Owners have filed 230 complaints
about the 2003 Chevrolet S10 with NHTSA between 2003 and 2021.
The largest single group is the brakes.
Across this model's run it ranks 9 of 12 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 21
Against the median year of the Chevrolet S10. 50 means typical for this
model; 100 means roughly double.
Severity — 85
16.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 66
39% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
137.6%
1,000 – 9,999 miles
2212.9%
10,000 – 24,999 miles
158.8%
25,000 – 49,999 miles
3520.6%
50,000 – 74,999 miles
2816.5%
75,000 – 99,999 miles
2212.9%
100,000 – 149,999 miles
2917.1%
150,000+ miles
63.5%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 2003peak 8Oct 2021
Recalls on the 2003 Chevrolet S10
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
09E025000
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
06E065000
EXTERIOR LIGHTING
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
06E060000
EXTERIOR LIGHTING
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
04V132000
EQUIPMENT:OTHER:LABELS
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION."
Risk: SOME OF THESE VEHICLES INCLUDE INCORRECT STATEMENTS ON ONE OF THE AIR BAG WARNING LABELS.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20041051,018 units in Canada
Label
On certain vehicles, the Supplemental Inflatable Restraint (SIR) caution label contains an incorrect statement. However, in every case, the owner's manual provided with the vehicle correctly describes the acceptable rear-facing child seat location for the particular vehicle configuration. Correction: A correct pressure-sensitive sunshade label and instructions for its application are to be mailed to owners.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 200,000 milesKershaw, SCCrash1 injured
AIR BAGS
The contact owned a 2003 Chevrolet S 10. The contact stated that while stopped at a stop sign, another vehicle T-boned his vehicle at a high rate of speed. The contact stated that the air bag did not deploy and the contact hit his head on the windshield. The contact was taken from the scene to a local hospital where they initially ran a test and found no injuries on his body. The contact stated that his head remained in pain and went back to the hospital the next day. The next day, the contact was informed that a blood clot was discovered near his brain, and was transferred to another hospital for surgery. The contact was sent to outpatient rehabilitation once he was released from the hospital. The contact stated that the other driver did not sustain any injuries. A police report was filed. The vehicle was towed to a body shop where it was deemed a total loss and his insurance had taken possession of the vehicle. The manufacturer was notified of the failure and offered no assistance. The vehicle was a total loss. The failure mileage was approximately 200,000.
NHTSA complaint #11437516 — an unverified report by a vehicle owner.
at 100,048 milesFresno, CACrash1 injured
AIR BAGS
TL* THE CONTACT OWNS A 2003 CHEVROLET S10. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT REACHED DOWN TO ACCESS AN ITEM AND CRASHED INTO THE PRECEDING VEHICLE. NONE OF THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE OFFICERS ALSO WONDERED WHY THE AIR BAGS HAD NOT DEPLOYED DUE TO THE EXTENSIVE DAMAGE TO THE FRONT END OF THE VEHICLE. THE CONTACT SUSTAINED WHIPLASH AND MINOR BRUISING, WHICH REQUIRED MEDICAL ATTENTION. THE SEAT BELT MANAGED TO RESTRAIN THE DRIVER SECURELY. THE INSURANCE COMPANY TOWED THE VEHICLE TO A YARD. IT WAS UNKNOWN IF THE VEHICLE WAS DESTROYED. THE MANUFACTURER HAD NOT ISSUED ANY AIR BAG RECALLS FOR THE YEAR, MAKE, AND MODEL VEHICLE; HOWEVER, THERE WAS ONE AIR BAG TECHNICAL SERVICE BULLETIN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 100,048.
NHTSA complaint #11176516 — an unverified report by a vehicle owner.
at 130,267 milesAshland, ALCrash2 injured
SEAT BELTS
I WAS GOING THROUGH A GREEN LIGHT AT AN INTERSECTION,WHEN ANOTHER VEHICLE RAN THE RED LIGHT AT A HIGH SPEED. THE VEHICLE HIT THE FRONT CENTER OF MY BUMPER AND THE AIRBAGS DID NOT DEPLOY AND THE SEAT BELTS DID NOT HOLD. I WAS HEADED SOUTH,AND THE OTHER VEHICLE WAS HEADED WEST,WHEN IT HIT ME. IT TURNED ME INTO THE WESTWARD DIRECTION. WHEN I CAME TO, MY HEAD WAS HANGING OUT THE WINDOW AND MY SON(WHO WAS IN THE PASSENGERS SEAT )WAS ON TOP OF ME. HE WAS THROWN ACROSS THE CONSOLE,OUR SEAT BELTS DID NOT HOLD. I WAS TRANSPORTED TO THE ER BY AMBULANCE. IF NEED BE I HAVE PHOTOS OF THE ACCIDENT SCENE...UPDATED 09-03-14 *BF UPDATED 09/10/2014
NHTSA complaint #10606586 — an unverified report by a vehicle owner.
