hit by several vehicles, because they had to put on brakes, I was trying to go up then down a hilly road. I finally was able to get to an Auto Advance Shop, I had to tow the car to Honda then to Buick for a diagnostic test. It had been over a month and I can’t get information in writing what the diagnostic test results are. I’ve had to rent a vehicle for over a month, even though I have a Lifetime Warranty on my power train and motor. I have submitted all my service and repair paperwork to John Miles Buick Conyers Georgia, the GM and Service Department, also I contacted GMC Corporate Office. I have been in a rental car for over a month that I can no longer afford. I don’t know where else to get results for my issue. Thank you, XXX. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11711624 — an unverified report by a vehicle owner.

ENGINE

On my way home in December 2025, my car started to sputter and make noises. All of a sudden the car started going about 10-15 miles. I almost go hit by several vehicles, because they had to put on brakes, I was trying to go up then down a hilly road. I finally was able to get to an Auto Advance Shop, I had to tow the car to Honda then to Buick for a diagnostic test. It had been over a month and I can’t get information in writing what the diagnostic test results are. I’ve had to rent a vehicle for over a month, even though I have a Lifetime Warranty on my power train and motor. I have submitted all my service and repair paperwork to John Miles Buick Conyers Georgia, the GM and Service Department, also I contacted GMC Corporate Office. I have been in a rental car for over a month that I can no longer afford. I don’t know where else to get results for my issue. Thank you, XXX. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11711624 — an unverified report by a vehicle owner.

POWER TRAIN

I was stopped at a traffic light and began moving forward to make a turn into traffic. As I activated my turn signal and started to proceed through the intersection, the vehicle suddenly stalled and shut off without warning, causing an immediate loss of power while the vehicle was in motion. Another vehicle was entering the intersection at the same time, creating a near-collision situation. I was forced to restart the vehicle in traffic. The incident occurred within less than 250 miles of purchasing the vehicle. The vehicle had recently received an oil change and inspection. No warning lights or messages were observed prior to the stall. This event created a serious safety risk.

NHTSA complaint #11709530 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I was stopped at a traffic light and began moving forward to make a turn into traffic. As I activated my turn signal and started to proceed through the intersection, the vehicle suddenly stalled and shut off without warning, causing an immediate loss of power while the vehicle was in motion. Another vehicle was entering the intersection at the same time, creating a near-collision situation. I was forced to restart the vehicle in traffic. The incident occurred within less than 250 miles of purchasing the vehicle. The vehicle had recently received an oil change and inspection. No warning lights or messages were observed prior to the stall. This event created a serious safety risk.

NHTSA complaint #11709530 — an unverified report by a vehicle owner.

ENGINE

I was stopped at a traffic light and began moving forward to make a turn into traffic. As I activated my turn signal and started to proceed through the intersection, the vehicle suddenly stalled and shut off without warning, causing an immediate loss of power while the vehicle was in motion. Another vehicle was entering the intersection at the same time, creating a near-collision situation. I was forced to restart the vehicle in traffic. The incident occurred within less than 250 miles of purchasing the vehicle. The vehicle had recently received an oil change and inspection. No warning lights or messages were observed prior to the stall. This event created a serious safety risk.

NHTSA complaint #11709530 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2016 Buick Encore. The contact stated that after starting the vehicle, the message "Steering Fault" was displayed, the steering icon was illuminated, and the steering wheel was difficult to turn in either direction. The following day, the contact discovered that the vehicle could be started. The cause of the failure was not yet determined. The manufacturer was notified of the steering failure. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 15V146000 (STEERING). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer had not yet been contacted. The failure mileage was 88,300.

NHTSA complaint #11695799 — an unverified report by a vehicle owner.

ENGINE

Vehicle unable to hold coolant. Local shop says the coolant lines hold pressure and leak appears to be with manifold and turbo. Car has less than 35k miles. There is a recall for this turbo issue with 2017 and up models but why not for 2016, or any other years with same issue?

NHTSA complaint #11680618 — an unverified report by a vehicle owner.

ENGINE

I believe my turbocharge is malfunctioning. The check engine light is on with code P0299. My vehicle is struggling to accelerate properly putting us in a few close calls while driving. Yes it is available for inspection - I've seen one mechanic on 6/13/25 - scheduled a follow up with a different one on 6/20/25 and have an appointment scheduled with GM on 7/1/25 should it go that far. I cannot pull out in front of vehicles even with double the normal amount of space confidently due to my lack of acceleration putting my family - pregnant wife and 1 year old at risk. We floor the gas pedal to try and get what should be normal acceleration but sometime it responds normally which has put us at risk of hitting vehicles in front of us. Yes - it has been inspected and we're getting more opinions. First appeared early June but no other warnings

NHTSA complaint #11667276 — an unverified report by a vehicle owner.

