Owners have filed 78 complaints
about the 2015 Chevrolet Silverado 3500 with NHTSA between 2015 and 2026.
The largest single group is the electrical system.
Across this model's run it ranks 2 of 28 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 76
Against the median year of the Chevrolet Silverado 3500. 50 means typical for this
model; 100 means roughly double.
Severity — 66
12.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 94
55% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2015 compares with every other Chevrolet Silverado 3500
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
714.3%
1,000 – 9,999 miles
918.4%
10,000 – 24,999 miles
48.2%
25,000 – 49,999 miles
918.4%
50,000 – 74,999 miles
24.1%
75,000 – 99,999 miles
612.2%
100,000 – 149,999 miles
714.3%
150,000+ miles
510.2%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Aug 2015peak 7Jul 2026
NHTSA investigations into the 2015 Chevrolet Silverado 3500
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
Recalls on the 2015 Chevrolet Silverado 3500
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
21V504000
AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Risk: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
20V736000
AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.
Risk: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.
18V578000
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Risk: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
17V664000
FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK
General Motors LLC (GM) is recalling certain 2011-2015 Chevrolet Silverado 3500 and GMC Sierra 3500 trucks equipped with dual fuel tanks. The low fuel level sensor for the front tank may stick causing the rear tank to overfill the front tank.
Risk: If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.
17V437000
AIR BAGS:FRONTAL
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
16V651000
AIR BAGS:FRONTAL
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
16V069000
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Risk: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Reports where the owner recorded a crash, a fire, an injury or a death.
Ogden, UTFire
VISIBILITY/WIPER
A rear defrost system malfunctioned and was smoking in the interior of the vehicle followed by the rear glass shattering. The electrical malfunction could have easily started a fire and glass flying around the cab a highway speeds could definitely be hazard. I called the dealership and they were unconcerned and gave me a quote to replace it. the dealer or the aftermarket glass replacement company have not heard of it happening. I did find a recall in Canada. Strangely enough mine was done in Canada and it happened again.
NHTSA complaint #11652076 — an unverified report by a vehicle owner.
at 90,000 milesVictorville, CAFire
ELECTRICAL SYSTEM
I WOULD NOTICE WHITE SMOKE COMING OUT UNDER THE HOOD OF MY VEHICLE. I WOULD MAINLY NOTICE IT WHEN I WOULD TURN ON THE AC . THIS WOULD HAPPEN EITHER PARKED OR IN MOTION. I WOULD OPEN THE HOOD AND THE SMOKE WOULD ONLY LAST A FEW MINUTES, WHICH CAUSED THE ALTERNATOR TO CATCH ON FIRE.
NHTSA complaint #11290791 — an unverified report by a vehicle owner.
at 2,000 milesValley Springs, ARCrash
UNKNOWN OR OTHER
VEHICLE WILL NOT STAY ENGAGED IN PARK, WAS PARKED OPENING A GATE AND THE VEHICLE MADE A LOUD POP AND STARTED ROLLING BACKWARD,WITH A TRAILER,LOAD OF HAY, HAS DONE LOTS OF DAMAGE HAS 2000 MILES ON IT. IT WAS STATIONARY THEN STARTED ROLLING BACKWARDS.
NHTSA complaint #10876508 — an unverified report by a vehicle owner.
at 35,000 milesCape MAY, NJFire
ENGINE
TL* THE CONTACT OWNED A 2015 CHEVROLET SILVERADO 3500. WHEN THE VEHICLE WAS SHIFTED IN REVERSE, THE DRIVER IMMEDIATELY OBSERVED SMOKE COMING FROM THE ENGINE COMPARTMENT. AFTER ALL THE PASSENGERS WERE EVACUATED FROM THE VEHICLE, THE HORN SOUNDED AND THE VEHICLE WAS ENGULFED IN FLAMES WITHIN 5 TO 10 MINUTES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DEEMED DESTROYED. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.