at 130,267 milesAshland, ALCrash2 injured
AIR BAGS
I WAS GOING THROUGH A GREEN LIGHT AT AN INTERSECTION,WHEN ANOTHER VEHICLE RAN THE RED LIGHT AT A HIGH SPEED. THE VEHICLE HIT THE FRONT CENTER OF MY BUMPER AND THE AIRBAGS DID NOT DEPLOY AND THE SEAT BELTS DID NOT HOLD. I WAS HEADED SOUTH,AND THE OTHER VEHICLE WAS HEADED WEST,WHEN IT HIT ME. IT TURNED ME INTO THE WESTWARD DIRECTION. WHEN I CAME TO, MY HEAD WAS HANGING OUT THE WINDOW AND MY SON(WHO WAS IN THE PASSENGERS SEAT )WAS ON TOP OF ME. HE WAS THROWN ACROSS THE CONSOLE,OUR SEAT BELTS DID NOT HOLD. I WAS TRANSPORTED TO THE ER BY AMBULANCE. IF NEED BE I HAVE PHOTOS OF THE ACCIDENT SCENE...UPDATED 09-03-14 *BF UPDATED 09/10/2014
NHTSA complaint #10606586 — an unverified report by a vehicle owner.
at 136,000 milesMassapequa Park, NYCrash
SERVICE BRAKES
TL* THE CONTACT OWNS A 2003 CHEVROLET S10. THE CONTACT WAS APPROACHING A TRAFFIC STOP WHEN HE APPLIED THE BRAKES AND THE VEHICLE FAILED TO RESPOND. THE BRAKE PEDAL BECAME STUCK TO THE FLOORBOARD, CAUSING THE CONTACT TO BECOME INVOLVED IN A CRASH THAT INVOLVED FOUR ADDITIONAL VEHICLES. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS ADVISED THAT THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 136,000. THE VIN WAS NOT AVAILABLE. UPDATED 04/29/14
NHTSA complaint #10548288 — an unverified report by a vehicle owner.
at 50,000 milesReagan, TNCrash1 injured
AIR BAGS:FRONTAL
TL*THE CONTACT OWNS A 2003 CHEVROLET S-10. WHILE DRIVING APPROXIMATELY 45 MPH ON A DIRT ROAD, THE CONTACT DROVE OVER A PATCH OF WET GRASS AND LOST CONTROL OF THE VEHICLE. HE ATTEMPTED TO REGAIN CONTROL OF THE VEHICLE, STRUCK A TREE, AND THE VEHICLE FLIPPED OVER. THE AIR BAGS FAILED TO DEPLOY AND THE VEHICLE WAS COMPLETELY DESTROYED. THE CONTACT SUSTAINED THREE BROKEN RIBS AND BRUISES. A POLICE REPORT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE 50,000. UPDATED 07/22/08 *BF UPDATED 07/24/08
NHTSA complaint #10232485 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 200,000 milesKershaw, SCCrash1 injured
AIR BAGS
The contact owned a 2003 Chevrolet S 10. The contact stated that while stopped at a stop sign, another vehicle T-boned his vehicle at a high rate of speed. The contact stated that the air bag did not deploy and the contact hit his head on the windshield. The contact was taken from the scene to a local hospital where they initially ran a test and found no injuries on his body. The contact stated that his head remained in pain and went back to the hospital the next day. The next day, the contact was informed that a blood clot was discovered near his brain, and was transferred to another hospital for surgery. The contact was sent to outpatient rehabilitation once he was released from the hospital. The contact stated that the other driver did not sustain any injuries. A police report was filed. The vehicle was towed to a body shop where it was deemed a total loss and his insurance had taken possession of the vehicle. The manufacturer was notified of the failure and offered no assistance. The vehicle was a total loss. The failure mileage was approximately 200,000.
NHTSA complaint #11437516 — an unverified report by a vehicle owner.
