113 of the 355 complaints filed about the Chevrolet G20 are about the braking system — 32% of everything owners reported. The worst model year for it is 1995.
113
Complaints
32%
Share of all complaints
23
Crashes
1
Fires
SERVICE BRAKES
TL* THE CONTACT OWNS A 1995 CHEVROLET G20. WHILE DRIVING 40 MPH, THE BRAKES FAILED. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY ENGAGING THE EMERGENCY BRAKE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
NHTSA complaint #10945850 — an unverified report by a vehicle owner.
SERVICE BRAKES
WHILE DRIVING APPROACHING STOPLIGHT BRAKES WOULD NOT ENGAGE. PRESSED BRAKE PEDAL TO FLOOR AND DRIVE VAN UP AND OVER CURB WHILE USING EMERGENCY BRAKE. CONTACTED DEALER WHERE VAN WAS TOWED. SAID BRAKES NEEDED TO BE BLED AGAIN. BRAKES BLED AND PEDAL STILL FELT THE SAME-SPONGY. TOLD THIS IS NORMAL. DRIVING HOME ON WINDDY ROAD,APPLIED BRAKES NOTHING HAPPEND RELEASED BRAKES AND TRIED AGAIN AND THE FRONT BRAKES LOCKED UP. DEALER SAID TO BRING BACK. THEY INSPECTED SYSTEM SAID BAD MASTER CYLINDER. REPLACED MASTER CYLINDER AND STILL SPONGY BRAKES. DEALER SAID THIS IS NORMAL. THEY STILL DO NOT GRIP AS STRONG DESPITE ALL BRAKE COMPONENTS REPLACED EXCEPT FOR THE VACCUME BOOSTER AND ABS MODULE. I ALSO NO LONGER HEAR THE ABS MODULE COME ON LIKE IT USED TO BEFORE ALL OF THIS, THE ABS LIGHT DOES COME ON AND GOES OUT AFTER STARTING VAN. THE OWNERS MANUAL STATES YOU SHOULD HEAR THE ABS PUMP COME ON WHEN STARTING VAN THEN COME ON AGAIN AT ABOUT 7MPH. IT DOES NOT. TOLD DEALER THIS AND THEY SAID THE MANUAL IS WRONG AND THAT THE BRAKES ARE FINE. YEAH, RIGHT. WHEN GOING 55 MPH DOWN HILL VAN WOULD NOT SLOW DOWN UNLESS I HOLD THE BRAKE PEDAL ALMOST ALL THE WAY DOWN OR USE THE EMERGENCY BRAKE AND COME TO A VERY FAST STOP. AS THIS BEING A FAMILY VAN WE A SCARED TO DRIVE IT. OTHER MECHANICS CAME TO CONCLUSION THE ABS IS AT FAULT. POSSIBLE AIR IN CHAMBERS AND HAS TO BE SERVICED BY DEALER COMPUTER. DEALER SAYS THE ABS IS FINE. WE HAVE ALSO FOUND RECALL ON ABS, BUT OUR VAN IS NOT INCLUDED ACCORDING TO G.M. PLEASE HELP US GET THIS RESOLVED!! THANK YOU
NHTSA complaint #10596774 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 1995 CHEVROLET G20. THE CONTACT WAS DRIVING 20 MPH AND APPLIED THE BRAKES WHEN THE PEDAL DEPRESSED TO THE FLOORBOARD ABNORMALLY. THE VEHICLE WAS MANEUVERED TO THE SHOULDER AND COASTED TO A STOP. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME WHERE AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE BUT WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO FILED A COMPLAINT WITH THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 62,173. THE PLUNGER IN THE MASTER CYCLINDER WAS INCAPABLE OF PROPELLING THE BRAKE FLUID THROUGH THE LINES AND THE BRAKE CYCLINDERS COULD NOT EXPAND. VEHICLE HAS STOP BECAUSE OF TRANSMISSION. FAILURE DURING DOWN GRADE. VEHICLE PICKED UP SPEED WHEN TRANSMISSION WAS USED TO STOP ITS FORWARD PROGRESS. UPDATED 11/09/2011 *LN
NHTSA complaint #10426891 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 1992 CHEVROLET G20. THE CONTACT STATED THAT THE BRAKES FAILED AND CAUSED THE CONTACT TO CRASH INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO A MECHANIC AND WAS TOLD THAT THE SUPPORT FOR THE BRAKE LINE WAS RUSTED AND THE PRESSURE CAUSED THE BRAKE LINE TO RUPTURE. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 171,000. UPDATED 09/27/11*LJ UPDATED 2/23/12
NHTSA complaint #10419985 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
DT*: THE CONTACT STATED WHILE DRIVING LESS THAN 10 MPH ON AN ICY ROAD, A VEHICLE STOPPED SHORT IN FRONT OF THE CONTACT'S VEHICLE. IN AN ATTEMPT TO BRAKE, THE ABS ON THE VEHICLE DID NOT ENGAGE. THE CONTACT'S VEHICLE COLLIDED WITH THE VEHICLE IN FRONT OF IT. THERE WAS A DRILL-LIKE SOUND WHEN THE BRAKES ARE DEPRESSED. THE VEHICLE DOES NOT NORMALLY ENGAGE ON WET OR ICY SURFACES. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THERE IS A NHTSA RECALL, 99I006000, REGARDING THE SERVICE BRAKES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
NHTSA complaint #10150352 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
DT: THE CONTACT STATED ONE MONTH AGO HE NOTICED A BRAKE PROBLEM. WHEN APPLYING THE BRAKE AT ANY SPEED THE PEDAL WENT TO THE FLOOR AND THERE WERE NO BRAKES. JUST AS HE WAS PRESSING THE PEDAL THE ABS LIGHT CAME ON. AFTER HE WAS OFF OF THE PEDAL THE LIGHT DISAPPEARED. HE THE CONTACT CITED RECALL 99I006000. HE CALLED THE MANUFACTURER, AND THEY TOLD HIM THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN.
