2010 Chevrolet Equinox body problems

STRUCTURE:BODY

I took the Chevy Equinox to the Chevy dealership to have the oil changed. The House Technician said it was unsafe to put it on a lift. The entire frame was corroded. On 02/28/2023, I had the dealership do a Multi-Point Vehicle Inspection. This is their findings: #1-1010: INSPECTIONS INSPECT/CHECK inspect due to customer request Inspected unit due to customers request found excessive rear under body rust and left rear upper control arm is held on by two bolts, but structure is unstable due to corrosion. The rear drive shaft has been removed for unknown reasons. This assessment is visual and at this time. Unit looks unsafe and unstable to drive due to rear under vehicle rust. l would recommend to park the unit and get alternative transportation and replacing the vehicle due to rust. Customer has been advised of our findings. I called GM and reported the problem. They couldn't do a buyback on the Equinox. I filed a complaint with BBB AUTO-LINE, they closed the case said the vehicle was to old. GM said the Equinox came from up north, and since I live in Arkansas the climate change made the vehicles frame rust rapidly due to the moisture. The emergency brake cable, and control arm is rusted into. The vehicle went from excellent condition to unsafe to drive in one day. Their was no visibility of rust in December2022.

NHTSA complaint #11516512 — an unverified report by a vehicle owner.

STRUCTURE:FRAME AND MEMBERS

The contact's granddaughter owns a 2010 Chevrolet Equinox. The contact stated that upon inspection of the vehicle, severe corrosion and several holes were discovered on the subframe. The dealer nor the manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was unknown. The VIN was unavailable.

NHTSA complaint #11506564 — an unverified report by a vehicle owner.

STRUCTURE:FRAME AND MEMBERS

The contact owns a 2010 Chevrolet Equinox. The contact stated while entering the vehicle she noticed that the rear of the vehicle was full of water, and condensation was in the front of the vehicle. The vehicle was taken to the dealer, and the vehicle was drained of the water, but no failure was found. The failure reoccurred. The manufacturer was not contacted. The failure mileage was 50,000. The VIN was not available.

NHTSA complaint #11496151 — an unverified report by a vehicle owner.

STRUCTURE:BODY

THE OTHER DAY IT WAS RAINING SLIGHTLY AND I WAS AT MY FRIENDS HOUSE. LATER WHEN I LEFT IT WAS RAINING HARDER SO I WAS USING MY WIPERS AND WHEN I HAD GOTTEN 5 MINS DOWN THE ROAD MY WINDSHIELD WIPERS STOPPED WORKING AND IT CAUSED ME TO LOSE CONTROL BECAUSE I COULD NOT SEE A THING. WHEN THAT HAPPENED I HIT SOMETHING AND WAS IN THE GRASS A BIT. NOW I HAVE A CHUNK OF MY BUMPER GONE AND A HEADLIGHT OUT CAUSE OF WHAT I HIT. WHICH I REALLY DON'T KNOW WHAT IT WAS I HIT. NOW MY WIPERS DON'T WORK, A CHUNK OF MY BUMPER IS GONE, AS WELL AS SOME PLASTIC UNDER MY CAR CAME OFF.

NHTSA complaint #11325917 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I STARTED NOTICING THAT WATER WAS SOAKING THE FLOOR MAT ON THE DRIVERS SIDE OF THE CAR AFTER IT RAINED OR I WENT THROUGH A CAR WASH. I TOOK THE CAR TO A REPAIR SHOP AND THEY NOTIFIED ME THAT THE BOTTOM OF THE CAR IS NOT WELDED PROPERLY FROM THE MANUFACTURER, SO THE SPACE WHERE IT SHOULD HAVE BEEN WELDED TOGETHER HAS LEFT HOLES ON BOTH SIDES OF THE BOTTOM OF THE CAR. THESE HOLES PROVIDE AN AREA WHERE WATER LEAKS INTO THE CAR AND CONTINUOUSLY SOAKS THE FLOORS. THERE IS ALSO INFORMATION FROM GM THAT STATES OTHER 2010 CHEVROLET EQUINOX CARS HAVE HAD THIS SAME PROBLEM, SO IT IS CLEARLY A MANUFACTURING PROBLEM.

NHTSA complaint #11218521 — an unverified report by a vehicle owner.