Pittsburg, KS
AIR BAGS
Twice now while lightly applying brakes to come to a stop at an intersection the antilock brake system engaged. Since it was unexpected I almost didn't come to a stop in time before rolling into the intersection into traffic. The ABS warning indicator was illuminated intermittently before this with recorded DTC C0268 (Pump motor circuit shorted). Also the transfer case input shaft seal failed which caused transmission fluid to leak into the transfer case, completely filling it. That caused the transfer case vacuum switch to fail and transmission fluid was sucked into the vacuum lines and eat through them causing a vacuum leak. Because of the vacuum leak, whenever I would accelerate to highway speeds and the engine would use what vacuum it could, the 4WD actuator would lose its vacuum then regain it when the RPM's dropped and try to lock the front axle while at highway speeds which would cause the truck to jerk and the gears to grind. And lastly the Airbag warning indicator is always illuminated for reasons I do not know.
NHTSA complaint #11437098 — an unverified report by a vehicle owner.
Pittsburg, KS
UNKNOWN OR OTHER
Twice now while lightly applying brakes to come to a stop at an intersection the antilock brake system engaged. Since it was unexpected I almost didn't come to a stop in time before rolling into the intersection into traffic. The ABS warning indicator was illuminated intermittently before this with recorded DTC C0268 (Pump motor circuit shorted). Also the transfer case input shaft seal failed which caused transmission fluid to leak into the transfer case, completely filling it. That caused the transfer case vacuum switch to fail and transmission fluid was sucked into the vacuum lines and eat through them causing a vacuum leak. Because of the vacuum leak, whenever I would accelerate to highway speeds and the engine would use what vacuum it could, the 4WD actuator would lose its vacuum then regain it when the RPM's dropped and try to lock the front axle while at highway speeds which would cause the truck to jerk and the gears to grind. And lastly the Airbag warning indicator is always illuminated for reasons I do not know.
NHTSA complaint #11437098 — an unverified report by a vehicle owner.
Pittsburg, KS
SERVICE BRAKES
Twice now while lightly applying brakes to come to a stop at an intersection the antilock brake system engaged. Since it was unexpected I almost didn't come to a stop in time before rolling into the intersection into traffic. The ABS warning indicator was illuminated intermittently before this with recorded DTC C0268 (Pump motor circuit shorted). Also the transfer case input shaft seal failed which caused transmission fluid to leak into the transfer case, completely filling it. That caused the transfer case vacuum switch to fail and transmission fluid was sucked into the vacuum lines and eat through them causing a vacuum leak. Because of the vacuum leak, whenever I would accelerate to highway speeds and the engine would use what vacuum it could, the 4WD actuator would lose its vacuum then regain it when the RPM's dropped and try to lock the front axle while at highway speeds which would cause the truck to jerk and the gears to grind. And lastly the Airbag warning indicator is always illuminated for reasons I do not know.
NHTSA complaint #11437098 — an unverified report by a vehicle owner.
Beaufort, SC
ENGINE
2003 Chevy S10 has been maintained and taking care of. Brakes in rear were sticking due to factory defective ABS control module. Rear wheel bearing gave out and started leaking axle fluid cause of a sticking drivers side brake from ABS control module malfunctioning. After much cost of replacing calipers and brake pads the culprit from a defectively ABS control module making the brake caliper stick to the rotor.. Next the coolant leaks from the intake manifold gasket and now the heater core leaks… this truck has only 146k miles on it and I always taking care of it keeping up before it’s schedule maintenance. But what I see is poor defective parts from GM. SO I have to make sure I get this work done and keep the coolant filled or there be a motor issue from overheating. This is a SAFETY concern and if the heater core leaks then breathing the toxic coolants isn’t safe at all when the AC is on or no heat in winter!. Now GM discontinued making the S10 in North America but redesigned a front wheel drive diesel version in South America.
NHTSA complaint #11430001 — an unverified report by a vehicle owner.
Beaufort, SC
SERVICE BRAKES
2003 Chevy S10 has been maintained and taking care of. Brakes in rear were sticking due to factory defective ABS control module. Rear wheel bearing gave out and started leaking axle fluid cause of a sticking drivers side brake from ABS control module malfunctioning. After much cost of replacing calipers and brake pads the culprit from a defectively ABS control module making the brake caliper stick to the rotor.. Next the coolant leaks from the intake manifold gasket and now the heater core leaks… this truck has only 146k miles on it and I always taking care of it keeping up before it’s schedule maintenance. But what I see is poor defective parts from GM. SO I have to make sure I get this work done and keep the coolant filled or there be a motor issue from overheating. This is a SAFETY concern and if the heater core leaks then breathing the toxic coolants isn’t safe at all when the AC is on or no heat in winter!. Now GM discontinued making the S10 in North America but redesigned a front wheel drive diesel version in South America.
