Owners have filed 417 complaints
about the 2001 Chevrolet Monte Carlo with NHTSA between 2000 and 2020.
The largest single group is the engine & cooling.
Across this model's run it ranks 1 of 13 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 93
Against the median year of the Chevrolet Monte Carlo. 50 means typical for this
model; 100 means roughly double.
Severity — 100
21.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 39
23% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2001 compares with every other Chevrolet Monte Carlo
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
31.2%
1,000 – 9,999 miles
114.4%
10,000 – 24,999 miles
239.2%
25,000 – 49,999 miles
3915.5%
50,000 – 74,999 miles
4015.9%
75,000 – 99,999 miles
4919.5%
100,000 – 149,999 miles
5220.7%
150,000+ miles
3413.5%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2000peak 14Oct 2020
NHTSA investigations into the 2001 Chevrolet Monte Carlo
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA02030Opened 22 Oct 2002Closed 9 Mar 2004FUEL SYSTEM, GASOLINE:DELIVERY
ENGINE COMPARTMENT FIRES
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICL...
Recalls on the 2001 Chevrolet Monte Carlo
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
15V701000
ENGINE AND ENGINE COOLING:ENGINE
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Risk: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
14V400000
ELECTRICAL SYSTEM:IGNITION
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
09V116000
ENGINE AND ENGINE COOLING
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Risk: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
09E005000
STEERING
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
08E063000
STEERING
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Risk: IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
00V244000
AIR BAGS
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Risk: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
00V228003
SEAT BELTS
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2015501105,933 units in Canada
Engine
On certain vehicles equipped with a 3.8L engine, degradation of the front rocker cover gasket may result in eventual oil seepage. Under hard braking, drops of engine oil may be deposited on the exhaust manifold. If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and, in some instances, the fire may spread to the plastic spark plug wire channel and beyond. An under-hood fire could result in injury and/or property damage. Correction: Dealers will replace the engine’s front valve cover and front-valve-cover gasket with new parts. The engine’s plastic “beauty” cover and plastic oil-fill-tube extension will also be removed, if they haven’t been already. Note: This recall supersedes and is an expansion of recalls 2008-081, 2009-105 and 2015-145. All vehicles having been inspected and/or serviced under the previous recall will require re-inspection and repair.
Recall 2014284641,121 units in Canada
Electrical
On certain vehicles, a defect in the ignition switch could allow the switch to move out of the "run" position if the key ring is carrying added weight or the vehicle goes off-road or is subjected to some other jarring event. If this were to occur, engine power, power steering and power braking would be affected, increasing the risk of a crash causing injury and/or damage to property. The timing of the key movement out of the “run” position, relative to the activation of the sensing algorithm of the crash event, may also result in the airbags not deploying in a subsequent collision, increasing the risk of injury. Correction: For each key, dealers will install two key rings and modify the key ring opening shape. Note: Until the correction is performed, all items should be removed from the key ring.
Recall 2009105128,726 units in Canada
Engine
On certain vehicles equipped with a 3.8L naturally aspirated engine, degradation of the front rocker cover gasket may result in eventual oil seepage. Under hard braking, drops of engine oil may be deposited on the exhaust manifold. If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and, in some instances, the fire may spread to the plastic spark plug wire channel and beyond. An under-hood fire could result in property damage, personal injury or death. Correction: Dealers will remove the spark plug wire retention channel at the front of the engine and install two new-revised spark plug wire retainers.
Recall 200018111 units in Canada
Seats And Restraints
On certain vehicles, the airbag sensing and diagnostic modules (SDM) could experience a memory error resulting in the airbags not deploying in a crash situation. In a vehicle crash, a front seat occupant may receive more severe injuries. Correction: Dealers will replace the sensing and diagnostic module.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 90,000 milesLebanon, VACrash1 injured
AIR BAGS
MY 2001 MONTECARLO WAS HIT IN FRONT WITH FRONT END DAMAGE AND THE AIR BAGS DIDN'T GO OFF CAUSING MY GIRL FRIEND TO HAVE A BROKEN NOSE ..THE VEHICLE WAS IN MOTION ON A CITY STREET IN THE TURNING LANE
NHTSA complaint #11321466 — an unverified report by a vehicle owner.
at 90,000 milesLebanon, VACrash1 injured
STRUCTURE:BODY
MY 2001 MONTECARLO WAS HIT IN FRONT WITH FRONT END DAMAGE AND THE AIR BAGS DIDN'T GO OFF CAUSING MY GIRL FRIEND TO HAVE A BROKEN NOSE ..THE VEHICLE WAS IN MOTION ON A CITY STREET IN THE TURNING LANE
NHTSA complaint #11321466 — an unverified report by a vehicle owner.