NHTSA complaint #10865421 — an unverified report by a vehicle owner.
at 125,000 milesRigby, IDCrash1 injured
POWER TRAIN
I WAS DRIVING ON US HIGHWAY 12 GOING APPROX. 35 MPH WHEN THE REAR END DIFFERENTIAL LOCKUP AND CAUSED ME TO SLID OFF THE ROAD IN A TURN THAT ALSO HAD ICE WHILE TOWING A FIFTH WHEEL THE ACCIDENT CAUSED DAMAGE TO THE RIGHT FRONT FENDER AND THE RIGHT REAR AND RIGHT SIDE OF THE 8 FOOT BED ALONG WITH THE WINDSHIELD AND A FRONT DRIVE LINE FOR 4 WHEEL DRIVE I HAVE HAD MULTIPLE ISSUES WITH THE FRONT DRIVE LINE BREAKING UNDER NORMAL CONDITIONS AS WELL I ALSO HAVE VIDEO OF THE REAR END DIFFERENTIAL MOVING FROM SIDE TO SIDE TO SHOW THE MOVEMENT AND SHOW WHAT CAUSED THE REAR END TO LOCK UP IT HAD MOVED AN 1/4 OF AND INCH TO 1/2 INCH IN EITHER DIRECTION.
NHTSA complaint #10840319 — an unverified report by a vehicle owner.
at 125,000 milesRigby, IDCrash1 injured
SEAT BELTS
I WAS DRIVING ON US HIGHWAY 12 GOING APPROX. 35 MPH WHEN THE REAR END DIFFERENTIAL LOCKUP AND CAUSED ME TO SLID OFF THE ROAD IN A TURN THAT ALSO HAD ICE WHILE TOWING A FIFTH WHEEL THE ACCIDENT CAUSED DAMAGE TO THE RIGHT FRONT FENDER AND THE RIGHT REAR AND RIGHT SIDE OF THE 8 FOOT BED ALONG WITH THE WINDSHIELD AND A FRONT DRIVE LINE FOR 4 WHEEL DRIVE I HAVE HAD MULTIPLE ISSUES WITH THE FRONT DRIVE LINE BREAKING UNDER NORMAL CONDITIONS AS WELL I ALSO HAVE VIDEO OF THE REAR END DIFFERENTIAL MOVING FROM SIDE TO SIDE TO SHOW THE MOVEMENT AND SHOW WHAT CAUSED THE REAR END TO LOCK UP IT HAD MOVED AN 1/4 OF AND INCH TO 1/2 INCH IN EITHER DIRECTION.
NHTSA complaint #10840319 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Dallas, OR
FUEL/PROPULSION SYSTEM
I own a 2015 Chevrolet Silverado 3500HD Duramax diesel. At approximately 130,000 miles, the high-pressure CP4 fuel pump failed internally, sending metal shavings throughout the fuel system and contaminating major components. The truck suddenly lost power on the freeway and became inoperable without warning. I was barely able to get out of traffic before it had to be towed to a Chevrolet dealership. This created a serious safety hazard, especially considering the risk if it had happened while towing my fifth wheel with my family. A failure like this should not happen at this mileage on a heavy-duty diesel truck. I also cannot afford the extremely high cost of repairing the entire fuel system. From my research, many other owners have experienced the same CP4 fuel pump failure, which often destroys the entire fuel system and leads to very expensive repairs. I believe this is a widespread defect, not normal wear and tear. I ask NHTSA to review these failures and take action to protect vehicle owners from similar dangerous and costly failures. This truck currently sits at the dealership as I cannot afford the repairs and GM will not fix what they know is faulty parts.
NHTSA complaint #11751378 — an unverified report by a vehicle owner.
Mesa, AZ
FUEL/PROPULSION SYSTEM
Truck was operating on the highway at highway speed. Suddenly the truck went into a drastic engine power reduction mode and severe automatic downshifting occurred; the truck came to a complete stop on the highway. Diagnostics proved to be a CP4 injector pump failure sending metal into the fuel system, needing a complete contamination kit and new CP3 pump conversion. This apparently is a known defect in GM vehicles and should have been recalled.