NHTSA complaint #11430001 — an unverified report by a vehicle owner.
at 133,998 milesPhoenix, AZ
AIR BAGS
TRUCK WAS PURCHASED 7/7/20. SEEMED TO WORK FINE, BUT STARTED NOTICING ENGINE TROUBLE ON 9/10/20. HAD ONLY DRIVEN IT ~150 MILES SINCE PURCHASE, NEVER ANY STRENUOUS DRIVING. TOOK IT IN TO GET SERVICED ON 9/21/20, WHERE SEVERAL PROBLEMS WERE SPOTTED, ONE OF WHICH IS TRACEABLE TO THE DEALER: 1) THE DISTRIBUTOR CAP WAS BEING HELD ON ONLY BY TWO ZIPTIES. THIS IS WHY IT SEEMED TO RUN FINE ON THE DATE OF PURCHASE, BUT CAUSED ENGINE MISFIRES WITHIN A FEW MONTHS OF LIGHT USE. THE DEALERSHIP NOTIFIED ME THE DAY BEFORE I PURCHASED IT THAT THE DISTRIBUTOR WAS BEING FIXED, BUT THEY FAILED TO NOTIFY ME THAT IT WASN'T FIXED PROPERLY. TRUCK NOW MISFIRES, HAS AN ARCING WIRE, AND IS UNSAFE TO DRIVE. 2)TRUCK WAS SOLD WITH NO PARKING BRAKE, AND NO WARNING THAT IT WAS NOT INSTALLED. THIS INFORMATION HAS OMITTED WHEN I ASKED ABOUT SAFETY ISSUES BEFORE PURCHASING. NEVER NOTICED BECAUSE PHX IS SO FLAT. HAD I NEEDED TO USE THE PARKING BRAKE, NOT HAVING ONE INSTALLED IS A SIGNIFICANT SAFETY ISSUE. 3) AN IMPACT SENSOR WAS LEFT HANGING FROM THE REAR OF THE VEHICLE. A LARGE ENOUGH BUMP OR A ROCK COULD SET OFF AIRBAGS WHILE DRIVING, PUTTING MY PASSENGERS, MYSELF, AND OTHER DRIVERS AND PEDESTRIANS AT SERIOUS RISK. THIS TRUCK IS VERY UNSAFE TO DRIVE, AND I WAS NOT RESPONSIBLE FOR ANY OF THE ISSUES THAT MADE IT UNSAFE. THE FIRST ISSUE WAS CAUSED BY A BAD REPAIR MADE BY THE DEALERSHIP, AND THE OTHER TWO NOTED ISSUES WERE NOT NOTED IN THE CARFAX OR BY THE SALESPERSON WHEN I ASKED ABOUT SAFETY ISSUES.
NHTSA complaint #11360475 — an unverified report by a vehicle owner.
at 133,998 milesPhoenix, AZ
SERVICE BRAKES
TRUCK WAS PURCHASED 7/7/20. SEEMED TO WORK FINE, BUT STARTED NOTICING ENGINE TROUBLE ON 9/10/20. HAD ONLY DRIVEN IT ~150 MILES SINCE PURCHASE, NEVER ANY STRENUOUS DRIVING. TOOK IT IN TO GET SERVICED ON 9/21/20, WHERE SEVERAL PROBLEMS WERE SPOTTED, ONE OF WHICH IS TRACEABLE TO THE DEALER: 1) THE DISTRIBUTOR CAP WAS BEING HELD ON ONLY BY TWO ZIPTIES. THIS IS WHY IT SEEMED TO RUN FINE ON THE DATE OF PURCHASE, BUT CAUSED ENGINE MISFIRES WITHIN A FEW MONTHS OF LIGHT USE. THE DEALERSHIP NOTIFIED ME THE DAY BEFORE I PURCHASED IT THAT THE DISTRIBUTOR WAS BEING FIXED, BUT THEY FAILED TO NOTIFY ME THAT IT WASN'T FIXED PROPERLY. TRUCK NOW MISFIRES, HAS AN ARCING WIRE, AND IS UNSAFE TO DRIVE. 2)TRUCK WAS SOLD WITH NO PARKING BRAKE, AND NO WARNING THAT IT WAS NOT INSTALLED. THIS INFORMATION HAS OMITTED WHEN I ASKED ABOUT SAFETY ISSUES BEFORE PURCHASING. NEVER NOTICED BECAUSE PHX IS SO FLAT. HAD I NEEDED TO USE THE PARKING BRAKE, NOT HAVING ONE INSTALLED IS A SIGNIFICANT SAFETY ISSUE. 3) AN IMPACT SENSOR WAS LEFT HANGING FROM THE REAR OF THE VEHICLE. A LARGE ENOUGH BUMP OR A ROCK COULD SET OFF AIRBAGS WHILE DRIVING, PUTTING MY PASSENGERS, MYSELF, AND OTHER DRIVERS AND PEDESTRIANS AT SERIOUS RISK. THIS TRUCK IS VERY UNSAFE TO DRIVE, AND I WAS NOT RESPONSIBLE FOR ANY OF THE ISSUES THAT MADE IT UNSAFE. THE FIRST ISSUE WAS CAUSED BY A BAD REPAIR MADE BY THE DEALERSHIP, AND THE OTHER TWO NOTED ISSUES WERE NOT NOTED IN THE CARFAX OR BY THE SALESPERSON WHEN I ASKED ABOUT SAFETY ISSUES.
