63 of the
905 complaints filed about the Buick Encore
are about the fuel system —
7% of everything owners reported.
The worst model year for it is 2016.
Not long after I purchased my car, i noticed it was lacking power during takeoff and when driving uphill which forced my car to hit very high RPMs during normal use. There was also a P0299 code that appeared then disappeared frequently. I discovered a turbo special coverage N232395330 and took it to Williams GMC in Charlotte. After i told them very clearly what happened MULTIPLE times, confirming the underboost and the code, I even brought it in with the code, they told me the code wasnt "active" and that there no problems...even after i told them I didnt feel safe and couldnt pull out at intersections with fear of being rear-ended. I had videos, they refused to look at and told me to come back when the code was permanent. I drove the vehicle for the next year, 20k miles in order to get the code permanent, after a trip home, through the mountains, really tough without the turbo, my car was consistently pinging 4-5000 RPM under the speed limit on inclines...this happened every time I drove through, but this time the code was active the entire time. 2-3000 miles with the code, finally it was permanent. I brought the car back to Williams GMC, to get the turbo changed. I updated them on recent occurrences, flashing check engine light, the code active for 2-3k miles, and they performed a road test, and declared it wasn't a problem. I told them i recently spent 5k on repairing my cooling and AC system because the turbo, they said that wouldn't affect those components, meanwhile i know they have plastic parts that can melt and the engine being forced to push 4-5k RPM the extra heat could easily melt those parts. They said, nothing was wrong and the road test was good. sent me on my way. I called corporate, they told me to get a second opinion. I did [XXX] found the problem and changed the turbo per the special coverage N232395330. a week later, my engine overheated, i pulled over and it wouldnt start, engin won't hold compression. Car is tot now. Long story shrt INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM
NHTSA complaint #11754320 — an unverified report by a vehicle owner.
The factory-installed turbocharger assembly on my 2017 Buick Encore failed mechanically while operating the vehicle, creating an immediate and severe roadway safety hazard.The structural failure of the turbocharger causes the vehicle to experience a sudden, unpredictable, and extreme loss of engine propulsion while actively driving. This severe power degradation makes it incredibly dangerous to accelerate, merge into highway traffic, or clear busy intersections safely, as the vehicle fails to respond to throttle input and drops speed rapidly. The vehicle is displaying an active diagnostic trouble code P0299 (Turbocharger Underboost condition).The manufacturer, General Motors, is fully aware of this exact component defect and has issued corporate Special Coverage Adjustment Bulletin N232395330 to address cracked turbo housings and wastegate failures on this model. However, because my vehicle is over their arbitrary 120,000-mile corporate warranty limit, GM’s Executive Resolution Team (Case #103125607) has issued a final refusal to repair the component.The manufacturer's mileage limitation leaves a documented, highly dangerous engine propulsion defect completely uncorrected on an active vehicle, posing a continuing, severe safety risk to the occupants and other drivers on public roads.
NHTSA complaint #11752260 — an unverified report by a vehicle owner.
92,000 miles my catalytic convertor went bad, had for 5 years. This resulted in lag when trying to accelerate and pull out in traffic. It cost $3,000 to fix as well as the turbocharger being broke. The blind spot detection to passenger side mirror stays on at all times and should only come on when there is an object detected in the right side blind area. I'm [XXX] old and have never ever has a catalytic convertor go bad. Buick should be responsible for these repairs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11751732 — an unverified report by a vehicle owner.
Strong odor of gasoline, followed by a crack in the high pressure fuel line. Gasoline poured out under pressure from fuel line approximately 1 foot ahead of the right rear tire. Major amount of spillage - literally several gallons within a minute or so, that eventually faded as the system lost pressure. Could have been a significant safety issue and catastrophic loss if there had been an ignition source nearby. Overall repair required dropping the fuel tank and the replacement of GM Part Number 95080144, a plastic fuel pipe. Overall, a safety issue and expensive (~$900) repair.
NHTSA complaint #11751621 — an unverified report by a vehicle owner.
The turbo in my vehicle has a check engine light come on and than the engine does no act right. The repair shop that looked at car stated that the manufacture knows this is a known issue and they have not made a recall as several cars my year range has this going on. If this is a known issue why is there no recall. I worked had for my car and I can not afford the repair of a know issues with the turbo as it cost a lot and I should not have to cover this as it is apparent this is a manufacture defect that is known. It puts me as risk as the car is not preforming properly and it jumps and does not go properly when it has the issue arise. I will get hit for not going after I come to a stop and will not accelerate properly. This issue appeared 2 months after I purchased the car and I took it to a shop who told me he has tried to contact Buick to cover the repairs for others and gets no where. I think that the manufacture knows and will not repair something that is not the owners fault but there shafty part and they know this as it was a recall in other years of my vehicle.
NHTSA complaint #11746663 — an unverified report by a vehicle owner.
