2002 Chevrolet Silverado 1500 transmission problems

POWER TRAIN

I was driving today and my truck started making a strange noise(like something was loose). I stop the truck to see what was loose, I found nothing. I got back in the truck driving about 20 mph the truck started making the noise again and the truck started dragging( like it wouldn't go faster). I then stop and pulled in a church parking lot where the truck was not drivable. I was told by a concern passerby( mechanic, which happen to be) it's has something to do with the rest axle. The truck gave me no warning whatever. I was told I could have had a major accident and I had NO!!! warning. Please, fix. I have nothing but, issues with this truck.

NHTSA complaint #11702860 — an unverified report by a vehicle owner.

POWER TRAIN

my truck won't pick up speed when trying to accelerate. I don't know what it is. I know it's a problem and it's a hazard and accident waiting to happen!!!! Please, fix. I have had nothing but, issues with this Chevy Silverado.

NHTSA complaint #11702867 — an unverified report by a vehicle owner.

POWER TRAIN

I FIRST OF ALL ABOUT A YEAR AGO AND NOTICED 2ND GEAR HAS GONE OUT IN IT SINCE I VERY RARELY WENT IN THE REVERSE IT DIDN'T NOTICE THAT TELL HER I WAS IN A PREDICAMENT AND HAD TO PUSH IT OUT AND NOW IT'S STUCK IN FIRST GEAR

NHTSA complaint #11112912 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 60 MPH, THE TRANSMISSION FAILED TO RESPOND PROPERLY IN THE OVERDRIVE POSITION. IN ADDITION, THE TRANSMISSION TEMPERATURE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON THREE SEPARATE OCCASIONS WHERE A REPAIR WAS PERFORMED EACH TIME. THE CONTACT WAS UNCERTAIN OF THE SPECIFIC PARTS THAT WERE REPLACED. THE FAILURE RECURRED AND AN INDEPENDENT MECHANIC WAS DIAGNOSING THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNAVAILABLE.

NHTSA complaint #10765058 — an unverified report by a vehicle owner.

POWER TRAIN

CRESTED A SMALL HILL TO SEE A RED LIGHT WITH THREE CARS IN LINE. I DEPRESSED BRAKE PEDAL, WHICH WENT TO THE FLOOR. THE VEHICLE WAS STOPPED USING THE PARKING BRAKE AFTER SWERVING INTO EMPTY LANE OF ONCOMING TRAFFIC IN ORDER TO AVOID HITTING THE LINE OF CARS FROM BEHIND. UPON INSPECTION, THE FRONT BRAKE CIRCUIT WAS BLOWN IN THE PIPING JUST AFT OF THE FRONT DRIVER'S SIDE WHEEL. IT IS EXTREMELY DIFFICULT TO STOP A LARGE TRUCK WITH EMPTY BED USING ONLY THE REAR BRAKES AS THEY LOCK UP EASILY. THERE SEEMED TO BE NO BRAKE POWER USING THE BRAKE PEDAL, WHICH IS WHY THE PARKING PEDAL WAS USED. EVEN WITH A FUNCTIONAL PARKING BRAKE, THE "FAILSAFE" OF HAVING ONLY ONE CIRCUIT IS NEARLY USELESS GIVEN AN EMPTY TRUCK BED (LOW REAR-WHEEL TRACTION) AND A LOSS OF PRESSURE ON THE FRONT CIRCUIT. IN MY OPINION, LOSING THE FRONT BRAKES ON A TRUCK IS CATASTROPHIC. IN ANY EVENT, IN MY CASE, THE SUPPOSED FAIL-SAFE EITHER DID NOT WORK OR WAS INCONSEQUENTIAL. ALL OF THE HARD LINES (FUEL AND BRAKE) ON THIS VEHICLE ARE EXTREMELY CORRODED AND ARE BEING REPLACED WITH STAINLESS. THIS CAR SPENT THE FIRST FIVE YEARS OF ITS LIFE IN OKLAHOMA AND MISSOURI (WHERE LITTLE TO NO SALT IS USED) AND MOVED TO NH IN 2006. THE REAR DRIVER'S SIDE ROCKER PANEL IS ALSO RUSTED THROUGH AND THE FRAME HAS VERY SIGNIFICANT RUST, ESPECIALLY ON THE LEAF SPRING HANGERS. IN ADDITION, THE FRONT DRIVESHAFT IS RUSTED TO THE POINT THAT I WILL NOT OPERATE THE VEHICLE IN 4WD UNTIL I REPLACE IT. THIS VEHICLE SEEMS VERY SUSCEPTIBLE TO RUST, ESPECIALLY THE BRAKE LINES, SOME OF WHICH CRUMBLED IN MY HUSBANDS HANDS WHILE REMOVING.

NHTSA complaint #10660844 — an unverified report by a vehicle owner.