NHTSA complaint #11751129 — an unverified report by a vehicle owner.
Ormond Beach, FL
UNKNOWN OR OTHER
The 2nd stage of this truck was not completed and the title was done in fraud in 2015 by Jon Hall Chevy in Daytona. I need this inspected as it shouldn't be on the road. Only 1 MCO without water Marks on it. this is a 2 stage truck should have 2. but nope only one we are getting the run around.
NHTSA complaint #11718995 — an unverified report by a vehicle owner.
Roseville, IL
ENGINE
Exhaust filter plugged due to turbo not working properly. Been at dealership going on 7 weeks This is the 3rd new vehicle we have had this has happened to.
NHTSA complaint #11697982 — an unverified report by a vehicle owner.
Lakeview, AR
ENGINE
Catastrophic failure of the CP4 fuel pump
NHTSA complaint #11698006 — an unverified report by a vehicle owner.
Roseville, IL
FUEL/PROPULSION SYSTEM
Exhaust filter plugged due to turbo not working properly. Been at dealership going on 7 weeks This is the 3rd new vehicle we have had this has happened to.
NHTSA complaint #11697982 — an unverified report by a vehicle owner.
at 270,000 milesGilchrist, TX
FUEL SYSTEM, DIESEL
The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while driving 65 MPH, the message "Fuel Filter Needed to be Replaced" followed by the "Engine Power Reduced" were displayed on the instrument panel. The contact then stated that fuel started leaking from the vehicle and the vehicle stalled. The contact was left stranded in the middle of the road; a tow truck was called, and the vehicle was towed to an independent diesel mechanic. The mechanic performed a diagnostic test, and the contact was informed that the fuel pump had disintegrated which caused debris from the fuel pump to leak into the fuel system. The contact was provided an estimate to replace the fuel pump, fuel pump filter, fuel pump housing, and the fuel injectors. The manufacturer was notified of the failure and referred the contact to the NTHSA Hotline to file a complaint. The vehicle had yet to be repaired. The failure mileage was approximately 270,000.
NHTSA complaint #11666246 — an unverified report by a vehicle owner.
at 270,000 milesGilchrist, TX
ENGINE
The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while driving 65 MPH, the message "Fuel Filter Needed to be Replaced" followed by the "Engine Power Reduced" were displayed on the instrument panel. The contact then stated that fuel started leaking from the vehicle and the vehicle stalled. The contact was left stranded in the middle of the road; a tow truck was called, and the vehicle was towed to an independent diesel mechanic. The mechanic performed a diagnostic test, and the contact was informed that the fuel pump had disintegrated which caused debris from the fuel pump to leak into the fuel system. The contact was provided an estimate to replace the fuel pump, fuel pump filter, fuel pump housing, and the fuel injectors. The manufacturer was notified of the failure and referred the contact to the NTHSA Hotline to file a complaint. The vehicle had yet to be repaired. The failure mileage was approximately 270,000.
NHTSA complaint #11666246 — an unverified report by a vehicle owner.
Ogden, UTFire
VISIBILITY/WIPER
A rear defrost system malfunctioned and was smoking in the interior of the vehicle followed by the rear glass shattering. The electrical malfunction could have easily started a fire and glass flying around the cab a highway speeds could definitely be hazard. I called the dealership and they were unconcerned and gave me a quote to replace it. the dealer or the aftermarket glass replacement company have not heard of it happening. I did find a recall in Canada. Strangely enough mine was done in Canada and it happened again.
NHTSA complaint #11652076 — an unverified report by a vehicle owner.
at 5,100 milesCedarburg, WI
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while the vehicle was parked, the contact noticed that the instrument panel was inoperable. The contact stated that the instrument panel failed to function properly while attempting to activate the windshield wiper. The vehicle was taken to the dealer, where it was diagnosed that the fuse block had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 5,100.
