Owners have filed 30 complaints
about the 2004 Chevrolet S10 with NHTSA between 2003 and 2020.
The largest single group is the brakes.
Across this model's run it ranks 12 of 12 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 3
Against the median year of the Chevrolet S10. 50 means typical for this
model; 100 means roughly double.
Severity — 52
10% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 67
39% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade:
A
B
C
D
F
ungraded
What breaks on a 2004 Chevrolet S10
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Brakes
723.3%
Median failure at 38,000 miles
Windows, Mirrors & Wipers
310.0%
Median failure at 15,777 miles
Body & Structure
310.0%
Median failure at 92,000 miles
Airbags
310.0%
1 crashes, 0 fires · median 100,000 mi
Electrical System
310.0%
0 crashes, 1 fires · median 91,500 mi
Suspension
26.7%
Median failure at 100,000 miles
Steering
26.7%
Median failure at 139,000 miles
Transmission & Drivetrain
26.7%
Median failure at 9,888 miles
Doors, Latches & Locks
13.3%
Median failure at 92,000 miles
Tires
13.3%
Fuel & Propulsion
13.3%
Median failure at 149,450 miles
Lights
13.3%
Median failure at 15,777 miles
Engine & Cooling
13.3%
Median failure at 15,777 miles
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
28.7%
10,000 – 24,999 miles
730.4%
50,000 – 74,999 miles
313.0%
75,000 – 99,999 miles
313.0%
100,000 – 149,999 miles
730.4%
150,000+ miles
14.3%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Oct 2003peak 4Dec 2020
Recalls on the 2004 Chevrolet S10
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
09E025000
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
06E065000
EXTERIOR LIGHTING
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
04V132000
EQUIPMENT:OTHER:LABELS
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION."
Risk: SOME OF THESE VEHICLES INCLUDE INCORRECT STATEMENTS ON ONE OF THE AIR BAG WARNING LABELS.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20041051,018 units in Canada
Label
On certain vehicles, the Supplemental Inflatable Restraint (SIR) caution label contains an incorrect statement. However, in every case, the owner's manual provided with the vehicle correctly describes the acceptable rear-facing child seat location for the particular vehicle configuration. Correction: A correct pressure-sensitive sunshade label and instructions for its application are to be mailed to owners.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 50,000 milesToney, ALFire
ELECTRICAL SYSTEM
CHEVY S-10 QUAD CAB CAUGHT ON FIRE DUE TO ELECTRICAL MALFUNCTION; PASSENGER SEAT WAS ADJUSTED (ELECTRIC SEAT WITH HEAT) SMELLED SMOKE AND PARKED VEHICLE TOOK KEYS AND EXITED VEHICLE WITH PASSENGER. VEHICLE BURNED ALL WIRING AND THE FUSE BOX UNDER THE HOOD MELTED. NO FLAMES SEEN ONLY SMOKE, ALL WIRING MELTED UNDER THE SEAT AND CARPET THE VEHICLE WOULD NOT START AND NO ELECTRICAL ITEM WOULD TURN ON. HAD VEHICLE TOWED ON BACK OF FLAT BED TO CHEVY DEALER. THEY SAID IT WAS OUR FAULT THAT A WIRE UNDER THE SEAT WAS PINCHED BY THE SEAT TRACK. THE COST WAS OVER $4,000. THEY SAID THAT THE INSTALLED ZIP TIES AND THAT THE WIRE WOULD NOT HAVE ANY ISSUES AGAIN, THEY ALSO REPLACED CARPET, FUSE BOX, JUNCTION CLOCK, SIR MODULE, (CARPET, HARNESS, MODULE, BLOCK, HARNESS, FUSE KIT, FUSE, COIL KIT, HEATER YES TWO HARNESS WERE REPLACED) AND THE COMPLETE WIRING HARNESS. THIS THEN HAPPEN A SECOND TIME, HOWEVER WE TOOK IT TO A SECOND DEALERSHIP IN AL BENTLEY GMC THEY DETERMINED THAT ORIGINAL REPAIR WIRE SHORTEN OUT THE SYSTEM, THE WIRING HARNESS BECAME UNFASTENED AND WAS CUT BY THE SEAT TRACK. THIS TIME DUE TO MY WIFE QUICK THINKING THERE WAS LESS DAMAGE (TURNED OFF VEHICLE IMMEDIATELY AND LEFT VEHICLE IN PARKING SPOT.) FIRST TIME HAPPEN WHILE DRIVING DOWN HIGHWAY. BOTH TIMES PARTS REPLACED WE HAVE OLD PARTS IN OUR HOUSE MINUS- CARPET. DEALERSHIP CONFIRMED NO RECALL ON TRUCK. DEALERSHIP SAID NO MALFUNCTION OCCURRED EVEN THOUGH FUSES DID NOT BREAK CURRENT. SECOND TIME OCCURRED IN JUNE 2009 PART NUMBERS 15191717,15406165, 12210609, 15075526, 12474331, 88909754, 88914568, 26087310, 88934564.