at 90,000 milesLebanon, VACrash1 injured
ELECTRICAL SYSTEM
MY 2001 MONTECARLO WAS HIT IN FRONT WITH FRONT END DAMAGE AND THE AIR BAGS DIDN'T GO OFF CAUSING MY GIRL FRIEND TO HAVE A BROKEN NOSE ..THE VEHICLE WAS IN MOTION ON A CITY STREET IN THE TURNING LANE
NHTSA complaint #11321466 — an unverified report by a vehicle owner.
at 117,166 milesN. Highlands, CAFire1 injured
UNKNOWN OR OTHER
I PURCHASED A 2001 CHEVY MONTE CARLO SS IN 9-01. I DID NOT REALIZE UNTIL RECENTLY THE ENGINE WAS BUILT 2000. I WOULD NOT HAVE PURCHASED. MY CAR HAS HAD MULTIPLE PROBLEMS. THE RECENT OCCURRED JULY 20TH 2019. MY ODOMETER IS 117,166 ORIGINAL MILES. THE INTAKE MANIFOLDS AND UPPER INTAKE MANIFOLD IS ALL MADE OF A PLASTIC. I WENT TO START MY CAR WHICH HAS BEEN RUNNING FINE. AROUND 6-7:00 PM I HEARD A LOUD BOOM. IT STARTLED ME AND MY NIEGHBORS EVEN CAME OUT. I NOTICED SMOKE COMING FROM THE FRONT DRIVERS SIDE. I POPPED THE HOOD AND FLAMES WERE SHOOTING STRAIGHT UP THE FIREWALL ONTO THE INSIDE HOOD. I IMMEDIATELY SCREAMED GET ME WATER AND NOTICED THE FIRE EXTINGUISHER. I SMASHED THE GLASS GRABBED IT AND BEGAN TO PUT OUT THE FIRE. REMIND YOU THE CAR HAS A COVER I WAS USING BOTH HANDS REMOVED THE OIL CAP PULLED THE COVER AND STILL SPRAYING I PUT THE COVER OUT AND CONTINUED WITH THE ENGINE PLACING THE OIL CAP TO PREVENT CROSS CONTAMINATION. I WAS ABLE TO PUT OUT THE FIRE I HAD CUTS TO MY HAND AND IT SINGED THE HAIR ON MY ARMS AND MY WRIST HAD A SLIGHT BURN. HOWEVER, I HAVE KNOW IDEA HOW I WAS OVER LOOKED ON THE 5-17-04 FUEL PRESSURE REGULATOR RECALL PART #03064B MY CAR IS A 3.8 LITRE K SERIES. IF I WOULD HAVE HAD MY GRANDDAUGHTER SHE IS IN A CAR SEAT THE DAMAGE WOULD HAVE BEEN MUCH WORSE. THE FLAMES WERE SO HIGH THEY ALMOST REACHED THE TREE BRANCH. THE SCARY PART IS GMAC IS AWARE OF THE POSSIBLE FIRE AND IS TRYING TO SETTLE WITH ME FOR MINIMAL AMOUNT. I JUST SPENT THOUSANDS BECAUSE THE CAR HIT 100,000 SO NEW RADIATOR, TUNE UP ETC. THIS WAS A VERY EXPENSIVE PURCHASE AND TO THINK I HAVE BEEN DRIVING A TIME BOMB. LUCKILY I WASN'T IN TRAFFIC OR IN A PLACE WHERE I HAD TO PULL MY GRANDDAUGHTER OUT AND THE CAR SEAT BECAUSE THE ENTIRE CAR WOULD HAVE BURNED. I HONESTLY THOUGHT IT WAS GOING TO BLOW UP. I CAN ACTUALLY SHOVE MY FIST IN THAT UPPER INTAKE MANIFOLD. SEE COMPLAINT ODI112351110
NHTSA complaint #11244180 — an unverified report by a vehicle owner.
