2001 Chevrolet Monte Carlo brake problems

SERVICE BRAKES

TL* THE CONTACT OWNS A 2001 MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START UNLESS THE KEY WAS SHAKEN IN THE IGNITION. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE HEAD GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 110,597. UPDATED 9/11/14*CN THE CONSUMER STATED THE VEHICLE SHOULD BE PUT ON A RECALL LIST FOR FAULTY IGNITION. THE VEHICLE SHOULD BE ADDED TO ALL FORMER RECALL LIST THAT EXIST OR EXISTED FOR THE MODEL. THE CONSUMER REQUESTED FOR THE VEHICLE TO BE REPAIRED AND TO BE REIMBURSED FOR WHAT HAS ALREADY BEEN REPAIRED. UPDATED 1/20/2015

NHTSA complaint #10607477 — an unverified report by a vehicle owner.

SERVICE BRAKES

WHILE DRIVING MY 2001 MONTE CARLO SS AT 65 MILES PER HOUR ON THE INTERSTATE THE CAR WOULD SHUT OFF ON ITS OWN LEAVING NO POWER STEERING, BRAKES, OR POWER TO ANYTHING. THE CAR DID THIS SEVERAL TIMES. I CONTACTED GM DIRECTLY WHEN THIS STARTED HAPPENING. BASICALLY I WAS TOLD TOO BAD AND THEY COULDN'T HELP ME. JUNE 5, 2014 SUMMARY HISTORY DISPLAY STORE 01 SERVC01 TOTAL R/O'S 1 TOTAL SERV. DAYS 3 MAKE CV CHEVROLET LN# RO.NO. RO. DATE.. MILES. ADV/TECH J# T OPERATION CODE. DESCRIPTION 600760 04/20/2007 98020 A 7368 31973 1 C 32CTZ001 CHECK ENGINE LIG 4757 JUNE 5, 2014 R/O CLOSE OUT STORE 01 SERVC01 DESC. CV MONTE CARLO BLCK 01 | 4. LABOR 211.40 0.00 0.00 | | 5. PARTS 6.96 0.00 0.00 | | | 8. MISC 14.95 0.00 0.00 | | 9. TAX 13.11 0.00 0.00 | |10. EST $ [ ] TOTALS C 246.42 W 0.00 I 0.00 | | | COMPLAINT CUSTOMER STATES THE CHECK ENGINE IS ON | | DIES WHILE DRIVING ANDM DOESN'T SHIFT WELL | | CAUSE PERFORMED DIAG SYS CHECK AND FOUND DTC P0128 ENGINE COOLANT | | TEMP INCORRECT. AND P1811 SHIFT ADAPT. | | CORRECTION NEEDS NEW THERMOSTAT FOR P0128 | | NEEDS VALVE BODY AND PRESSURE CONTROL SOLENOID FOR P1811 |

NHTSA complaint #10598614 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT HE DROVE OVER A PUDDLE OF WATER AT 20 MPH WHEN THE ABS AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT SHUT OFF AND RESTARTED THE VEHICLE, AND THE PROBLEM RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE VEHICLE NEED TO BE DIAGNOSED HOWEVER, THE CONTACT DECLINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 60,000.

NHTSA complaint #10494661 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHEN DRIVING AT LOW SPEEDS AND BRAKING TO A STOP, THE TRACTION CONTROL WARNING LIGHT ILLUMINATED ALONG WITH OTHER WARNING LIGHTS. AS SHE DEPRESSED THE BRAKE PEDAL, THE CONTACT WOULD FEEL A VIBRATING SENSATION BEFORE THE VEHICLE WOULD COME TO A STOP. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS. AFTER DIAGNOSIS THEY ADVISED THAT THE ABS SYSTEM FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 148,000.

NHTSA complaint #10482083 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, ALL OF THE LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE BRAKE PEDAL WAS APPLIED AND THE PEDAL DEPRESSED TO THE FLOOR. THE CONTACT WAS ABLE TO STOP THE VEHICLE. THE CONTACT ALSO STATED THAT THE ACCELERATOR PEDAL WAS APPLIED AND THE TRACTION CONTROL ACTIVATED, CAUSING THE ANTI LOCK BRAKES TO SEIZE THE WHEELS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 170,000.