NHTSA complaint #10326080 — an unverified report by a vehicle owner.
at 6,600 milesWeatogue, CTCrash1 injured
AIR BAGS:FRONTAL
WHILE PULLING INTO A DRIVEWAY ANOTHER VEHICLE T-BONED CONSUMER'S VEHICLE ON THE RIGHT FRONT. THIS CAUSED CONSUMER'S VEHICLE TO BECOME AIR BORN. WHEN THE VEHICLE DESCENDED IT WAS STRUCK HEAD ON WITH ANOTHER VEHICLE. CONSUMER WAS WEARING SEAT BELTS, BUT THE FRONT AIR BAGS DID NOT DEPLOY. CONSUMER SUSTAINED MINOR INJURIES TO THE LEGS, CHEST, AND ARMS. THE POLICE ARRIVED AND CITED THE CONSUMER.
NHTSA complaint #10080071 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 139,000 milesMerced, CA
AIR BAGS
THE SERVICE AIR BAGS IS STUCK ON ALSO THE SERVICE BRAKE SYSTEM WONT GO OFF.
NHTSA complaint #11385492 — an unverified report by a vehicle owner.
at 139,000 milesMerced, CA
STEERING
THE SERVICE AIR BAGS IS STUCK ON ALSO THE SERVICE BRAKE SYSTEM WONT GO OFF.
NHTSA complaint #11385492 — an unverified report by a vehicle owner.
at 139,000 milesMerced, CA
SERVICE BRAKES
THE SERVICE AIR BAGS IS STUCK ON ALSO THE SERVICE BRAKE SYSTEM WONT GO OFF.
NHTSA complaint #11385492 — an unverified report by a vehicle owner.
at 100,000 milesEuclid, OH
AIR BAGS
THE AIRBAG LIGHT CONTINUE TO BLINK OFF AND ON.
NHTSA complaint #11115269 — an unverified report by a vehicle owner.
at 100,000 milesEuclid, OH
SUSPENSION
THE AIRBAG LIGHT CONTINUE TO BLINK OFF AND ON.
NHTSA complaint #11115269 — an unverified report by a vehicle owner.
at 149,450 milesOrlando, FL
FUEL/PROPULSION SYSTEM
THE FUEL TANK ON MY TRUCK HAS CRACKED WHERE THE INLET TUBE CONNECTS TO THE TANK , CAUSING A FUEL LEAK. THERE IS A RECALL BY CHEVROLET FOR THE SAME CONDITION ON 2004 CHEVROLET TAHOE WITH THE PLASTIC TANK. GENERAL MOTORS HAS DISCONTINUED THE TANK FOR REPLACEMENT AND WILL NOT VERIFY THERE IS A PROBLEM WITH THIS TANK ALSO. THE TANK EMITS GAS FUMES OUT OF THE CRACKS DUE TO EGR PRESSURE REQUIREMENTS.