at 117,166 milesN. Highlands, CAFire1 injured
FUEL/PROPULSION SYSTEM
I PURCHASED A 2001 CHEVY MONTE CARLO SS IN 9-01. I DID NOT REALIZE UNTIL RECENTLY THE ENGINE WAS BUILT 2000. I WOULD NOT HAVE PURCHASED. MY CAR HAS HAD MULTIPLE PROBLEMS. THE RECENT OCCURRED JULY 20TH 2019. MY ODOMETER IS 117,166 ORIGINAL MILES. THE INTAKE MANIFOLDS AND UPPER INTAKE MANIFOLD IS ALL MADE OF A PLASTIC. I WENT TO START MY CAR WHICH HAS BEEN RUNNING FINE. AROUND 6-7:00 PM I HEARD A LOUD BOOM. IT STARTLED ME AND MY NIEGHBORS EVEN CAME OUT. I NOTICED SMOKE COMING FROM THE FRONT DRIVERS SIDE. I POPPED THE HOOD AND FLAMES WERE SHOOTING STRAIGHT UP THE FIREWALL ONTO THE INSIDE HOOD. I IMMEDIATELY SCREAMED GET ME WATER AND NOTICED THE FIRE EXTINGUISHER. I SMASHED THE GLASS GRABBED IT AND BEGAN TO PUT OUT THE FIRE. REMIND YOU THE CAR HAS A COVER I WAS USING BOTH HANDS REMOVED THE OIL CAP PULLED THE COVER AND STILL SPRAYING I PUT THE COVER OUT AND CONTINUED WITH THE ENGINE PLACING THE OIL CAP TO PREVENT CROSS CONTAMINATION. I WAS ABLE TO PUT OUT THE FIRE I HAD CUTS TO MY HAND AND IT SINGED THE HAIR ON MY ARMS AND MY WRIST HAD A SLIGHT BURN. HOWEVER, I HAVE KNOW IDEA HOW I WAS OVER LOOKED ON THE 5-17-04 FUEL PRESSURE REGULATOR RECALL PART #03064B MY CAR IS A 3.8 LITRE K SERIES. IF I WOULD HAVE HAD MY GRANDDAUGHTER SHE IS IN A CAR SEAT THE DAMAGE WOULD HAVE BEEN MUCH WORSE. THE FLAMES WERE SO HIGH THEY ALMOST REACHED THE TREE BRANCH. THE SCARY PART IS GMAC IS AWARE OF THE POSSIBLE FIRE AND IS TRYING TO SETTLE WITH ME FOR MINIMAL AMOUNT. I JUST SPENT THOUSANDS BECAUSE THE CAR HIT 100,000 SO NEW RADIATOR, TUNE UP ETC. THIS WAS A VERY EXPENSIVE PURCHASE AND TO THINK I HAVE BEEN DRIVING A TIME BOMB. LUCKILY I WASN'T IN TRAFFIC OR IN A PLACE WHERE I HAD TO PULL MY GRANDDAUGHTER OUT AND THE CAR SEAT BECAUSE THE ENTIRE CAR WOULD HAVE BURNED. I HONESTLY THOUGHT IT WAS GOING TO BLOW UP. I CAN ACTUALLY SHOVE MY FIST IN THAT UPPER INTAKE MANIFOLD. SEE COMPLAINT ODI112351110
NHTSA complaint #11244180 — an unverified report by a vehicle owner.
at 117,000 milesNorth Highlands, CAFire
ENGINE
TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHEN SHE STARTED HER VEHICLE, SHE HEARD A LOUD BOOM FROM UNDER THE HOOD. THE IGNITION WAS TURNED OFF AND THERE WAS SMOKE COMING FROM THE HOOD. THE HOOD WAS OPENED AND A FIRE WAS DISCOVERED. THE CONTACT GOT A FIRE EXTINGUISHER AND WAS ABLE TO PUT OUT THE FIRE. THE POLICE AND FIRE DEPARTMENT WERE NOT CALLED AND NO REPORTS WERE FILED. THERE WERE NO INJURIES REPORTED. THE CONTACT CALLED THE DEALER FUTURE CHEVROLET OF SACRAMENTO (4811 MADISON AVE, SACRAMENTO, CA 95841 (916) 265-2473) AND THEY SUGGESTED THAT THE VEHICLE BE TOWED OVER SO THEY COULD INSPECT IT FOR THE CAUSE OF THE FIRE. THE VEHICLE HAD A NHTSA CAMPAIGN NUMBER: 09V-116000 (ENGINE AND ENGINE COOLING) THAT MAY HAVE CONTRIBUTED TO THE VEHICLE CATCHING ON FIRE. THE CONTACT HAD NOT MOVED THE VEHICLE OVER TO THE DEALER YET. THE MANUFACTURER TOOK THE INCIDENT DOWN AND GAVE THE CONTACT A CASE NUMBER AND A CASE SPECIALIST TO CALL BACK. THE FAILURE MILEAGE WAS 117,000.
