44 of the 912 complaints filed about the Chevrolet Caprice are about the fuel system — 5% of everything owners reported. The worst model year for it is 1991.
44
Complaints
5%
Share of all complaints
2
Crashes
3
Fires
FUEL/PROPULSION SYSTEM
THIS IS ONLY A 2013 CAPTIVA, ENGINE LIGHT CAME ON, FUEL PUMP CONTROL SYSTEM IS ON ITS WAY OUT. THINK WE BOUGHT A LEMON AS WE JUST HAD THE SHIFTING SENSOR CHIP GO OUT A MONTH AGO, NOT GOOD ON A WELL TAKEN CARE OF VEHICLE THAT IS ONLY 2 YEARS OLD.
NHTSA complaint #10811253 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1996 CHEVROLET CAPRICE. THE CONTACT WAS DRIVING 45 MPH WHEN HE HEARD A DRAGGING NOISE COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS MANEUVERED TO THE SHOULDER AND THE CONTACT NOTICED THAT THE STRAPS WHICH HELD THE FUEL TANK IN PLACE WERE FRACTURED DUE TO CORROSION. THE VEHICLE WAS SAFELY DRIVEN HOME AND PARKED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 145,000.
NHTSA complaint #10425416 — an unverified report by a vehicle owner.
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
DIGITAL SPEEDOMETER WAS 35 MPH OFF WHICH RESULTED IN A REAR END COLLISION BECAUSE VEHICLE WAS GOING FASTER THAN THE SPEEDOMETER INDICATED. DIGITAL GAS GAUGE ALSO FAILED TO FUNCTION WHICH RESULTED IN VEHICLE RUNNING OUT OF GAS WHILE DRIVING ALTHOUGH THE GAUGE READ HALF OF TANK. THE CAUSE OF BOTH FAILURES WAS UNDETERMINED.
NHTSA complaint #10040204 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
CONSUMER STATES THAT GAS TANK IS LEAKING FUEL. DEALER NOTIFIED.
NHTSA complaint #10024793 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
PLASTIC FUEL TANK IS LEAKING. TANK IS MANUFACTURED WITH TWO CONE SHAPED DEPRESSIONS IN THE BOTTOM OF THE TANK. STRAPS HOLD THE TANK IN PLACE. THESE STRAPS ALMOST COVER THESE DEPRESSIONS, THE TANK LEAKS AT THE DEPRESSION ON THE RIGHT HAND SIDE ALLOWING FUEL TO ESCAPE. CONTACTED GM, FILE NUMBER 1-109-911-920, BUT WAS TOLD THAT GM WOULD NOT COVER THE COST TO REPLACE AT THIS TIME SINCE INSUFFICIENT COMPLAINTS HAD BEEN RECEIVED TO DATE.
NHTSA complaint #10023217 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
CONSUMER COMPLAINED ABOUT FUEL PUMP PROBLEMS. ALSO, WHILE DRIVING FUEL PUMP BURNED OUT, AND LUCKILY IT DID NOT EXPLODE. FUEL PUMP AND FUEL SENDING MODULE WERE REPLACED. *TS *TT *NLM.
NHTSA complaint #8023678 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
CONSUMER STATES THE FUEL PUMP ON THE VEHICLE WENT OUT WHILE THE CONSUMER WAS DRIVING, CAUSING THE VEHICLE TO SHUT OFF AND NOT MOVE ANY WHERE. ALSO THE CONSUMER DOES NOT THINK THAT THE FUEL PUMP IS IN A PROPER PLACE, BECAUSE IF THERE WAS A SPARK THE VEHICLE COULD HAVE CAUGHT ON FIRE. CONTACTED DEALER.