NHTSA complaint #11647041 — an unverified report by a vehicle owner.
at 5,100 milesCedarburg, WI
VISIBILITY/WIPER
The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while the vehicle was parked, the contact noticed that the instrument panel was inoperable. The contact stated that the instrument panel failed to function properly while attempting to activate the windshield wiper. The vehicle was taken to the dealer, where it was diagnosed that the fuse block had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 5,100.
NHTSA complaint #11647041 — an unverified report by a vehicle owner.
Eatonton, GA
SERVICE BRAKES
The brake pedal pivot bolt nut loosened itself and came off of the bolt, allowing the bolt to back out of the pedal mount and the brake pedal fell out of position and became lodged behind the accelerator pedal. Thankfully no accident occurred. After performing research with local dealer and independent repair shop it was found to be an obvious repeat failure of the General Motors safety recall #20760E already performed on the vehicle. I reached out to GM customer support who were rude and I received no help in the matter. Can provide more information upon request.
NHTSA complaint #11643118 — an unverified report by a vehicle owner.
Oceanside, NY
TIRES
Cooper Discoverer STT Pro (LT295/55R20/10). Driving south bout on Meadowbrook State Parkway about 1/2 mile north of the Southern State Parkway in New York State (Long Island) when a catstrophic failure of the front right tire occurred without warning or provocation. Tires were about 18 months old and had about 25000 miles on them. All traffic was at extreme risk with the sudden blow out at highway speed. The tire failed in its entirety becoming completely separated! I struggled to maintain control of the vehicle while avoiding contact with other vehicles barely managing to get off the road. This tire was most likely defective and should not have failed. The vehicle was towed with the help of AAA to Mavis Discount tire who replaced the tires with a different brand.The seller and manufacturer customer service was god awful and didn't care. All four tires had to be replaced. NO warning indicators were present at any time. The cause of the catastrophic failure is unknown but like I said the tire appears to have been defective. There was no contact or damage prior to the failure. I have pictures of the failed tire.
NHTSA complaint #11629460 — an unverified report by a vehicle owner.
Kimberly, ID
FUEL/PROPULSION SYSTEM
Bosch CP4 fuel pump failed 400 miles from home leaving us stranded. We were towed in and spent thousands of dollars and 5 weeks to have the truck repaired. Only warning was that the truck was losing power and barely got off the road.
NHTSA complaint #11590505 — an unverified report by a vehicle owner.
Kimberly, ID
FUEL/PROPULSION SYSTEM
CP4 fuel pump failed while driving 250 miles from home. It was towed in and diagnosed, resulting in over $12,000.00 Dollars to replace fuel system due to metal pumped into fuel system. The mechanic sent the pump back as a core charge. We were stranded and freezing with our dog and towed in after several hours. The only warning was the vehicle was reducing power and I was able to get off the highway.
NHTSA complaint #11588240 — an unverified report by a vehicle owner.
Vinton, IA
ELECTRICAL SYSTEM
2015 CHEVY 3500 HD HAS 65,XXX MILES ON IT CURRENTLY. TRUCK PERIODICALLY AND USUALLY RANDOMLY DISPLAYS A "SERVICE TRAILER BRAKE" MESSAGE WHICH CONSTANTLY GOES OFF WHEN NOTHING IS BEING TOWED. NOW ABOUT 1 IN 15 TIMES DRIVEN WILL IT NOT DISPLAY THIS MESSAGE. IVE HAD THE TOWING BRAKE MODULE REPLACED AND THAT DID NOT FIX THIS PROBLEM. I'M AT MY WITS END WITH THIS TRUCK. CHEVROLET / GMC NEED TO STEP UP AND MAKE THIS WIDELY KNOWN PROBLEM A RECALL. THANKS
NHTSA complaint #11572688 — an unverified report by a vehicle owner.