NHTSA complaint #11235110 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 80,000 milesTioga, PA
ENGINE
LEAKS TIMING AND HEAD GASKETS
NHTSA complaint #11365402 — an unverified report by a vehicle owner.
at 90,000 milesLebanon, VACrash1 injured
AIR BAGS
MY 2001 MONTECARLO WAS HIT IN FRONT WITH FRONT END DAMAGE AND THE AIR BAGS DIDN'T GO OFF CAUSING MY GIRL FRIEND TO HAVE A BROKEN NOSE ..THE VEHICLE WAS IN MOTION ON A CITY STREET IN THE TURNING LANE
NHTSA complaint #11321466 — an unverified report by a vehicle owner.
at 90,000 milesLebanon, VACrash1 injured
STRUCTURE:BODY
MY 2001 MONTECARLO WAS HIT IN FRONT WITH FRONT END DAMAGE AND THE AIR BAGS DIDN'T GO OFF CAUSING MY GIRL FRIEND TO HAVE A BROKEN NOSE ..THE VEHICLE WAS IN MOTION ON A CITY STREET IN THE TURNING LANE
NHTSA complaint #11321466 — an unverified report by a vehicle owner.
at 90,000 milesLebanon, VACrash1 injured
ELECTRICAL SYSTEM
MY 2001 MONTECARLO WAS HIT IN FRONT WITH FRONT END DAMAGE AND THE AIR BAGS DIDN'T GO OFF CAUSING MY GIRL FRIEND TO HAVE A BROKEN NOSE ..THE VEHICLE WAS IN MOTION ON A CITY STREET IN THE TURNING LANE
NHTSA complaint #11321466 — an unverified report by a vehicle owner.
at 117,166 milesN. Highlands, CAFire1 injured
UNKNOWN OR OTHER
I PURCHASED A 2001 CHEVY MONTE CARLO SS IN 9-01. I DID NOT REALIZE UNTIL RECENTLY THE ENGINE WAS BUILT 2000. I WOULD NOT HAVE PURCHASED. MY CAR HAS HAD MULTIPLE PROBLEMS. THE RECENT OCCURRED JULY 20TH 2019. MY ODOMETER IS 117,166 ORIGINAL MILES. THE INTAKE MANIFOLDS AND UPPER INTAKE MANIFOLD IS ALL MADE OF A PLASTIC. I WENT TO START MY CAR WHICH HAS BEEN RUNNING FINE. AROUND 6-7:00 PM I HEARD A LOUD BOOM. IT STARTLED ME AND MY NIEGHBORS EVEN CAME OUT. I NOTICED SMOKE COMING FROM THE FRONT DRIVERS SIDE. I POPPED THE HOOD AND FLAMES WERE SHOOTING STRAIGHT UP THE FIREWALL ONTO THE INSIDE HOOD. I IMMEDIATELY SCREAMED GET ME WATER AND NOTICED THE FIRE EXTINGUISHER. I SMASHED THE GLASS GRABBED IT AND BEGAN TO PUT OUT THE FIRE. REMIND YOU THE CAR HAS A COVER I WAS USING BOTH HANDS REMOVED THE OIL CAP PULLED THE COVER AND STILL SPRAYING I PUT THE COVER OUT AND CONTINUED WITH THE ENGINE PLACING THE OIL CAP TO PREVENT CROSS CONTAMINATION. I WAS ABLE TO PUT OUT THE FIRE I HAD CUTS TO MY HAND AND IT SINGED THE HAIR ON MY ARMS AND MY WRIST HAD A SLIGHT BURN. HOWEVER, I HAVE KNOW IDEA HOW I WAS OVER LOOKED ON THE 5-17-04 FUEL PRESSURE REGULATOR RECALL PART #03064B MY CAR IS A 3.8 LITRE K SERIES. IF I WOULD HAVE HAD MY GRANDDAUGHTER SHE IS IN A CAR SEAT THE DAMAGE WOULD HAVE BEEN MUCH WORSE. THE FLAMES WERE SO HIGH THEY ALMOST REACHED THE TREE BRANCH. THE SCARY PART IS GMAC IS AWARE OF THE POSSIBLE FIRE AND IS TRYING TO SETTLE WITH ME FOR MINIMAL AMOUNT. I JUST SPENT THOUSANDS BECAUSE THE CAR HIT 100,000 SO NEW RADIATOR, TUNE UP ETC. THIS WAS A VERY EXPENSIVE PURCHASE AND TO THINK I HAVE BEEN DRIVING A TIME BOMB. LUCKILY I WASN'T IN TRAFFIC OR IN A PLACE WHERE I HAD TO PULL MY GRANDDAUGHTER OUT AND THE CAR SEAT BECAUSE THE ENTIRE CAR WOULD HAVE BURNED. I HONESTLY THOUGHT IT WAS GOING TO BLOW UP. I CAN ACTUALLY SHOVE MY FIST IN THAT UPPER INTAKE MANIFOLD. SEE COMPLAINT ODI112351110
NHTSA complaint #11244180 — an unverified report by a vehicle owner.