NHTSA complaint #10846432 — an unverified report by a vehicle owner.
at 75,000 milesPort Orchard, WA
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 CHEVROLET S10. THE CONTACT STATED THAT THE LIFT GATE COLLAPSED ABNORMALLY. THE CONTACT STATED THAT THE CABLES WERE FRACTURED AND CAUSED THE LIFT GATE TO STRIKE THE BUMPERS. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND CONFIRMED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE MILEAGE WAS 75,000.
NHTSA complaint #10485304 — an unverified report by a vehicle owner.
Milan, KS
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 CHEVROLET S-10. THE CONTACT STATED THAT THE VEHICLE WOULD STALL WITHOUT WARNING. THE CONTACT WOULD HAVE TO REMOVE AND REINSERT THE FUSE IN ORDER TO BE ABLE TO RESTART THE VEHICLE. THE CONTACT WAS UNSURE WHAT THE EXACT FUSE WAS THAT WAS BEING REMOVED CONSTANTLY. THE VEHICLE WAS NOT INSPECTED. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 54,000.
NHTSA complaint #10478488 — an unverified report by a vehicle owner.
at 133,000 milesDacula, GA
ELECTRICAL SYSTEM
HEADLIGHTS GO OUT WHEN DRIVING AND HORN STARTS SOUNDING WHEN THE VEHICLE IS PARK AND WITHOUT KEYS. PROBLEM REPORTED TO GM WHEN THE VEHICLE WAS NEW. GM DEALERSHIP WORKED ON THE VEHICLE AND SAID THAT IS WAS FIXED. PROBLEM HAS REAPPEARED. ALSO A LOT OF MINOR ELECTRICAL PROBLEMS *
NHTSA complaint #10407657 — an unverified report by a vehicle owner.
at 50,000 milesToney, ALFire
ELECTRICAL SYSTEM
CHEVY S-10 QUAD CAB CAUGHT ON FIRE DUE TO ELECTRICAL MALFUNCTION; PASSENGER SEAT WAS ADJUSTED (ELECTRIC SEAT WITH HEAT) SMELLED SMOKE AND PARKED VEHICLE TOOK KEYS AND EXITED VEHICLE WITH PASSENGER. VEHICLE BURNED ALL WIRING AND THE FUSE BOX UNDER THE HOOD MELTED. NO FLAMES SEEN ONLY SMOKE, ALL WIRING MELTED UNDER THE SEAT AND CARPET THE VEHICLE WOULD NOT START AND NO ELECTRICAL ITEM WOULD TURN ON. HAD VEHICLE TOWED ON BACK OF FLAT BED TO CHEVY DEALER. THEY SAID IT WAS OUR FAULT THAT A WIRE UNDER THE SEAT WAS PINCHED BY THE SEAT TRACK. THE COST WAS OVER $4,000. THEY SAID THAT THE INSTALLED ZIP TIES AND THAT THE WIRE WOULD NOT HAVE ANY ISSUES AGAIN, THEY ALSO REPLACED CARPET, FUSE BOX, JUNCTION CLOCK, SIR MODULE, (CARPET, HARNESS, MODULE, BLOCK, HARNESS, FUSE KIT, FUSE, COIL KIT, HEATER YES TWO HARNESS WERE REPLACED) AND THE COMPLETE WIRING HARNESS. THIS THEN HAPPEN A SECOND TIME, HOWEVER WE TOOK IT TO A SECOND DEALERSHIP IN AL BENTLEY GMC THEY DETERMINED THAT ORIGINAL REPAIR WIRE SHORTEN OUT THE SYSTEM, THE WIRING HARNESS BECAME UNFASTENED AND WAS CUT BY THE SEAT TRACK. THIS TIME DUE TO MY WIFE QUICK THINKING THERE WAS LESS DAMAGE (TURNED OFF VEHICLE IMMEDIATELY AND LEFT VEHICLE IN PARKING SPOT.) FIRST TIME HAPPEN WHILE DRIVING DOWN HIGHWAY. BOTH TIMES PARTS REPLACED WE HAVE OLD PARTS IN OUR HOUSE MINUS- CARPET. DEALERSHIP CONFIRMED NO RECALL ON TRUCK. DEALERSHIP SAID NO MALFUNCTION OCCURRED EVEN THOUGH FUSES DID NOT BREAK CURRENT. SECOND TIME OCCURRED IN JUNE 2009 PART NUMBERS 15191717,15406165, 12210609, 15075526, 12474331, 88909754, 88914568, 26087310, 88934564.