NHTSA complaint #11360475 — an unverified report by a vehicle owner.
at 133,998 milesPhoenix, AZ
FUEL/PROPULSION SYSTEM
TRUCK WAS PURCHASED 7/7/20. SEEMED TO WORK FINE, BUT STARTED NOTICING ENGINE TROUBLE ON 9/10/20. HAD ONLY DRIVEN IT ~150 MILES SINCE PURCHASE, NEVER ANY STRENUOUS DRIVING. TOOK IT IN TO GET SERVICED ON 9/21/20, WHERE SEVERAL PROBLEMS WERE SPOTTED, ONE OF WHICH IS TRACEABLE TO THE DEALER: 1) THE DISTRIBUTOR CAP WAS BEING HELD ON ONLY BY TWO ZIPTIES. THIS IS WHY IT SEEMED TO RUN FINE ON THE DATE OF PURCHASE, BUT CAUSED ENGINE MISFIRES WITHIN A FEW MONTHS OF LIGHT USE. THE DEALERSHIP NOTIFIED ME THE DAY BEFORE I PURCHASED IT THAT THE DISTRIBUTOR WAS BEING FIXED, BUT THEY FAILED TO NOTIFY ME THAT IT WASN'T FIXED PROPERLY. TRUCK NOW MISFIRES, HAS AN ARCING WIRE, AND IS UNSAFE TO DRIVE. 2)TRUCK WAS SOLD WITH NO PARKING BRAKE, AND NO WARNING THAT IT WAS NOT INSTALLED. THIS INFORMATION HAS OMITTED WHEN I ASKED ABOUT SAFETY ISSUES BEFORE PURCHASING. NEVER NOTICED BECAUSE PHX IS SO FLAT. HAD I NEEDED TO USE THE PARKING BRAKE, NOT HAVING ONE INSTALLED IS A SIGNIFICANT SAFETY ISSUE. 3) AN IMPACT SENSOR WAS LEFT HANGING FROM THE REAR OF THE VEHICLE. A LARGE ENOUGH BUMP OR A ROCK COULD SET OFF AIRBAGS WHILE DRIVING, PUTTING MY PASSENGERS, MYSELF, AND OTHER DRIVERS AND PEDESTRIANS AT SERIOUS RISK. THIS TRUCK IS VERY UNSAFE TO DRIVE, AND I WAS NOT RESPONSIBLE FOR ANY OF THE ISSUES THAT MADE IT UNSAFE. THE FIRST ISSUE WAS CAUSED BY A BAD REPAIR MADE BY THE DEALERSHIP, AND THE OTHER TWO NOTED ISSUES WERE NOT NOTED IN THE CARFAX OR BY THE SALESPERSON WHEN I ASKED ABOUT SAFETY ISSUES.
NHTSA complaint #11360475 — an unverified report by a vehicle owner.
at 187,000 milesJasper, FL
VISIBILITY/WIPER
WE OWN 2-2003 S-10S SAME YEAR MODELS AND COLOR. THE ONLY THING DIFFERENT ARE THE MOTORS. BOTH HAVE BEEN HAVING THE WINDSHIELD WIPERS GO OUT WHILE IN A HEAVY RAINSTORMS AND ON BUSY INTERSTATES.