NHTSA complaint #10136449 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
WHEN THE CONSUMER SHIFTED THE GEAR TO REVERSE AND ACCELERATED AT A LOW SPEED THE FRONT BRAKE PIN SNAPPED. THE CONSUMER LOST STEERING CONTROL BUT MANAGED TO PULL OVER. THE CONSUMER CONTACTED THE DEALERSHIP MECHANIC BUT THE PROBLEM HAS NOT BEEN RESOLVE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NLM
NHTSA complaint #10042286 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
FRONT END- WHEN APPLYING THE BRAKES THE ENTIRE FRONT END SHIMMIES AND VIBRATES MAKING IT DIFFICULT TO CONTROL THE VAN. WE HAVE ONLY OWNED THIS VAN FOR LESS THAN 2 YEARS BUT THIS SHOULD NOT BE HAPPENING.
NHTSA complaint #10030420 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
NHTSA# 99-I-006-000: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: CERTAIN LIGHT DUTY PICKUP TRUCKS, SPORT UTILITY VEHICLES, OR MINIVANS EQUIPPED WITH 3-SENSOR ABS (ANTI-LOCK BRAKING SYSTEM) EBC4 UNITS. THE CONSUMER'S VEHICLE EXPERIENCED THE SAME FAILURE, HOWEVER THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED.
NHTSA complaint #10022436 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
ANTI LOCK BRAKES FAIL WHEN A BUMP, POT HOLE OR SLICK SURFACE IS ENCOUNTERED
NHTSA complaint #10005280 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
CONSUMER STATED THE VEHICLE PULLS TO THE RIGHT WHEN BRAKING, CONSUMER WAS INFORMRED THAT THE ABS MODULATOR NEEDS TO BE REPLACED.
NHTSA complaint #785898 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
CONSUMER STATED THE VEHICLE PULLS TO THE RIGHT WHEN BRAKING, CONSUMER WAS INFORMRED THAT THE ABS MODULATOR NEEDS TO BE REPLACED.
NHTSA complaint #785898 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
NO SUMMARY LISTED FOR ABOVE VEHICLE.
NHTSA complaint #752088 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
VEHICLE PULLS TO THE LEFT WHEN APPLYING BRAKES. I HAD THE FRONT BRAKES REPLACED AND ROTORS TURNED LAST MONTH AT 32,095 ACTUAL MILES. THE PROBLEM OF PULLING TO THE LEFT CONTINUES WHEN BRAKES ARE APPLIED. WHEN BRAKES ARE RELEASED, IT PULLS TO THE RIGHT--IT DOESN'T RELEASE. IN CASE OF AN EMERGENCY STOP, IT PULLS TO THE LEFT, THEN RIGHT, THEN LEFT, THEN RIGHT. I WAS TOLD I NEED TO REPLACE THE BRAKE PRESSURE MODULATOR VALVE TO CORRECT THIS PROBLEM. THIS WILL COST APPROXIMATELY $1100.00. I FEEL THIS SHOULD NOT HAPPEN AT THIS LOW MILEAGE.
NHTSA complaint #748216 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
VEHICLE PULLS TO THE LEFT WHEN APPLYING BRAKES. I HAD THE FRONT BRAKES REPLACED AND ROTORS TURNED LAST MONTH AT 32,095 ACTUAL MILES. THE PROBLEM OF PULLING TO THE LEFT CONTINUES WHEN BRAKES ARE APPLIED. WHEN BRAKES ARE RELEASED, IT PULLS TO THE RIGHT--IT DOESN'T RELEASE. IN CASE OF AN EMERGENCY STOP, IT PULLS TO THE LEFT, THEN RIGHT, THEN LEFT, THEN RIGHT. I WAS TOLD I NEED TO REPLACE THE BRAKE PRESSURE MODULATOR VALVE TO CORRECT THIS PROBLEM. THIS WILL COST APPROXIMATELY $1100.00. I FEEL THIS SHOULD NOT HAPPEN AT THIS LOW MILEAGE.