NHTSA complaint #10326080 — an unverified report by a vehicle owner.
at 64,000 milesLA Vista, NE
PARKING BRAKE
EMERGENCY BRAKE LEVER FAILED TO LATCH IN LOCKED POSITION.
NHTSA complaint #10289487 — an unverified report by a vehicle owner.
at 840,000 milesEveleth, MN
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
I HAVE A 2004 S-10 PICKUP AND HAD A NEARMISS A PERSON WAS SITTING ON MY TAILGATE AND THE LEFT TAILGATE CABLE BROKE AND THE RIGHT ONE IS BULGING I BELIEVE THERE WAS A RECALL ON THIS VEHICLE HOW DO I GET THESE CABLES CHANGED.
NHTSA complaint #10288605 — an unverified report by a vehicle owner.
at 62,500 milesFritch, TX
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
TL*THE CONTACT OWNS A 2004 CHEVROLET S10. WHILE DRIVING 30 MPH, THE CONTACT NOTICED THAT THE VEHICLE WAS PULLING TO THE RIGHT. THE VEHICLE WAS INSPECTED BY A TECHNICIAN WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT MADE MULTIPLE REPAIRS TO THE VEHICLE INCLUDING A FRONT END ALIGNMENT, NEW BRAKES PADS FOR ALL FOUR WHEELS, THE MASTER CYLINDER, AND ALL FOUR TIRES. HOWEVER, THE FAILURE STILL PERSISTS. UPON FURTHER RESEARCH, THE CONTACT WAS ABLE TO DETERMINE THAT THE BRAKE LINES WERE FAILING AND CAUSED THE VEHICLE TO PULL TO THE RIGHT. THE VEHICLE WAS INSPECTED BY A TECHNICIAN WHO REPLACED THE BRAKE LINES AT THE COST OF $150. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 62,500 AND CURRENT MILEAGE WAS 63,000.
NHTSA complaint #10270090 — an unverified report by a vehicle owner.
at 92,000 milesEldersburg, MD
STRUCTURE:BODY:TAILGATE
2004 CHEVROLET S-10 CREW CAB TRUCK TAILGATE CABLES FAILED. THE CABLES EACH BROKE IN THE CENTER CAUSING THE TAILGATE TO DROP AGAINST THE REAR BUMPER. CONTACTED CHEVY ABOUT THEIR SPECIAL POLICY 06020 TO REPLACE THE KNOWN DEFECT, BUT IT ONLY COVERS 2000-2003. HOWEVER, 2004 USES THE SAME CABLES. I WILL HAVE TO PAY THE DEALER TO REPLACE THE CABLES.
NHTSA complaint #10258553 — an unverified report by a vehicle owner.
at 92,000 milesEldersburg, MD
LATCHES/LOCKS/LINKAGES
2004 CHEVROLET S-10 CREW CAB TRUCK TAILGATE CABLES FAILED. THE CABLES EACH BROKE IN THE CENTER CAUSING THE TAILGATE TO DROP AGAINST THE REAR BUMPER. CONTACTED CHEVY ABOUT THEIR SPECIAL POLICY 06020 TO REPLACE THE KNOWN DEFECT, BUT IT ONLY COVERS 2000-2003. HOWEVER, 2004 USES THE SAME CABLES. I WILL HAVE TO PAY THE DEALER TO REPLACE THE CABLES.