POWER TRAIN

I WENT TO STOP AT STREET LIGHT AND THE BRAKE WENT TO THE FLOOR NO BRAKES AT ALL. LATER FOUND BRAKES LINES RUSTED THREW. ALL TRANSMISSION LINES ALSO RUST THREW. PRICE TO HAVE FIXED OVER $2000.00

NHTSA complaint #10467487 — an unverified report by a vehicle owner.

POWER TRAIN

CHEVY EXTENDED CAB, 1500 SILVERADO: WHILE DRIVING 45 MPH, TRUCK LOST COMPLETE POWER, I.E. ENGINE QUIT, PWR STEERING LOSS, NO RADIO, GAUGES LOSS PWR. COMPLETE LOSS OF POWER IN TRAFFIC. TRUCK RESTARTED, SPUTTERED, POWER LOSS, ENGINE BACK ON LINE (INTERMITTENTLY FOR APPROXIMATELY 1/4 MILE). VEHICLE RESUMED NORMAL OPERATION FOR SEVERAL DAYS. GARAGE FOUND NOT DISCREPANCIES WITH VEHICLE. FIVE DAYS ELAPSED. VEHICLE LOSS (DIED) ON HIGHWAY AGAIN. SAME DESCRIBED SYMPTOMS. IS THERE A RECALL OR OTHER SIMILAR ISSUES OUT THERE?

NHTSA complaint #10395951 — an unverified report by a vehicle owner.

POWER TRAIN

2002 CHEVY SILVERADO C1500 PLASTIC CLUTCH PEDAL AND PLASTIC SLATE CYLINDER HAS BROKEN APART TWICE. ONCE AROUND 80,000 MILES AND 128,000 ENDANGER MY LIFE ONCE ON THE FREEWAY AND ON HEAVY STREET TRAFFIC . I FEEL THAT THE PROBLEM I AM HAVING IS DANGER TO MY HEALTH. I KNOW THESE PART SHOULD NOT HAVE BEEN INSTALLED OR APPROVED. SINCE THIS IS THE MOST IMPORTANT PARTS WITH A MANUAL TRANSMISSION, I FEEL THESE PLASTIC DO NOT BELONG IN THE POWERTRAIN SYSTEM PLEASE HELP ME WITH THIS PROBLEMS I HAVE TWO PLASTIC CLUTCH OLD PARTS FOR PROOF. THANK YOU

NHTSA complaint #10280689 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL*THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT EXPERIENCED SEVERAL ISSUES WITH HIS VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC FOR REPAIR. WHEN HE TOOK THE RECEIPT FOR THE REPAIR TO THE DEALER, THEY REFUSED TO SPEAK WITH HIM. THE DEALER CLAIMED TO HAVE CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY WERE NOT RESPONSIBLE FOR THE REPAIR CHARGES BECAUSE THE VEHICLE WAS SERVICED BY AN INDEPENDENT MECHANIC. THE REAR END SEAL, TRANSMISSION COLLAR, INTAKE GASKET, THEUPDATED 04-20-09 *BF HEAD GASKET ON THE ENGINE, AND THE CATALYTIC CONVERTER WERE ALL REPLACED. THE FAILURE MILEAGE WAS 98,000.

NHTSA complaint #10262750 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

TL*THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT EXPERIENCED SEVERAL ISSUES WITH HIS VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC FOR REPAIR. WHEN HE TOOK THE RECEIPT FOR THE REPAIR TO THE DEALER, THEY REFUSED TO SPEAK WITH HIM. THE DEALER CLAIMED TO HAVE CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY WERE NOT RESPONSIBLE FOR THE REPAIR CHARGES BECAUSE THE VEHICLE WAS SERVICED BY AN INDEPENDENT MECHANIC. THE REAR END SEAL, TRANSMISSION COLLAR, INTAKE GASKET, THEUPDATED 04-20-09 *BF HEAD GASKET ON THE ENGINE, AND THE CATALYTIC CONVERTER WERE ALL REPLACED. THE FAILURE MILEAGE WAS 98,000.

NHTSA complaint #10262750 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION FAILED WHILE DRIVING. LOST REVERSE 2ND AND 4TH. COMMON PROBLEM WITH POOR QUALITY TRANSMISSION COMPONENTS USED BY GM. SCUM. ANYWAYS, ECONOMY IS IN A RECESSION AND I HAVE LOTS OF BILLS TO PAY AND NOW THIS ONE AS WELL. THANKS. I LAUGH EVERYTIME GM'S STOCK GETS LOWER. THEY TRULY DESERVE IT.

