2005 Chevrolet Impala fuel system problems

FUEL/PROPULSION SYSTEM

I AM COMPLAINING ABOUT THE JUST PURCHASED WHIC WAS VAVOLINE WHEN PLACED IN VEHICLE ENGINE THERMAL VISCOSITY BREAKDOWN HAPPENED AND ENGINE BLOCK SEIZED. RESTARTED AFTER OIL CHANGE SAME OIL ENGINE BLOCK SEIZED. WITH WHAT I'M READING AND WATCHING THE THIRD OR FOURTH VEHICLE TOWED FROM THE NEIGHBORHOOD MAYBE IT'S THE MOTOR OIL. I UNDERSTAND THAT HIGH HEAT BREAKS DOWN RAPIDLY WITH SOY BASED LUBRICANTS. I UNDERSTAND YOU MIGHT NOT BE ABLE TO ADMIT THIS OR ARE UNAWARE BUT COULD YOU PLEASE KEEP ON FILE.

NHTSA complaint #11173352 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

THE FUEL PRESSURE REGULATOR LEAKING GAS.. AND SMELLS GASOLINE REALLY STRONG.. AND HARD STARTING ISSUE.

NHTSA complaint #11002742 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN I AM DRIVING MY VEHICLE THE GEAR SHIFT THE STICK ON IT'S OWN.I HEAR A POP SOUND WHEN IT HAPPENS.THIS HAPPENS WHEN I AM IN MOTION AND DRIVING THE CAR..I HAVE ALREADY TAKEN MY CAR IN FOR A RECALL LAST YEAR TO REPLACE A IGNITION SWITCH.IT HAS BEEN HAPPENING FOR A FEW WEEKS AND I THOUGHT IT WAS NORMAL,UNTIL I WAS IN TRAFFIC AND IT MOVED ON IT'S OWN. ALSO LAST YEAR I HAD TO HAVE THE FUEL INJECTOR REPLACED ON MY CAR.IT HAD BEEN LEAKING GAS FOR A WHILE.THE DEALERSHIP TOLD ME I WOULD HAVE TO PAY TO HAVE IT FIXED.THERE WEREN'T ANY RECALLS DURING THE TIME.

NHTSA complaint #10875870 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

175555 MILES FUEL SMELL AND FUEL LOSS WHEN CAR IS RUNNING. ROUGH START, SOME MISSING. FUEL FILTER FAILED AT FILTER INLET SPRAYING GAS ONTO UNDERBODY OF CAR SO DIDN'T SEE THE FUEL SPILL. REPLACED FILTER AND O RINGS.SQUEALING BELT SOUND AT START UP. SERPENTINE BELT TENSIONER BROKE, REPLACED TENSIONER AND BELT. NO CHECK ENGINE WARNINGS, NO ELECTRONIC GAUGES I HAVE THE BASIC IMPALA MODEL. WATCHED THE FUEL GAUGE DROP BY LINES WHILE DRIVING AND SMELLED GAS WHEN SHUT OFF CAR. FIRE HAZARD, AND ENGINE FAILURE IF THE BELT BROKE COMPLETELY..ANOTHER 300$ SPENT

NHTSA complaint #10860661 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I PURCHASED THIS VEHICLE FOR SUBURBAN KIA IN TROY. ON THE THIRD DAY OF DRIVING IT, I NOTICED GASOLINE SMELLS COMING INTO THE CAR. I TOOK THE VEHICLE BACK ON 1/18/16 AND THEY WERE NOT ABLE TO FIND OUT THE CAUSE OF THE GAS SMELL COMING INTO THE CAR. I WILL BE TAKING IT BACK ON 1/21/16 WHEN THEY CAN KEEP IT ALL DAY. THE SMELLS COME WHEN THE CARE IS IN MOTION. ENOUGH FUMES TO TAKE MY BREATH AWAY. I HAVE TO DRIVE WITH THE WINDOWS OPEN.

NHTSA complaint #10821050 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

2005 IMPALA BOUGHT FROM ELDERLY MOTHER 50,000 MIES FUEL LEAK BEFORE FUEL INJECTOR PIPE ONTO MOTOR.

NHTSA complaint #10809580 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2005 CHEVROLET IMPALA. THE CONTACT NOTICED A STRONG FUEL ODOR OUTSIDE THE VEHICLE. THE FAILURE WAS PERSISTENT. THE CONTACT ALSO STATED THAT THE VEHICLE SURGED FORWARD RANDOMLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 114,742. UPDATE 01/15/16 MA