NHTSA complaint #10258553 — an unverified report by a vehicle owner.
at 15,777 milesLeesburg, OH
EXTERIOR LIGHTING:TAIL LIGHTS
VEHICLE PURCHASED 2/23/04 NEW 2004 S-10 CLUB CAB - IN FEB 05 WAS RETURNED DUE TO COOLANT LEAK - BOTH ENG. OIL COOLER HOSES REPLACED. ALSO FUEL GAUGE WAS ERRATIC THEY REPLACED FUEL LEVEL SENSOR IN TANK REPLACED MILEAGE 15777. AT THAT TIME THE 4WD WAS NOT ENGAGING PROPERLY BUT THEY COULD NOT DUPLICATE THE PROBLEM SO NO REPAIR WAS MADE. MARCH 9, 2005 MOTOR HAD A TICKING NOISE - A LIFTER COLLAPSED AND REPLACED ALONG WITH THE INTAKE GASKET. THERE WAS ALSO A LEAK - THEY FOUND THE REAR EXTENSION HOUSING LEAKING -THE REAR DRIVE SHAFT WAS REMOVED AND SEAL REPLACED. OCT 10, 2005 TRANSMISSION LEAK AND ENGINE NOISE UNDER ACCELERATION - REAR TRANSFER CASE OUTPUT SEAL REPLACED AND ENGINE PRESSURE CHECK. MARCH 30, 2006 CHECK ENGINE LIGHT ON AND EXHAUST SYSTEM RATTLING - THERMOSTAT REPLACED AND CATALYTIC CONVERTER. MILEAGE 34,997 JUNE 2007 TAIL LIGHT ON RIGHT NOT WORKING - WIRING ISSUES REPAIRED TWICE. NOVEMBER 2007 GRINDING NOISE WHEN PUT INTO 4WD BUT ONCE PUT BACK INTO 2WD OKAY. MARCH 2008 - 4WD MAKING LOUD NOISE WHEN ENGAGED AND ALSO MAKING CONTINUING NOISE WHEN IN 2WD - FOUND TO BE TRANSAXLE GOING OUT. WIPER MOTOR GUIT - REPLACED. MILEAGE NOW 74,540 THIS IS WHERE I AM NOW DRIVING WITH THE TRANSAXLE GOING OUT. LOVE TRUCK SIZE AND COMFORT BUT TO MANY PROBLEMS. WILL PROBABLY GO WITH DIFFERENT BRAND NEXT PURCHASE BUT ONLY AFTER MUCH RESEARCH. FOUND MANY COMPLAINTS ON TRANSAXLE ISSUE AND FEEL MANUFACTURER. SHOULD TAKE CARE OF THIS ONE.
NHTSA complaint #10223227 — an unverified report by a vehicle owner.
at 15,777 milesLeesburg, OH
ENGINE AND ENGINE COOLING:COOLING SYSTEM
VEHICLE PURCHASED 2/23/04 NEW 2004 S-10 CLUB CAB - IN FEB 05 WAS RETURNED DUE TO COOLANT LEAK - BOTH ENG. OIL COOLER HOSES REPLACED. ALSO FUEL GAUGE WAS ERRATIC THEY REPLACED FUEL LEVEL SENSOR IN TANK REPLACED MILEAGE 15777. AT THAT TIME THE 4WD WAS NOT ENGAGING PROPERLY BUT THEY COULD NOT DUPLICATE THE PROBLEM SO NO REPAIR WAS MADE. MARCH 9, 2005 MOTOR HAD A TICKING NOISE - A LIFTER COLLAPSED AND REPLACED ALONG WITH THE INTAKE GASKET. THERE WAS ALSO A LEAK - THEY FOUND THE REAR EXTENSION HOUSING LEAKING -THE REAR DRIVE SHAFT WAS REMOVED AND SEAL REPLACED. OCT 10, 2005 TRANSMISSION LEAK AND ENGINE NOISE UNDER ACCELERATION - REAR TRANSFER CASE OUTPUT SEAL