at 117,166 milesN. Highlands, CAFire1 injured
FUEL/PROPULSION SYSTEM
I PURCHASED A 2001 CHEVY MONTE CARLO SS IN 9-01. I DID NOT REALIZE UNTIL RECENTLY THE ENGINE WAS BUILT 2000. I WOULD NOT HAVE PURCHASED. MY CAR HAS HAD MULTIPLE PROBLEMS. THE RECENT OCCURRED JULY 20TH 2019. MY ODOMETER IS 117,166 ORIGINAL MILES. THE INTAKE MANIFOLDS AND UPPER INTAKE MANIFOLD IS ALL MADE OF A PLASTIC. I WENT TO START MY CAR WHICH HAS BEEN RUNNING FINE. AROUND 6-7:00 PM I HEARD A LOUD BOOM. IT STARTLED ME AND MY NIEGHBORS EVEN CAME OUT. I NOTICED SMOKE COMING FROM THE FRONT DRIVERS SIDE. I POPPED THE HOOD AND FLAMES WERE SHOOTING STRAIGHT UP THE FIREWALL ONTO THE INSIDE HOOD. I IMMEDIATELY SCREAMED GET ME WATER AND NOTICED THE FIRE EXTINGUISHER. I SMASHED THE GLASS GRABBED IT AND BEGAN TO PUT OUT THE FIRE. REMIND YOU THE CAR HAS A COVER I WAS USING BOTH HANDS REMOVED THE OIL CAP PULLED THE COVER AND STILL SPRAYING I PUT THE COVER OUT AND CONTINUED WITH THE ENGINE PLACING THE OIL CAP TO PREVENT CROSS CONTAMINATION. I WAS ABLE TO PUT OUT THE FIRE I HAD CUTS TO MY HAND AND IT SINGED THE HAIR ON MY ARMS AND MY WRIST HAD A SLIGHT BURN. HOWEVER, I HAVE KNOW IDEA HOW I WAS OVER LOOKED ON THE 5-17-04 FUEL PRESSURE REGULATOR RECALL PART #03064B MY CAR IS A 3.8 LITRE K SERIES. IF I WOULD HAVE HAD MY GRANDDAUGHTER SHE IS IN A CAR SEAT THE DAMAGE WOULD HAVE BEEN MUCH WORSE. THE FLAMES WERE SO HIGH THEY ALMOST REACHED THE TREE BRANCH. THE SCARY PART IS GMAC IS AWARE OF THE POSSIBLE FIRE AND IS TRYING TO SETTLE WITH ME FOR MINIMAL AMOUNT. I JUST SPENT THOUSANDS BECAUSE THE CAR HIT 100,000 SO NEW RADIATOR, TUNE UP ETC. THIS WAS A VERY EXPENSIVE PURCHASE AND TO THINK I HAVE BEEN DRIVING A TIME BOMB. LUCKILY I WASN'T IN TRAFFIC OR IN A PLACE WHERE I HAD TO PULL MY GRANDDAUGHTER OUT AND THE CAR SEAT BECAUSE THE ENTIRE CAR WOULD HAVE BURNED. I HONESTLY THOUGHT IT WAS GOING TO BLOW UP. I CAN ACTUALLY SHOVE MY FIST IN THAT UPPER INTAKE MANIFOLD. SEE COMPLAINT ODI112351110
NHTSA complaint #11244180 — an unverified report by a vehicle owner.
Orange Cove, CA
ELECTRICAL SYSTEM
CECKING THE FUSES, NONE OF THEM WERE BLOWN. GAUGE WOULD BE READING HOT TEMPERATURE, WOULD CHECK THE HOSES AND RADIATOR NOTHING. FUEL SYSTEM IS DOWN NOW.
NHTSA complaint #11241335 — an unverified report by a vehicle owner.
Orange Cove, CA
ENGINE
CECKING THE FUSES, NONE OF THEM WERE BLOWN. GAUGE WOULD BE READING HOT TEMPERATURE, WOULD CHECK THE HOSES AND RADIATOR NOTHING. FUEL SYSTEM IS DOWN NOW.