STRUCTURE

2010 CHEVROLET EQUINOX. CONSUMER WRITES IN REGARDS TO FRONT AND REAR RUSTED SUBFRAME. *LD THE CONSUMER STATED THE FRONT AND REAR SUBFRAME WAS COMPLETELY ROTTED. THE ROCKER ARMS ON BOTH SIDES WERE EXTREMELY RUSTED AND SOFT. THE BOTTOM OF THE DOORS WERE ALSO ROTTED. THE MANUFACTURER WAS NOTIFIED.

NHTSA complaint #11195213 — an unverified report by a vehicle owner.

STRUCTURE:BODY

TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING APPROXIMATELY 40 MPH OVER A POTHOLE, THE REAR PASSENGER TIRE BECAME FLAT. THE CONTACT USED THE SPARE TIRE AND DROVE THE VEHICLE TO A TIRE FACILITY TO PURCHASE A NEW TIRE. THE MECHANIC DISCOVERED THAT THE FRAME AND COMPONENTS WERE SEVERELY RUSTED AND THE CONTROL ARM WAS FRACTURED. THE VEHICLE WAS DEEMED UNSAFE TO BE DRIVEN. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNAVAILABLE.

NHTSA complaint #11203061 — an unverified report by a vehicle owner.

STRUCTURE:BODY

RUST ON BOTTOM OF DOOR PANELS, ALSO HATCH DOOR CAR IS OILED ANNUALLY,

NHTSA complaint #10940414 — an unverified report by a vehicle owner.

STRUCTURE:BODY

TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. THE CONTACT STATED THAT THE VEHICLE WAS ABLE TO BE IN MOTION WITHOUT THE KEY IN THE IGNITION. ALSO, WHEN THE GEAR WAS SHIFTED INTO PARK, IT WAS NOT FULLY IN GEAR SO THE CONTACT CONSTANTLY HAD TO CHECK. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 16V502000 (ELECTRICAL SYSTEM, POWER TRAIN). IN ADDITION, WATER ENTERED VARIOUS AREAS OF THE VEHICLE AND THE ELECTRONIC STABILITY TRACTION CONTROL WARNING INDICATOR RANDOMLY ILLUMINATED. THE VEHICLE ALSO ROLLED BACKWARD AND FORWARD WITHOUT WARNING AND THE HATCH CAME DOWN UNEXPECTEDLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE MULTIPLE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA complaint #10939970 — an unverified report by a vehicle owner.

STRUCTURE:BODY

VEHICLE IS 5 YEARS OLD AND THERE IS RUST ON THE INSIDE LOWER DOOR HEM ON THREE OF THE 4 DOORS. IT HAS ALWAYS BEEN HOUSED IN A GARAGE IN THE EVENINGS AND WASHED WITH RELATIVE FREQUENCY. GM HAS ISSUED A NOTICE TO FIX THIS ISSUE BUT FOR VEHICLES HOUSED IN CANADA ONLY NOT IN THE US. IT IS OBVIOUS THIS IS A DESIGN FLAW THAT GM IS CORRECTING IN CANADA BUT NOT THE US.

NHTSA complaint #10763708 — an unverified report by a vehicle owner.

STRUCTURE:BODY

GM, USED A FELT LIKE MATERIAL ON THE 2010 EQUINOX BETWEEN THE FRONT FENDER AND THE FIRE WALL FOR SOUND DEADENING . I HAVE CHECKED OUT THEIR NEW MODELS AND THEY ARE USING IT ON ALL OF THEM NOW [TRUCKS,CARS,SUVS]. THE PROBLEM IS THAT THIS MATERIAL STAYS WET, COLLECTS SALT, MUD, ETC. AS WE DRIVE ON ROADS WHERE SALT IS USED IN THE US AND CANADA I HAVE REMOVED ON THE PASSENGER SIDE SO FAR. THE FIRE WALL AND FENDER BOTH HAVE SERIOUS RUST WHICH WILL LEAD TO A PERFORATION OF THE PASSENGER CABIN. THERE MUST BE A BETTER MATERIAL TO USE FOR THIS PURPOSE THAT WILL NOT STAY WET. I HAVE CONTACTED GM BUT THEY DID NOT SEEM TOO CONCERNED ABOUT THE ISSUE. HOPE YOU FOLKS HAVE BETTER LUCK THEN MYSELF. PLEASE NOTE WE LIVE IN CANADA AND ARIZONA ABOUT 50/50.

NHTSA complaint #10616586 — an unverified report by a vehicle owner.