REPLACED AND ENGINE PRESSURE CHECK. MARCH 30, 2006 CHECK ENGINE LIGHT ON AND EXHAUST SYSTEM RATTLING - THERMOSTAT REPLACED AND CATALYTIC CONVERTER. MILEAGE 34,997 JUNE 2007 TAIL LIGHT ON RIGHT NOT WORKING - WIRING ISSUES REPAIRED TWICE. NOVEMBER 2007 GRINDING NOISE WHEN PUT INTO 4WD BUT ONCE PUT BACK INTO 2WD OKAY. MARCH 2008 - 4WD MAKING LOUD NOISE WHEN ENGAGED AND ALSO MAKING CONTINUING NOISE WHEN IN 2WD - FOUND TO BE TRANSAXLE GOING OUT. WIPER MOTOR GUIT - REPLACED. MILEAGE NOW 74,540 THIS IS WHERE I AM NOW DRIVING WITH THE TRANSAXLE GOING OUT. LOVE TRUCK SIZE AND COMFORT BUT TO MANY PROBLEMS. WILL PROBABLY GO WITH DIFFERENT BRAND NEXT PURCHASE BUT ONLY AFTER MUCH RESEARCH. FOUND MANY COMPLAINTS ON TRANSAXLE ISSUE AND FEEL MANUFACTURER. SHOULD TAKE CARE OF THIS ONE.
NHTSA complaint #10223227 — an unverified report by a vehicle owner.
at 15,777 milesLeesburg, OH
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
VEHICLE PURCHASED 2/23/04 NEW 2004 S-10 CLUB CAB - IN FEB 05 WAS RETURNED DUE TO COOLANT LEAK - BOTH ENG. OIL COOLER HOSES REPLACED. ALSO FUEL GAUGE WAS ERRATIC THEY REPLACED FUEL LEVEL SENSOR IN TANK REPLACED MILEAGE 15777. AT THAT TIME THE 4WD WAS NOT ENGAGING PROPERLY BUT THEY COULD NOT DUPLICATE THE PROBLEM SO NO REPAIR WAS MADE. MARCH 9, 2005 MOTOR HAD A TICKING NOISE - A LIFTER COLLAPSED AND REPLACED ALONG WITH THE INTAKE GASKET. THERE WAS ALSO A LEAK - THEY FOUND THE REAR EXTENSION HOUSING LEAKING -THE REAR DRIVE SHAFT WAS REMOVED AND SEAL REPLACED. OCT 10, 2005 TRANSMISSION LEAK AND ENGINE NOISE UNDER ACCELERATION - REAR TRANSFER CASE OUTPUT SEAL REPLACED AND ENGINE PRESSURE CHECK. MARCH 30, 2006 CHECK ENGINE LIGHT ON AND EXHAUST SYSTEM RATTLING - THERMOSTAT REPLACED AND CATALYTIC CONVERTER. MILEAGE 34,997 JUNE 2007 TAIL LIGHT ON RIGHT NOT WORKING - WIRING ISSUES REPAIRED TWICE. NOVEMBER 2007 GRINDING NOISE WHEN PUT INTO 4WD BUT ONCE PUT BACK INTO 2WD OKAY. MARCH 2008 - 4WD MAKING LOUD NOISE WHEN ENGAGED AND ALSO MAKING CONTINUING NOISE WHEN IN 2WD - FOUND TO BE TRANSAXLE GOING OUT. WIPER MOTOR GUIT - REPLACED. MILEAGE NOW 74,540 THIS IS WHERE I AM NOW DRIVING WITH THE TRANSAXLE GOING OUT. LOVE TRUCK SIZE AND COMFORT BUT TO MANY PROBLEMS. WILL PROBABLY GO WITH DIFFERENT BRAND NEXT PURCHASE BUT ONLY AFTER MUCH RESEARCH. FOUND MANY COMPLAINTS ON TRANSAXLE ISSUE AND FEEL MANUFACTURER. SHOULD TAKE CARE OF THIS ONE.