NHTSA complaint #11221490 — an unverified report by a vehicle owner.
at 167,000 milesJasper, FL
VISIBILITY/WIPER
THIS IS SECOND VEHICLE OF PREVIOUS COMPLAINT. WE HAVE TWO 2003 CHEVROLET S-10S WHERE THE WIPERS STOP WORKING DURING RAIN. IN MOST CASES DURING HEAVY RAINS WHILE DRIVING ON HIGHWAYS AND INTERSTATES. VEHICLE HAS TO BE PULLED OVER AND THE HOOD HAS TO BE RAISED TO TAP THE MOTOR TO BE ABLE TO CONTINUE.
NHTSA complaint #11221496 — an unverified report by a vehicle owner.
at 100,048 milesFresno, CACrash1 injured
AIR BAGS
TL* THE CONTACT OWNS A 2003 CHEVROLET S10. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT REACHED DOWN TO ACCESS AN ITEM AND CRASHED INTO THE PRECEDING VEHICLE. NONE OF THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE OFFICERS ALSO WONDERED WHY THE AIR BAGS HAD NOT DEPLOYED DUE TO THE EXTENSIVE DAMAGE TO THE FRONT END OF THE VEHICLE. THE CONTACT SUSTAINED WHIPLASH AND MINOR BRUISING, WHICH REQUIRED MEDICAL ATTENTION. THE SEAT BELT MANAGED TO RESTRAIN THE DRIVER SECURELY. THE INSURANCE COMPANY TOWED THE VEHICLE TO A YARD. IT WAS UNKNOWN IF THE VEHICLE WAS DESTROYED. THE MANUFACTURER HAD NOT ISSUED ANY AIR BAG RECALLS FOR THE YEAR, MAKE, AND MODEL VEHICLE; HOWEVER, THERE WAS ONE AIR BAG TECHNICAL SERVICE BULLETIN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 100,048.
NHTSA complaint #11176516 — an unverified report by a vehicle owner.
at 70,000 milesAthol, MA
UNKNOWN OR OTHER
THE TRUCK WAS OCCASIONALLY NOT TURNING OVER. TRIED THINGS LIKE TURNING FAN ON, RADIO, ETC AND IT WOULD START. SECURITY LIGHT COMES ON OR WILL BLINK. TRUCK NOW IS NOT TURNING OVER AT ALL. DASH LIGHTS BLINK AND OR COME ON WHEN DOOR OPENS. THIS IS A PROBLEM I'VE SEEN ALL OVER INTERNET, BUT NOTHING HAS WORKED. I THINK IT SHOULD HAVE A RECALL. I AM PAYING FOR A DEAD TRUCK NOW. TRUCK WAS STATIONARY-WON'T START.
NHTSA complaint #11112131 — an unverified report by a vehicle owner.
at 70,000 milesAthol, MA
ELECTRICAL SYSTEM
THE TRUCK WAS OCCASIONALLY NOT TURNING OVER. TRIED THINGS LIKE TURNING FAN ON, RADIO, ETC AND IT WOULD START. SECURITY LIGHT COMES ON OR WILL BLINK. TRUCK NOW IS NOT TURNING OVER AT ALL. DASH LIGHTS BLINK AND OR COME ON WHEN DOOR OPENS. THIS IS A PROBLEM I'VE SEEN ALL OVER INTERNET, BUT NOTHING HAS WORKED. I THINK IT SHOULD HAVE A RECALL. I AM PAYING FOR A DEAD TRUCK NOW. TRUCK WAS STATIONARY-WON'T START.
NHTSA complaint #11112131 — an unverified report by a vehicle owner.
at 140,000 milesWappingers Falls, NY
AIR BAGS
LIGHT FOR AIR BAGS READS THE AIR BAGS ARE NOT WORKING. MECHANIC SAYS HE HAS TO GO INTO THE COMPUTER TO SEE WHAT THE PROBLEMS IS. IT IS A LOT OF WORK INVOLVED TO SEE WHAT THE PROBLEMS IS. THE LIGHT CONSTANTLY ON WHILE VEHICLE RUNNING.
NHTSA complaint #11092239 — an unverified report by a vehicle owner.
at 100,000 milesPrichard, AL
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2003 CHEVROLET S10. WHILE DRIVING 35 MPH, THE CONTACT HEARD AN ABNORMAL TICKING NOISE AND THE ENTIRE INSTRUMENT CLUSTER FAILED. DUE TO THE FAILURE, THE CONTACT RECEIVED A TICKET BECAUSE OF THE UNKNOWN SPEED LIMIT AND WAS SPEEDING 20 MPH OVER THE SPEED LIMIT. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED OR MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS OVER 100,000.