ENGINE

Add my car to your recall. Past recalls on these vehicles for oil leaking, which can cause a fire.

NHTSA complaint #11655642 — an unverified report by a vehicle owner.

ENGINE

The turbo has gone out on this and its not even 10 years old. I saw on other VIN's it got recalled and I believe all VIN's should be included

NHTSA complaint #11653370 — an unverified report by a vehicle owner.

POWER TRAIN

My wife is [XXX] and I am [XXX] old. We purchased the 2016 Buick Encore with 29,000 miles from Buick GMC of Beaverton, Oregon on [XXX], expecting that it would out last both of us, since we are retired and only drive to the store and doctor's appointments; my wife has miraculously survived Stage IV cancer since February 1, 2019. The Encore is our only car and we depend on it for all transportation. We love the vehicle, changed the oil about every 3,000 miles, and have had no complaints for almost six years. On [XXX], my wife and I were driving home from shopping, in rain at night on [XXX] north bound, left lane, uphill at 55MPH in moderate traffic on a six-lane divided freeway. Suddenly the car lost half power, began missing and shaking badly, speed dropped to about 30 MPH with cars serving behind us, flying past us honking. We were panicked, not knowing if the car would seize up completely or the engine would explode. Fortunately, we limped off the highway without having to stop. We took the car back to the dealership where we bought it, for service. The next day they emailed a video of their inspection of the vehicle showing Cylinder 1 has very low compression of about 60 when normal should be 180 to 210 psi, which indicates a likely blown piston. April 30, 2019, NHTSA Service Bulletin 19-NA-090 describes the identical symptoms the Encore is experiencing: Misfire and low compression in one or more cylinders. Both the Buick GMC of Beaverton dealership and General Motors, 800-521-7300 are refusing to honor the original 70K mile warranty since they're indicating the warranty expired on 01/21/2023. We are devastated that because we pampered the vehicle and only drove it 17,000 miles in nearly 6 years, we are being unfairly penalized. GM admits that if we had driven the vehicle more and this same engine failure occurred at just 49K miles prior to January 20, 2023, they would immediately replace the engine. Help! We are requesting that NHTSA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

NHTSA complaint #11644925 — an unverified report by a vehicle owner.

POWER TRAIN

This is an addendum to Complaint # 11644925 Before taking the car back to the dealership, Buick GMC of Beaverton, for repairs, I called the owner of Bassitt Auto Repair in Beaverton Oregon, 503-616-2007. He told me that they've had 3 other Buick Encores come to his repair shop in just the last 6 months, all with the identical problem. He said, without seeing our vehicle, that it is low compression due to a blown piston. He said to take the car to a Buick dealership, that this repair should be a recall, that the engine is most likely blown, and that no one with rebuild that engine.

NHTSA complaint #11644927 — an unverified report by a vehicle owner.

ENGINE

My wife is [XXX] and I am [XXX] old. We purchased the 2016 Buick Encore with 29,000 miles from Buick GMC of Beaverton, Oregon on [XXX], expecting that it would out last both of us, since we are retired and only drive to the store and doctor's appointments; my wife has miraculously survived Stage IV cancer since February 1, 2019. The Encore is our only car and we depend on it for all transportation. We love the vehicle, changed the oil about every 3,000 miles, and have had no complaints for almost six years. On [XXX], my wife and I were driving home from shopping, in rain at night on [XXX] north bound, left lane, uphill at 55MPH in moderate traffic on a six-lane divided freeway. Suddenly the car lost half power, began missing and shaking badly, speed dropped to about 30 MPH with cars serving behind us, flying past us honking. We were panicked, not knowing if the car would seize up completely or the engine would explode. Fortunately, we limped off the highway without having to stop. We took the car back to the dealership where we bought it, for service. The next day they emailed a video of their inspection of the vehicle showing Cylinder 1 has very low compression of about 60 when normal should be 180 to 210 psi, which indicates a likely blown piston. April 30, 2019, NHTSA Service Bulletin 19-NA-090 describes the identical symptoms the Encore is experiencing: Misfire and low compression in one or more cylinders. Both the Buick GMC of Beaverton dealership and General Motors, 800-521-7300 are refusing to honor the original 70K mile warranty since they're indicating the warranty expired on 01/21/2023. We are devastated that because we pampered the vehicle and only drove it 17,000 miles in nearly 6 years, we are being unfairly penalized. GM admits that if we had driven the vehicle more and this same engine failure occurred at just 49K miles prior to January 20, 2023, they would immediately replace the engine. Help! We are requesting that NHTSA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

NHTSA complaint #11644925 — an unverified report by a vehicle owner.