NHTSA complaint #10789210 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

HAD TO RECENTLY REPLACE FUEL EJECTION AND OTHER PART FOR FUEL LEAKING AND FUMES OVERCOMING IN CAR. NOW THE SPEEDOMETER, FUEL AND TACK GAUGE STOPPED WORKING. GM HAS NOT RECALLED THIS ON THE IMPALA AND THEY ARE AWARE THIS IS A PROBLEM BUT WILL NOT TAKE RESPONSIBILITY. THESE ISSUES HAVE BEEN A SERIOUS SAFETY HAZARD FOR MY DAUGHTER AND CANNOT DRIVE THE CAR. EVERY CHEVY DEALERSHIP AND PARTS STORES THINK THERE IS A RECALL UNTIL THEY LOOK IT UP. THATS HOW MUCH THEY ARE AWARE OF THE ISSUES. ONCE AGAIN ILL HAVE TO PAY APPROX. 300.00 JUST FOR THE PART. DORMAN OE SOLUTIONS INSTRUMENT CLUSTER. HOW CAN WE STOP GM FROM GETTING AWAY WITH THIS! WE NEED HELP!

NHTSA complaint #10765372 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

INTERMITTENT NO CRANK, NO START. PROBLEM IS KNOWN PROBLEM WITH IGNITION SWITCH, TUMBLER, AND DEFECTIVE "PASSLOCK SYSTEM". DEALERS CHARGE EXCESSIVE PROCES FOR REPAIRS THAT MAY OR MAY NOT ACTUALLY FIX THE PROBLEM. IT SEEMS TO BE A BAD DESIGN ISSUE, AND IS RELATED TO THE DEFECTIVE IGNITION RECALLS. THERE IS A FAIRLY EXTENSIVE COMPLAINT LIST, AND THE MFR CERTAINLY HAS DATA REFLECTING THAT THE PROBLEM COVERS MULTI MODEL AND YEARS OF GM CARS AND TRUCKS.

NHTSA complaint #10750173 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

GAS FUMES INSIDE AND OUT. CAN'T DRIVE CAR IT'S THAT BAD. HAD CHEVY DEALER TOLD ME IT WAS FUEL FILTER REPLACED IT GUESS WHAT STILL HAD FUMES AFTER DRIVING HALF A MILEHAD CAR SINCE 2006 .80000 MILES ON CAR 68 YEAR OLD , CAR IN EXCELLENT CONDITION, CAN'T DRIVE OR WOULD END UP IN HOSPITAL. GM DEALER TOLD ME THERE IS NO RECALL . SOMEBODY HAS ROCKS IN THERE HEAD. THERE HAS BEEN A LOT OF COMPLAINTS ABOUT THIS,SOMEBODY NEEDS TO QUIET LINING THEIR POCKETS AND TAKE CARE OF THEIR PRODUCTS.

NHTSA complaint #10691225 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

OWNER OF 2005 CHEVY IMPALA TRIED MULTIPLE TIMES TO START CAR. PASSLOCK SYSTEM PREVENTING CAR TO START.

NHTSA complaint #10683857 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

OVER THE LAST 2 YEARS I HAVE EXPERIENCED NUMEROUS PROBLEMS. THE FIRST PROBLEM WAS SHIFTING OF THE VEHICLE WHICH SHIFTS VERY HARD. THE SECOND PROBLEM WAS A LOT OF RUST AND NEEDING TO HAVE BODY WORK DONE. NOW WITH A LITTLE OVER 70,000 MILES ON THE CAR IT MIGHT NOT PASS INSPECTION NEXT YEAR BECAUSE THE BODY/FRAME IS SO RUSTED THAT IT WOULD COST MORE TO HAVE IT FIXED THAN THE CAR IS WORTH. THE CAR IS WELL TAKEN CARE OF SO IT IS NOT FOR LACK OF CARETAKING ON MY PART. THE THIRD PROBLEM IS IN THE LAST 2 MONTHS PERIODICALLY WE CAN SMELL GAS IN THE INSIDE OF THE CAR, NOT EXHAUST FUMES - GAS. IT'S AWFUL; NAUSEATING AND UNBEARABLE. THIS SMELL CAN ALSO BE DETECTED OUTSIDE OF THE VEHICLE. I WORRY ABOUT THE HEALTH AND SAFETY OF ME AND MY FAMILY IN THIS VEHICLE FOR THESE REASONS. ALSO, AT THIS POINT I AM AFRAID TO PARK THE CAR IN OUR ATTACHED GARAGE FOR FEAR IT COULD START A FIRE.

NHTSA complaint #10618614 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FUEL STOPPED WORKING. TEMP GAUGE AS WELL.