NHTSA complaint #10259637 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSMISSION FAILED AT 58000 MILES. THIS TRUCK WAS NEVER USED FOR TOWING. THE REVERSE WENT OUT BACKING OUT THE GARAGE. ALSO, THE VENT AND VAPOR SENSOR FOR THE FUEL TANK FAILED. I WAS TOLD THERE HAVE BEEN MANY UPDATES FOR THE TRANSMISSION.

NHTSA complaint #10258381 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

SUN SHELL GEARS IN AUTOMATIC TRANSMISSION (4L60E) STRIPPED. LOSS OF REVERSE, SECOND AND FOURTH GEARS IN AUTOMATIC TRANSMISSION. 1ST TIME WITH 17,982 MILES ON VEHICLE AND THE 2ND TIME WITH 78,407 MILES ON VEHICLE. DEALER REPAIRED FIRST TIME UNDER WARRANTY. SECOND TIME THEY SPLIT THE REPAIR BILL OF $850.00.

NHTSA complaint #10240153 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL*THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT ATTEMPTED TO PLACE THE VEHICLE INTO REVERSE, BUT IT WOULD NOT MOVE. THE TRANSMISSION FAILED AND WAS REBUILT; HOWEVER, IT FAILED AGAIN WITHIN 2.5 YEARS. THE FAILURE MILEAGE WAS 119,000 AND CURRENT MILEAGE WAS 159,000.

NHTSA complaint #10239229 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL*THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE DRIVING 15 MPH, THE VEHICLE BEGAN TO VIBRATE AND SHAKE. THE VEHICLE WOULD ALSO NOT SHIFT INTO REVERSE, SECOND, AND FOURTH GEARS. THE DEALER STATED THAT THE TRANSMISSION REACTION SHELL CAUSED THE FAILURE AND WAS REPLACED AT THE COST OF $1,728. THE CURRENT AND FAILURE MILEAGES WERE 57,000. UPDATED 01/11/08. *LJ THE FUEL PUMP AND U-JOINTS WERE REPLACED. UPDATED

NHTSA complaint #10205406 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION OF 2002 CHEVROLET TAHOE FAILED FOR THE SECOND TIME. 79,000 MILES. HAD BEEN DRIVING ON FREEWAY TO DESTINATION. 10 YARDS FROM DESTINATION I PUT THE CAR IN REVERSE, BUT REVERSE DID NOT WORK. CAR IN DRIVE SUDDENLY HAD SAME WHINE AS WHEN OEM TRANSMISSION BROKE. NEEDED 2ND NEW TRANSMISSION.

NHTSA complaint #10203146 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION FAILURE ON 02' CHEVROLET SILVERADO AT ONLY 23K MILES. DEALER RECOMMENDS REPLACEMENT. MANY REPORTS OF FAILURES ON GM VEHICLES..PLEASE HELP US.

NHTSA complaint #10189148 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

(1) NO EVENTS NOTED LEADING UP TO THE FAILURE. NORMAL DRIVING CONDITIONS WERE IMPLEMENTED. PROPER MAINTENANCE AND INTERVALS WERE OBSERVED. WARRANTY HAD RECENTLY EXPIRED. MILEAGE AT TIME OF FAILURE WAS ~49,000 MILES. (2) TRANSMISSION FAILURE OCCURRED LEAVING FAMILY STRANDED IN MIDDLE OF TRAFFIC. AFTER TROUBLESHOOTING EFFORTS FROM 2 GARAGES, IT WAS DETERMINED THE SUN REACTION GEAR FAILED. THIS FAILURE HAS NO FOREWARNING AND IS DUE TO INFERIOR QUALITY OF MATERIALS/PARTS USED IN THE TRANSMISSION. THIS EVENT LEFT MY FAMILY STUCK IN TRAFFIC UNTIL, THROUGH TRIAL AND ERROR, IT WAS FOUND THAT 1 GEAR WAS LEFT SEMI-FUNCTIONAL. THE LACK OF REVERSE GEAR ALSO PUT MY FAMILY IN DANGER WHILE ATTEMPTING TO REACH A SAFE AREA, OUT OF TRAFFIC. GM IS AWARE OF THE ISSUE AS NOTED IN NUMEROUS FACTORY TECHNICAL BULLETINS AND CONVERSATIONS HAD BETWEEN MANUFACTURER CUSTOMER SERVICE AND MYSELF BUT ARE UNWILLING TO MAKE ANY STRIDES FOR CORRECTING THE ISSUE OR COMPENSATE FOR DAMAGES. (3) AT MY EXPENSE, THE REPAIR OPTIONS WERE TOTAL REPLACEMENT OF TOTAL REBUILD OF THE TRANSMISSION. WE OPTED TO TOTAL REBUILD FOR 2 REASONS; FIRST - THE REPLACEMENT WAS ONLY AVAILABLE FROM GM AND IT COULD NOT BE VERIFIED IF THE SAME ISSUE WOULD EXIST IN THE REPLACEMENT; SECOND - PROPER REBUILD EXPENSE WAS FOR COST EFFICIENT. THE ORIGINAL DEFECTIVE PART IS AVAILABLE.