NHTSA complaint #10456865 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

I HAVE HAD CONSISTENT PROBLEMS WITH THE ABS ON THIS VEHICLE. I HAVE HAD IT DIAGNOSED AT CHEVROLET DEALERS AND INDEPENDENT DEALERS IN VA. I HAVE REPLACED ALL WHEEL HUB/BEARING ASSEMBLIES. THAT IS NOT THE PROBLEM. THE PROBLEM IS WITH THE ABS WHEEL SENSOR WIRING HARNESSES. IT IS OBVIOUS IF YOU GO ONLINE AND RESEARCH THIS ISSUE THERE IS NO WAY THAT CHEVROLET IS NOT AWARE AND THE MANY MODELS OF VEHICLES THAT ARE AFFECTED. I CONTACTED CHEVROLET AND THEY HAVE NO DESIRE TO ATTEMPT TO HELP WITH REPAIRING THIS SAFETY ISSUE THAT IS WELL KNOWN BY DEALERS, MECHANICS AND CONSUMERS. THERE ARE CURRENTLY NO TSB'S OR RECALLS FOR THIS ISSUE. THANKS

NHTSA complaint #10444058 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

TL*THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE ABS LAMP ILLUMINATED AND WHEN SHE TRIED TO ENGAGE THE BRAKE PEDAL IT REMAINED IN THE UP POSITION, MADE A LOUD NOISE AND FAILED TO ENGAGE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 95,000.

NHTSA complaint #10407013 — an unverified report by a vehicle owner.

SERVICE BRAKES, ELECTRIC

I HAVE A 2001 CHEVY MONTE CARLO SS. I RECENTLY STARTED GETTING A SERVICE TRACTION CONTROL LIGHT COMING ON. ALSO, MY ABS WOULD ENGAGE AT AN INAPPROPRIATE TIME. I WOULD BE EASING TO A STOP AND THE ABS WOULD KICK IN FOR NO REASON. I TOOK IT TO THE DEALERSHIP AND AFTER PAYING ABOUT 1,000.00 TO HAVE THE SPEED SENSORS REPLACED'.I HAVE THE SAME PROBLEM. AFTER DOING SOME INTERNET SEARCHES I HAVE FOUND 'THOUSANDS' OF SIMILAR COMPLAINTS. APPARENTLY IT IS A PROBLEM WITH THE WIRING HARNESS THAT IS INCIDENTALLY A MUCH LESS EXPENSIVE FIX. THERE ARE CONSUMER REPORTS OF THEIR ABS ENGAGING AT HIGH SPEEDS FOR NO REASON. I SEE THIS AS VERY DANGEROUS.

NHTSA complaint #10290259 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

TL*THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. WHEN THE CONTACT STARTED THE VEHICLE, HE NOTICED A WARNING MESSAGE INDICATING SERVICE TRACTION SYSTEM AND ABS FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE TECHNICIAN FLASHED THE COMPUTER SYSTEM TO CLEAR THE CODE. THE VEHICLE HAS NOT BEEN REPAIRED AND THE FAILURE PERSISTS. THE CONTACT RESEARCHED THE FAILURE AND WAS ABLE TO DETERMINE THAT THE WHEEL SENSOR ON EACH WHEEL, GROUND, CONTROL SYSTEM, OR A FAULTY WIRING HARNESS COULD BE CAUSING THE FAILURE. THE CONTACT IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER AND NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 140,000 AND CURRENT MILEAGE WAS 153,000.