NHTSA complaint #10607268 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

WHEN THE IMPALA IS AT NORMAL OPERATING TEMPERATURE THE ENGINE DIES WHEN YOU REMOVE YOUR FOOT OFF THE ACCELERATOR AS WHEN APPROACHING A STOP SIGN . IF THE ENGINE HAS NOT REACHED NORMAL OPERATING TEMPERATURE THIS DOES NOT OCCUR.

NHTSA complaint #10576466 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2005 CHEVROLET IMPALA. THE CONTACT STATED THAT THERE WAS A STRONG ODOR OF GASOLINE BEING EMITTED FROM THE FUEL LINE. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO DIAGNOSE THE PROBLEM. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER:07E021000 (FUEL SYSTEM, OTHER). THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70000.

NHTSA complaint #10566947 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

GAS SMELL.

NHTSA complaint #10562741 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

CAR HAS JUST ROLLED OVER TO A LITTLE OVER 165,,000 MILES AND WHEN WE BOUGHT IT AT THE TIME WE DIDN'T THINK ANYTHING OF IT AND THEN TURNS OUT A YEAR AFTER WE BOUGHT THE CAR IT STARTED SMELLING LIKE GAS BIG TIME BUT WE DIDN'T KNOW WHERE IT WAS COMING FROM THEN WHEN I WENT TO PUT THE CAR IN PARK THE CHECK ENGINE LIGHT CAME ON SO IM LIKE THINKING NOW WHAT AND SO WE TAKE IT TO A GARAGE AND THEY SAY OH YOUR ENTIRE EXHAUST SYSTEM IS RUSTED OUT AND THAT THERE'S A DOLLAR SIZE HOLE NEAR THE FRONT OF THE EXHAUST BUT WE DIDN'T GET IT FIXED BECUZ WE COULDN'T AT THE TIME SO THEY JUST TOLD ME TO DRIVE IT AS IS AND I HAVE BEEN BUT I'VE BEEN NOTICING THAT IT SOUNDS LOUDER AND LOUDER ALMOST LIKE HOW A CAR DOES NOT HAVE AN EXHAUST SYSTEM AND I REALLY DON'T FEEL SAFE BECUZ ITS LOUD AND IT SMELLS LIKE GAS ON THE INSIDE AND IM AFRAID OF IT CATCHING ON FIRE ONE OF THESE DAYS AND AS FOR THE RESISTOR BLOWER MODULE FOR THE A/C AND HEATER WE ALREADY HAD TO REPLACE THAT THREE TIMES BECUZ IT KEPT GOING OUT AND I REALLY DON'T WANT TO HAVE THE CAR CATCH ON FIRE BECUZ THE BLOWER MOTOR RESISTOR MODULE ISN'T WORKING PROPERLY AND I DON'T HAVE ANY MONEY TO KEEP FIXING THINGS ON MY CAR.

NHTSA complaint #10536838 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FROM STOP I WOULD STEP ON THE GAS, AND THE CAR WOULD SLAM INTO GEAR. I HAVE HAD TO HAVE THE ELECTRICAL CLUSTER REPLACED $300, AND THE FUEL CONTROL REPLACED (CAR ALWAYS SMELT LIKE GAS) NOW THEY THINK THIS SLAM IS THE TCC VALVE IN THE TRANSMISSION WHICH IS ANYWHERE FROM $600-$900. ALSO THE STEERING KNUCKLE MAKES A LOUD NOISE ON SHARP TURNS. WHATS NEXT? ARE ANY OF THESE ISSUES RECALLS?

NHTSA complaint #10508694 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FOR SEVERAL MONTHS I HAVE BEEN SMELLING STRONG GAS FUMES. TOOK TO PEP BOYS AND THEY CANNOT FIND ISSUE.

NHTSA complaint #10503518 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

EXPERIENCED FUEL SMELL IN THE VEHICLE WHEN OPERATING THE BLOWER. NOTED FUEL REGULATOR VALVE LEAKS FUEL. STOP ENGINE ALLOW TO EVAPORATE AND WHEN THE ENGINE IS WARM STOPPED LEAKING. VEHICLE NOW HAS 161000 MILES AND STOPPED LEAKING. LEAKS WHEN THE TEMPERATURE GETS COOL OR COLD OUTDOORS. DEALER CANNOT FIND THE CAUSE OF THE LEAK. THIS IS A FIRE HAZARD.

NHTSA complaint #10471263 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

THE TEMPERATURE GAUGE, FUEL GAUGE, AND SPEEDOMETER HAVE GONE COMPLETELY HAYWIRE! THE TEMPERATURE GAUGE GOES TO HOT AND BUZZES BUT MY CAR IS NO WHERE NEAR HOT. I DON'T KNOW IF MY TANK IS FULL OR EMPTY BECAUSE THE GAUGE IS ALWAYS ON THE BOTTOM. I DON'T KNOW HOW FAST I'M GOING BECAUSE MY SPEEDOMETER IS STUCK ON 120. THE DEALERSHIP KNOWS THAT THIS IS A COMMON PROBLEM BUT THEY INSIST ON CHARGING $500 OR MORE TO FIX IT...JUST OWN UP AND DO THE RECALL!!