NHTSA complaint #748216 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
BRAKES SPONGIE, PEDAL GOES TO FLOOR, BREAK FLUID OK. POWER ASSIST BOOSTER WEAK.
NHTSA complaint #747634 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
BRAKES SPONGIE, PEDAL GOES TO FLOOR, BREAK FLUID OK. POWER ASSIST BOOSTER WEAK.
NHTSA complaint #747634 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
WHEN DRIVING DIFFERENTIAL WOULD MAKE GRINDING NOISE. NOISE WAS LIKE IT WAS STRAINING WHEN ACCLELRATING AND/OR BRAKING. *AK CONSUMER HAD A LOSS OF POWER HAD TO REPLACE SWAY BUSHINGS, VEHICLE BEGAN TO OVER HEAT IN WHICH THERMOSTAT WAS REPLACED, CONSUMER COMPLAINED OF NOISES FROM REAR END BUT WAS ADVISED COULD NOT DUPLICATE, CONSUMER ALSO COMPLAINED OF A TICKING NOISE BUT WAS ADVISED THAT WAS NORMAL, ALSO SPEAKER ON LEFT SIDE HAS STATIC UNABLE TO BE DUPLICATED, NOISE IN BRAKES WHEN BACKING UP,FRONT DOOR DOES NOT CLOSE PROPERLY MAKES A BANG NOISE,DRIVE BELT SQUEAKING, SERPENTINE BELT WAS REPLACED, WATER LEAKING INTO VEHICLE WINDSHIELD WAS FITTING POOLY REPLACED WINDSHIELD, VACUUM BRAKE BOOSTER WAS REPLACED,STEERING WHEEL VIBRATES AT 40 MPH, CIGARRETTE LIGHTER WHEN IN USE SMOKES DUE TO ASHES ON LIGHTER ELEMENT ALSO IGNITION COIL HAD TO BE RELACED DUE TO CORROSION HYDRAULIC SYSTEM WAS REPLACED .
NHTSA complaint #889102 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:POWER ASSIST
WHEN DRIVING DIFFERENTIAL WOULD MAKE GRINDING NOISE. NOISE WAS LIKE IT WAS STRAINING WHEN ACCLELRATING AND/OR BRAKING. *AK CONSUMER HAD A LOSS OF POWER HAD TO REPLACE SWAY BUSHINGS, VEHICLE BEGAN TO OVER HEAT IN WHICH THERMOSTAT WAS REPLACED, CONSUMER COMPLAINED OF NOISES FROM REAR END BUT WAS ADVISED COULD NOT DUPLICATE, CONSUMER ALSO COMPLAINED OF A TICKING NOISE BUT WAS ADVISED THAT WAS NORMAL, ALSO SPEAKER ON LEFT SIDE HAS STATIC UNABLE TO BE DUPLICATED, NOISE IN BRAKES WHEN BACKING UP,FRONT DOOR DOES NOT CLOSE PROPERLY MAKES A BANG NOISE,DRIVE BELT SQUEAKING, SERPENTINE BELT WAS REPLACED, WATER LEAKING INTO VEHICLE WINDSHIELD WAS FITTING POOLY REPLACED WINDSHIELD, VACUUM BRAKE BOOSTER WAS REPLACED,STEERING WHEEL VIBRATES AT 40 MPH, CIGARRETTE LIGHTER WHEN IN USE SMOKES DUE TO ASHES ON LIGHTER ELEMENT ALSO IGNITION COIL HAD TO BE RELACED DUE TO CORROSION HYDRAULIC SYSTEM WAS REPLACED .
NHTSA complaint #889102 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
WHILE DRIVING, VEHICLE WOULD WANDER SIDE TO SIDE AND PULL TO SIDE. SOMETIMES COULD FLIP OVER. THEN, TOOK VEHICLE TO DEALER , AND THEY FOUND TREAD SEPARATION. FIRESTONE, FIREHAWK TIRES. *AK CONSUMER STATES WHEN VEHICLE WAS TAKEN IN FOR REGULAR MAINTENANCE IT WAS DISCOVERED THAT ALL FOUR TIRES WERE FOUND TO HAVE BROKEN BELTS AND TIRES WERE UNABLE TO BE ROTATED, BALANCED OR ALIGNED, CONSUMER WAS ADVISED BY MECHANIC TO GO TO FIRESTONE ABOUT THE TIRES, WHEN CONSUMER ARRIVED SHE WAS TOLD THEY HAD TOO MANY VEHICLES TO SERVICE. CONSUMER ALSO WAS ADVISED THAT BRAKES WERE NEEDED.
NHTSA complaint #882138 — an unverified report by a vehicle owner.