NHTSA complaint #11241335 — an unverified report by a vehicle owner.
Orange Cove, CA
FUEL/PROPULSION SYSTEM
CECKING THE FUSES, NONE OF THEM WERE BLOWN. GAUGE WOULD BE READING HOT TEMPERATURE, WOULD CHECK THE HOSES AND RADIATOR NOTHING. FUEL SYSTEM IS DOWN NOW.
NHTSA complaint #11241335 — an unverified report by a vehicle owner.
at 117,000 milesNorth Highlands, CAFire
ENGINE
TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHEN SHE STARTED HER VEHICLE, SHE HEARD A LOUD BOOM FROM UNDER THE HOOD. THE IGNITION WAS TURNED OFF AND THERE WAS SMOKE COMING FROM THE HOOD. THE HOOD WAS OPENED AND A FIRE WAS DISCOVERED. THE CONTACT GOT A FIRE EXTINGUISHER AND WAS ABLE TO PUT OUT THE FIRE. THE POLICE AND FIRE DEPARTMENT WERE NOT CALLED AND NO REPORTS WERE FILED. THERE WERE NO INJURIES REPORTED. THE CONTACT CALLED THE DEALER FUTURE CHEVROLET OF SACRAMENTO (4811 MADISON AVE, SACRAMENTO, CA 95841 (916) 265-2473) AND THEY SUGGESTED THAT THE VEHICLE BE TOWED OVER SO THEY COULD INSPECT IT FOR THE CAUSE OF THE FIRE. THE VEHICLE HAD A NHTSA CAMPAIGN NUMBER: 09V-116000 (ENGINE AND ENGINE COOLING) THAT MAY HAVE CONTRIBUTED TO THE VEHICLE CATCHING ON FIRE. THE CONTACT HAD NOT MOVED THE VEHICLE OVER TO THE DEALER YET. THE MANUFACTURER TOOK THE INCIDENT DOWN AND GAVE THE CONTACT A CASE NUMBER AND A CASE SPECIALIST TO CALL BACK. THE FAILURE MILEAGE WAS 117,000.
NHTSA complaint #11235110 — an unverified report by a vehicle owner.
Oklahoma City, OKFire
ENGINE
ENGINE FIRE CLAIM# [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11202937 — an unverified report by a vehicle owner.
Paducah, KY
ENGINE
2001 MONTE CARLO SS. CONSUMER WRITES IN REGARDS TO LEAKING VALVE COVER GASKET. *LD *TR THE CONSUMER STATED THE VEHICLE WAS REPAIRED UNDER RECALL, BUT THE FAILURE RECURRED.
NHTSA complaint #11184070 — an unverified report by a vehicle owner.
at 134,000 milesMedical Lake, WAFire1 injured
ENGINE
ENGINE BACKFIRED AND EXPLODED UPON IGNITION AFTER SITTING FOR A WEEK. ENGINE WAS COLD AND IN COLD WEATHER. 3 FOOT FLAMES, MINOR BURNS AND INJURIES SUSTAINED ER VISIT FOR SMOKE INHALATION WHILE EXTINGUISHING FIRE. VEHICLE WAS PARKED ON PRIVATE PROPERTY. A NEIGHBOR'S CAR THE SAME MAKE AND MODEL SIMILAR YEAR DID THE SAME THING A FEW WEEKS AGO.
NHTSA complaint #11181640 — an unverified report by a vehicle owner.
at 134,000 milesMedical Lake, WAFire1 injured
FUEL/PROPULSION SYSTEM
ENGINE BACKFIRED AND EXPLODED UPON IGNITION AFTER SITTING FOR A WEEK. ENGINE WAS COLD AND IN COLD WEATHER. 3 FOOT FLAMES, MINOR BURNS AND INJURIES SUSTAINED ER VISIT FOR SMOKE INHALATION WHILE EXTINGUISHING FIRE. VEHICLE WAS PARKED ON PRIVATE PROPERTY. A NEIGHBOR'S CAR THE SAME MAKE AND MODEL SIMILAR YEAR DID THE SAME THING A FEW WEEKS AGO.
NHTSA complaint #11181640 — an unverified report by a vehicle owner.