NHTSA complaint #10265442 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING

TL*THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. WHEN THE CONTACT STARTED THE VEHICLE, HE NOTICED A WARNING MESSAGE INDICATING SERVICE TRACTION SYSTEM AND ABS FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE TECHNICIAN FLASHED THE COMPUTER SYSTEM TO CLEAR THE CODE. THE VEHICLE HAS NOT BEEN REPAIRED AND THE FAILURE PERSISTS. THE CONTACT RESEARCHED THE FAILURE AND WAS ABLE TO DETERMINE THAT THE WHEEL SENSOR ON EACH WHEEL, GROUND, CONTROL SYSTEM, OR A FAULTY WIRING HARNESS COULD BE CAUSING THE FAILURE. THE CONTACT IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER AND NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 140,000 AND CURRENT MILEAGE WAS 153,000.

NHTSA complaint #10265442 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

DT*: THE CONTACT STATED WHILE DRIVING 20 MPH, THE TRACTION AND LOW HYDRAULIC FLUID LIGHT ILLUMINATED. THE VEHICLE WAS DRIVEN HOME AND A PINT OF HYDRAULIC FLUID WAS ADDED WHICH LEAKED ONTO THE GARAGE FLOOR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR FURTHER INSPECTION WHERE IT WAS DETERMINED THE BRAKE LINES NEEDED TO BE REPLACED. THE MECHANIC NOTED THE BRAKE LINES WERE VERY CORROSIVE. THE VEHICLE WAS NOT EXPOSED TO EXCESSIVE ROAD SALTS OR HARSH, WINTER WEATHER. THE MANUFACTURER WAS ALERTED. UPDATED 01/10/07.

NHTSA complaint #10170379 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

STOP & GO DRIVING. ABS WARNING LIGHT COMES ON, TRACTION CONTROL TURNS OFF, SERVICE TRACTION CONTROL WARNING LIGHT COMES ON, BRAKE PEDAL VIBRATES. ALL LIGHTS STAY ON WHILE DRIVING BUT RESET AFTER IGNITION TURN OFF/ TURN ON PROCEDURE AS DESCRIBED IN OWNERS MANUAL. NEXT DAY, SAME LIGHTS & WARNINGS. TAKE VEHICLE TO DEALER ON 4/05/06. "COMPUTER CHECKED SYSTEM CODES P1189, P0135, C1216 IN SYSTEM. ITEMS TESTED PER TROUBLE TREE. ALL ITEMS TEST GOOD." NO CHARGE. NEXT DAY, 4/6/06, SAME WARNINGS! TAKE TO DEALER AGAIN WITHOUT RESETTING WARNINGS. NO COMPUTER SYSTEM CODES SHOWING, BUT NO INPUT SIGNAL FROM RIGHT FRONT HUB. DEALER REPLACES RIGHT FRONT HUB ASSEMBLY - COST $479. VEHICLE SEEMS FINE, UNTIL ABOUT 4/20 WHEN BRAKE PEDAL VIBRATION COMES BACK AND WARNING LIGHTS COME ON AND OFF. I TURNED OFF THE TRACTION CONTROL SYSTEM AND EVERYTHING WAS FINE FOR SEVERAL DAYS. ON 4/25, WITH THE TRACTION SYSTEM OFF, THE PEDAL VIBRATION WAS BACK AND THE ABS & TRACTION CONTROL WARNING LIGHTS CAME ON AGAIN. WENT BACK TO DEALER. ALTHOUGH THEY TOLD ME THE COMPUTER CHECK SHOW CODES OF C1222 AND C1226, THE CODES DO NOT SHOW ON MY INVOICE. CODE C1226 APPEARS ON NHTSA TECHNICAL SERVICE BULLETIN ITEM NUMBER 10017271 FOR MY YEAR AND MAKE OF VEHICLE. HOWEVER THE SERVICE BULLETIN NUMBER 3500 IS NOT KNOW TO THE DEALER AS A VALID TSB NUMBER, AND THEY COULD NOT LOCATE ANY INFORMATION ABOUT IT. DEALER "DIAGNOSED AND REPLACED EBTCM, AND PROGRAMMED SYSTEM" - COST $697. I FEEL THAT BY REPLACING THE "BRAIN" (EBTCM) AND PROGRAMMING IT, THE DEALER AND/OR THE MANUFACTURER MAY BE COVERING UP A POTENTIAL SAFETY ISSUE WITH EITHER ONE OR BOTH SYSTEMS, ABS AND TRACTION CONTROL. I ALSO FEEL THAT THE DEALER PUT ME AND MY FAMILY IN A DANGEROUS POSITION BY FAILING TO DIAGNOSIS ANY PROBLEMS ON THE FIRST VISIT, AND THEN DOING IT AGAIN BY MAKING ME FEEL SAFE BY PAYING FOR A REPLACEMENT PART THAT HAS NOTHING TO DO WITH EITHER SYSTEM!