NHTSA complaint #8017915 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
FUEL LEAK AT TANK FIRST OCCURRED APRIL 22 THIS YEAR. FUEL LEVEL SENDER SEAL REPLACED. MAY !7 FUEL LEVEL SENDER DEFECTIVE, FUEL LEAK. REPLACED FUEL TANK, SENDING UNIT SEAL, FUEL PUMP. TODAY-JULY 18, MASSIVE FUEL LEAK AT TANK WITH GASOLINE PUDDLING UNDER CAR WHILE ENGINE IDLING. 20 MINUTES OF IDLING CAUSED OVER 1 GALLON OF FUEL TO BE EXPELLED FROM TANK. INSPECTION SHOWS POSSIBLE DEFECT IN FUEL VAPOR RECOVERY SYSTEM CAUSING EXCESS FUEL TANK PRESSURE, SUFFICIENT TO CAUSE FUEL TANK SEAL FAILURE WHERE SENDING UNIT MOUNTS TO TANK. THIS IS A VERY SERIOUS PROBLEM. A DISCARDED CIGARETTE COULD CAUSE FUEL VAPORS TO IGNITE. THIS LEAK WILL CONTINUE TO OCCUR UNTIL SOURCE OF EXCESSIVE FUEL TANK PRESSURE CAN BE DETERMINED. IT MAY BE THE RESULT OF FAILURE TO MAINTAIN FUEL VAPOR RECOVERY SYSTEM OR A COMPONENT FAILURE. IF SO, WHY SHOULD A FAILURE RESULT IN MASSIVE FUEL LEAKAGE? THIS IS A PROBLEM WITH LIFE THREATENING POTENTIAL AND SHOULD RECEIVE YOUR HIGHEST PRIORITY IN FOLLOW UP.
NHTSA complaint #764435 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
FUEL TANK IS LEAKING FUEL BECAUSE THE PLASTIC TANK IS SEPARATING FROM SEAM. DEALER CONTACTED.*AK. ALSO THE SERPENTINE BELT WAS REPLACED.
NHTSA complaint #8009483 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
CONNECTOR IN FUEL TANK IS DETERIORATING, FUEL PUMP CONNECTOR FAILED, THE INSULATION ON THE WIRE MELTED, ARCING AT THE CONNECTOR LEAVING A CARBON TRAIL. *JG
NHTSA complaint #8006317 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
THE HOOD AND TRUNK, WAS NEVER PAINTED CORRECTLY FROM THE FACTORY.
NHTSA complaint #746953 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
WIRES FOR FUEL SENDING UNIT HAVE BURNED AND MELTED, INCLUDING ELECTRICAL FUEL CONNECTOR PLUG INSIDE GAS TANK, CAUSING A FIRE HAZARD. CONSUMER HAS REPLACED UNIT, AND NOTICED THAT NEW PART WAS REDESIGNED AND BEEN MODIFIED, INDICATING A PROBLEM WITH OLD DESIGN. CONSUMER STILL HAS ORIGINAL UNIT. *AK *SLC
NHTSA complaint #889361 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
FUEL PUMP FAILURE CAUSED STALL AT HIGHWAY SPEED, ALTHOUGH THE FUSE WAS BLOWN, WIRING HARNESS MELTED AT THE FUEL PUMP AND TANK SENDING UNIT SUGGESTING LETHAL CONCERNS FOR SAFETY.
NHTSA complaint #744306 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
WIRING HARNESS TO FUEL PUMP (INSIDE FUEL TANK)SOMEHOW SHORTED OUT CAUSING WIRING TO GET HOT ENOUGH TO MELT THE WIRE INSULATION AND PLASTIC CONNECTORS,WHICH ATTACH TO THE FUEL PUMP.
NHTSA complaint #742554 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
PLASTIC GAS TANK LEAKS AT TOP.
NHTSA complaint #737486 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
THE PROBLEM IS GAS FUMES, THE FUMES ENTER THRU THE VENTS A) WHEN IDLING B)AT STOP AND DEPRESS THE ACCELERATOR PEDAL TO MOVE FORWARD OR REDUCING THE SPEED. DEALERSHIP COULD NOT FIND ANY PROBLEM.