Oviedo, FL
ENGINE
2001 CHEVROLET MONTE CARLO. CONSUMER REQUESTS REIMBURSEMENT FOR REPAIRS. *SMD UPDATED 07/13/2017
NHTSA complaint #10933549 — an unverified report by a vehicle owner.
at 57,000 milesDedham, MA
ELECTRICAL SYSTEM
THE DEALER YEARS AGO JUST PUT AN INSERT INTO THE KEY. NOW THE IGNITION DOES NOT PROPERLY WORK. YOU HAVE TO WIGGLE THE KEY FOR OPERATION. SOMETIMES THE CAR WON'T START,OTHER TIMES THE COMPONENTS WON'T WORK UNLESS I WIGGLE THE KEY. CAR HAS 57,000 MILES. WAS PART OF THE ORIGINAL RECALL FOR IGNITION PROBLEMS.
NHTSA complaint #11004765 — an unverified report by a vehicle owner.
at 175,089 milesAlexandria, VA
POWER TRAIN
I WENT TO A DEALERSHIP TO DEAL WITH A KEY IGNITION RECALL 2 MONTHS AGO. NOW MY CAR IS STALLING IN THE MIDDLE OF THE ROAD WHICH NEVER HAPPENED BEFORE THE RECALL..
NHTSA complaint #10990718 — an unverified report by a vehicle owner.
at 175,089 milesAlexandria, VA
ENGINE
I WENT TO A DEALERSHIP TO DEAL WITH A KEY IGNITION RECALL 2 MONTHS AGO. NOW MY CAR IS STALLING IN THE MIDDLE OF THE ROAD WHICH NEVER HAPPENED BEFORE THE RECALL..
NHTSA complaint #10990718 — an unverified report by a vehicle owner.
at 175,089 milesAlexandria, VA
ELECTRONIC STABILITY CONTROL (ESC)
I WENT TO A DEALERSHIP TO DEAL WITH A KEY IGNITION RECALL 2 MONTHS AGO. NOW MY CAR IS STALLING IN THE MIDDLE OF THE ROAD WHICH NEVER HAPPENED BEFORE THE RECALL..
NHTSA complaint #10990718 — an unverified report by a vehicle owner.
at 78,000 milesKirksey, KYFire1 injured
STEERING
TL* THE CONTACT OWNED A 2001 CHEVROLET MONTE CARLO. WHILE DRIVING 35 MPH, ANOTHER MOTORIST INFORMED THE CONTACT THAT FLAMES WERE COMING FROM THE FRONT OF HER VEHICLE. WHILE PULLING OFF THE ROADWAY THE STEERING WHEEL LOCKED AND ALL POWER WAS LOST. THERE WERE NO WARNING INDICATORS ILLUMINATED. TWO WEEKS PRIOR TO THE FAILURE, A DIAGNOSTIC TEST WAS PERFORMED BUT NO FAILURE CODES WERE FOUND. THE CONTACT ALSO MENTIONED THAT SHE RECEIVED A RECALL NOTIFICATION FOR A KEY FOB, BUT NOT NHTSA CAMPAIGN NUMBER: 15V70100 (ENGINE AND ENGINE COOLING). THE FIRE DEPARTMENT WAS NOTIFIED AND EXTINGUISHED THE FIRE. A FIRE REPORT AND A POLICE REPORT WERE FILED. THE CONTACT RECEIVED MEDICAL TREATMENT FOR ELEVATED CARBON MONOXIDE IN THE BLOOD AND POST TRAUMATIC STRESS DISORDER. THE VEHICLE WAS TOWED AND DEEMED A TOTAL LOSS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE RECALL DETAILS FOR THE KEY FOB WERE NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000. UPDATED 06/28/17*LJ UPDATED 9/28/18
NHTSA complaint #10981679 — an unverified report by a vehicle owner.
at 78,000 milesKirksey, KYFire1 injured
ELECTRICAL SYSTEM
TL* THE CONTACT OWNED A 2001 CHEVROLET MONTE CARLO. WHILE DRIVING 35 MPH, ANOTHER MOTORIST INFORMED THE CONTACT THAT FLAMES WERE COMING FROM THE FRONT OF HER VEHICLE. WHILE PULLING OFF THE ROADWAY THE STEERING WHEEL LOCKED AND ALL POWER WAS LOST. THERE WERE NO WARNING INDICATORS ILLUMINATED. TWO WEEKS PRIOR TO THE FAILURE, A DIAGNOSTIC TEST WAS PERFORMED BUT NO FAILURE CODES WERE FOUND. THE CONTACT ALSO MENTIONED THAT SHE RECEIVED A RECALL NOTIFICATION FOR A KEY FOB, BUT NOT NHTSA CAMPAIGN NUMBER: 15V70100 (ENGINE AND ENGINE COOLING). THE FIRE DEPARTMENT WAS NOTIFIED AND EXTINGUISHED THE FIRE. A FIRE REPORT AND A POLICE REPORT WERE FILED. THE CONTACT RECEIVED MEDICAL TREATMENT FOR ELEVATED CARBON MONOXIDE IN THE BLOOD AND POST TRAUMATIC STRESS DISORDER. THE VEHICLE WAS TOWED AND DEEMED A TOTAL LOSS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE RECALL DETAILS FOR THE KEY FOB WERE NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000. UPDATED 06/28/17*LJ UPDATED 9/28/18
NHTSA complaint #10981679 — an unverified report by a vehicle owner.