NHTSA complaint #10156207 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

THE BRAKE ROTORS ON MY 2001 MONTE CARLO HAVE HAD TO BE RESURFACED TWICE AND NOW NEED TO BE RESURFACED A THIRD TIME FOR BECOMING WARPED. THE FIRST TIME I HAD THE BRAKES RESURFACED WAS AT 19,874 MILES. THE SECOND TIME WAS AT 40,644. I HAVE 55,562 MILES ON MY VEHICLE NOW AND THEY NEED TO BE RESURFACED AGAIN, BUT THE VIBRATIONS HAVEN'T GOTTEN THAT BAD YET. ASSOCIATED WITH THE VIBRATIONS FROM MY ROTORS BECOMING WARPED, I EXPERIENCE A "KNOCKING" FEELING IN THE STEERING WHEEL. I TOOK MY CAR INTO MY LOCAL CHEVY DEALER AT ABOUT 39,700 MILES AND DESCRIBED MY PROBLEM TO THEM. THEY TOLD ME THAT THE BRAKE ROTORS WERE WARPED AND NEEDED RESURFACING AND THAT THE STEERING SHAFT HAD GONE BAD AND NEEDED REPLACING. I HAD THEM REPLACE THE STEERING SHAFT ($480 JOB) BUT NOT THE BRAKES. I TOOK MY CAR TO A LOCAL REPAIR SHOP TO RESURFACE THE ROTORS (LESS EXPENSIVE THAN DEALER COST). I AM HAVING THE SAME SYMPTOMS OF THE STEERING SHAFT GOING BAD AGAIN. I DON'T UNDERSTAND WHY CHEVROLET WON'T DO SOMETHING FOR ITS MONTE CARLO CUSTOMERS.

NHTSA complaint #10145667 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS

DT: FEBUARY OF THIS YEAR ABS TRACTION SENSOR AND BRAKE SYSTEM WARNING LIGHT ILLUMINATED. WHEN BACKING IOUT OF DRIVEWAY OR IN NORMAL DRIVING AT ANY GIVEN SPEED THE BRAKES WOULD GRAB AND THE TRACTION ACTIVE LIGHTS WOULD ILLUMINATE. TOOK VEHICLE TO A DEALER, THEY SAID IT WAS THE LEFT REAR WHEEL HUB SENSOR THAT FAILED, BUT COULD NOT DUPLICATE PROBLEMS CONSUMER WAS HAVING AT THAT TIME. THE DEALER DID NOT REPLACE THIS, BUT DID RESET THE SENSOR. WHEN VEHICLE WAS DRIVEN AWAY FROM DEALER BRAKES STILL HAD THE SAME PROBLEM. WITHIN 24 HOURS THE SAME ISSUE WAS ACTIVED ON THE VEHICLE. RETURNEDS TO DEALER, THIS TIME THEY REPLACED THE LEFT REAR WHEEL HUB SENSOR. ABOUT A MONTH LATER THIS HAPPENED AGAIN. DID PHONE DEALER ABOUT THIS. CONSUMER MADE ANOTHER TRIP TO THE DEALER, WHO NOTED AGAIN THE LEFT REAR WHEEL SENSOR HAD GONE BAD AGAIN. CURRENTLY, CAR IS AGAIN AT THE DEALER FOR THE 4TH TIME FOR THE SAME PROBLEM. THE LAST OCCURRENCE WAS AT A AT STOP SIGN, AND WHEN APPLYING BRAKE PRESSURE DISCOVERED NO BRAKES. AFTERWARDS, IMMEDIATELY DROVE TO DEALERSHIP, WHERE CAR IS NOW. ALSO HAS HAD ROTORS RESURFACED, AND REPLACED REAR BRAKE PADS AS WELL DURING THIS PROCESS.

