43 of the
1,453 complaints filed about the Chevrolet Silverado 3500
are about the body and structure —
3% of everything owners reported.
The worst model year for it is 2000.
I purchased a brand-new Chevrolet dually truck from Bomnin Chevrolet Dadeland in Miami, Florida. Since delivery, the vehicle has had serious unresolved defects and safety concerns. The truck has ongoing alignment issues that the dealership has been unable or unwilling to properly repair. The vehicle does not drive correctly and there are concerns regarding safe operation while hauling. In addition, a major issue has now developed involving the rear passenger door. The rear door does not properly close and latch securely. This creates a serious safety concern because the door may open unexpectedly while driving. I brought these issues to the dealership under warranty, but the problems remain unresolved. I was also informed that the dealership could not properly perform the alignment on the dually truck. This vehicle was sold new and should not have these defects. I am filing this complaint due to concerns about vehicle safety, defective components, and inability to obtain proper warranty repairs.
NHTSA complaint #11737999 — an unverified report by a vehicle owner.
Water entered tailgate through drainage hole in tailgate cap. The water then dripped on the tailgate switch causing it to short out. This short circuit caused my tailgate to open and close randomly without pressing any switches or buttons or key fobs. May tailgate has a small ding it it now from where it kept hitting the wall while parked in the garage. I took the truck to the dealership to get repairs done and was charged 308.88 for the tailgate switch and diagnosis that should have been under a recall for this truck. Safety Recall N232426400 Tailgate May Open Unexpectedly issued May 2024. I called the customer service number [XXX] to try and get reimbursed for the repairs and they told me there is no recall on my truck. I had this problem and it clearly states the year, make and model of my truck in the recall, but because my vin wasn't included I'm out of luck? I will attach all the info i have on this matter. Any help would be greatly appreciated. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11734635 — an unverified report by a vehicle owner.
The tailgate will go up and down when the vehicle is turned off and in park. It will also do this while driving the vehicle. * I notice there has already been a recall for this issue, but my VIN shows NO RECALLS
NHTSA complaint #11721418 — an unverified report by a vehicle owner.
Pulled in drive way and tailgate open light came on and noises was coming from rear or truck. I have a bed cover so I could not see tailgate but it was beeping, going up and down on it own. I finally pulled the fuse to get it stopped. Seen the recall and though all would be good BUT NO they say my truck is not on recall list evan though its doing the exact thing recall is for.
NHTSA complaint #11668484 — an unverified report by a vehicle owner.
Tailgate opens by itself. This happened 3 times in 2 hours while the vehicle was parked. I tow a 5th-wheel trailer. If this happens when towing it can cause a catastrophe.
NHTSA complaint #11654556 — an unverified report by a vehicle owner.
Roof flex under certain conditions Car wash loud banging and movement of Roof lining Loud bang at pavement or bridge approaches. Dealer has inspected and verified with same model. GM does not recognize problem and has no fix,vehicles with sunroof have know problem because of reinforcement of Roof
NHTSA complaint #11651474 — an unverified report by a vehicle owner.
The contact owns a 2024 Chevrolet Silverado 3500. The contact stated while driving at approximately 60 MPH, the front driver's side and passenger's side wheels shuddered when the vehicle drove over a pothole or an object in the roadway. No warning light was illuminated. The contact researched and was made aware of Technical Service Bulletin Number: PIT6154A; however, the vehicle was not included. The vehicle was taken back to the residence. A dealer was contacted however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 13,000.
NHTSA complaint #11631639 — an unverified report by a vehicle owner.
The complaint is against Reading Truck Body, LLC regarding safety concerns left unresolved and property damage incurred because of the recall remedy work (NHTSA Campaign Number 18E-021) performed on my 2017 Silverado 3500HD Crew Cab service truck by Reading Truck Body, LLC. In May 2020, I was notified by Reading Truck Body, LLC of a safety recall specific to the aluminum service body on my truck. Following the initial remedy “patch” work done by the company, I was shocked to discover damages to the rear crossmember and compromising cracks in the welding of the body, as well as to the integrity and functionality of the wiring harnesses on my vehicle. Despite assurances that these damages would be addressed, I have been met with delays, unresponsiveness, and ultimately a subpar replacement body that does not meet the quality and craftsmanship of the original. The replacement body not only fails to match the size and finish of the original, but also poses serious safety risks due to missing bolts, faulty wiring harnesses, and overall poor construction. Despite my repeated attempts to seek resolution through the company’s Recall and Warranty departments, I have been met with dismissive treatment, unfounded accusations, and a refusal to address the issues at hand. This has not only caused financial loss and property damage but has also taken a toll on my emotional well-being and business operations. As a concerned customer, I am requesting your support to hold Reading Truck Body, LLC accountable for their actions in this complaint and fully remedy the recall. To do so, I request they replace the service body with one of equal quality, size, and finish as my original. Proper powder coating and meticulous craftsmanship are essential to restoring the value and integrity of my vehicle. I urge you to help rectify these issues promptly and help me ensure Reading Truck Body, LLC addresses the safety concerns outlined in my complaint. Supporting documentation attached
NHTSA complaint #11627643 — an unverified report by a vehicle owner.