at 78,000 milesKirksey, KYFire1 injured
ENGINE
TL* THE CONTACT OWNED A 2001 CHEVROLET MONTE CARLO. WHILE DRIVING 35 MPH, ANOTHER MOTORIST INFORMED THE CONTACT THAT FLAMES WERE COMING FROM THE FRONT OF HER VEHICLE. WHILE PULLING OFF THE ROADWAY THE STEERING WHEEL LOCKED AND ALL POWER WAS LOST. THERE WERE NO WARNING INDICATORS ILLUMINATED. TWO WEEKS PRIOR TO THE FAILURE, A DIAGNOSTIC TEST WAS PERFORMED BUT NO FAILURE CODES WERE FOUND. THE CONTACT ALSO MENTIONED THAT SHE RECEIVED A RECALL NOTIFICATION FOR A KEY FOB, BUT NOT NHTSA CAMPAIGN NUMBER: 15V70100 (ENGINE AND ENGINE COOLING). THE FIRE DEPARTMENT WAS NOTIFIED AND EXTINGUISHED THE FIRE. A FIRE REPORT AND A POLICE REPORT WERE FILED. THE CONTACT RECEIVED MEDICAL TREATMENT FOR ELEVATED CARBON MONOXIDE IN THE BLOOD AND POST TRAUMATIC STRESS DISORDER. THE VEHICLE WAS TOWED AND DEEMED A TOTAL LOSS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE RECALL DETAILS FOR THE KEY FOB WERE NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000. UPDATED 06/28/17*LJ UPDATED 9/28/18
NHTSA complaint #10981679 — an unverified report by a vehicle owner.
at 155,000 milesAnderson, INFire
ENGINE
INTAKE MANIFOLD EXPLOSION RESULTING IN DAMAGE TO NEARBY VEHICLE. ATTEMPTING TO START THE VEHICLE ONE CRANK FOLLOWED BY LOUD EXPLOSION FROM UNDER THE HOOD. UPON INSPECTION, THE INTAKE MANIFOLD HAD BEEN BLOWN APART INTO 15 - 20 PIECES. A SMALL FIRE ERUPTED. WAS ABLE TO EXTINGUISH THE FIRE QUICKLY ONE PIECE OF THE DESTROYED MANIFOLD HIT A NEARBY VEHICLE RESULTING IN PAINT DAMAGE.
NHTSA complaint #10978676 — an unverified report by a vehicle owner.
at 180,000 milesSeekonk, MA
FUEL/PROPULSION SYSTEM
AFTER CHARGING THE BATTERY L THEN STARTED THE CAR AN HAD A BACK FIRE. WHEN THE CAR BACK FIRED IT BLEW OUT THE INTAKE MANIFOLD AN THERE WAS A LOT OF SMOKE . WAS WONDERING IF THER WAS A RECALL ON THE FUEL PUMP PRESSURE REGULATER . WHICH COULD BE THE CAUSE OF IT .
NHTSA complaint #10970573 — an unverified report by a vehicle owner.
at 150,000 milesWichita Falls, TX
SEAT BELTS
PASSENGER SEAT BELT COMES UNBUCKLED FOR NO REASON. IT ALSO WONT LOCK ALL THE WAY WHEN YOU PLUG IT IN. RELEASE BUTTON SOME TIMES STAYS IN WHEN YOU PUSH IT TO TAKE THE SEAT BELT OFF. SCARED TO RIDE IN PASSENGER SEAT BECAUSE THE SEAT BELT DOES NOT WORK PROPERLY. NO RESTRAINT NOTHING. RIDING 45-50 MPH IN PASSENGER SEAT BELT JUST UNPLUGGED ALL BY IT SELF WOULD NOT PLUG BACK IN BECAUSE THE BUTTON STAYS DOWN. I HAD TO HIT IT WITH A FLSH LIGHT TO GET IT TO RELEASE.
NHTSA complaint #10965996 — an unverified report by a vehicle owner.