ENGINE

This is an addendum to Complaint # 11644925 Before taking the car back to the dealership, Buick GMC of Beaverton, for repairs, I called the owner of Bassitt Auto Repair in Beaverton Oregon, 503-616-2007. He told me that they've had 3 other Buick Encores come to his repair shop in just the last 6 months, all with the identical problem. He said, without seeing our vehicle, that it is low compression due to a blown piston. He said to take the car to a Buick dealership, that this repair should be a recall, that the engine is most likely blown, and that no one with rebuild that engine.

NHTSA complaint #11644927 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My wife is [XXX] and I am [XXX] old. We purchased the 2016 Buick Encore with 29,000 miles from Buick GMC of Beaverton, Oregon on [XXX], expecting that it would out last both of us, since we are retired and only drive to the store and doctor's appointments; my wife has miraculously survived Stage IV cancer since February 1, 2019. The Encore is our only car and we depend on it for all transportation. We love the vehicle, changed the oil about every 3,000 miles, and have had no complaints for almost six years. On [XXX], my wife and I were driving home from shopping, in rain at night on [XXX] north bound, left lane, uphill at 55MPH in moderate traffic on a six-lane divided freeway. Suddenly the car lost half power, began missing and shaking badly, speed dropped to about 30 MPH with cars serving behind us, flying past us honking. We were panicked, not knowing if the car would seize up completely or the engine would explode. Fortunately, we limped off the highway without having to stop. We took the car back to the dealership where we bought it, for service. The next day they emailed a video of their inspection of the vehicle showing Cylinder 1 has very low compression of about 60 when normal should be 180 to 210 psi, which indicates a likely blown piston. April 30, 2019, NHTSA Service Bulletin 19-NA-090 describes the identical symptoms the Encore is experiencing: Misfire and low compression in one or more cylinders. Both the Buick GMC of Beaverton dealership and General Motors, 800-521-7300 are refusing to honor the original 70K mile warranty since they're indicating the warranty expired on 01/21/2023. We are devastated that because we pampered the vehicle and only drove it 17,000 miles in nearly 6 years, we are being unfairly penalized. GM admits that if we had driven the vehicle more and this same engine failure occurred at just 49K miles prior to January 20, 2023, they would immediately replace the engine. Help! We are requesting that NHTSA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

NHTSA complaint #11644925 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

This is an addendum to Complaint # 11644925 Before taking the car back to the dealership, Buick GMC of Beaverton, for repairs, I called the owner of Bassitt Auto Repair in Beaverton Oregon, 503-616-2007. He told me that they've had 3 other Buick Encores come to his repair shop in just the last 6 months, all with the identical problem. He said, without seeing our vehicle, that it is low compression due to a blown piston. He said to take the car to a Buick dealership, that this repair should be a recall, that the engine is most likely blown, and that no one with rebuild that engine.

NHTSA complaint #11644927 — an unverified report by a vehicle owner.

ENGINE

Please help me. Please add my Vin# [XXX] for repair on a Past recall 2016 Buick. Dealer will not Fix my car, I need Vin Number added to recall. I have attached a copy of the recall. 43210 Engine Oil Leakage at Oil Cooler Pipe Reference Number: A162043210 GWM Number: 2043210 Condition Engine oil leakage at the oil cooler pipe caused by damaged O-ring. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11635756 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2016 Buick Encore. The contact stated while driving at an undisclosed speed, the service power steering warning light illuminated. The contact stated that the vehicle lost power steering functionality. The contact stated that if his wife had been driving the vehicle at the time of the failure, she would not have been able to steer the vehicle. The vehicle was taken to the dealer where it was diagnosed with a circuit board failure inside the steering column. The contact was informed that the circuit board needed to be replaced. The vehicle was being repaired. The contact referenced an unknown recall; however, the VIN was not included in the unknown recall. The manufacturer was made aware of the failure. The failure mileage was approximately 78,000.

NHTSA complaint #11627275 — an unverified report by a vehicle owner.

POWER TRAIN

I purchased my 2016 Buick encore from the car dealer name [XXX] in Rochester Michigan. I purchased it in December 20 23 beginning in January when I would change gears the car sounded like the gears were clunking like they were gonna fall out or something. also, the engine hesitates and then excels really fast like I’m racing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11625525 — an unverified report by a vehicle owner.