NHTSA complaint #10128732 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

DT: FEBUARY OF THIS YEAR ABS TRACTION SENSOR AND BRAKE SYSTEM WARNING LIGHT ILLUMINATED. WHEN BACKING IOUT OF DRIVEWAY OR IN NORMAL DRIVING AT ANY GIVEN SPEED THE BRAKES WOULD GRAB AND THE TRACTION ACTIVE LIGHTS WOULD ILLUMINATE. TOOK VEHICLE TO A DEALER, THEY SAID IT WAS THE LEFT REAR WHEEL HUB SENSOR THAT FAILED, BUT COULD NOT DUPLICATE PROBLEMS CONSUMER WAS HAVING AT THAT TIME. THE DEALER DID NOT REPLACE THIS, BUT DID RESET THE SENSOR. WHEN VEHICLE WAS DRIVEN AWAY FROM DEALER BRAKES STILL HAD THE SAME PROBLEM. WITHIN 24 HOURS THE SAME ISSUE WAS ACTIVED ON THE VEHICLE. RETURNEDS TO DEALER, THIS TIME THEY REPLACED THE LEFT REAR WHEEL HUB SENSOR. ABOUT A MONTH LATER THIS HAPPENED AGAIN. DID PHONE DEALER ABOUT THIS. CONSUMER MADE ANOTHER TRIP TO THE DEALER, WHO NOTED AGAIN THE LEFT REAR WHEEL SENSOR HAD GONE BAD AGAIN. CURRENTLY, CAR IS AGAIN AT THE DEALER FOR THE 4TH TIME FOR THE SAME PROBLEM. THE LAST OCCURRENCE WAS AT A AT STOP SIGN, AND WHEN APPLYING BRAKE PRESSURE DISCOVERED NO BRAKES. AFTERWARDS, IMMEDIATELY DROVE TO DEALERSHIP, WHERE CAR IS NOW. ALSO HAS HAD ROTORS RESURFACED, AND REPLACED REAR BRAKE PADS AS WELL DURING THIS PROCESS.

NHTSA complaint #10128732 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

DT: FEBUARY OF THIS YEAR ABS TRACTION SENSOR AND BRAKE SYSTEM WARNING LIGHT ILLUMINATED. WHEN BACKING IOUT OF DRIVEWAY OR IN NORMAL DRIVING AT ANY GIVEN SPEED THE BRAKES WOULD GRAB AND THE TRACTION ACTIVE LIGHTS WOULD ILLUMINATE. TOOK VEHICLE TO A DEALER, THEY SAID IT WAS THE LEFT REAR WHEEL HUB SENSOR THAT FAILED, BUT COULD NOT DUPLICATE PROBLEMS CONSUMER WAS HAVING AT THAT TIME. THE DEALER DID NOT REPLACE THIS, BUT DID RESET THE SENSOR. WHEN VEHICLE WAS DRIVEN AWAY FROM DEALER BRAKES STILL HAD THE SAME PROBLEM. WITHIN 24 HOURS THE SAME ISSUE WAS ACTIVED ON THE VEHICLE. RETURNEDS TO DEALER, THIS TIME THEY REPLACED THE LEFT REAR WHEEL HUB SENSOR. ABOUT A MONTH LATER THIS HAPPENED AGAIN. DID PHONE DEALER ABOUT THIS. CONSUMER MADE ANOTHER TRIP TO THE DEALER, WHO NOTED AGAIN THE LEFT REAR WHEEL SENSOR HAD GONE BAD AGAIN. CURRENTLY, CAR IS AGAIN AT THE DEALER FOR THE 4TH TIME FOR THE SAME PROBLEM. THE LAST OCCURRENCE WAS AT A AT STOP SIGN, AND WHEN APPLYING BRAKE PRESSURE DISCOVERED NO BRAKES. AFTERWARDS, IMMEDIATELY DROVE TO DEALERSHIP, WHERE CAR IS NOW. ALSO HAS HAD ROTORS RESURFACED, AND REPLACED REAR BRAKE PADS AS WELL DURING THIS PROCESS.