NHTSA complaint #10184401 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

HEARD SEVERAL THINGS COMING FROM UNDER THE CAR WHILE THE AUTOMATIC TRANSMISSION WAS SHIFTING, THEN A CONSTANT WHINNING SOUND WITH NO POWER. HAD TO HAVE THE TRUCK TOWED. DEALER LOOKED AT IT AND DETERMINED IT WAS A TRANSMISSION FAILURE AND THE SUN GEAR ASSEMBLY HAD TO BE REPLACED. COSTS WERE AROUND $1600. THE TRUCK ONLY HAS 66,000 MILES AND IS NOT QUITE FIVE YEARS OLD (2002 CHEVROLET SILVERADO 1500).

NHTSA complaint #10180939 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

I WAS DRIVING MY 2002 CHEVY 4X4 PICKUP (46,000 MILES) HOME WHEN A LOUD CLANK NOISE OCCURRED AND THEN A HIGH PITCHED GRINDING NOISE FOLLOWED. MY TRUCK WOULD NOT SHIFT NORMALLY (2ND, 4TH, AND REVERSE WERE OUT). I WAS LUCKY TO MAKE IT HOME AS I DRIVE ON A HIGHWAY THROUGH THE NATIONAL FOREST WHERE CELL PHONE COVERAGE IS VERY LIMITED. I TOOK MY PICKUP INTO THE DEALERSHIP AND THEY INDICATED THE PROBLEM WAS WITH MY SUN SHELL IN THE TRANSMISSION. IT HAD APPARENTLY FAILED AND WOULD COST BETWEEN $1300 AND $2500 TO GET EVERYTHING FIXED DEPENDING ON HOW EXTENSIVE THE DAMAGE. I BOUGHT THE PICKUP NEW AND ITS NEVER BEEN OFF-ROAD, TOWED OR HAULED ANYTHING AND ONLY HAS 46,000 MILES.

NHTSA complaint #10177853 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

I PURCHASED A 2002 Z71 CHEVROLET CREWCAB 4 W/D PICKUP TRUCK FROM HENDRICK CHEVROLET IN SEPTEMBER OF 2004, AND HAVE HAD MY TRANSMISSION (1ST, 3RD AND REVERSE) GO OUT TWICE IN LESS THAN A YEAR. I CONTACTED GM, BUT THERE WAS NO RECALL AT THAT TIME, BUT THERE WERE A LOT OF COMPLAINTS ON THE NHTSA SITE ABOUT THIS SAME PROBLEM ON MY MODEL TRUCK. THE FIRST TIME IT WENT OUT OF MAY OF 2005, IT HAPPENED AGAIN FEBRUARY OF THIS YEAR. I HAD TO PAY $1,400 TO HAVE IT FIXED IN MAY 2005, BUT THE PLACE OF BUSINESS WHO FIXED IT, FIXED IT AGAIN AT NO COST, AS HE SAID HE GUARANTEES HIS WORK FOR A YEAR, AND SINCE IT HAD NOT BEEN A FULL YEAR, HE DIDN'T CHARGE ME...YOU MIGHT SAY I WAS UNLUCKY AND LUCKY AT THE SAME TIME. I BELIEVE THERE IS A SERIOUS PROBLEM WITH THAT PARTICULAR MODEL PICKUP.

NHTSA complaint #10155436 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

1. NORMAL USE OF THE VEHICLE. 2.TRANSMISSION FAILED, LEAVING ME STRANDED. 3. TRANSMISSION WAS REBUILT AT MY COST. THERE ARE MANY PARTS JUST LIKE MINE AT THE AAMCO TRANSMISSION SHOP IN LAKE CHARLES, LA.

NHTSA complaint #10098351 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHILE DRIVING TRANSMISSION MADE A NOISE, SLIPPED,AND THEN LOCKED. WHEN THIS OCCURRED VEHICLE STOPPED ACCELERATING. VEHICLE WAS TOWED TO A DEALERSHIP, WHO REPLACED THE SUN SEAL AND PINS THAT SHEARED OFF. THE FAILURE RECURRED 3 TIMES IN WHICH THE SAME PARTS WERE REPLACED. THE CAUSE OF THE FAILURES WAS UNDETERMINED.

NHTSA complaint #10080019 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHEN SHIFTING FROM FIRST TO SECOND GEAR, AND SECOND TO THIRD GEAR, TRANSMISSION SHIFTS HARD. LOUD NOISE FROM THE TRANSMISSION/ REAREND. OCCURRED AFTER FREEWAY DRIVING REPEATEDLY.

NHTSA complaint #761032 — an unverified report by a vehicle owner.