Electrical components are failing in the tailgate lock/unlock mechanism. The tailgate goes up and down on its own while in park. It will also go up and down on its own after the truck is off and unattended This started happening about a week ago. It is available for inspection upon request and has not been inspected by any agency yet. The tailgate could damage itself or other property randomly. It could also impact someone standing near it causing injury. There is a service appointment scheduled 3 days from now. There were no symptoms or warnings of a problem. The Chevy App actually says that all systems are ok.
NHTSA complaint #11627812 — an unverified report by a vehicle owner.
#N232426400-04: Safety Recall - Tailgate May Open Unexpectedly lists RPO code QT5 as the only applicable RPO code for the issue of tailgate opening unexpectedly. QT5 is for manual gate function with EZ lift, power lock release. The recall blames water intrusion into these vehicles’ tailgates that can come into contact with the electronic gate-release switch, potentially causing a short circuit, which may inadvertently unlatch and open the tailgate when in park. The correction is to replace the exterior touchpad switch assembly with part number 85734717. My vehicle has RPO code QT6, which is for power up/down gate function with power lock and release. That option uses the same exterior touchpad switch assembly with part number 85734717. My vehicle did exhibit the same problem of opening unexpectedly while in park. That exterior touchpad switch eventually stopped opening or closing the tailgate altogether, and occasionally the tailgate would get stuck in the closed position while a dash message would say it is open. When it was immobilized in the closed position neither the exterior switch, the interior switch, or the key fob would make the tailgate open. It's my opinion that my vehicle experienced the same root problem as is described in the recall with the exterior switch assembly short circuiting, and that RPO code QT6 units should be included in the recall.
NHTSA complaint #11624358 — an unverified report by a vehicle owner.
The tailgate spontaneously unlatches without operator input while driving or parked. The dealer thinks it is caused by moisture in the latch gate switch. The tailgate has spontaneously unlatched on several occasions while pulling a trailer without the driver/operator being aware this has occurred. Then when making a turn the tailgate wedges into the trailer jack and makes the tailgate inoperable. The bodyshop quote to repair the tailgate is: 2,275.92 Dinsdale Chevrolet dealer says there is not a recall and has declined to pay for repairs. Contact was made with GM Customer Service, "Reggie" on 10/23/2024 at 11:46, 866.636.2273 He noted, as there has not been a recall, they are not responsible for the issue. Respectfully, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11622062 — an unverified report by a vehicle owner.
The tailgate opened and closes on its own while trailering causing sever binds and damage to the trailer and allowing loads to become unsecured. There is a recall already from GM on this issue, but for some reason our VIN is not included. This is a well documented issue. We have video of this occurrence if necessary. The dealer said it’s water in the tailgate switch.
NHTSA complaint #11593598 — an unverified report by a vehicle owner.
The vehicle was involved in a single vehicle roll over crash. The sheet metal of the roof pealed down and away from the frame of the vehicle. The windshield separated from the metal at the top portion of the windshield. The metal then began to separate from underneath the weld along the sides of the roof. The metal was then rolled inward into the passenger compartment of the vehicle. The metal pinned the front passenger seat back down and to the right against the passenger side B-pillar. Both A-pillars did not sustain any structural damage as the result of the crash.
NHTSA complaint #11576046 — an unverified report by a vehicle owner.
Our dashboard is beyond cracked, repair cost $2100.00 plus. I was told that the dash needed to have a metal brace installed with repair. We used a sun reflector from day one. We have a little more than 25k miles on it and the vehicle is immaculate except for the 3rd brake light leaking which we have tried to repair over and over again another flaw design. We finally got our airbag replaced and now the dash is worse than ever. How are we expected to ever get anything even close to resale value for this vehicle. We paid 36,000.00 We did nothing wrong except be a loyal chevrolet customer for our entire lives. We loved chevy but unfortunately since chevrolet refuses to admit that there is a flaw in these dashboards we would not in clear conscience buy from the company again, it's too bad we wanted to trade it in for a 2023. David Shoemaker The starburst breakage is from airbag replacement the straight lines is chevy defect. I think you should meet us halfway on this at least.
NHTSA complaint #11521797 — an unverified report by a vehicle owner.
DRIVERS DOOR LATCH SCREWS HAVE LOOSENED- 1 OF 3 SCREWS MISSING. IF THE OTHER 2 BREAK OR FALL OUT, THE DRIVERS DOOR COULD OPEN UNEXPECTEDLY. THE TRUCK HAS LESS THAN 52,000MILES ON IT.
NHTSA complaint #11300632 — an unverified report by a vehicle owner.