NHTSA complaint #10128732 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

DT: FEBUARY OF THIS YEAR ABS TRACTION SENSOR AND BRAKE SYSTEM WARNING LIGHT ILLUMINATED. WHEN BACKING IOUT OF DRIVEWAY OR IN NORMAL DRIVING AT ANY GIVEN SPEED THE BRAKES WOULD GRAB AND THE TRACTION ACTIVE LIGHTS WOULD ILLUMINATE. TOOK VEHICLE TO A DEALER, THEY SAID IT WAS THE LEFT REAR WHEEL HUB SENSOR THAT FAILED, BUT COULD NOT DUPLICATE PROBLEMS CONSUMER WAS HAVING AT THAT TIME. THE DEALER DID NOT REPLACE THIS, BUT DID RESET THE SENSOR. WHEN VEHICLE WAS DRIVEN AWAY FROM DEALER BRAKES STILL HAD THE SAME PROBLEM. WITHIN 24 HOURS THE SAME ISSUE WAS ACTIVED ON THE VEHICLE. RETURNEDS TO DEALER, THIS TIME THEY REPLACED THE LEFT REAR WHEEL HUB SENSOR. ABOUT A MONTH LATER THIS HAPPENED AGAIN. DID PHONE DEALER ABOUT THIS. CONSUMER MADE ANOTHER TRIP TO THE DEALER, WHO NOTED AGAIN THE LEFT REAR WHEEL SENSOR HAD GONE BAD AGAIN. CURRENTLY, CAR IS AGAIN AT THE DEALER FOR THE 4TH TIME FOR THE SAME PROBLEM. THE LAST OCCURRENCE WAS AT A AT STOP SIGN, AND WHEN APPLYING BRAKE PRESSURE DISCOVERED NO BRAKES. AFTERWARDS, IMMEDIATELY DROVE TO DEALERSHIP, WHERE CAR IS NOW. ALSO HAS HAD ROTORS RESURFACED, AND REPLACED REAR BRAKE PADS AS WELL DURING THIS PROCESS.

NHTSA complaint #10128732 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

BRAKE ROTORS WERE TURNED BY DEALER IN JUNE 2004 AT 43,000 MILES. STEERING WHEEL STARTED SHAKING, HAD BRAKES CHECKED, BRAKES WERE FINE. WAS TOLD THE FRONT ROTORS WERE NO GOOD AND NEEDED TO BE REPLACED. THIS OCCURED 3 MONTHS AND 4,000 MILES LATER. THE DEALER REPLACED THE ROTORS, CHARGED $205.00 (DID NOT CHARGE LABOR). I'VE NOTICED ON THIS SITE MANY PEOPLE HAVE COMPLAINED OF THE SAME PROBLEM. I'VE SPENT OVER $450.00 IN 90 DAYS FOR BRAKE ROTOR ISSUES.

NHTSA complaint #10092997 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

SERIES OF HIGH COST REPAIRS AT MY EXPENSE WITH NO WARRANTY: DRIVER INFOMATION CENTER HAS ALWAYS BEEN WRONG AND INACCURATE AND UNFIXABLE; AT 24446 MILES, REPLACED FRONT ROTORS AT MY EXPENSE (; AC AT 30825 WORKED INTERMITTENLY AND BATTERY LIGHT INDICATOR STAYED ON AND SERPENTINE BELT WORN OUT (REPLACED WITH AFTER MARKET BRAND ($90) THAT HAS LASTED PERFECTLY AT ALMOST 80,000 MILES; ENGINE COOLANT LEAK NOTICE BY CHEVROLET ON JULY 2003 FIXED ON 7/30-03 AT 58009MILES; AT 34607 VIBRATION FROM INTERMID. STEERING SHAFT AND BUSHING REPLACED ($60); VIBRATION BACK AT 75,000MILES AND THEY WOULD NOT FIX IT; CHEV DIAGNOSIS ON 7/8/04 FOR LEFT REAR WHEEL SPEED SENSOR NEEDS LEFT REAR WHEEL HUB ASSEMBLY (ABS BRAKES WILL NOT WORK AND NOT FIXED, $700) AND TURN SIGNALS WORK INTERMITTENLY (NOT FIXED) AND AC COMPRESSOR LEAKING (NOT FIXED, $900), AND DRIVER SEAT POWER SEAT HEATER DEFECTIVE (NOT FIXED, $230).