STRUCTURE

THE CHEVROLET EQUINOX INSTRUMENT PANEL TOP PAD HAS A INTEGRATED COMPARTMENT IN THE CENTER. THE COMPARTMENT HAS A BRIGHT CHROME LATCH FOR OPENING THE COMPARTMENT. THE LATCH HAS A VERY REFLECTIVE SURFACE. WHEN DRIVING SOUTH EAST THE SUN REFLECTED OFF THE LATCH BLINDING THE DRIVER EVEN WITH SUNGLASSES. VIEW OF THE ROAD WAS LOST AND THE SEAT HAD TO BE REPOSITIONED TO MOVE THE DRIVERS EYES FROM THE REFLECTION. PHOTOGRAPH IS AVAILABLE.

NHTSA complaint #10595979 — an unverified report by a vehicle owner.

STRUCTURE:BODY:HATCHBACK/LIFTGATE

THE BACK HATCH LOCK WILL NOT RELEASE ON MY 2010 EQUINOX TO OPEN THE HATCH. IT STARTED WITH A DIFFICULT TRY TO OPEN IT. NOW IT WILL NOT OPEN AT ALL. I AM BRINGING IT TO THE DEALER TOMORROW (IT IS OUT OF WARRANTY OVER 36,0000 MILES) THIS HATCH IS NOT OPEN EVERY DAY. IN REALITY IT IS OPEN ONLY ABOUT ONCE A WEEK, SO IT SHOULDN'T HAVE BROKEN.

NHTSA complaint #10560559 — an unverified report by a vehicle owner.

STRUCTURE:BODY

MILDEW SMELL IN CAR FROM AIR VENTS, AND ALSO STRONGER SMELL FROM WINDOW WELLS WHEN WINDOWS ARE ROLLED DOWN. FIRST, DEALERSHIP REPLACED CABIN AIR FILTER. DIDN'T CORRECT PROBLEM. TWO WEEKS LATER, TOOK IT BACK AND THEY DETERMINED DRAIN HOLES IN ALL FOUR DOORS WERE "CLOGGED" AND MILDEW WAS BUILDING UP INSIDE DOORS. DEALERSHIP CLAIMS THEY TOOK APART ALL DOORS, CLEANED AND SPRAYED INSIDE WITH DISINFECTANT AND CLEANED OUT WEEP HOLES IN DOORS.- ALL WITHIN TWO HOURS. THEY TOLD US TO "KEEP AN EYE ON THE WEEP HOLES YOU'LL PROBABLY HAVE TO KEEP HAVING THIS DONE." THIS IS UNACCEPTABLE ON A BRAND-NEW CAR. IT CAUSES A TERRIBLE SMELL, AND AN UNSAFE RESPIRATORY ENVIRONMENT FOR PASSENGERS.

NHTSA complaint #10408730 — an unverified report by a vehicle owner.

STRUCTURE:BODY:HATCHBACK/LIFTGATE

+2010 EQUINOX LIFTGATE GOES ALL THE WAY UP, BUT IN A COUPLE OF SECONDS SLOWLY COMES BACK DOWN TO ABOUT 3/4 OPEN. I TRIED EVERYTHING TO CORRECT THE PROBLEM. COULD NOT FIND ANYTHING ON THE INTERNET OF ANYONE ELSE HAVING THIS PROBLEM.

NHTSA complaint #10369993 — an unverified report by a vehicle owner.

STRUCTURE

IN NEW CHEVY VEHICLES THERE IS A CENTER STORAGE COMPARTMENT LOCATED ABOVE THE CENTER CONSOLE. THIS IS HELD DOWN IN PLACE BY A SIMPLE PUSH BUTTON. THE BUTTON HOWEVER IS PROBLEMATIC AS IN SOME TRIMS IT IS A CHROME FEATURE. IN SUNNY CONDITION, THE REFLECTION FROM THE CHROME PUSH BUTTON REFLECTS INTO THE DRIVER'S EYES. THIS COULD LEAD TO POSSIBLE DANGEROUS DRIVING CONDITIONS.

NHTSA complaint #10342100 — an unverified report by a vehicle owner.

STRUCTURE:FRAME AND MEMBERS

HARD TO PUT GAS ON THIS VEHICLES AND TEND TO EJECT GAS PUMP TRIGGER WHEN PUTTING GAS. ROOF WOOBLY NOT STRONGLY CONSTRUCTED.

NHTSA complaint #10313857 — an unverified report by a vehicle owner.