My check engine light continues to turn on and the code is related to the wastegate actuator/turbo charger. My car is running rough and doesn't accelerate properly. It sometimes rocks back and forth when I try to accelerate. Which is a KNOWN PROBLEM WITH BUICK. GMC REFUSES TO RECALL THIS WELL DOCUMENTED ISSUE. And naturally, it becomes an issue after the warranty expires. Mileage: 67,067
NHTSA complaint #11735620 — an unverified report by a vehicle owner.
Defective "TURBO CHARGER" at 38,091 miles. The defective worn-out or damaged turbocharger was removed from the engine and a new one was installed at a cost of $1816.00. This part should not wear out at 38,000 miles. My mechanic informed me that this is common in the Buick Encore vehicles to experience a defective "TURBO CHARGER" at low vehicle mileage.
NHTSA complaint #11720398 — an unverified report by a vehicle owner.
Turbo exhibits exact same symptoms of 17-18 encore recall for the turbo. I frequently get the p0299 code the car becomes sluggish and hesitates to take off from a stop when this code comes on making this car dangerous to drive. This issue has almost caused multiple accidents because the car is so under powered that its hard to get the car across traffic without being hit. I have been having this issue for several years and no one has been able to tell me why the car does this.
NHTSA complaint #11715060 — an unverified report by a vehicle owner.
Turbocharger gasket failed resulting in leaking coolant and overheating of engine. Damages resulted turbocharge replacement and replacement of water outlet in $4463.43 repair bill.
NHTSA complaint #11709627 — an unverified report by a vehicle owner.
85,000 miles bought new. Was having hesitation and power issues, experienced increased fatigue the longer I drove. Took it in for service at 85,000 miles and the turbo PVC valve was bad as well as the catalytic converter. I’ve never had a catalytic converter go bad on any vehicle in my 42 years of driving. Cost = $2,000 for just the catalytic converter and extended warranty covered. Advised at time of being repaired that blind spot monitoring on right side of passenger mirror was malfunctioning. The dealer insisted I make a separate appointment which is another $100 co-pay so they can fix it. I was told the insurance company may delay or deny the claim. I know that can’t be true but my boyfriend has cancer and need the vehicle back asap for his treatment transportation. Sounds like problem with Encore.
NHTSA complaint #11705468 — an unverified report by a vehicle owner.
My check engine light has been appearing off and on for a few months. I received a diagnostic code of P0325 TWICE by two different professional technicians. I ordered an OEM knock sensor, hired a technician to replace the knock sensor, drove about 10 miles and the check engine light came back on. Then, I received a diagnostic code of P-1101, and the recommended solution is to replace the intake manifold and all necessary gadgets. After speaking with professional technicians and doing thorough online research, I discovered that General Motors issued a service bulletin No. 19-NA-101, dated July 2024, covers certain 2013–2019 model vehicles (including Buick Encore with 1.4L turbo) for oil consumption and/or leaks caused by a missing non-return valve in the intake manifold. The bulletin acknowledges that the intake manifold design on these 1.4L turbo engines has a non-return (check) valve or PCV system component inside the manifold that can fail or go missing, leading to issues like boost/vacuum leaks, oil consumption, engine performance faults. •The PCV valve is non-serviceable (you can’t replace it separately), meaning the only fix is replacing the manifold — which GM calls out in the bulletin. If GM or Buick hasn't issued a recall they should offer goodwill assistance especially since this is a defect on their end.
NHTSA complaint #11699532 — an unverified report by a vehicle owner.
The car only has 54700 I am orginal owner. Drivers seat does not work, Catalytic converter, GM Service Bulletin #43210. Ask if your VIN is affected or if they’ve seen similar failures in 2014 models. This car is a lemon.
NHTSA complaint #11694037 — an unverified report by a vehicle owner.
I've been dealing with a frustrating car issue lately where my vehicle keeps stalling and hesitating during acceleration - whether I'm pulling away from a stop or trying to pick up speed on the road. After getting it checked out, my mechanic determined that the high pressure fuel pump control module is the culprit and needs replacement. The problem is, we're stuck waiting for the part because Buick has it on backorder indefinitely. What's particularly concerning is that GM recently issued a recall for this exact same fuel pump issue on certain models, but somehow my VIN number didn't make the cut. I strongly believe it should have been included, especially considering the safety implications here. When this fuel pump control module fails, it can completely cut off fuel flow to the engine, which creates a serious traffic safety hazard. Nobody wants their car suddenly losing power while merging onto a highway or navigating through an intersection. This isn't just an inconvenience - it's a legitimate safety concern that affects real people on real roads every day.
NHTSA complaint #11691163 — an unverified report by a vehicle owner.
I have went to the dealership for the past two years with this problem and they keep saying they are not getting any codes: when the air conditioner is on it’s pulling the power from the motor and makes it hard to go up hill. Hard To accelerate when going on to the freeway as well. The problem is only getting worse and worse.
NHTSA complaint #11687912 — an unverified report by a vehicle owner.