NHTSA complaint #10080631 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

SERIES OF HIGH COST REPAIRS AT MY EXPENSE WITH NO WARRANTY: DRIVER INFOMATION CENTER HAS ALWAYS BEEN WRONG AND INACCURATE AND UNFIXABLE; AT 24446 MILES, REPLACED FRONT ROTORS AT MY EXPENSE (; AC AT 30825 WORKED INTERMITTENLY AND BATTERY LIGHT INDICATOR STAYED ON AND SERPENTINE BELT WORN OUT (REPLACED WITH AFTER MARKET BRAND ($90) THAT HAS LASTED PERFECTLY AT ALMOST 80,000 MILES; ENGINE COOLANT LEAK NOTICE BY CHEVROLET ON JULY 2003 FIXED ON 7/30-03 AT 58009MILES; AT 34607 VIBRATION FROM INTERMID. STEERING SHAFT AND BUSHING REPLACED ($60); VIBRATION BACK AT 75,000MILES AND THEY WOULD NOT FIX IT; CHEV DIAGNOSIS ON 7/8/04 FOR LEFT REAR WHEEL SPEED SENSOR NEEDS LEFT REAR WHEEL HUB ASSEMBLY (ABS BRAKES WILL NOT WORK AND NOT FIXED, $700) AND TURN SIGNALS WORK INTERMITTENLY (NOT FIXED) AND AC COMPRESSOR LEAKING (NOT FIXED, $900), AND DRIVER SEAT POWER SEAT HEATER DEFECTIVE (NOT FIXED, $230).

NHTSA complaint #10080631 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

CONSUMER COMPLAINED ABOUT FRONT BRAKE PADS. CONSUMER STATED THAT THE FRONT BRAKE PADS HAD TO BE REPLACED EVERY 3,000 MILES, BUT PROBLEM RECURRED.

NHTSA complaint #10073630 — an unverified report by a vehicle owner.

PARKING BRAKE:INDICATOR LIGHT

TRANSMISSION OIL LEAK, GRINDING NOISE IN THE TRANSMISSION,COOLANT LEAK AT THE LOWER INTAKE MANIFOLD.

NHTSA complaint #10066026 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

EVERY 15,000 TO 17,000 I HAVE TO HAVE THE ROTORS TURNED BECAUSE OF WARPING. I HAVE CONTACTED THE MANUFACTERS CUSTOMER SERVICE AND THEY SENT BACK A STANDARD FORM LETTER. AFTER SECOND TIME MANUFACTURER TOLD ME THEY COULD NOT HELP AND TO MAKE AN APPOINTMENT WITH MY DEALER. ALL THEY DID WAS TO TURN THE ROTORS NO CHARGE. THAT DOES NOT SOLVE THE PROBLEM. THERE HAS TO BE A DEFECT. JUST LIKE ONE OF THE OTHER COMPLAINTS, ALL MY DRIVING IS ON THE HIGHWAY.

NHTSA complaint #10058252 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WHILE APPLYING THE BRAKES PEDAL VIBRATED, RESULTING IN LESS BRAKING POWER DUE TO ABS BRAKING SYSTEM FAILURE. DEALERSHIP WAS AWARE OF THE PROBLEM BECAUSE VEHICLE WAS TOWED TO DEALER FOR THE SAME PROBLEM TWICE.