NHTSA complaint #11032689 — an unverified report by a vehicle owner.
at 75,000 milesReidsville, NC
AIR BAGS
TL* THE CONTACT OWNS A 2003 CHEVROLET S10. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (HOMETOWN CHEVROLET BUICK GMC INC, 2009 BARNES ST, REIDSVILLE, NC, 27320) WHERE IT WAS DIAGNOSED THAT IT COULD BE ONE OUT OF TWO FAILURES: AN AIR BAG WARNING SENSOR OR SOMETHING BEHIND THE STEERING WHEEL. THE DIAGNOSIS WAS INCOMPLETE UNTIL THE VEHICLE COULD BE SERVICED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER CONFIRMED THAT THERE WAS NO RECALL ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
NHTSA complaint #11031513 — an unverified report by a vehicle owner.
at 75,000 milesReidsville, NC
ELECTRONIC STABILITY CONTROL (ESC)
TL* THE CONTACT OWNS A 2003 CHEVROLET S10. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (HOMETOWN CHEVROLET BUICK GMC INC, 2009 BARNES ST, REIDSVILLE, NC, 27320) WHERE IT WAS DIAGNOSED THAT IT COULD BE ONE OUT OF TWO FAILURES: AN AIR BAG WARNING SENSOR OR SOMETHING BEHIND THE STEERING WHEEL. THE DIAGNOSIS WAS INCOMPLETE UNTIL THE VEHICLE COULD BE SERVICED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER CONFIRMED THAT THERE WAS NO RECALL ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
NHTSA complaint #11031513 — an unverified report by a vehicle owner.
at 211,000 milesGeorgetown, KY
SERVICE BRAKES
TOTAL SUDDEN BRAKE FAILURE I HAD TO LEAVE THE ROAD TO AVOID OTHER CARS. 40MPH FRONT RIGHT STEAL LINE FAILED AND RIGHT REAR LINE FAILED AT THE SAME TIME LINES ARE RUSTY BUT THE REST OF THE TRUCK IS OK THERE WAS NO WARNING SIGNS ( LIKE DRIPS OR LOW LEVEL IN THE BOOSTER)
NHTSA complaint #11030219 — an unverified report by a vehicle owner.
at 124,000 milesLugoff, SD
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
TL* THE CONTACT OWNS A 2003 CHEVROLET S-10. WHEN THE CONTACT STARTED THE PARKED VEHICLE, THE SERVICE ENGINE LIGHT ILLUMINATED. THE CONTACT DROVE THE VEHICLE TO A LOCAL MECHANIC WHERE IT WAS DIAGNOSED AND PRODUCED CODE B0036 (AIR BAG IMPACT SENSOR). THE MECHANIC TOLD THE CONTACT THAT THE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000.
NHTSA complaint #10860057 — an unverified report by a vehicle owner.
at 130,000 milesDecatur, GA
ENGINE
TL* THE CONTACT OWNS A 2003 CHEVROLET S10. WHILE DRIVING APPROXIMATELY 50 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. AFTER EXITING THE VEHICLE, THE CONTACT OBSERVED AN UNKNOWN FLUID LEAKING UNDER THE FRONT OF THE VEHICLE. THE CONTACT ALSO OBSERVED CORROSION AROUND THE HEATING COIL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000. UPDATED 02/23/16*LJ THE EXPERIENCED PROBLEMS WITH THE CHECK ENGINE LIGHT AND LEAKS IN THE INTAKE MANIFOLD AND HEAD GASKETS. AN INSPECTION REVEALED, THE GASKET WAS COMING APART AND WAS CORRODED. THE HEATER COIL WAS CORRODED AND LEAKING. UPDATED 03/03/16.