NHTSA complaint #10446940 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

STARTED SMELLING GAS WHILE DRIVING HOME FROM CHURCH ON JANUARY 8, 2012. SMELL OF FUMES INTENSIFIED. MUST ROLL DOWN WINDOWS WHENEVER DRIVING. MY EYES BEGAN TO BURN. I PARKED THE CAR WHEN I GOT HOME, AND I COULD SMELL A LOT OF GAS WHEN I GOT OUT OF THE CAR. CAR SAT UNTIL MONDAY JANUARY 9, 2012. I STILL SMELLED GAS. MY CAR BEGAN BURNING EXTREME AMOUNT OF GAS. CAR SAT UNTIL THE 13TH. I FILLED UP TO A FULL TANK OF GAS. I DROVE 7 MILES TO THE STORE AND 7 MILES BACK. THE CAR BURNED 1/8 TANK OF GAS. LEARNED OF 2005 CHEVY IMPALA RECALL DUE TO FUEL SYSTEM/ FUEL PRESSURE REGULATOR. RECALL ID# 64377. I CONTACTED DEALERSHIP. I DROVE HOME WITH THE WINDOWS DOWN IN 19 DEGREE WEATHER. NOW IT IS SITTING AGAIN DUE TO MECHANIC RECOMMENDATION.

NHTSA complaint #10443801 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

THE SPEEDOMETER JUST STOPPED WORKING, THE TRANSMISSION SHIFT HARD BUT WHEN YOU SHUT OFF THE ENGINE AND START IT BACK UP IT STOPS SHIFTING HARD, AND THE CAR STALLS.

NHTSA complaint #10441700 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL- THE CONTACT OWNS A 2005 CHEVROLET IMPALA. THE CONTACT WAS DRIVING 30 WHEN THE STEERING WHEEL SEIZED AND BECAME DIFFICULT TO MANEUVER. THE CONTACT ALSO STATED THAT AT ENGINE STARTUP, THE SMELL OF FUEL EMITTED INSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO BOTH A PRIVATE MECHANIC AND THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 83,000. KMJ

NHTSA complaint #10441448 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2005 CHEVROLET IMPALA. THE CONTACT STARTED THE IGNITION AND ACTIVATED THE AIR CONDITIONER, THEN THERE WAS AN OVERPOWERING GASOLINE FUEL ODOR INSIDE OF THE VEHICLE. THE FAILURE WOULD OCCUR INTERMITTENTLY AT INITIAL STARTUP WITH THE ACTIVATION OF THE AIR CONDITIONER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE FAILURE CONTINUED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000.

NHTSA complaint #10351419 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

TL* THE CONTACT OWNS A 2005 CHEVROLET IMPALA. THE CONTACT STATED WHILE DRIVING AT 25 MPH, THERE WAS AN UNUSUAL NOISE HEARD AND AS THE CONTACT ATTEMPTED TO BRAKE, THERE WAS AN ABNORMAL INCREASE IN STOPPING DISTANCE AND TIME. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE MECHANIC ADVISED REPLACING THE ROTORS. THE VEHICLE WAS REPAIRED. TWO AND A HALF YEARS LATER, THE FAILURE RECURRED. THE MANUFACTURER ADVISED THE CONTACT THAT THE FAILURE POTENTIALLY WAS CONTRIBUTED TO THE FACT THAT HE RESIDED IN A SALT BELT STATE. THE MANUFACTURER ADVISED BECAUSE HE DID NOT HAVE PRIOR REPAIR PERFORMED AT AN AUTHORIZED DEALER, THEY WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 20,000. UPDATED 8/4/10 *CN THE CONSUMER ALSO STATED HE WAS HAVING PROBLEMS WITH THE FUEL PUMP. UPDATED 08/09/10

NHTSA complaint #10339870 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL PRESSURE REGULATOR LEAKING.

NHTSA complaint #10333873 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

STRONG GAS SMELL IN CAR WHILE IDLING AND DRIVING.

NHTSA complaint #10326761 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

2005 CHEVY IMPALA WHICH LEAKS GAS EVERY MOURNING WHEN THE CAR HAS SET OVERNIGHT. THE RECALL IS THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER, SO THIS CAUSE THE GAS TO LEAK.

NHTSA complaint #10302116 — an unverified report by a vehicle owner.