I have been calling Autonations for months now since my car started driving funny. I was first told it was a head gasket that needed replacement however using my vin number the engine that’s currently inside the vehicle is not the one that matches with what pulls up using the vin number. Than the antifreeze leaks out, the oil leaks out and one day the car started smoking on the freeway with my children and I inside. It just stopped and haven’t been working ever since. I literally just got messed out of money because I purchased this vehicle a year ago not knowing it was a recall and this is one of the recalls now I am completely screwed over without a car and my money!! Now I’m being told I have to pay because this car was sold to me already over the mileage limit to be fixed for free!!
NHTSA complaint #11687171 — an unverified report by a vehicle owner.
On March 18 , 2025 I purchased a 2014 Buick Encore with an implied warranty, the vehicle had 128,644 miles on the odometer. At the time of purchase the check light was not on and the vehicle had no visible or audible mechanical issues. Not 14 days after purchase there was a strong odor of burning oil due to an oil leak dripping into the splash shield. A certified mechanic advised me that the problem was a very common issue with the 2014 Buick Encore and the oil cooler associated with the turbo charger needed to be replaced. This issue is so common that the NHTSA issued a GM part failure warning for the 2017 model and instructed GM to reimburse all vehicle owners to replace the part (N232395330). This issue clearly a problem that needs to be addressed with the 2014 model as well. My mechanic said that auto dealers are cleaning the splash pad prior to selling the vehicle so that the burning oil smell is not noticeable until 14 days or so after purchase. The repairs cost me $1148.00 just weeks after purchasing the vehicle. This problem of dealers covering up the problem and faulty GM parts needs to be addressed. I believe my vehicle falls under the previous GM parts needs failure warning and I should be reimbursed the cost of the repairs in the amount of $1148.00.
NHTSA complaint #11664894 — an unverified report by a vehicle owner.
My daughter owns a 2019 Buick Encore and the check engine light keeps going on. She took her car to the dealer and was told that it needed a Turbo Bypass Valve and Solenoid valve. The car is just a few months within the 10 year powertrain warranty and the dealer refused to cover as defect. She drives on the freeway 45 minutes to/from work and this is a serious issue that causes the engine to rev hard and not stop as well as stall intermittently.
NHTSA complaint #11664937 — an unverified report by a vehicle owner.
They sold me a car and 2 days later the check engine light came on I fixed it then a second time it came on I fixed again then a third time it came on I fixed it again now this is the 4th time that this light has come on and I called up there they tell me well we can see about putting you in another car. I go up there today and they tell me well the loan place you chose won’t do it because what’s on my credit so I ask if they can fix it for free because I can’t afford to pay 500$ 9’ car note and 500$ for car Insurance they said it’s nothing they could do to help me I asked for a manger Chelsea , she walked passed me 3 times and one of the times was to go smoke a cigarette didn’t even try to aknowlege me until I called my salesmen Veronica too say she walked passed me 3 times and didn’t say anything I don’t appreciate im working hard to try and pay for this car and. I felt as if no one cares I feel as if I was sold a lemon and they continue to say well we didn’t sale you a lemon how would you know if it’s a lemon or not prior to buying know one knows that
NHTSA complaint #11663741 — an unverified report by a vehicle owner.
On 4/24/25 I noticed a pungent odor (like rotten eggs). The odor is worse today. I did research and it appears there may be a problem and or leak with the catalytic converter. The emissions are making me and my kids feel sick, nauseous, headache, irritated eyes, etc.
NHTSA complaint #11656756 — an unverified report by a vehicle owner.
First the car started to act odd, jumpy or you could tell there was issues with the turbo. On [XXX] car overheated??? Out of nowhere. Mileage 82049. No warnings, no lights. We had it towed to shop where we were told we need new turbo, new engine, power steering service, ac service. The total Cost was $6813.54. We had to take out 2 loans - 90 days same as cash then 145% interest as well as pay $243.54 in Cash. We were guaranteed the car was in great condition. We picked it up on 1/24/25. Then on [XXX] - Odometer reading 82509 - We pulled over on the side of the road to grab something from the trunk. Driver got back in car and all of a sudden the car just shut down saying overheated and smoke was coming out of the hood. Again, Absolutely no warning, no lights, no weird noises, nothing! We are now stuck in the middle of nowhere with our [XXX] granddaughter. Thank God a police man drove by. The next day we had to have it towed back to shop. Once back to the shop we were told that the engine or labor that they just put in our vehicle would not be covered by warranty. Nothing was fixed!!! I contacted the attorney general. We went to pick it up on 3/28/2025. Once they got involved the shop agreed to do all repairs for $1873.96. (pay $600 now and then post date 2 more checks). The owners said they looked over everything and nothing should be going wrong. It should be good as new. On [XXX] We were on our way to Puerto Penasco Mexico where we have a vacation home. About 20 miles into Mexico the car just stopped. Tons of Smoke from the tail pipe, Low oil pressure all of a sudden came on. I am attaching pics showing that the car was not showing overheated. So now my husband and i are stuck on the side of the road in Mexico with no cell phone service with a [XXX] car that we can not get fixed no matter how much money or time we put into it. When we finally got ahold of the shop they said they are washing their hands of it and do not want to see this car again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
NHTSA complaint #11652657 — an unverified report by a vehicle owner.