Vinton, IA
SERVICE BRAKES
2015 CHEVY 3500 HD HAS 65,XXX MILES ON IT CURRENTLY. TRUCK PERIODICALLY AND USUALLY RANDOMLY DISPLAYS A "SERVICE TRAILER BRAKE" MESSAGE WHICH CONSTANTLY GOES OFF WHEN NOTHING IS BEING TOWED. NOW ABOUT 1 IN 15 TIMES DRIVEN WILL IT NOT DISPLAY THIS MESSAGE. IVE HAD THE TOWING BRAKE MODULE REPLACED AND THAT DID NOT FIX THIS PROBLEM. I'M AT MY WITS END WITH THIS TRUCK. CHEVROLET / GMC NEED TO STEP UP AND MAKE THIS WIDELY KNOWN PROBLEM A RECALL. THANKS
NHTSA complaint #11572688 — an unverified report by a vehicle owner.
Vinton, IA
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
2015 CHEVY 3500 HD HAS 65,XXX MILES ON IT CURRENTLY. TRUCK PERIODICALLY AND USUALLY RANDOMLY DISPLAYS A "SERVICE TRAILER BRAKE" MESSAGE WHICH CONSTANTLY GOES OFF WHEN NOTHING IS BEING TOWED. NOW ABOUT 1 IN 15 TIMES DRIVEN WILL IT NOT DISPLAY THIS MESSAGE. IVE HAD THE TOWING BRAKE MODULE REPLACED AND THAT DID NOT FIX THIS PROBLEM. I'M AT MY WITS END WITH THIS TRUCK. CHEVROLET / GMC NEED TO STEP UP AND MAKE THIS WIDELY KNOWN PROBLEM A RECALL. THANKS
NHTSA complaint #11572688 — an unverified report by a vehicle owner.
Ridgecrest, CA
ELECTRICAL SYSTEM
As I am driving I am routinely warned about the trailer brake system with or without a trailer hooked up. It is distracting and could cause potential danger while driving. It has been going on for some time and progressively getting worse.
NHTSA complaint #11562967 — an unverified report by a vehicle owner.
Ridgecrest, CA
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
As I am driving I am routinely warned about the trailer brake system with or without a trailer hooked up. It is distracting and could cause potential danger while driving. It has been going on for some time and progressively getting worse.
NHTSA complaint #11562967 — an unverified report by a vehicle owner.
at 150,000 milesHesperia, CA
FUEL SYSTEM, DIESEL
The contact owns a 2015 Chevrolet Silverado 3500. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the High-Pressure Fuel Pump (HPFP) needed to be replaced. The vehicle had not been repaired. The contact was advised that the HPFP were on national back order. The manufacturer had been informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 21E101000 (Fuel System, Diesel). The failure mileage was approximately 150,000.
NHTSA complaint #11518893 — an unverified report by a vehicle owner.
Lancaster, KY
VEHICLE SPEED CONTROL
There are several problems I’ve noticed some I fix myself! First of all, I was driving my truck at night on the country road and all of a sudden it starts losing power shut down on me on a little road with no pull over spots in Kentucky and just dies completely. My service charging system light came on. I worked on this forever. I noticed it. All of my grounds were completely nasty and pretty much not making contact. I fix the ones that I can find only two I know there’s more, I’ve changed the generator three times and the battery once, the problem happened again and again and again the only way I can stop my truck from dying is when that light come on if I got out and I took the negative wire off of my battery and then put it back on it would run again for about another three days and then if I didn’t see it, I’m stranded very dangerous. Finally I took it to my mechanic up the road and he basically did the same things. I did something about a door switch also though not another battery another generator and he added new battery cables so far it hasn’t done it again. Now my truck when starting to slow down, it will vibrate and shake you to death. You hit a little vibration in the road say a rumble strip. This thing will shake you through the roof in about make you run into another Vehicle , also, it’s hard to fill up the gas if you have to turn the gas nozzle almost straight up and down if you’re low on gas to make it except it or you’ll be sitting there for 30 minutes putting gas in your truck. I noticed also all of my wheels are having rough spots on them everywhere and they are rusting into . Another thing that happens this truck eats breaks for breakfast. I have put in the past two years at least have the change the brakes, calipers rotors and all twice a year sometimes three times a year. Also, the trailer brake system light comes on nonstop along with a service stability track on when happen. No Wasey no cruise control. I am a masterelect. Maintain truck it ju
NHTSA complaint #11500067 — an unverified report by a vehicle owner.