NHTSA complaint #10042009 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

VIOLET SHAKING WHEN APPLYING BRAKE CAUSED BY WARPING OF BRAKE DISCS. I'VE HAD TO HAVE RESURFACED 3 TIMES SINCE OWNERSHIP & IT'S GOING BACK IN FOR THE 4TH TIME. DEALERSHIP SAYS NOTHING CHEVROLET CAN DO ABOUT IT! MOST OF MY DRIVING IS HIGHWAY.

NHTSA complaint #10032921 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

MY 2001 CHEVROLET MONTE CARLO HAS A SAFETY-RELATED DEFECT WITH THE FRONT BRAKE ROTORS. THE ROTORS ARE MADE OF A COMPOSITE MATERIAL AND WARP VERY EASILY. AT 1500 MILES, I NOTICED A STEERING WHEEL VIBRATION WHEN APPLYING THE BRAKES AT 45-60 MPH. I HAD THE ROTORS REMOVED AND RESURFACED AT MY LOCAL GARAGE SINCE THE CHEVY DEALER TOLD ME THAT BRAKE REPAIRS WOULD NOT BE COVERED UNDER THE WARRANTY. I NOW HAVE 25000 MILES ON THE VEHICLE, AND THE BRAKING VIBRATION IS RECURRING. MY MECHANIC TELLS ME THAT THE ROTORS MUST BE REPLACED. THIS IS CLEARLY A SAFETY-RELATED, DESIGN DEFECT THAT CHEVROLET IS REFUSING TO FIX. NHTSA SHOULD INVESTIGATE THIS AND FORCE CHEVROLET TO FIX THE PROBLEM.

NHTSA complaint #10028827 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

THE CONSUMER FELT THE OVERALL DESIGN INCLUDING THE ENGINE, TRANSMISSION, AND THE BRAKES WERE SERIOUSLY FLAWED. THE VEHICLE WAS PROPERLY REPAIRED BY THE DEALER. ON TWO OCCASIONS, THE IGNITION HAD GOTTEN STUCK, THE ENGINE LOST OIL, AND THE DIPSTICK CYLINDER HAD LOOSENED. THE CONSUMER REQUESTED A REFUND. GM DID NOT AGREE WITH THE ABOVE COMMENT, AND STATED THE DEALER HANDLED THE SITUATION PROPERLY. (MODEL SS) MR SCC

NHTSA complaint #10015970 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

THE VEHICLE EXPERIENCED THE FOLLOWING: STALLED WHEN COLD AND UPON HARD ACCELERATION, THE KEY STUCK IN THE IGNITION, SUSPENSION AND BRAKE PROBLEMS(ROD KIT WAS INSTALLED/NO BRAKES), THE TRANSMISSION HAD GONE OUT(REPAIRED), THE VEHICLE HESITATED AND JUMPED FROM PARK GEAR TO DRIVE, AND AFTER THE IGNITION REPAIRS, THE VEHICLE STALLED AND HESITATED IN SHIFTING TO GEAR. THE CONSUMER REQUESTED THE DEALER TO REPURCHASE THE VEHICLE, AND REIMBURSE FOR THE REPAIR(S), AND THE RENTAL. MR SCC

NHTSA complaint #10015209 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:DISC:ROTOR

HAVE HAD TO HAVE MY ROTORS TURNED AND THEN REPLACED IN UNDER 40,000 MILES. NOW AT 56,000- I AM EXPERIENCING THE SAME SYMPTOMS. DEALER PAID FOR TURNING THE FIRST TIME. WHEN THE ROTORS NEEDED TO BE REPLACED- WARRANTY HAD EXPIRED. I WENT DIRECTLY TO CHEVY WHO REFUSED (THEY WERE ALSO EXTREMELY RUDE AND UNPROFESSIONAL, DID NOT RESPOND TO MESSAGES AND REFUSED TO LET ME SPEAK TO A MANAGER!) TO REPLACE.

NHTSA complaint #10008049 — an unverified report by a vehicle owner.