NHTSA complaint #10223227 — an unverified report by a vehicle owner.
at 15,777 milesLeesburg, OH
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
VEHICLE PURCHASED 2/23/04 NEW 2004 S-10 CLUB CAB - IN FEB 05 WAS RETURNED DUE TO COOLANT LEAK - BOTH ENG. OIL COOLER HOSES REPLACED. ALSO FUEL GAUGE WAS ERRATIC THEY REPLACED FUEL LEVEL SENSOR IN TANK REPLACED MILEAGE 15777. AT THAT TIME THE 4WD WAS NOT ENGAGING PROPERLY BUT THEY COULD NOT DUPLICATE THE PROBLEM SO NO REPAIR WAS MADE. MARCH 9, 2005 MOTOR HAD A TICKING NOISE - A LIFTER COLLAPSED AND REPLACED ALONG WITH THE INTAKE GASKET. THERE WAS ALSO A LEAK - THEY FOUND THE REAR EXTENSION HOUSING LEAKING -THE REAR DRIVE SHAFT WAS REMOVED AND SEAL REPLACED. OCT 10, 2005 TRANSMISSION LEAK AND ENGINE NOISE UNDER ACCELERATION - REAR TRANSFER CASE OUTPUT SEAL REPLACED AND ENGINE PRESSURE CHECK. MARCH 30, 2006 CHECK ENGINE LIGHT ON AND EXHAUST SYSTEM RATTLING - THERMOSTAT REPLACED AND CATALYTIC CONVERTER. MILEAGE 34,997 JUNE 2007 TAIL LIGHT ON RIGHT NOT WORKING - WIRING ISSUES REPAIRED TWICE. NOVEMBER 2007 GRINDING NOISE WHEN PUT INTO 4WD BUT ONCE PUT BACK INTO 2WD OKAY. MARCH 2008 - 4WD MAKING LOUD NOISE WHEN ENGAGED AND ALSO MAKING CONTINUING NOISE WHEN IN 2WD - FOUND TO BE TRANSAXLE GOING OUT. WIPER MOTOR GUIT - REPLACED. MILEAGE NOW 74,540 THIS IS WHERE I AM NOW DRIVING WITH THE TRANSAXLE GOING OUT. LOVE TRUCK SIZE AND COMFORT BUT TO MANY PROBLEMS. WILL PROBABLY GO WITH DIFFERENT BRAND NEXT PURCHASE BUT ONLY AFTER MUCH RESEARCH. FOUND MANY COMPLAINTS ON TRANSAXLE ISSUE AND FEEL MANUFACTURER. SHOULD TAKE CARE OF THIS ONE.
NHTSA complaint #10223227 — an unverified report by a vehicle owner.
at 11,540 milesCedar Rapids, IA
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
TL*THE CONTACT OWNS A 2004 CHEVROLET S10. WHILE DRIVING 40 MPH, THE VEHICLE SWAYED LEFT TO RIGHT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER STATED THAT THE ABS ACTIVATED, WHICH WAS A NORMAL OCCURRENCE. APPROXIMATELY THREE DAYS LATER, THE DEALER STATED THAT THE ROTORS WERE WARPED. THE CONTACT TOOK THE VEHICLE TO A MECHANIC FOR REPAIR. THE MECHANIC REPLACED THE FRONT ROTORS AND BRAKE PADS. THE FAILURE MILEAGE WAS 11,540 AND CURRENT MILEAGE WAS 20,881.
NHTSA complaint #10202475 — an unverified report by a vehicle owner.
at 11,540 milesCedar Rapids, IA
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
TL*THE CONTACT OWNS A 2004 CHEVROLET S10. WHILE DRIVING 40 MPH, THE VEHICLE SWAYED LEFT TO RIGHT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER STATED THAT THE ABS ACTIVATED, WHICH WAS A NORMAL OCCURRENCE. APPROXIMATELY THREE DAYS LATER, THE DEALER STATED THAT THE ROTORS WERE WARPED. THE CONTACT TOOK THE VEHICLE TO A MECHANIC FOR REPAIR. THE MECHANIC REPLACED THE FRONT ROTORS AND BRAKE PADS. THE FAILURE MILEAGE WAS 11,540 AND CURRENT MILEAGE WAS 20,881.