Lancaster, KY
ELECTRICAL SYSTEM
There are several problems I’ve noticed some I fix myself! First of all, I was driving my truck at night on the country road and all of a sudden it starts losing power shut down on me on a little road with no pull over spots in Kentucky and just dies completely. My service charging system light came on. I worked on this forever. I noticed it. All of my grounds were completely nasty and pretty much not making contact. I fix the ones that I can find only two I know there’s more, I’ve changed the generator three times and the battery once, the problem happened again and again and again the only way I can stop my truck from dying is when that light come on if I got out and I took the negative wire off of my battery and then put it back on it would run again for about another three days and then if I didn’t see it, I’m stranded very dangerous. Finally I took it to my mechanic up the road and he basically did the same things. I did something about a door switch also though not another battery another generator and he added new battery cables so far it hasn’t done it again. Now my truck when starting to slow down, it will vibrate and shake you to death. You hit a little vibration in the road say a rumble strip. This thing will shake you through the roof in about make you run into another Vehicle , also, it’s hard to fill up the gas if you have to turn the gas nozzle almost straight up and down if you’re low on gas to make it except it or you’ll be sitting there for 30 minutes putting gas in your truck. I noticed also all of my wheels are having rough spots on them everywhere and they are rusting into . Another thing that happens this truck eats breaks for breakfast. I have put in the past two years at least have the change the brakes, calipers rotors and all twice a year sometimes three times a year. Also, the trailer brake system light comes on nonstop along with a service stability track on when happen. No Wasey no cruise control. I am a masterelect. Maintain truck it ju
NHTSA complaint #11500067 — an unverified report by a vehicle owner.
Lancaster, KY
SERVICE BRAKES
There are several problems I’ve noticed some I fix myself! First of all, I was driving my truck at night on the country road and all of a sudden it starts losing power shut down on me on a little road with no pull over spots in Kentucky and just dies completely. My service charging system light came on. I worked on this forever. I noticed it. All of my grounds were completely nasty and pretty much not making contact. I fix the ones that I can find only two I know there’s more, I’ve changed the generator three times and the battery once, the problem happened again and again and again the only way I can stop my truck from dying is when that light come on if I got out and I took the negative wire off of my battery and then put it back on it would run again for about another three days and then if I didn’t see it, I’m stranded very dangerous. Finally I took it to my mechanic up the road and he basically did the same things. I did something about a door switch also though not another battery another generator and he added new battery cables so far it hasn’t done it again. Now my truck when starting to slow down, it will vibrate and shake you to death. You hit a little vibration in the road say a rumble strip. This thing will shake you through the roof in about make you run into another Vehicle , also, it’s hard to fill up the gas if you have to turn the gas nozzle almost straight up and down if you’re low on gas to make it except it or you’ll be sitting there for 30 minutes putting gas in your truck. I noticed also all of my wheels are having rough spots on them everywhere and they are rusting into . Another thing that happens this truck eats breaks for breakfast. I have put in the past two years at least have the change the brakes, calipers rotors and all twice a year sometimes three times a year. Also, the trailer brake system light comes on nonstop along with a service stability track on when happen. No Wasey no cruise control. I am a masterelect. Maintain truck it ju
NHTSA complaint #11500067 — an unverified report by a vehicle owner.
at 1,000 milesMiami, FL
SERVICE BRAKES
The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while towing a camper, the brakes locked up. The service trailer brake system message was displayed. There was an abnormal beeping noise detected and the instrument cluster was flashing. While driving approximately 60 MPH, the vehicle was vibrating. The vehicle was taken to the local dealer but the mechanic was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic but the mechanic was unable to assist. The manufacturer was not contacted. The failure mileage was approximately 1,000.
NHTSA complaint #11466432 — an unverified report by a vehicle owner.