NHTSA complaint #552892 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
TUESDAY MORNING, AUGUST 17, 1999, I STOPPED AND PUT $10.00 WORTH OF GASOLINE IN THIS VEHICLE, AND DROVE TO WORK. AT LUNCH, I DROVE THE VEHICLE TO LUNCH, PARKED IN THE PARKING LOT ON A SLIGHT INCLINE, AND WENT TO LUNCH. UPON RETURNING, WE FOUND A SMALL GROUP OF ANXIOUS PEOPLE LOOKING AT MY CAR FROM A SHORT DISTANCE. GASOLINE WAS LEAKING OUT FROM UNDER IT, AND HAD RUN ABOUT 15' DOWN THE PAVEMENT, FORMING A PUDDLE. THE FIRE DEPARTMENT HAD BEEN CALLED, AND WAS ON THEIR WAY. WE MANUALLY PUSHED THE CAR AWAY FROM THAT SPOT, ONTO LEVEL GROUND, AND THE DRIPPING FUEL STOPPED. WHEN WE GOT THE CAR ON A LIFT, IT TOOK THE SERVICE TECHNICIAN ABOUT 30 MINUTES TO IDENTIFY A CRACK IN A MOLD SEAM. HE REMOVED THE TANK, REPLACED IT WITH A NEW ONE, AND I DROVE TO THE NEAREST CHEVROLET DEALER, (JOHN SMITH @ 770 953 0100), WHOSE SERVICE MANAGER HAD NEVER HEARD OF A GAS TANK SPONTANEOUSLY FAILING. HOWEVER, HE COULD SEE THAT THIS TANK HAD NOT HIT ANYTHING. HE REFERRED ME TO THE GM HELP LINE 800 NUMBER. (800 222 1020) THEY HAD ALSO NOT HEARD OF THIS PARTICULAR FAILURE, AND AFTER APPROXIMATELY 20 MINUTES ON HOLD, CAME BACK ON AND TOLD ME THAT THIS FAILURE WOULD NOT BE WARRANTED, AS THE CAR WAS TOO OLD, IN SPITE OF THE LOW MILEAGE ON THE VEHICLE. THEY ALSO OPENED FILE #990 470 854. I ASKED IF IT WAS REASONABLE FOR ME TO EXPECT MY GAS TANK TO NOT LEAK, AND WAS TOLD THAT IT WAS. I REALIZE THAT GM IS SENSITIVE ABOUT GAS LEAKS. WELL, I HAVE, IN MY BACK YARD, A GAS TANK THAT LEAKS, AND WOULD LIKE SOMETHING MORE THAN THEIR SYMPATHY. THE NEW OEM TANK COST ME OVER $600. HAD THE GAS IGNITED, WE WOULD NOT HAVE THE TANK TO EXAMINE. I WOULD LIKE THEM TO AT LEAST WANT TO SEE THE TANK, AND THINK ABOUT THE PROBLEM. THANK YOU FOR YOUR HELP.
NHTSA complaint #711298 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY
THE FUEL PUMP IN TANK APPEARS TO HAVE OVERHEATED CAUSING THE CONNECTION PLUG TO OVERHEAT AND MELT THE CONNECTOR AND WIRE. THIS VEHICLE IS A POLICE PATROL CAR AND WAS IN BEING DRIVEN IN REGUALR SERVICE WHEN IT BEGAN TO STALL. THE OFFICER RESTARTED THA CAR SVERAL TIMES AS HE DROVE IT BACK TO THE STATION. OUR REPAIR SHOP DROVE THE CAR INTO THE SERVICE BAY AND PERFORMED REGULAR DIAGOSTIC SERVICE. THE FUEL PRESSURE WAS TESTED AT 70 LBS. CHEVROLET SPEC IS 41 TO 47 LBS. WE PULLED THE PUMP AND FOUND THE PUMP POWERE WIRE AND PLUG MELTED. OUR CONCERN IS THAT THIS WIRE BEING SUBMERSED INSIDE THE FUEL TANK COULD HAVE CAUSED AN EXPLOSION IF THE FUEL LEVEL HAD BEEN LOW. THE HEAT GENERATED FROM THIS PROBLEM AREA SHOULD HAVE CAUSED AN INTERUPTION IN POWER TO THE PUMP BEFORE THE WIRE AND CONNECTOR WERE HOT ENOUGH TO MELT. WE ARE CALLING IN ALL CAPRICES TO INSPECT THIS PROBLEM.
NHTSA complaint #714487 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
THE ENGINE HAD DIED OUT WITH WARNING. HAD HAPPENED TWICE BEFORE. WHENEVER VEHICLE WAS PARKED FOR A LONG TIME. VEHICLE WAS DRIVEABLE UNTIL IT STALLED OUT. HAD TAKEN VEHICLE TO DEALER & MECHANIC COULD NOT LOCATE PROBLEM FIRST TIME. THE NEXT IT HAPPENED & WAS AT DEALER , CONSUMER WAS INFORMED DEFECTIVE FUEL PUMP WAS CAUSING STALLING. HAD REPLACED THE FUEL PUMP.
NHTSA complaint #848595 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
VEHICLE JERKED/BACKFIRED IN MOTION LIKE FUEL NOT GETTING INTO ENGINE. TOOK TO DEALER & INFORMED CONSUMER THAT FUEL PUMP NEEDED REPLACING.
NHTSA complaint #844012 — an unverified report by a vehicle owner.