NHTSA complaint #10202475 — an unverified report by a vehicle owner.
Durand, MI
TIRES
TL*THE CONTACT OWNS A 2004 CHEVROLET S-10. WHILE DRIVING AT 70 MPH ON A CLEAR, DRY DAY A LOUD NOISE WAS HEARD. THE CONTACT PULLED OFF THE ROAD AND NOTICED THE DRIVER'S SIDE REAR TIRE WAS COMPLETELY SHREDDED. ALL THAT REMAINED WAS A REMNANT OF THE TIRE AND THE RIM. THE VEHICLE WAS BROUGHT TO A MECHANIC, VALLEY TIRE, WHERE THE TIRES WERE STILL UNDER WARRANTY AND REPLACED. THE VEHICLE HAD FOUR GOODYEAR WRANGLER RTS TIRES , SIZE P235/75R15. THE MECHANIC STATED THAT THE FAILURE MAY HAVE OCCURRED BECAUSE THE TIRE WAS UNDER INFLATED.
NHTSA complaint #10187763 — an unverified report by a vehicle owner.
Newport News, VA
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
THE FRONT WINDOWS ON MY TRUCK WOULD COME OFF TRACK WHILE BEING ROLLED UP WHEN TRAVELING. I DRIVE A 2004 CHEVROLET S10 CREW CAB. I HAD THIS PROBLEM FOR AWHILE. EVERY TIME I TOOK VEHICLE TO CHEVROLET FOR REPAIRS THEY WOULD SAY IT WAS FIXED, BUT IT WASN'T. THEN THEY FOUND OUT FROM GM THAT THIS WAS A PROBLEM IN A LOT OF THE SAME TRUCKS. SO GM TOLD THE DEALERSHIP TO PUT SHIMS IN THE WINDOWS TO KEEP THEM ON TRACK. SINCE THIS HAS BEEN FIXED I HAVE HAD TO TAKE IT IN TO CHEVROLET AGAIN FOR THE WINDOW MOTOR BURNING OUT FROM THE PRESSURE THE SHIMS WERE PUTTING ON THE MOTOR.
NHTSA complaint #10149032 — an unverified report by a vehicle owner.
at 13,500 milesCamillus, NY
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
DT: CONTACT STATES VEHICLE VIBRATES AT HIGH SPEEDS. THE SERVICE DEALER STATED IT WAS A BRAKE PROBLEM; THE ROTORS WERE WARPED NOT AND THEY WERE NOT COVERED UNDER THE WARRANTY. THE ROTORS WERE REPLACED BY AN INDEPENDENT SERVICE SHOP. IN WARMER WEATHER THE VIBRATION BECAME WORSE.*AK
NHTSA complaint #10125581 — an unverified report by a vehicle owner.
at 6,600 milesWeatogue, CTCrash1 injured
AIR BAGS:FRONTAL
WHILE PULLING INTO A DRIVEWAY ANOTHER VEHICLE T-BONED CONSUMER'S VEHICLE ON THE RIGHT FRONT. THIS CAUSED CONSUMER'S VEHICLE TO BECOME AIR BORN. WHEN THE VEHICLE DESCENDED IT WAS STRUCK HEAD ON WITH ANOTHER VEHICLE. CONSUMER WAS WEARING SEAT BELTS, BUT THE FRONT AIR BAGS DID NOT DEPLOY. CONSUMER SUSTAINED MINOR INJURIES TO THE LEGS, CHEST, AND ARMS. THE POLICE ARRIVED AND CITED THE CONSUMER.
NHTSA complaint #10080071 — an unverified report by a vehicle owner.