WATER LEAKING INTO THE VEHICLE FROM THE ONSTAR/XM ANTENNA. GM ISSUES A TSB FOR THE ISSUE IN 2017. WILL NOT WARRANTY THE NECESSARY REPAIRS AFTER THE INITIAL BUMPER TO BUMPER COVERAGE. TURNED A CORNER GOT A LAP FULL OF WATER, LUCKILY I WASN'T IN HEAVY TRAFFIC. HEADLINER AND CARPET ARE WET, PROBABLY THE ELECTRONICS AS WELL. NOT SURE HOW LONG IT HAS BEEN LEAKING JUST NOTICED IT.
NHTSA complaint #11299933 — an unverified report by a vehicle owner.
WHILE DRIVING ON THE HIGHWAY, VEHICLE FILLED WITH SMOKE ACCOMPANIED BY A STRONG BURNING ODOR. AT THE SAME TIME THE HVAC BLOWER STOPPED FUNCTIONING AND THE WINDSHIELD FOGGED UP. AFTER STOPPING THE VEHICLE, BURNED WIRES AND MELTED HARNESS CONNECTORS WHERE FOUND AT THE HVAC BLOWER THE HVAC BLOWER MOTOR OVERHEATED DUE TO A SHORT CAUSED BY REPEATED WATER INTRUSION FROM DEFECTIVE AND MISSING BODY SEAMS ALONG THE ROOF, COWL, AND NUMEROUS OTHER LOCATIONS. SAFETY BELT WARNING CHIMES REPEATEDLY FOR NO APPARENT REASON, MANY OTHER ELECTRONIC COMPONENTS INTERMITTENTLY FAIL OR OPERATE ERRATICALLY WHEN IT RAINS OR SNOWS. VEHICLE FLOOR FILLS WITH WATER FREQUENTLY. MOLD HAS STARTED GROWING UNDER CARPET. REPEATED ISSUES FROM DATE OF PURCHASE, ISSUES CONTINUE TO BE UNRESOLVED, DEALERSHIP HAS BEEN UNABLE TO IDENTIFY ALL LEAK SOURCES TO STOP WATER INTRUSION.
NHTSA complaint #11281686 — an unverified report by a vehicle owner.
WHILE PULLING A 40' GOOSENECK TRAILER ON THE HIGHWAY AT POSTED SPEED THE BALL HITCH ON THE BED OF THE TRUCK CAME DETACHED FROM THE TRUCK. TRAILER NECK SLAMMED INTO THE CENTER OF THE BED. I HAVE AN OEM CROWNLINE AFTERMARKET FLAT BED ON MY TRUCK. ONCE THE TRAILER WAS REMOVED THE BALL HITCH FELL TO THE GROUND. INVESTIGATION FOUND LITTLE TO NO WELD PRESENT.
NHTSA complaint #11161987 — an unverified report by a vehicle owner.
TAKATA RECALL: THERE IS A RECALL FOR 2014-15 SILVERADO (RECAL # 14V301000). I AM HAVING THE EXACT SAME ISSUES. I HAVE HAD THE TRUCK ABOUT A YEAR, 2ND OWNER, BOUGHT IT AT 30K MILES.ON NOV. 25 I CAME OUT TO START MY START MY TRUCK AND I IMMEDIATELY COULDN'T POWER UP STEREO AND THEN I NOTICED I HAVE NO DOOR CHIME FOR OPEN DOOR, NO CHIME FOR KEY IN IGNITION AND NO CHIME FOR MY SEATBELT. MY TURN SIGNAL INDICATOR NO LONGER LETS ME KNOW WHEN IT IS ON. MY KEY FOB WILL NOT OPERATE KEYLESS START. I BELIEVE MY VEHICLE COULD EASILY BE INCLUDED IN RECALL. I'M SURE THERE WERENT MANY BECAUSE MOST DEALERSHIPS ARE NOT GIVING ANY SIGNS THAT THEY HAVE DEALT WITH THIS ISSUE. I HAVE ALL GOOD FUSES IN BOTH BOXES TOO. THE 1 DEALERSHIP JUMPED RIGHT TO REPLACING STEREO FOR A $1000. NOW I JUST DONT HAVE THAT KIND OF MONEY NOR CAN I AFFORD TO BE COMING IN AND OUT OF DEALERSHIP TRYING TO FIGURE THIS OUT. SOMEBODY KNOWS WHAT IT IS AND THEIR NOT SHARING THAT INFO. CAN YOU HELP MEFIGURE OUT WHAT TO DO NEXT.I HAVE NO AUDIBLE INDICATOR LETTING ME KNOW DOOR IS OPEN WHILE KEY IS IN IGNITION AND AUDIBLE INDICATOR LETTING ME KNOW IF SEATBELT IS BUCKLED AND I AM A OVER THE ROAD CARRIER AND SPEND ALOT OF TIME IN MY TRUCK. THANK YOU
NHTSA complaint #11155416 — an unverified report by a vehicle owner.