NHTSA complaint #10806220 — an unverified report by a vehicle owner.
at 122,250 milesBaltimore, MD
ENGINE
WHEN TRYING TO USE THE WIPERS THE SWITCH REFUSES TO OPERATE CORRECTLY. BEEN REPLACED TWICE ( THIS HAPPENS UNDER ALL THREE SWITCHES). WHEN YOU TURN IT ON IT WILL NOT RESPOND AND DOES NOT WIPE. WHEN YOU USE THE SINGLE WIPE WILL WIPE CONTINUAL AND NOT SHUT OFF AT TIMES. SOME TIMES WHEN YOU USE THE FLUID WILL NOT TURN OFF UNLESS YOU TURN THE ENGINE OFF AND RESTART THE VEHICLE. WHEN IN THE FIRST TWO NOTCHES FOR WIPING WILL START TO WIPE AND STOP ABOUT 1/4 OF THE WAY UP THE WINDSHIELD. IN HIGH POSITION OPERATES AS IF NORMAL, MUST SET IT ABOVE HIGH TO GET IT TO OPERATE IN HIGH. SOMETIMES IT ONLY OPERATES AT ONE SPEED NO MATTER THE POSITION EXCEPT WHEN IN HIGH MODE. MANY TIMES WILL NOT TURN ON WHEN YOU TURN IT ON AND WHEN YOU TURN IT OFF WILL NOT TURN OF IF WORKING. THIS IS THE THIRD SWITCH THAT HAS DONE THIS TO ME. ? IS THERE A RECALL ON GM SWITCHES AS I CAN FIND NONE AND MANY PEOPLE SAY THEY HAVE EXPERIENCED SAME RESULTS ON OTHER GM VEHICLES OR HEARD OF IT OCCURRING UPDATE 9/15/15*CW THE CONSUMER WAS INFORMED THE WIPER CONTROL MODULE FAILED. IT WAS REPLACED AND THERE WERE NO MORE PROBLEMS. THE CONSUMER STATED THE ENGINE CONTROL MODULE FAILED, PREVIOUSLY. UPDATED 10/13/15
NHTSA complaint #10743643 — an unverified report by a vehicle owner.
at 122,250 milesBaltimore, MD
VISIBILITY/WIPER
WHEN TRYING TO USE THE WIPERS THE SWITCH REFUSES TO OPERATE CORRECTLY. BEEN REPLACED TWICE ( THIS HAPPENS UNDER ALL THREE SWITCHES). WHEN YOU TURN IT ON IT WILL NOT RESPOND AND DOES NOT WIPE. WHEN YOU USE THE SINGLE WIPE WILL WIPE CONTINUAL AND NOT SHUT OFF AT TIMES. SOME TIMES WHEN YOU USE THE FLUID WILL NOT TURN OFF UNLESS YOU TURN THE ENGINE OFF AND RESTART THE VEHICLE. WHEN IN THE FIRST TWO NOTCHES FOR WIPING WILL START TO WIPE AND STOP ABOUT 1/4 OF THE WAY UP THE WINDSHIELD. IN HIGH POSITION OPERATES AS IF NORMAL, MUST SET IT ABOVE HIGH TO GET IT TO OPERATE IN HIGH. SOMETIMES IT ONLY OPERATES AT ONE SPEED NO MATTER THE POSITION EXCEPT WHEN IN HIGH MODE. MANY TIMES WILL NOT TURN ON WHEN YOU TURN IT ON AND WHEN YOU TURN IT OFF WILL NOT TURN OF IF WORKING. THIS IS THE THIRD SWITCH THAT HAS DONE THIS TO ME. ? IS THERE A RECALL ON GM SWITCHES AS I CAN FIND NONE AND MANY PEOPLE SAY THEY HAVE EXPERIENCED SAME RESULTS ON OTHER GM VEHICLES OR HEARD OF IT OCCURRING UPDATE 9/15/15*CW THE CONSUMER WAS INFORMED THE WIPER CONTROL MODULE FAILED. IT WAS REPLACED AND THERE WERE NO MORE PROBLEMS. THE CONSUMER STATED THE ENGINE CONTROL MODULE FAILED, PREVIOUSLY. UPDATED 10/13/15
NHTSA complaint #10743643 — an unverified report by a vehicle owner.
Waikoloe, HI
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 2003 CHEVROLET S-10. THE CONTACT STATED THAT WHEN ATTEMPTING TO START THE VEHICLE, IT FAILED TO TURN ON. THE CONTACT ALSO STATED THAT A CLICKING SOUND WOULD COME FROM THE STEERING COLUMN WHEN THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THERE WAS A POSSIBLE IGNITION FAILURE. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #10704558 — an unverified report by a vehicle owner.
at 54,000 milesDenver, CO
EXTERIOR LIGHTING:BRAKE LIGHTS
TL* THE CONTACT OWNS A 2003 CHEVROLET S10. THE CONTACT STATED THAT THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE BRAKE LIGHT MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 54,000.
NHTSA complaint #10694650 — an unverified report by a vehicle owner.